2002 Chevrolet Express Problems

2002 CHEVY 2500 EXPRESS VAN. FAILURE OF POWER BOOSTER, LOST BOTH BRAKE POWER AS WELL AS STEERING POWER. ALMOST IMPOSSIBLE TO CONTROL CAR. REPLACED ONCE, FAILED AGAIN 6 MONTHS LATER. REPLACED AGAIN. FAILED AGAIN THIS YEAR. I AM NOW ON MY FORTH POWER BOOSTER, FAILURE IS VERY DANGEROUS AS YOU LOSE BOTH STEERING AND BRAKES AT SAME TIME. *TR

BRAKES ON MY 2002 CHEVY EXPRESS VAN ARE NOT LARGE ENOUGH TO STOP VEHICLE WITHOUT WARPING ROTORS. THIS IN TURN CAUSES LONGER STOPPING DISTANCES AND A VIBRATION THAT CAUSES STEERING WHEEL TO PULSATE. *NM

TL*THE CONTACT OWNS A 2002 CHEVROLET EXPRESS. WHILE DRIVING 50 MPH, THE VEHICLE COMPLETELY SHUT OFF AND WOULD NOT RESTART. THE VEHICLE WAS TOWED TO THE DEALER AND THEY REPLACED THE FUEL FILTER, HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS THEN TOWED TO A GM DEALER, WHO REPLACED THE CRANK SENSOR. THE CONTACT STATED THAT THE VEHICLE IS CURRENTLY OPERATING NORMALLY. THE CURRENT MILEAGE WAS 16,612 AND FAILURE MILEAGE WAS 16,594.

INTAKE MANIFOLD GASKET FAILURE CAUSING ENGINE TO SEIZE AT 69,700 MILES. *TR

THE SIDE HINGES SEIZE UP AND BREAK. IT THROWS THE DOOR ALIGNMENT OFF AND I AM NO LONGER ABLE TO COMPLETELY CLOSE THE FRONT SIDE DOOR AND IT KEEPS THE PASSENGER DOOR FROM OPENING ALSO. THIS IS A CONTINUEING PROBLEM CHEVROLET HAS WITH THEIR EXPRESS VANS. IT IS A DESIGN PROBLEM AND ALSO CHEAP MATERIALS CAUSED IT TO RUST AND SEIZE UP AND THEN BREAK THE HINGE, THE HINGE IS WELDED ON. VERY EXPENSIVE TO HAVE REPARED. IT IS DANGEROUS AS PEOPLE CAN NOT GET OUT OF THE VAN. CHEVROLET NEEDS TO OFFER AN INEXPENSIVE FIX FOR THIS.

WHEN I CAME OUTSIDE THE GLASS WAS BROKEN AND HAD BEEN THROWN TO THE OUTSIDE OF THE VEHICLE. THE VEHICLE HAD BEEN DRIVEN THE DAY BEFORE AND WAS FINE. IT WAS PARKED IN THE SHADE AND AWAY FROM ANYTHING WHICH COULD HAVE HIT IT. IT WAS LOCKED AND NOT TOUCHED IN ANY WAY. THE BROKEN FRAGMENTS WERE ON THE GROUND BELOW THE GLASS FRAME AREA. IT IS THE SAME TYPE OF GLASS THAT I SAW IN THE STORY ON THE NEWS YESTERDAY ABOUT THE SUN ROOFS THAT BREAK. WHEN I SAW THE STORY I KNEW THIS HAD TO BE THE EXPLANATION. I HAVE A PICTURE AND THE TEXT I SENT THAT DAY BECAUSE I WAS SO SHOCKED AT HOW SOMETHING LIKE THIS COULD HAPPEN, IT MADE NO SENSE. NOW IT MAKES PERFECT SENSE.

THE VEHICLE SHUTS DOWN WITHOUT WARNING WHILE DRIVING, FOUND A GM SERVICE BULLETIN STATING TO REPLACE THE DISTRIBUTOR CAP AND ROTOR BUT HAVE DONE THAT NOW 4 FOUR TIMES BUT THIS DOESN'T CORRECT THE CAUSE JUST THE EFFECT. TO DATE IT HAS REDENDERED OUR VEHICLE UNDRIVEIBLE DUE TO IT'S UNRELIBILITY. GM ISN'T DOING ANYTHING TO HELP US OUR OUR WHEELCHAIR BOUND SON WHO RELIES ON THIS VEHICLE FOR MEDICAL APPOINTMENTS.

VAN IS USED IN A MUNICIPAL PARKS AND RECREATION DEPARTMENT FOR MAINTENANCE DUTIES. OPERATOR STARTED VEHICLE AT BEGINNING OF DAY TO WARM UP. OPERATOR LEFT THE VEHICLE. OPERATOR RETURNED APPROXIMATELY FIVE MINUTES LATER AND SAW SMOKE COMING FROM INSIDE THE PASSENGER AREA. OPERATOR CALLED 911 AND RETRIEVED A DRY POWDER EXTINGUISHER. OPERATOR SAW FLAMES COMING FROM AN AREA IN THE REAR OF THE DRIVER'S SEAT. OPERATOR TURNED OFF IGNITION AND USED EXTINGUISHER ON THE FIRE, PUTTING IT OUT. INVESTIGATION SHOWS AREA OF ORIGIN TO INSIDE THE DRIVER?S SIDE SEAT BELT CHANNEL. PLASTIC MOLDING COVERS THIS CHANNEL. A WIRING HARNESS IS LOCATED IN THIS CHANNEL. HEAVIEST BURN OF THE HARNESS IS DIRECTLY AT THE CONNECTION OF THE HARNESS TO THE DRIVER?S SIDE SEAT BELT MECHANISM LOCATED AT THE FLOOR. FIRE PARTIALLY CONSUMED HARNESS AND PLASTIC MOLDING. THERE ARE PICTURES OF THE DAMAGE AND HARNESS. HARNESS WAS CUT BACK TO CLEAN WIRING ON BOTH SIDES OF DAMAGED SECTION AND IS AVAILABLE FOR INSPECTION.*AK

2002 CHEVROLET CONVERSION VAN EXPRESS 1500 HAD A PROBLEM WITH THE DRIVERS SIDE WINDOW. EXPRESS WINDOW WOULD GO DOWN BUT NOT GO BACK UP. *TS THE MOTOR WAS REPLACED THREE TIMES, FINALLY THE SWITCH WAS REPLACED. THE BRAKES AND MASTER CYLINDER HAD TO BE REPLACED. THE CONSUMER WAS TOLD THE BRAKES WERE INSUFFICIENT FOR THE WEIGHT OF THE VEHICLE. THE MICHELIN TIRES ONLY LASTED 24,000 MILES. *JB

DT:THE CONTACT STATED THE LEFT REAR TIRE DEVELOPED A BULGE WITHIN THE TREAD. HE BROUGHT THE VEHICLE TO AN INDEPENDENT REPAIR SHOP, AND THEY REPLACED THE TIRE WITH A SPARE. WHEN HE RETURNED HOME THE VEHICLE WAS TAKEN TO A FIRESTONE DEALER, WHO DISCOVERED THERE WAS A COMPLETE BELT SEPARATION ON THAT TIRE. A SECOND INCIDENT LATER OCCURRED ON THE LEFT FRONT TIRE IN A SIMILAR FASHION. BOTH OF THE FAILED FIRESTONE TIRES WERE REPLACED WITH GOODYEAR TIRES. WHILE DRIVING THE RIGHT REAR REMAINING FIRESTONE TIRE BLEW OUT AT 75 MPH RESULTING IN DAMAGE TO THE VEHICLES FENDER AND BUMPER AREA. HE AVOIDED ANY COLLISION. HE TOOK PHOTOGRAPHS OF THE EXTENSIVE DAMAGE. NO FURTHER REPAIRS OR CORRECTIONS HAVE BEEN MADE AT THIS TIME. THIS IS A FIRESTONE STEELTEX R4S LT245/75/R16 LOAD RANGE E. THESE WERE THE ORIGINAL TIRES ON THE VEHICLE AT PURCHASE. *AK UPDATE 12/27/2005 - THE TIRES WERE MADE IN CANADA. *NM

