2009 Chevrolet Express 2500 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2009 Chevrolet Express 2500, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Driver assistance133.3%
- Electrical133.3%
- Visibility133.3%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
WHILE DRIVING ON A BUSY HIGHWAY, THE ENGINE SHUT OFF COMPLETELY. I PULLED OVER TO THE SHOULDER AND THE DIC INDICATED A THROTTLE POSITION SENSOR PROBLEM. I HAD IT TOWED TO A CHEVROLET DEALER AND THEY TOLD ME IT WAS THE ECM. I PAID TO HAVE IT FIXED AND SENT AN EMAIL (ATTACHED) TO CHEVROLET CUSTOMER ASSISTANCE CENTER REQUESTING REIMBURSEMENT.SINCE THE VEHICLE'S MILEAGE WAS ONLY 39226 MILES. I'M STILL PURSUING REIMBURSEMENT BUT WANT TO FILE THIS COMPLAINT SINCE THIS IS A MAJOR SAFETY PROBLEM TO HAVE VEHICLE TOTALLY SHUT DOWN. INTERESTINGLY, CHEVROLET WAS AWARE OF A SIMILAR PROBLEM WITH THE THROTTLE POSITION SENSOR AND SENT ME A LETTER (ATTACHED) TO EXTEND THE WARRANTY.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
2009 CHEVY EXPRESS VAN G2500 THE DEFROST BLOWER FAN STOPPED WORKING ON ANY SETTING. I HAD TO STOP THE VEHICLE UNTIL I COULD SEE OUT THE WIND SHIELD. VERY DANGEROUS. ONLY 37,404 MILES ON THIS CHEVY EXPRESS 2500 VAN! I LIVE IN THE SAN FRANCISCO BAY AREA AND A WIND SHIELD DEFROST IS A MUST!! WE HAVE FOG AND TEMPS IN THE AREA AND WEATHER CONDITIONS CAN CHANGE RAPIDLY. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Visibility
Reports naming windshields, glass, wipers, defrosters and mirrors.
From owner reports, verbatim
2009 CHEVY EXPRESS VAN G2500 THE DEFROST BLOWER FAN STOPPED WORKING ON ANY SETTING. I HAD TO STOP THE VEHICLE UNTIL I COULD SEE OUT THE WIND SHIELD. VERY DANGEROUS. ONLY 37,404 MILES ON THIS CHEVY EXPRESS 2500 VAN! I LIVE IN THE SAN FRANCISCO BAY AREA AND A WIND SHIELD DEFROST IS A MUST!! WE HAVE FOG AND TEMPS IN THE AREA AND WEATHER CONDITIONS CAN CHANGE RAPIDLY. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .