Reports submitted to NHTSA by owners and drivers, shown in full
Data refreshed
Our database holds 726 NHTSA owner-reported complaints for the 2007 Chevrolet Hhr. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Showing 1–25 of 726 · page 1 of 30
The fuel line rusted causing it to leak. We discovered it when we had some exhaust work done on the car. No one other then myself and the people that have done the exhaust work. There was no warning of the issue.
Car has developed a fuel leak once again in the rear of the vehicle. this is the second time a fuel leak has been noted. the first time the mechanic replaced a portion of the line that had corroded and was leaking fuel near the driver rear tire. now the leak is in another section of the original pipe near the fuel tank. this is poor quality and engineering.
Power steering went out while I was driving and it put me in danger and other drivers because it was hard to control the vehicle, the steering wheel was really tough to turn. The vehicle wasn't inspected by a professional because the problem just occurred.
Power steering lights up and I am unable to turn the steering wheel. When I shut the motor down and start back up, the steering starts working again. This has been doing this for about 4 years now. I took it to White Allen Chevrolet when it first started happening and they told me that they drove it around and that it did not happen while they test drove the car. It happens intermittingly. I never know when it is going to happen. When it first started, it only happened about once every six months or so. Now it is happening every time I am in the car. Sometimes when I pull out onto a street and into traffic the power steering light comes on and I have to find a spot to get off the street so that I can turn the motor off and restart the engine. Today 09/18/2025, it cut off 3 times. I am checking to see if there is a recall on this model for the power steering. I have found out that it does not use power steering fluid but that it has a motor under the steering wheel that controls the power steering.
My power steering keeps going out. It randomly makes it hard to turn which could cause a crash. It's common in other hhr models, mine has not been inspected personally yet. It has a chime and then the console says "power steering". There were no signs before it started. It goes away when you restart the car but will come back randomly. I was advised by an auto repair place to replace the battery, but it didn't help.
Power steering motor went out. Went to the dealer to get special coverage 14119 ( I was aware of the issue ). Dealership refused to do work for free as stated in service bulletin. Called GM Corporate and they also said work would would not be done for free. 14119 specifically stated that power steering motor would be changed and I quote " at no cost to the customer " unquote. They want $175 just to look at my vehicle. When does the " at no cost to the customer " come in, apparently we seem to have forgotten that. I would like some legal clarification to this from the nhtsa.
The fuel line on the left back side of the car (back drivers side) was leaking fuel when it was in parking or sitting and idling. Noted fuel smell when car started up and was idling, car was taken to independent mechanic, fuel line was broke in 2 places. It was broke close by the wheel are and the other spot was back by the exhaust
The fuel line is leaking due to it being metal and rusted.
Fuel line leaking next to exhaust. This is very dangerous and could kill someone. Bad design on Chevy's part.
Fuel leak coming from the Left (Drivers Side) of the vehicle in the area of the rear wheel. There was a strong odor of fuel, Fuel was observed dripping to the ground under the vehicle in front of the Left rear wheel. This condition was observed only when the vehicle was running and in park. The condition does not seem to happen when the vehicle is off and not running. No repair has been made yet , vehicle can be inspected in its current condition. This is a severe safety concern of ignition/explosion due to a fuel leak; risk of property damage or even death. This problem has not been addressed yet to a dealer or local mechanic as of yet . Failed component has not yet been inspected by GM, Police or insurance. No warning lamps or messages were illuminated on dashboard, prior to failure, vehicle did have some difficulty starting, possibly due to this problem, but it did start.
Fuel line leak. My fuel line has cracked in multiple places and needs to be replaced entirely. The leak was consistent, with a constant stream leaking out when in operation and for several minutes after stopping the engine. The odor of gasoline was strong from inside of the vehicle when in operation and large puddles of gas were visible on the ground afterwards when I first noticed the issue. My repair quote is about $500 to get the line replaced entirely.
Body clips holding fuel line causing rusting at these points. Leaking fuel from body clip in front of driver’s side rear tire. Based on caked on debris (mud like consistency), it has been happening for a while but wasn’t leaking to driveway due to disuse of the vehicle. This has commonly happened on 2008-2010 HHRs and Cobalts too.
The contact owns a 2007 Chevrolet HHR. The contact stated while her aunt was driving at an undisclosed speed, there was an abnormal gasoline odor inside the vehicle. After a visual inspection, it was discovered that there was fuel leaking from the rear of the vehicle. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to a past NHTSA investigation but was unable to provide specific information. The manufacturer was notified of the failure, and a case was filed. The failure mileage was unknown.
I HAVE A FUEL LINE LEAK NEAR THE LEFT REAR TIRE WHICH HAS BEEN HAPPENING WITH OTHER VEHICLES SUCH AS THE COBALT AND OTHER HHR'S. I TOOK IT TO A DEALER AND THEY SAID IT IS GOING TO COST ME $1500 TO REPLACE ALL THE FUEL LINES BECAUSE THEY WERE RUSTED REALLY BAD. THIS SHOULDN'T BE HAPPENING PLUS IT'S NOT VERY SAFE. THIS SHOULD BE A RECALL ITEM. MY VEHICLE ONLY HAS ~156000 MILES ON IT. THANKS
Leaking fuel near the left rear tire I have read online that other individuals are having the same issue. Please advise Thanks
The contact owns a 2007 Chevrolet HHR. The contact stated while exiting the driveway of a restaurant, the steering wheel failed to respond as needed. The contact turned off the vehicle. The contact stated that while attempting to restart the vehicle, the vehicle failed to restart. There were unknown warning lights illuminated. The vehicle was towed to an independent mechanic where it was diagnosed that the alternator and battery needed to be replaced. The vehicle was then towed to a second independent mechanic who informed the contact that the key was stuck in the ignition switch and the electrical system was burned. The vehicle was not repaired. The dealer and the manufacturer were not notified of the failure. The failure mileage was approximately 144,000.
The contact owns a 2007 Chevrolet HHR. The contact stated while driving at various speeds between 30-65 MPH, the steering wheel became extremely difficult to steer and the vehicle lost electrical power. The contact stated that she would veer to the side of the road or park the vehicle whenever the failure occurred. There was no warning light illuminated. Additionally, the contact stated that upon attempting to restart the vehicle and inserting the key in the ignition switch, the vehicle failed to start. The contact stated that she continually turned the key in the ignition switch until the vehicle restarted. The contact stated that the failure had been reoccurring increasingly and the vehicle failed to restart after several attempts. The dealer was notified of the failure. The vehicle was not diagnosed or repaired. The contact stated that the vehicle was previously repaired under an NHTSA Campaign Number: 14V171000 (Electrical System) however, the failure persisted. The manufacturer was not notified of the failure. The failure mileage was approximately 15,000.
While driving, more specific while turning the powersteering goes out at any given time. It has also done this while switching lanes on the freeway.
Notice a gas smell coming from the car when I would get out of the car after driving it . but could not find the source of the smell at first . Then one day I was parked on a black Asphalt payment and seen a wet spot on the payment I then looked under and seen a small wet spot on the protector where the gas line run through on the left side near the lower rear door wear it opens up I then made a call to my GM car dealer ship to see if it is under warranty or a recall but they said no recall for the Fuel lines that when i looked up if other people are having the same problem . And found over 614,000 having the same problem . Note I am waiting on the parts from my dealer so they can fix it which is over $900.00 I am paying for it .
The power steering keeps going out. This caused my 15 year old daughter to nearly run into a concrete barrier wall on her way to school. It sent her into a panic and scared the life out of her.
The power steering intermittently (but quite regularly) goes out. The "power steering" warning also comes up on the display panel on the dash. If vehicle is restarted, the power steering seems to resolve itself again but only temporarily. This problem is becoming much more frequent. This is a safety issue because without the power steering in working order, the steering wheel becomes difficult to turn and this happens not only on the road but also on the highway as well when the vehicle is going 70 miles per hour. We have not had the vehicle serviced or looked at for this issue. It has been ongoing for several months but seems to be getting worse/more frequent.
While driving the vehicle approximately 45mph, the power steering light came on the dash. While driving straight was not an issue, attempting to pull off the road was difficult. I checked owners manual which told me to take it to a dealer. This in itself was bothersome. I opened the hood and called my mechanic, who told me to check fuses. I replaced the fuse and the vehicle was fine for about 4 weeks, but once again driving 30-35 mph, the light came on the dashboard. I have saved both replaced fuses, I’m wondering after reading other reports whether the fuses are even blown? Either way, this is not a safe situation to be driving any speed without power steering. Mine is a 2007 Chevrolet HHR with approximately 163 k miles
FUEL LINE ROTTED THRU SPRAYING ON EXHAUST LEFT REAR
when I went to push on the brake, the brake pedal went to the floor... I had No Brakes? This could have been a terrible accident had I been going faster.
My 2007 HHR (I also hve a 2008 with the same issue as this) was being configured with replacement front seats and after completion the mechanic/installer informed me that there was a strong gas leak on the driver's side. Upon looking at the car a very noticeable puddle of gas was on the ground. I had the car moved to my home and it is currently unable to use due to the gas leak. This is ridiculous. Everything I have read points to Chevy cheaping out and not using non-corroding metal lines or nylon and the proximity of the heat shield which traps the moisture and corrodes the fuel lines. This REALLY needs to be recalled at Chevy's expense as it is a manufacturer's error. I have no idea if a prior situation had been addressed by the previous owner (commercial computer repair shop).
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .