2007 Chevrolet Hhr Problems

Power steering went out while I was driving and it put me in danger and other drivers because it was hard to control the vehicle, the steering wheel was really tough to turn. The vehicle wasn't inspected by a professional because the problem just occurred.

Power steering lights up and I am unable to turn the steering wheel. When I shut the motor down and start back up, the steering starts working again. This has been doing this for about 4 years now. I took it to White Allen Chevrolet when it first started happening and they told me that they drove it around and that it did not happen while they test drove the car. It happens intermittingly. I never know when it is going to happen. When it first started, it only happened about once every six months or so. Now it is happening every time I am in the car. Sometimes when I pull out onto a street and into traffic the power steering light comes on and I have to find a spot to get off the street so that I can turn the motor off and restart the engine. Today 09/18/2025, it cut off 3 times. I am checking to see if there is a recall on this model for the power steering. I have found out that it does not use power steering fluid but that it has a motor under the steering wheel that controls the power steering.

The contact owns a 2007 Chevrolet HHR. The contact stated while exiting the driveway of a restaurant, the steering wheel failed to respond as needed. The contact turned off the vehicle. The contact stated that while attempting to restart the vehicle, the vehicle failed to restart. There were unknown warning lights illuminated. The vehicle was towed to an independent mechanic where it was diagnosed that the alternator and battery needed to be replaced. The vehicle was then towed to a second independent mechanic who informed the contact that the key was stuck in the ignition switch and the electrical system was burned. The vehicle was not repaired. The dealer and the manufacturer were not notified of the failure. The failure mileage was approximately 144,000.

The contact owns a 2007 Chevrolet HHR. The contact stated while driving at various speeds between 30-65 MPH, the steering wheel became extremely difficult to steer and the vehicle lost electrical power. The contact stated that she would veer to the side of the road or park the vehicle whenever the failure occurred. There was no warning light illuminated. Additionally, the contact stated that upon attempting to restart the vehicle and inserting the key in the ignition switch, the vehicle failed to start. The contact stated that she continually turned the key in the ignition switch until the vehicle restarted. The contact stated that the failure had been reoccurring increasingly and the vehicle failed to restart after several attempts. The dealer was notified of the failure. The vehicle was not diagnosed or repaired. The contact stated that the vehicle was previously repaired under an NHTSA Campaign Number: 14V171000 (Electrical System) however, the failure persisted. The manufacturer was not notified of the failure. The failure mileage was approximately 15,000.

when I went to push on the brake, the brake pedal went to the floor... I had No Brakes? This could have been a terrible accident had I been going faster.

TL* THE CONTACT OWNED A 2007 CHEVROLET HHR. WHILE DRIVING APPROXIMATELY 37 MPH, THE BRAKE PEDAL WAS ABRUPTLY DEPRESSED, BUT FAILED TO ENGAGE IN TIME. AS A RESULT, THE CONTACT REAR ENDED ANOTHER VEHICLE. THE DRIVER SUSTAINED INJURIES TO THE RIGHT TOE AND CHEST, WHICH DID NOT REQUIRE MEDICAL ATTENTION. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS DESTROYED AND TOWED TO AN UNDISCLOSED LOCATION. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE MANUFACTURER WAS NOTIFIED, BUT THE LOCAL DEALER WAS NOT. THE FAILURE MILEAGE WAS 71,000. *TT *TR

The fuel line rusted causing it to leak. We discovered it when we had some exhaust work done on the car. No one other then myself and the people that have done the exhaust work. There was no warning of the issue.

Car has developed a fuel leak once again in the rear of the vehicle. this is the second time a fuel leak has been noted. the first time the mechanic replaced a portion of the line that had corroded and was leaking fuel near the driver rear tire. now the leak is in another section of the original pipe near the fuel tank. this is poor quality and engineering.

I HAD AN AUTO ACCIDENT ON FEBRUARY 7, 2021. I LOST CONTROL ON AN ICY HIGHWAY AND FLIPPED MY CAR IN A DITCH FACING THE OPPOSITE DIRECTION. I HIT THE DRIVER'S SIDE IN THE DITCH HARD ENOUGH IT BOUNCED BACK ON ALL FOUR TIRES. MY JAW HIT THE STEERING WHEEL, MY LEFT SHOULDER WENT THROUGH THE DRIVERS WINDOW AND OF COURSE I NOW HAVE ONGOING BACK ISSUES AT THIS TIME. MY CONCERN IS THE AIRBAG NEVER DEPLOYED. I FIND THIS CONCERNING AS THE IMPACT WAS GREAT AND I HOT THE STEERING WHEEL WITH MY FACE.

MY DAUGHTER IN LAW WAS INVOLVED IN A ROLL OVER ACCIDENT TODAY AND NOT ONE OF THE AIRBAGS DEPLOYED, RESULTING IN A CONCUSSION TO THE LEFT SIDE OF HEAD WHEN IT HIT THE DRIVERS SIDE WINDOW AND BUSTED IT!

THIS COMPLAINT CONCERNS A 2007 CHEVROLET HHR LT WHICH WAS PURCHASED AS A NEW VEHICLE. IT IS 'ALWAYS GARAGED'. IT HAS 36,1XX ORIGINAL MILES. ABOUT 2 WEEKS AGO WE BEGAN TO NOTICE 'CHUNKS' OF RUST GATHERING UNDER THE REAR OF THE VEHICLE. AN INSPECTION MADE BY SELF REVEALED EXTENSIVE RUST-OUT TO THE "REAR REINFORCEMENT BAR" (PART #10 IN THE ENCLOSED DIAGRAM). I CONTACTED "GM" VIA THEIR 'SOCIAL MEDIA CUSTOMER CARE CENTER', THOROUGHLY EXPLAINED THE ISSUE, AND WAS DIRECTED TO A LOCAL BUICK/GMC DEALERSHIP FOR AN EVALUATION, WITHIN HOURS I HEARD A NEGATIVE RESPONSE TO MY REQUEST FOR ASSISTANCE. SUBSEQUENT ATTEMPTS BY SELF HAVE NOT GIVEN ME A SATISFACTORY EXPLANATION AS TO THE "WHY" OF THIS RUSTED PART. THIS VEHICLE HAS ALWAYS BEEN MAINTAINED TO A HIGH DEGREE. THE EXAMINER TOLD ME HE DID NOT OBSERVE ANY OTHER RUST ISSUES ON OR UNDER THIS VEHICLE. KEEP IN MIND THAT I AM NOT AN 'AUTOMOTIVE' ENGINEER; BUT- TO MY 'UNTRAINED EYE' PART OF THE PROBLEM IS THAT THE PART IS DEEPLY HIDDEN WITHIN THE REAR BUMPER COVER; AND THE DESIGN OF THE REAR BUMPER COVER IS SUCH THAT IT FOSTERS THE COLLECTION OF DEBRIS FROM THE ROAD ON IT'S HORIZONTAL SURFACES. THIS DEBRIS THEN IS IN SITU WITH THE METAL PARTS OF THE ACTUAL 'REAR BUMPER'. GIVEN TIME THE DEBRIS RETAINS MOISTURE WHICH 'APPARENTLY' THEN COVERS THE METAL PARTS. ...AND ONE GETS THE RESULTS SHOWN IN THE PHOTOS. NONE OF THIS WOULD BE VISIBLE UNLESS A PERIODIC, CAREFUL EXAMINATION OF THE HIDDEN PARTS WERE TO BE MADE BY THE OWNER/OPERATOR OF THE VEHICLE. A "POSSIBLE" MEASURE TO BE TAKEN WOULD BE FOR GENERAL MOTORS TO EDUCATE/INFORM OWNER/OPERATORS AS TO THE POTENTIAL FOR A PROBLEM. ANOTHER "POSSIBLE" SOLUTION, WERE THIS A VEHICLE STILL IN PRODUCTION (AND NOT YET ANOTHER GM 'ORPHAN' CAR) WOULD BE, OF COURSE, TO CORRECT THE APPARENT, ORIGINAL 'DESIGN DEFICIENCY'.

I GOT INTO MY CAR WITH NO PROBLEM, WHEN IT WAS TIME TO GET OUT OF THE CAR I COULD NOT BECAUSE THE DRIVER SIDE DOOR WOULD NOT OPEN. I HAD TO LET THE WINDOW DOWN TO GET OUT.

DEFECTIVE TIMING CHAIN TENSIONER CAUSED CHAIN TO JUMP TIME AND CAUSE VALVE DAMAGE COSTING $2000 IN REPAIRS. APPARENTLY TENSIONER WAS KNOWN DEFECT BUT NEVER RECALLED.

I WAS DRIVING MY 07 CHEVROLET HHR @ 45 MPH WHEN THE DASH DISPLAY BLINKED THEN DISPLAYED ENGINE POWER REDUCED, FOLLOWED BY A SUBSTANTIAL REDUCTION OF SPEED. I COULDN'T ACCELERATE BEYOND 30 MPH, SO I PULLED OFF OF THE ROAD TO AVOID BEING HIT BY THE 18 WHEELER TRAVELING BEHIND ME. I TURNED THE ENGINE OFF AND BACK ON. THE CHECK ENGINE LIGHT CAME ON AND STAYED ON. I DROVE 15 MILES BACK HOME @ A SPEED OF 30 MPH. THE VEHICLE REFUSES TO ACCELERATE BEYOND 30 MPH

OUT OF NO WHERE, SPEED ODOMETER WENT TO FLASHING AND CAR WOULD NOT SPEED UP EVEN WHEN PUSHING THE GAS... HAD IT CHECKED AND WAS TOLD TO CHECK TO SEE IF THERE WAS A RECALL BECAUSE MECHANIC COULD NOT FIND ANYTHING WRONG WITH IT. IT STOPPED WORKING WHILE ON THE HIGHWAY, HAD TO TOW IT HOME BECAUSE WAS TOO SCARED TO TRY TO MAKE IT HOME. WHEN PUSHING THE GAS, YOU CAN FEEL IT LOSING POWER.

DRIVING AND PUSHED ON CLUTCH TO CHANGE GEARS , I HEARD A SNAP AND THE CLUTCH LOST ALL PRESSURE AND WENT TO THE FLOOR OF THE VEHICLE. UPON INSPECTION BY A MECHANIC , IT WAS DETERMINED THAT THE CLUTCH CYLINDER HAD PUNCHED THROUGH THE FIREWALL. THIS SHOULD NOT HAVE HAPPENED AND IS A MANUFACTURING DEFECT. I WAS DRIVING IN TRAFFIC AND THIS CAUSED THE CAR TO TURN OFF. IT COULD HAVE CAUSED A VERY SERIOUS ACCIDENT.

TL* THE CONTACT OWNS A 2007 CHEVROLET HHR. WHILE ATTEMPTING TO EXIT THE VEHICLE, THE DRIVER'S SIDE DOOR LATCH FAILED TO OPEN. THE CONTACT HAD TO EXIT THE VEHICLE THROUGH THE WINDOW. THE CONTACT ALSO STATED THAT PREVIOUSLY THE PASSENGER SIDE DOOR LATCH FAILED TO OPEN, AND THE CONTACT STOPPED USING THE DOOR. THE CONTACT WAS CONCERNED THAT SHE COULD INJURE HERSELF EXITING THROUGH THE WINDOWS AND, IF THE VEHICLE WERE TO LOSE POWER, THE WINDOWS WOULD FAIL TO OPERATE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT CALLED FERMAN CHEVROLET TARPON SPRINGS AT (727) 934-5789 (LOCATED AT 43520 US HWY 19 N, TARPON SPRINGS, FL 34689) WHERE IT WAS CONFIRMED THAT THERE WERE NO RECALLS ASSOCIATED WITH THE VIN AND THERE WOULD BE A FEE FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 175,000. *TT *TR

TL* THE CONTACT OWNS A 2007 CHEVROLET HHR. THE CONTACT STATED THAT WHILE ATTEMPTING A RIGHT TURN, THE VEHICLE ABNORMALLY ACCELERATED. THE CONTACT CRASHED INTO A RETAINING WALL AND ANOTHER VEHICLE. THE AIR BAGS FAILED TO DEPLOY AND THE SEAT BELT FAILED TO RESTRAIN THE CONTACT SECURELY. ADDITIONALLY, THE VEHICLE STALLED AND THE DOORS COULD NOT BE UNLOCKED. THE CONTACT BECAME TRAPPED IN THE VEHICLE. A POLICE REPORT WAS FILED OF THE INCIDENT. THE CONTACT SUSTAINED INJURIES TO THE KNEE, CHEST AND ARM. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 42,990. KMJ

TAKATA RECALL MY HORN DON'T WORK THE SERVICE AIRBAGS STAYS ON. THE STRUTS BACK HATCH DON'T OPEN CRUISE CONTROL DON'T WORK CHECKED ALL MY FUSES AND THEY ARE ALL GOOD

I PURCHASED THE CAR 5/13/14. SINCE THAT DATE THE CAR HAS BEEN "REPAIRED" 16 TIMES, BEGINNING ON 5/27/14 FOR ONGOING SUSPENSION PROBLEMS AND STEERING WHEEL/ELECTRICAL ISSUES. SUSPENSION ISSUES INCLUDED THE SWAY BAR, STABALIZER BAR AND BUSHINGS, DEFECTIVE STABLINK AND FROZED STRUT BEARING. REPLACED FRONT STRUTS. STEERING WHEEL ISSUES INCLUDED, REPLACING OF STEERING WHEEL COMPLETE DUE TO BAD WIRING, WIRING, WIRING HARNESS, SIR COIL REPLACED, SIR COIL CAUSING INTERFERANCE, REPLACED ENTIRE COLUMN, IGNITION SWITCH REPLACEMENT. THE CAR IS UNSAFE ON ANY ROAD IN MOTION. ENTIRE 14 PAGES OF SERVICE RECORDS AVAILABLE.

OUT OF NO WHERE, SPEED ODOMETER WENT TO FLASHING AND CAR WOULD NOT SPEED UP EVEN WHEN PUSHING THE GAS... HAD IT CHECKED AND WAS TOLD TO CHECK TO SEE IF THERE WAS A RECALL BECAUSE MECHANIC COULD NOT FIND ANYTHING WRONG WITH IT. IT STOPPED WORKING WHILE ON THE HIGHWAY, HAD TO TOW IT HOME BECAUSE WAS TOO SCARED TO TRY TO MAKE IT HOME. WHEN PUSHING THE GAS, YOU CAN FEEL IT LOSING POWER.

THE POWER STEERING WENT OUT MAKING IT UNABLE TO CONTROL THE VEHICLE MY 18 YEAR OLD SON WAS DRIVING AND COULD NOT STEER OR CONTROL THE VEHICLE CAUSING HIM TO WRECK AND DENTED THE CAR UP AND BUSTED THE OIL PAN LOCKING THE MOTOR UP JUST BY LUCK HE WAS NOT INJURED WE HAD TO HAVE IT TOWED HOME AND IT HAS SAT HERE CAUSE I CAN'T AFFORD A NEW MOTOR I AM VERY UPSET WITH THIS WHOLE ORDEAL I'VE BEEN OUT A LOT OF MONEY AND HAVE NO VEHICLE NOW PLUS MY SON WAS VERY TRAUMATIZED OVER THE WHOLE MATTER I TRULY LOVED THIS CAR NOW IT'S JUST WASTING AWAY AND I'M OUT A LOT OF MONEYNOT TO MENTION HAD PROBLEMS WITH THE WINDOWS ROLLING UP AND DOWN AND THE STEREO JUST QUIT WORKING AND THE BATTERIES I PUT IN IT KEPT GOING DEAD I'M TRULY UPSET OVER THIS

