2006 Chevrolet Express 1500 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2006 Chevrolet Express 1500, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Fuel system250.0%
- Body & structure125.0%
- Interior & seats125.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
FAULTY FUEL GAUGE SENSOR ON 2006 CHEVY EXPRESS VAN. MY FUEL GAUGE READ APPROX 1/8TH OF A TANK. THE LOW FUEL LIGHT HAD NOT COME ON. THE VAN STOPPED RUNNING AND COULD NOT BE STARTED. IT WAS TOWED TO NUCAR IN NEW CASTLE. SENSOR AND FUEL PUMP WERE REPLACED AS THE DEALER SAID THEY WOULD NOT GUARANTEE THE SENSOR WITHOUT REPLACING THE FUEL PUMP. THE COST > $1,000. I READ YOUR ARTICLE AND NOW FRIENDS OF MINE HAVE EXPERIENCED SIMILAR PROBLEMS. *TR
DRIVING ALONG THE HIGHWAY, MY WARNING LIGHT CAME ON STATING THERE WAS AN ENGINE PROBLEM. I WAITED TO GET IT CHECKED OUT. AS I WAS MAKING A DELIVERY THE 2006 EXPRESS CARGO STALLED ON THE HIGHWAY. HAD IT TOWED TO THE CHEVROLET DEALERSHIP AND THEY STATED IT WAS THE FUEL SENSOR IN THE GAS TANK THAT BURNT OUT. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
THE HINGES ON THE DOORS OF CHEVY VANS ARE DEFECTIVE IN THAT THEY ARE IMPROPERLY DESIGNED AND CORRODED AND BECOME DIFFICULT IF NOT IMPOSSIBLE TO OPEN AND CLOSE THE HINGES ARE INVERTED AND ALLOW DIRT AND WATER TO INVADE THE SWIVEL PORTION OF THE HINGE I HAVE REPORTED THIS TO THE DEALERS ARE THREE OCCASIONS AND THEY BASICALLY SAID TUFF LUCK THEY WERE AWARE OF THE PROBLEM WHEN I WENT IN THEY SAY ADDITIONAL MAINTENANCE IS REQUIRED BUT MAKE NO MENTION OF IT NOR DO THEY DO ANYTHING SPECIAL AT THEIR FACILITY I HAVE HAD MY VEHICLES SERVICED THERE AND IT MAKES NO DIFFERENCE. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Interior & seats
Reports naming seats, latches, locks, linkages and interior fittings.
From owner reports, verbatim
THE HINGES ON THE DOORS OF CHEVY VANS ARE DEFECTIVE IN THAT THEY ARE IMPROPERLY DESIGNED AND CORRODED AND BECOME DIFFICULT IF NOT IMPOSSIBLE TO OPEN AND CLOSE THE HINGES ARE INVERTED AND ALLOW DIRT AND WATER TO INVADE THE SWIVEL PORTION OF THE HINGE I HAVE REPORTED THIS TO THE DEALERS ARE THREE OCCASIONS AND THEY BASICALLY SAID TUFF LUCK THEY WERE AWARE OF THE PROBLEM WHEN I WENT IN THEY SAY ADDITIONAL MAINTENANCE IS REQUIRED BUT MAKE NO MENTION OF IT NOR DO THEY DO ANYTHING SPECIAL AT THEIR FACILITY I HAVE HAD MY VEHICLES SERVICED THERE AND IT MAKES NO DIFFERENCE. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .