Airbags
Filed Jul 2, 2026
Crash reported1 injury reported
Vehicle was in direct head on accident and air bags were not deployed.
- NHTSA ID
- 11748051
- Incident
- Jul 2, 2026
2022 Chevrolet Express Owner Complaints
Reports submitted to NHTSA by owners and drivers, shown in full
Data refreshed
Complaints on fileComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
4
Latest Jul 2, 2026
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
1
Filed in the last 12 monthsReports filed with NHTSA in the trailing 365 days. Recent volume reflects attention and vehicle age as much as anything else.
2
Reports on file since Sep 10, 2024
What this page shows
Our database holds 4 NHTSA owner-reported complaints for the 2022 Chevrolet Express. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Complaints, most recent first
Showing 1–4 of 4
BrakesElectrical
Filed Oct 21, 2025
I have 2023 Jayco Redhawk SE mounted on a Chevy Express 4500 Cutaway chassis with only 5300 miles on it. Chevrolet dealer ran diagnostics and replaced an ABS sensor which had no impact on the problem. I have an appointment to have it looked at by another dealership recommended by Chevy Customer Service. It is not safe to drive, going up straight steep grades on the interstate the right rear wheel keeps locking up under acceleration. Best I can tell the system just starts braking hard on the right rear and maybe both rear wheels even though you are trying to accelerate. It gets worse on steep entrance and exit ramps or steep curvy roads. Almost always when this happens there is traffic following closely at highway speeds (55 to 70 MPH).
- NHTSA ID
- 11694814
- Incident
- Oct 15, 2025
Electrical
Filed Jan 16, 2025
THE VAN HAS A ELECTRICAL ISSUE . ALL THE VAN DOORS UNLOCK AND LOCK.. WHEN I AM DRIVING THE VAN THE LOCKS UNLOCK AND LOCK 5 TIMES IN 2 BLOCKS. WHEN THE VAN IS PARKED AND ENGINE IS OFF AND NO KEY IN THE IGNITION THE LOCKS STILL UNLOCK AND LOCK. I TOOK IT TO MY CHEVY DEALER 3 DAYS AGO TO HAVE THE ELECTRICAL ISSUE DIAGNOSED AND FIXED. MY VAN IS STILL SITTING AT MY CHEVY DEALERSHIP FOR 3 DAYS TODAY JANUARY 16TH 2025 MY VEHICLES STILL HAS NOT BEEN DIAGNOSED YET TO EVEN FIX THE ELECTRICAL DOORS LOCKING SYSTEM
- NHTSA ID
- 11636260
- Incident
- Jan 12, 2025
Body & structureInterior & seats
Filed Sep 10, 2024
The contact owns a 2023 Gulf Stream Conquest built on a 2022 Chevrolet Express Chassis. The contact received notification of NHTSA Campaign Number: 23V231000 (Latches/Locks/Linkages, Structure); that was misplaced. The contact stated that the entry door latch had failed, and the door could only be locked or unlocked from the outside. The contact stated that he was physically disabled, and the failure required his wife to exit the RV through the front driver's side door to unlock or to lock the RV entry door. The RV was taken to the local dealer for the recall repair, but the dealer was unable to verify that the RV was covered under the recall. The RV was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure, but no assistance was provided. The failure mileage was approximately 4,000.
- NHTSA ID
- 11613845
- Incident
- May 10, 2024
- Mileage
- 4,000 mi
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints, published verbatim
Data on this page last refreshed .