THE REAR END WENT OUT AND THE ROTORS ARE WARPED. I HAD THE REAR END REPLACED AND THE SERVICE TECH SAID HE HAD NEVER SEEN ANYTHING LIKE THIS IN HIS HISTORY OF WORKING ON VEHICLES. I HAD JUST PURCHASED THE VAN JAN. 28TH AND IT HAD A 60 DAY WARRANTY. I HAD TAKEN IT BACK TO THE DEALERSHIP ON FEB 17TH AND REPORT THE NOISES IT WAS MAKING AND THEY IN TURN SAID NOTHING WAS WRONG. THE SERVICE TECH THAT REPLACED THE REAR END SAID IT COULD NOT HAVE BEEN MISSED BECAUSE THE DIFFERENTIAL WAS BENT COMPLETELY UP ON THE AXLES. HE SAID IT WAS DUE TO EITHER WHOEVER OWNED IT PREVIOUS HAD TOWED SOMETHING TO HEAVY OR THE THERE WAS A MANUFACTURER DEFECT IN THE DIFFERENTIAL. REGARDLESS HE DEALERSHIP (LAWRENCE MARSHALL) IN DENISON TX WILL NOT STAND BEHIND IT AND I AM OUT OF POCKET FOR THIS BIG EXPENSE. THEY OVER CHARGED ME FOR THE VEHICLE AND NOW THIS. I HAVE A BIG CONCERN BECAUSE THE NOISE IT WAS MAKING HAD STOPPED AFTER THE REAR END WAS REPLACED, BUT WHEN I WAS DRIVING IT TODAY IT CLUNKED TWO DIFFERENT TIMES, SAME NOISE AS BEFORE, SO NOW I AM WORRIED. I DON'T KNOW WHO TO TRUST TO HELP ME AS I HAVE BEEN RIPPED OFF SO BAD NOW. CAN YOU PLEASE HELP ME OR ADVISE ME WHERE I CAN HAVE THIS VEHICLE COMPLETELY CHECKED OUT. THE SERVICE TECH SAID IT WAS A MIRACLE THAT THE DRIVE SHAFT DID NOT FALL OUT ON THE TRIP MYSELF AND GRANDCHILDREN WERE ON. IT BROKE DOWN IN OHIO AND I LIVE IN OKLAHOMA SO OF COURSE IT SET ME BACK A LOT OF EXPENSE I COULD NOT AFFORD. I THOUGHT THE DEALERSHIP SHOULD STAND BEHIND THE 60 DAY WARRANTY SINCE I HAD TAKEN IT BACK TO THEM WITHIN THE WARRANTY TIME, BUT THEY HAVE GIVEN ME NOTHING BUT GRIEVE. I WOULD APPRECIATE ANY HELP I CAN GET AS I AM AFRAID OF THE VAN NOW. *JB

2002 CHEVROLET EXPRESS ENGINE LOST POWER AND REAR BRAKES CAUGHT ON FAILED. *BF THE CONVERTER WAS CLOGGED WHICH RESULTED IN THE ENGINE LOSING POWER. THE CHECK SERVICE ENGINE SOON LIGHT ILLUMINATED AND THE ENGINE MISSED ON ACCELERATION. THE DEALER REPLACED THE PLUG WIRE CAP ROTOR AND DISTRIBUTOR. THE CONSUMER HEARD A SCRAPPING NOISE COMING FROM THE REAR BRAKES AND VEHICLE SHOOK WHILE BRAKING. THERE WAS VIBRATION IN THE DRIVELINE ON ACCELERATION, THE BELT WAS REPLACED. VEHICLE CONSUMED EXCESSIVE AMOUNTS OF OIL. FLUID LEAKED FROM REAR AXLE, DEALER REPLACED THE REAR AXLE SEALS. THE DEALER REPLACED THE FUEL SENDER ASSEMBLY DUE TO STALLING. THE VEHICLE BATTERY WENT DEAD AFTER THE VEHICLE SAT OVERNIGHT. CLUTCH WAS LOUD AND PROVIDED NO POWER ON HOT DAYS, THE CLUTCH FAN WAS REPLACED. THE CONSUMER REQUEST THAT THE MANUFACTURER PROVIDE A REPLACEMENT VEHICLE OR REFUND THE FULL CONTRACT PRICE PLUS INCIDENTAL COST. *NM

DT: THE CONTACT STATED WHILE DRIVING THE VEHICLE STALLED INTERMITTENTLY. THE VEHICLE STALLED WHEN SLOWING DOWN OR WHEN STOPPING. THE VEHICLE WAS TAKEN TO THE DEALERSHIP AND THE FUEL INJECTOR PUMP WAS REPLACED, THIS REPAIRED THE VEHICLE.*AK UPDATED 12/07/05. *JB UPDATED 12/7/2005. *NM

CONSUMER 2002 CHEVROLET EXPRESS ENGINE ALMOST STALLED. CONSUMER HAD FUEL INJECTION SYSTEM CLEANED. *TS THE CONSUMER WAS TOLD THERE WAS CORROSION ON THE DISTRIBUTOR CAP AND ROTOR WHICH HAD ALREADY BEEN REPLACED TWICE. *JB

The contact owns a 2002 Chevrolet Express. The contact stated while driving 65 MPH, she heard an abnormal loud banging sound coming from the rear end of the vehicle. The contact stated that the passenger’s side rear axle detached from the vehicle, causing the tire to detach and roll away. The contact did not sustain any injury. The vehicle was towed to a tow lot. The dealer and the manufacturer were not notified. The vehicle was not diagnosed nor repaired. The approximate failure mileage was 100,000.

WHILE DRIVING AT ANY SPEED VEHICLE PULLED TO THE LEFT. DEALER STATED THEY HAVE REPAIRED THE VEHICLE. CONSUMER INSISTED THAT AS A RESULT OF THE REPAIRS WHEN APPLYING THE BRAKES VEHICLE PULLED TO THE LEFT EVEN MORE.*AK

2002 CHEVY 2500 EXPRESS VAN. FAILURE OF POWER BOOSTER, LOST BOTH BRAKE POWER AS WELL AS STEERING POWER. ALMOST IMPOSSIBLE TO CONTROL CAR. REPLACED ONCE, FAILED AGAIN 6 MONTHS LATER. REPLACED AGAIN. FAILED AGAIN THIS YEAR. I AM NOW ON MY FORTH POWER BOOSTER, FAILURE IS VERY DANGEROUS AS YOU LOSE BOTH STEERING AND BRAKES AT SAME TIME. *TR

THERE IS A KNOCKING IN THE STEERING. POOR STEERING CONTROL. DEALER REPLACED STEERING GEAR 3 TIMES AND THEN WAS TOLD BY GEN MOTORS NOT TO REPLACE IT AGAIN. THE PROBLEM STILL EXISTS. THE VEHICLE IS STILL IN WARRANTY. PRESENTLY AT A STANDOFF WITH GM. THEY WON'T FIX, I WON'T PAY.*AK

WHEN I CAME OUTSIDE THE GLASS WAS BROKEN AND HAD BEEN THROWN TO THE OUTSIDE OF THE VEHICLE. THE VEHICLE HAD BEEN DRIVEN THE DAY BEFORE AND WAS FINE. IT WAS PARKED IN THE SHADE AND AWAY FROM ANYTHING WHICH COULD HAVE HIT IT. IT WAS LOCKED AND NOT TOUCHED IN ANY WAY. THE BROKEN FRAGMENTS WERE ON THE GROUND BELOW THE GLASS FRAME AREA. IT IS THE SAME TYPE OF GLASS THAT I SAW IN THE STORY ON THE NEWS YESTERDAY ABOUT THE SUN ROOFS THAT BREAK. WHEN I SAW THE STORY I KNEW THIS HAD TO BE THE EXPLANATION. I HAVE A PICTURE AND THE TEXT I SENT THAT DAY BECAUSE I WAS SO SHOCKED AT HOW SOMETHING LIKE THIS COULD HAPPEN, IT MADE NO SENSE. NOW IT MAKES PERFECT SENSE.

