RoadVitals

2011 Chevrolet Express 1500 Owner Complaints

Reports submitted to NHTSA by owners and drivers, shown in full

Data refreshed

Complaints on fileComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
3
Latest Mar 20, 2020
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0
Filed in the last 12 monthsReports filed with NHTSA in the trailing 365 days. Recent volume reflects attention and vehicle age as much as anything else.
0
Reports on file since May 9, 2019

What this page shows

Our database holds 3 NHTSA owner-reported complaints for the 2011 Chevrolet Express 1500. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Complaints, most recent first

Showing 1–3 of 3

Airbags
Filed Mar 20, 2020

MY AIR BAG WARNING LIGHT CAME ON AND WHEN I INVESTIGATED I FOUND IT WAS PROBABLY RELATED TO THE FRONT AIR BAG SENSORS. WHEN I EXAMINED THE SENSORS I FOUND THAT THE ALUMINUM ALLOY BODY AND THE PLASTIC SHIELD SURROUNDING IT HAD SPLIT WIDE APART WHERE THE STEEL MOUNTING SCREW PASSED THROUGH THE SENSOR HOUSING. BOTH SENSORS HAVE FAILED IN EXACTLY THE SAME MANOR. THE VEHICLE HAS 83,000 MILES ON IT AND DOES NOT HAVE ANY OTHER OF ADVANCED CORROSION ANYWHERE ELSE. I CONTACTED GM AND THEY SEEMED TO HAVE NO INTEREST AND ADVISED ME TO TAKE IT TO A DEALER AND HAVE IT REPAIRED AT MY OWN EXPENSE.

NHTSA ID
11318814
Incident
Jun 30, 2019
Mileage
80,000 mi
Brakes
Filed Jan 31, 2020

WE DEVELOPED A SIGNIFICANT LEAK IN A REAR BRAKE LINE OF OUR VAN. THE LEAK DID NOT LEAD TO A LOSS OF CONTROL, BUT THE BRAKE RESERVOIR WAS NEARLY EMPTY WHEN I DISCOVERED THE ISSUE. THE LEAK WAS DISCOVERED BASED ON A LARGE SPOT LEFT ON OUR DRIVEWAY UNDER THE VAN. THE VEHICLE WAS PROBABLY DRIVEN ABOUT 50-100 MILES (ONE TO TWO DAYS) AFTER THE LEAK DEVELOPED BUT BEFORE THE ISSUE WAS DISCOVERED AND ADDRESSED. WHILE FIXING THE PROBLEM, I FOUND THAT THE LEAK WAS DUE TO AN ASSEMBLY ERROR. THE VAN'S FUEL FILLER DOWN-PIPE HAS A WORM-GEAR CLAMP THAT WAS NOT PROPERLY CLOCKED. THIS CAUSED THE CLAMP TO RUB ONE OF THE REAR BRAKE LINES AND WEAR A HOLE IN IT. I SENT TWO PICTURES SHOWING THE CLAMP AND BRAKE LINE AS I DISCOVERED THEM. I ALSO SENT A PICTURE OF THE DAMAGED LINE AFTER BEING REMOVED FROM THE VEHICLE. THE VAN HAD ABOUT 87,000 MILES WHEN THE LEAK DEVELOPED.

NHTSA ID
11306239
Incident
Jan 22, 2020
Mileage
87,000 mi
Exterior lighting
Filed May 9, 2019

TL* THE CONTACT OWNS A 2011 CHEVROLET EXPRESS 1500 CARGO VAN. THE CONTACT STATED THAT THE LOW BEAM HEAD LAMPS HAD FAILED ON FIVE SEPARATE OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO REPLACED THE HEAD LAMPS EACH TIME. THE CAUSE OF THE FAILURES WERE NOT DETERMINED. THE LOCAL DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES BUT NO ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 12,000. *BF CONSUMER STATED SEALED BEAM LAMPS ON BOTH SIDES WERE REPLACED MULITPLE TIMES. VIN IS INVALID. *JB

NHTSA ID
11206464
Incident
May 1, 2012
Mileage
12,000 mi

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Data sources

Data on this page last refreshed .