2009 Chevrolet Hhr Electrical Problems

The contact owns a 2009 Chevrolet HHR. The contact stated that while starting the vehicle, there was an abnormal clicking sound coming from the vehicle. In addition, the contact stated that the passenger’s side air bag warning light illuminated and occasionally flashed on and off. The vehicle was taken to the dealer but was not diagnosed or repaired due to the cost. The contact had previously received notification of NHTSA Campaign Number: 14V047000 (AIR BAGS, ELECTRICAL SYSTEM) and the vehicle was repaired; however, the failure persisted. The manufacturer was not made aware of the failure. The failure mileage was approximately 199,000.

NHTSA ID

11673723

Incident

Sep 15, 2024

Mileage

199,000 mi

When driving my 2009 HHR the steering wheel shakes & vibrate at different intervals. Usually while slowing down to a stop & sometimes after during high speeds. Recently the noise it made was frightening. I had to use my emergency flashers & drive 50 mi per hr. on the freeway to arrive home safely. I took my car to Mark Chevrolet & reported it on 08/02/2021. The car's mileage was 133344. The car is not an everyday vehicle that is driven often. I received the car on 08/17/2021 after the steering column & shaft were replaced along with resurfacing front brake rotors & rear brake job. On August 18, 2021 while driving on the freeway I went to blow my horn at a hazardous situation & discovered none of the steering wheels controls were working, horn & etc. I immediately returned my car to Mark Chevrolet & reported their negligence & how they had risk my life to release the car without these functions working. They supposedly corrected the problem. On 07/05/2022 I had to return my car to Mark Chevrolet because I was experiencing the identical problem with my steering wheel vibrating & make noise. My cars mileage was only 137641 less than a year later with just 4,297 miles driven. They claimed to have tightened something up in the column & returned my car on 07/12/2022. As I was driving on 07/16/2022 again the steering wheel started vibrating & making strange loud noises. I felt so unsafe & tried to make it home safely driving at a reduced speed. I plan to return the car this week back to Mark Chevrolet and am asking for support to rectify this situation. I understand there was a recall on Chevrolet HHR 2009 Steering Electric Power Assist System. I don't know if this issue is related to that. I never received communication from General Motors stating that my vehicle was affected but apparently there is a problem. Please Help!

NHTSA ID

11474383

Incident

Jul 16, 2022

The contact owns a 2009 Chevrolet HHR. The contact stated that after parking, a popping noise was present coming from inside the cabin of the vehicle. The contact discovered flames coming from the interior roof dome lights. The contact used water to extinguish the flames. The cause of the failure was not determined. The local dealer was notified of the failure. The manufacturer was not notified of the failure. The failure mileage was 145,853.

NHTSA ID

11429903

Incident

Jul 28, 2021

Mileage

145,853 mi

The contact owned a 2009 Chevrolet HHR. The contact stated that a loud popping sound was heard after exiting the vehicle. The contact turned around and saw fire coming from inside the roof of the vehicle. The fire was coming from the rear interior roof light. The contact was able to put out the fire with water. No police report was filed. There was no injury sustained. The dealer and manufacturer were not made aware of the failure. The vehicle was not diagnosed nor repaired. The failure mileage was 145,385. The VIN was unavailable.

NHTSA ID

11426855

Incident

Jul 25, 2021

Mileage

145,385 mi

I was driving about 30 miles an hour in town when the check engine light started to Flash then immediately following all the dashlight started to Flash and then not a second later the car shut off the steering will locked the brakes locked up And all the doors were locked So at 30 miles an hour the brakes locked up the steering wheel locked so I couldn't turn the wheel and the car shut off There were no injuries thank God