DRIVER'S SIDE REAR VIEW MIRROR VIBRATES EXCESSIVELY. HARD TO VIEW ITEMS ON THE MIRROR. *TR

CONSUMER NOTICED THAT WHEN HEADLIGHTS ARE TURNED ON TAIL LIGHTS FUSE BLOWS OUT INTERMITTENTLY.*AK

DEALERSHIP DON'T HAVE THE PARTS TO PERFORM THE OWNER NOTIFICATION FOR THE RUNNING BOARD LIGHTS.*AK

PROBLEMS WHILE USING CRUISE CONTROL ON VEHICLE.*MR WHEN THE CRUISE CONTROL WAS ENGAGED AND THE BRAKE PEDAL WAS PRESSED, THE VEHICLE TOOK A WHILE BEFORE RESPONDING AND REDUCING THE SPEED OF THE VEHICLE. WHEN THE CRUISE CONTROL WAS SET AT 65 MPH AND GOING DOWN GRADE, THE VAN WOULD PICK UP SPEED AND NEVER ADJUST BACK TO 65 MPH. IF THE SPEED WENT UP TO 70 MPH THE CRUISE CONTROL SET ITSELF AT 70 MPH. THE CONSUMER EXPERIENCED OTHER PROBLEMS WITH THE VEHICLE. THE VAN WOULD LOOSE POWER WHEN ACCELERATING. THE DEALER REPLACED THE PCM AND REPROGRAMMED IT. WHILE PERFORMING THE ENGINE DIAGNOSTIC THE TECHNICIAN FOUND THAT THE CAP AND ROTOR HAD MOISTURE IN THEM AND WERE CORRODED. THE VEHICLE'S BATTERY WAS ALSO REPLACED BECAUSE OF A DEAD CELL. *NM

THE VEHICLE'S TRANSMISSION HAS FAILED WITHOUT WARNING WHILE BACKING OUT OF THE DRIVEWAY. AS A RESULT THE VEHICLE COASTED SLOWLY INTO THE MIDDLE OF THE STREET. THE CAUSE HAS YET TO BE DETERMINED. PLEASE PROVIDE ANY ADDITIONAL INFORMATION. *NM

PROBLEMS WHILE USING CRUISE CONTROL ON VEHICLE.*MR WHEN THE CRUISE CONTROL WAS ENGAGED AND THE BRAKE PEDAL WAS PRESSED, THE VEHICLE TOOK A WHILE BEFORE RESPONDING AND REDUCING THE SPEED OF THE VEHICLE. WHEN THE CRUISE CONTROL WAS SET AT 65 MPH AND GOING DOWN GRADE, THE VAN WOULD PICK UP SPEED AND NEVER ADJUST BACK TO 65 MPH. IF THE SPEED WENT UP TO 70 MPH THE CRUISE CONTROL SET ITSELF AT 70 MPH. THE CONSUMER EXPERIENCED OTHER PROBLEMS WITH THE VEHICLE. THE VAN WOULD LOOSE POWER WHEN ACCELERATING. THE DEALER REPLACED THE PCM AND REPROGRAMMED IT. WHILE PERFORMING THE ENGINE DIAGNOSTIC THE TECHNICIAN FOUND THAT THE CAP AND ROTOR HAD MOISTURE IN THEM AND WERE CORRODED. THE VEHICLE'S BATTERY WAS ALSO REPLACED BECAUSE OF A DEAD CELL. *NM

WHEN DRIVING AT AN UNDETERMINED SPEED AIRBAG WARNING LIGHT APPEARED ON THE DASHBOARD. CONSUMER WILL TAKE THE VEHICLE TO THE DEALERSHIP FOR INSPECTION. *AK THE CONSUMER WAS TOLD THAT WATER CAUSED THE AIR BAG SENSOR TO FAIL. *NM