INSIDE DOOR HANDLE BROKEN CANT OPEN DOOR, ELECTRIC MIRROR SWITCH FELL INTO DOOR, BACK INDOOR PANEL FALLING OFF, LEAK THROUGH PASSENGER DOOR BEHIND FRONT PASSENGER. THESE ARE ONGOING ISSUES WITH OTHER HHR OWNERS AND NEED TO BE ADDRESSED. THE DOOR LATCH IS MADE OF VERY CHEAP PLASTIC. YOU CAN VERIFY WITH ALL YOUTUBE VIDEOS.

WAS BUCKLED IN THE CAR AND WHEN WE REACHED OUR DESTINATION THE FRONT PASSENGER SEATBELT WOULD NOT UNBUCKLE HAD TO CLIMB OUT OF SEAT BELT TO GET OUT OF CAR, THE SEATBELT JUST KEPT TIGHTENING AND IS STILL BUCKLED UP CAN NOT GET IT TO RELEASE.

PRIMEWELL VALERA SPORT AS 215/50R17X91W CRACK IN SIDEWALL.

FIREHAWK GTA 03. THESE TIRES ARE THE ORIGINAL FACTORY ISSUE ON MY 07CHEVY HHR. ALL 4 TIRES APPEAR TO HAVE THE SAME PROBLEM / DEFECT. THEY ARE ALL CRACKING ALONG THE OUTSIDE EDGE OF THE TREAD PATTERN. WHERE THE FLAT SURFACE OF THE TIRE MEETS THE SIDEWALLS. THE CRACKS ARE HARD TO SEE AT FIRST, BECAUSE THEY SO CLOSELY FOLLOW THE DEEPEST INDENTS OF THE TREADS. 2 OF THE 4 TIRES NOW HAVE A SLOW LEAK. THEY ARE AN ACCIDENT WAITING TO HAPPEN! TO DATE, NO ONE WANTS TO TAKE RESPONSIBILITY FOR THESE DEFECTIVE TIRES. CHEVY SAYS "TIRES' ARE COVERED BY MANUFACTURER'S WARRANTY. FIRESTONE SAYS THEY ARE NOT RESPONSIBLE FOR OEM PRODUCTS! WHAT A BUNCH OF FINGER-POINTERS! THESE TIRES NOW HAVE 43,100. MILES AND HAVE BEEN ROTATED EVERY 3-5 K ALONG WITH EACH OIL CHANGE. ON ANOTHER NOTE, THESE TIRES HANDLE POORLY IN MED.TO HEAVY RAINS. THEY WILL EASILY HYDRO-PLANE WITHOUT DUE CAUSE. *TR

MY CAR HAS THE SAME STERRING COLUMN AS IN THE COLBOLT I ONCE OWNED. THEY RECALLED MANY MAKES OF THE HHR FOR NEW COLUMNS. BUT NOT THE 2007 OR 2008. I HAVE REPLACED THE WIPER MOTOR ONCE BEFORE AND AFTRER 3 YEARS HAVE TO REPLACE AGAIN. ANY TIME THE TEMPERTURE GETS ABOVE 70 DEGREE, THE POWER STERRING GOES OUT. ALSO WHEN THE IGNITION SWITCH WAS RECALLED AND EXCHANGED, THE DEALERSHIP REFUSED TO RESET THE KEYLESS ENTRY KEY RINGS, SO CANNT USE MY AUTO STARTER, UNLOCK OR OPED MY DOORS, ESPECIALLY THE HATCH BACK. THERE IS NO WAY TO OPEN THAT DOOR, NO HANDLE, NO INNER BUTTON, NO PULL TO OPEN IT.

POWER STERRING IS GOING OUT JUST LIKE IT DID IN MY COLBOLT. BOTH ARE 2007. WIPER POWER DRIVE WENT OUT REPLACED THAT ON OUR OWN. WHEN DID THE IGNITION SWITCH, THE DEALERSHIP REFUSED TO RESET THE REMOTE CONTROLS, SAID RECALL WAS FOR SWITCH ONLY.