NHTSA ID

11423118

Incident

Mar 30, 2021

MY STEERING WHEEL BEGINS TO VIOLENTLY SHAKE, ONSET ABOUT 10 MINUTES INTO DRIVING, SPEEDING UP OR BRAKING HAS NO EFFECT ON THE FREQUENCY OR LEVEL OF SHAKE. MY STEERING WHEEL WILL BE NORMAL, ABOUT 10 MINUTES INTO THE DRIVE, GOING THE SAME SPEED WILL BEGIN TO SHAKE. I CAN STOP AND PARK THE CAR, RESTART IT, WILL NOT SHAKE UNTIL I AM DRIVING AGAIN ABOUT 10 MINUTES INTO THE DRIVE. WHILE SHAKING, IT BECOMES VERY DIFFICULT TO MOVE THE STEERING WHEEL EVEN TO GET INTO THE NEXT LANE. THIS HAS HAPPENED WHILE CITY DRIVING, I AM TOO AFRAID TO TAKE IT ON THE HIGHWAY OR GO OVER 40 MPH AS I FEEL LIKE I HAVE NO CONTROL OF THE VEHICLE WHEN THE STEERING WHEEL SHAKES.

NHTSA ID

11407079

Incident

Apr 2, 2021

Mileage

105,000 mi

STARTED SMELLING SMOKE AND THE WHOLE VEHICLE SHUT DOWN WITH THE BEING STUCK ON IGNITION. COULDN'T OPEN THE DOORS AND SMOKE WAS BILLOWING OUT AND FIRE START COMING OUT OF LOWER MIDDLE CONSOLE. LUCKILY WAS ABLE TO OPEN DOOR AND EXIT VEHICLE. FIRE THEN ERUPTED AND QUICKLY TRAVELED STRAIGHT DOWN THE CENTER CONSOLE TO THE REAR OF THE CAR. WITHIN MINUTES THE CAR WAS TOTALLY ENGULFED IN FLAMES AND WAS COMPLETELY BURNED TO NOTHING. SUFFERED SEVERAL BURNS AND SMOKE INHALATION AND THE CAR AND EVERY THING IN IT WAS DESTROYED

NHTSA ID

11406550

Incident

Apr 4, 2021

Mileage

60,000 mi

MY CAR'S POWER STEERING HAS DANGEROUSLY DISAPPEARED WHILE I WAS DRIVING ON THE HIGHWAY. THE POWER STEERING CAME ON ON THE DASHBOARD AND I HAD TO STIR THE CAR WITH SO MUCH FORCE TO GET OFF THE HIGHWAY. I HAD MY 10-YEAR-OLD SON WITH ME ON HIS WAY TO SCHOOL. NO ONE KNOWS WHY THIS HAPPENED AND I CAN'T DRIVE IT WITH A 10-YEAR-OLD BOY WHO I HAVE TO GET TO SCHOOL AND MYSELF AND MY WIFE TO WORK. MECHANIC AFTER MECHANIC NO ONE CAN TELL WHY THE POWER STEERING WONT WORK. PLEASE HELP!

NHTSA ID

11403627

Incident

Mar 13, 2021

Mileage

189,000 mi

BRAKE LIGHTS REMAIN TO BE ON AS PEDAL IS NOT PRESSED AND ESC, TRACTION CONTROL DO NOT WORK ALSO THIS IS A HAZARD TO THE POINT WHERE I HAVE HAD ROAD RAGE AGAINST ME BECAUSE OF THE BRAKE LIGHTS NOT TURNING OFF ISSUE NEEDS TO BE RESOLVED THROUGH GM AS A RECALL ON THESE VEHICLES THIS IS NOT THE ONLY 2009 CHEVY HHR THAT HAS HAD THIS PROBLEM

NHTSA ID

11354570

Incident

Aug 16, 2020

Mileage

162,000 mi

THE SERVICE ECS DOES NOT GO OFF. THEIRFOR THE CAR WILL NOT GO UNLESS THE ROADS ARE COMPLETELY FREE OF SNOW AND ICE. THE CAR JUST SITS AND SPINS. TRACTION CONTROL LIGHT ON CONSTANTLY .CAN NOT DRIVE CAR IN WINTER MONTHS

NHTSA ID

11290454

Incident

Oct 1, 2017

Mileage

39,000 mi

CHEVROLET HHR 2009, DOORS MECHANISM. DOOR LATCHES STOP WORKING AND CAN OPEN AT A TURN OR WHILE DRIVING. OR LATCH CAN LOCK YOU IN UNABLE TO GET OUT OF VEHICLE IN AN ACCIDENT AND OR EMERGENCY. I WAS DRIVING HOME AND BACK DOOR FLEW WIDE OPEN I HAD NOT OPENED IT AT ALL BUT WHEN DOORS LOCK AND OPEN THEY ALL DO SO THE BACK LATCH OPENED NEVER CLOSING UNAWARE OF THIS THE DOOR FLEW OPEN ALMOST CAUSING AN ACCIDENT AT AN INTERSECTION.