THE POWER STEERING LIGHT CAME ON AND THE CAR BECAME VERY DIFFICULT TO STEER AS I WAS DRIVING OUT OF A BUSINESS PARKING LOT. I PULLED TO THE SIDE AND TURNED OFF THE CAR. I RESTARTED THE CAR AND IT THE POWER STEERING LIGHT STAYED OFF AND THE POWER STEERING WORKED AGAIN. I CAUTIOUSLY DROVE HOME. THE CAR IS A 2007 CHEVROLET HHR WITH 153,000 MILES ON THE ODOMETER AND WE'VE OWNED THE VEHICLE SINCE IT WAS NEW.

TL* THE CONTACT OWNS A 2007 CHEVROLET HHR. AFTER STARTING THE VEHICLE, THE TRACTION SERVICE AND CHECK ENGINE WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN STATED THAT THE VEHICLE WAS OPERATING UP TO STANDARDS. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 66,000.

MY CLUTCH WENT OUT AND THE CAR STOPPED WORKING GAS I WAS DRIVING ALONG THE HIGHWAY. IT WAS NOT DURING A SHIFT, JUST ACCELERATION. THE CLUTCH DID THE EXACT SAME THING ON DECEMBER 23, 2013 (MILEAGE ABOUT 115,000). I HAVE DRIVEN MANUAL TRANSMISSIONS PREVIOUSLY AND HAVE GONE WELL OVER 100K MILES WITHOUT REPLACING THE CLUTCH AND I AM NOW ON MY 3RD CLUTCH. I KNOW THERE IS A TSB ON A POSSIBLE BAD FLYWHEEL (WHICH WAS NOT REPLACED EITHER TIME), BUT A CLUTCH TO GO OUT TWICE ON A CAR THAT HAS SEEN FOR THE LAST 55K ALMOST ALL HIGHWAY MILES INDICATES THERE IS A PROBLEM WITH THE CAR. *TR

KEY STUCK IN IGNITION, ABLE TO TURN CAR OFF, BUT WILL NOT TURN PAST ACC POSITION TO REMOVE KEY. CAR WILL SHIFT INTO PARK AND OUT AGAIN, BRAKE INTERLOCK STILL WORKS. *TR

I HAVE A PROBLEM WITH MY HEADLIGHTS MAINLY ON THE DRIVER SIDE I HAVE TO USE MY HIGH BEAMS IN ORDER TO SEE SOMETHING AND THAT'S WHEN I'M IN MOTION OR NOT. THEN NOW MY STEERING I DON'T KNOW WHAT'S WRONG WITH IT BUT I CAN START MY CAR UP AND I CAN DRIVE AND ALL THE SUDDEN MY STEERING WHEEL GETS HARD TO WHERE I CAN'T TURN IT, IT'S HARD TO TURN. MY ELECTRICAL IN MY VEHICLE IT IS VERY BAD MY RADIO KEEPS POPPING ON AND OFF. I HAVE TO HIT MY HEADLIGHTS TO KEEP THM ON AND IT KEEPS GOING ON AND OFF AND I'M GUESSING THIS DUE TO MY ELECTRICAL.

TL*THE CONTACT OWNS A 2007 CHEVROLET HHR. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE TURNING SIGNAL WARNING INDICATOR DID NOT WORK PROPERLY WHEN MAKING A TURN. THE CONTACT HAD TO MANUALLY TURN OFF THE WARNING SIGNAL INSTEAD OF IT TURNING OFF AUTOMATICALLY ONCE THE TURN WAS COMPLETED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 75,000.

GOT THE CAR BACK FROM A REPAIR TO THE COMPUTER SYSTEM, AND DROVE IT ABOUT TWO DAYS AND THE AC WENT OUT AND STARTED BLOWING HOT AIR, ON A 108 DEGREE TEXAS DAY! THE NEXT MORNING STARTED THE CAR TO GO TO THE DEALER AND THE AIR WAS COLD, BUT ABOUT A HALF HOUR INTO THE TRIP THE AIR WENT OUT AGAIN. SO WE TOOK CAR TO DEALER WHO SAID THEY WOULD CHECK IT OUT MAYBE THEY KNOCKED SOMETHING OFF WHEN THEY FIXED THE SENSORS. THE AIR WAS NOT WORKING WHEN WE DROPPED IT OFF, TECH SAID HE DROVE THE CAR TO LUNCH, LET IT IDLE AND PUT 30 MILES ON THE CAR AND THE AIR WORKED FINE, COME GET IT. *JB

POOR DESIGN OF THE FRONT BUMPER. THE HOLE ON THE BOTTOM WAS TOO BIG, ALLOWING DEBRIS TO HIT THE AIR CONDITIONER (A/C) CONDENSER AND RADIATOR. THIS WAS WHAT HAPPENED TO ME BUT THE FUNNY THING WA S THAT I WASN'T EVEN DRIVING THE CAR. I TURNED IT ON AND GOT THE AIR CONDITIONER GOING, WHICH WAS COLD AT FIRST. THE CAR SAT FOR A WEEK WHILE I WAS ON VACATION, SO I FOUND IT HARD TO BELIEVE THEY WON'T COVER IT AS A EQUIPMENT FAILURE. INSTEAD THEY CLAIMED SOMETHING FLEW THROUGH IT. CHEVROLET DIDN'T PUT A GRILL IN IT FROM THE FACTORY, WHICH WOULD HAVE SOLVED THE PROBLEM. WARRANTY WON'T COVER IT BECAUSE IT WAS CONSIDERED A ROAD HAZARD, AND WANTED ME TO CLAIM IT ON MY INSURANCE WHICH I THOUGHT WAS INSURANCE FRAUD. I THOUGHT THEY WANTED TO PASS THE BUCK TO SOMEONE ELSE RATHER THAN RECALL ALL THE VEHICLES TO PUT A GRILL ON IT TO PROTECT IT FROM THE ELEMENTS. I OWN A 2007 HHR WITH 6000 MILES ON IT. I DIDN'T HAVE AIR CONDITIONING BECAUSE THEY WON'T WARRANTY IT, AND I DIDN'T HAVE $800 TO FIX IT. THE GM REPRESENTATIVE CAME TO LOOK AT THE VEHICLE WHILE MY WIFE WAS AT THE DEALERSHIP SO SHE GOT TO TALK TO HIM ABOUT IT. HE SAID WELL IT WAS NO DIFFERENT THAN A ROCK HITTING THE WINDSHIELD. I THOUGHT THIS WAS THE LAZY WAY OUT, SAYING THEY DIDN'T WANT TO PROTECT VITAL PARTS OF THE CAR, (RADIATOR,CONDENSER,ETC. BY PUTTING A SIMPLE PIECE OF MESH OR GRILL IN PLACE. THIS SHOULDN'T BE OUR JOB TO MAKE SURE IT WA S PROTECTED. ALSO, THE REPRESENTATIVE STATED WELL,IF WE GET A LOT OF COMPLAINTS ABOUT IT THEN MAYBE THE DESIGNER WILL RECALL IT AND FIX IT. I COULD NOT WAIT FOR THEM TO GET OFF THE LAZY BOY AND FIX A FLAW THEY OVERLOOKED IN THE FIRST PLACE. I LOVE EVERYTHING ABOUT THE CAR, BUT CHEVROLET HAD TO GET THEIR HEAD OUT OF THEIR OWN BUTTS AND REALIZE THESE WERE THE REASONS WHY THEY WERE LOSING JOBS, AND STOCKS WERE FALLING, CAR SALES WERE DOWN, AND COMPETITION WA S GETTING STRONGER. THEY SHOULD BE MORE THAN HAPPY TO FIX THE PROBLEM. THEN I MIGHT GO BACK TO BUYING CHEVROLET CARS. *AK