NHTSA ID

11229155

Incident

Jun 6, 2019

Mileage

100,000 mi

FOR THE LAST MONTH MY ELECTRICAL SYSTEM HAS BEEN GOING HAYWIRE, ALL OF A SUDDEN ALL MY GAUGES START FLUCTUATING AND ALL SERVICE INDICATOR LIGHTS WILL COME ON AND AFTER THE CAR IS OFF FOR A WHILE ALL WARNING LIGHTS WILL GO OFF. THIS MORNING ON MY WAY TO WORK MY SECURITY LOCK AND ESC WARNING LIGHTS CAME ON AND WHEN I STOP AND START TO GO AGAIN THE CAR FEELS LIKE IT IS GETTING HIT FROM BEHIND. MY TWO REAR WINDOWS NO LONGER WORK, FRONT PASSENGER DOOR WILL NOT UNLOCK AUTOMATICALLY AND DRIVER DOOR HANDLE IS BROKEN. I HAVE SEEN A LOT OF ELECTRICAL ISSUES ON THIS SITE, YET THERE HAVE BEEN NO RECALLS. WHAT IS GOING ON??

NHTSA ID

11111836

Incident

Jul 17, 2018

Mileage

165,000 mi

TL* THE CONTACT OWNS A 2009 CHEVROLET HHR. WHILE DRIVING AT AN UNSPECIFIED RATE OF SPEED, THE CURTAIN AIR BAGS DEPLOYED WITH FORCE ON THE DRIVER'S AND FRONT PASSENGER SIDES. THE DRIVER'S HEARING WAS IMPACTED FOR DAYS AFTER THE AIR BAG DEPLOYMENT. A HEAD INJURY WAS SUSTAINED AND THE AIR BAGS HAD TO BE MANEUVERED FOR THE DRIVER TO EXIT THE VEHICLE. MEDICAL TREATMENT WAS NOT RECEIVED. THE VEHICLE WAS NOT DIAGNOSED; HOWEVER, OURISMAN CHEVROLET OF BOWIE (16610 GOVERNOR BRIDGE RD, BOWIE, MD 20716, (301) 262-7600) WAS CONTACTED. THE VEHICLE WAS PARKED AT THE CONTACT'S RESIDENCE. THE MANUFACTURER WAS TO INVESTIGATE THE FAILURE TO DETERMINE WHAT CAUSED THE AIR BAGS TO DEPLOY. A POLICE REPORT WAS NOT FILED. THE CONTACT AND THE DRIVER WERE WAITING FOR A RESPONSE FROM THE MANUFACTURER PERTAINING TO THE FAILURE AND TO ADDRESS NHTSA CAMPAIGN NUMBERS: 14V047000 (AIR BAGS, ELECTRICAL SYSTEM) AND 14V171000 (ELECTRICAL SYSTEM). THE FAILURE MILEAGE WAS NOT AVAILABLE. PARTS DISTRIBUTION DISCONNECT.

NHTSA ID

11063057

Incident

Dec 10, 2017

THE VAR JERKS WHEN IT REACHES GEAR CHANGES AND MAKES IT HARDER TO STEER AND THE CHECK ENGIN LIGHT STAYS ON. SHOWS ERROR CODE U0101

NHTSA ID

11047158

Incident

Jul 28, 2017

Mileage

1,088,223 mi

ONE NIGHT AFTER WORK I GOT INTO MY CAR AND HAD NO HEADLIGHTS AFTER HAVING BULB CHANGED THREE TIMES!!! THIS CAR HAS COST ME MORE MONEY THEN ANY CAR I HAVE EVER OWNED AND THERE'S NOT EVEN 100000 MILES ON IT THE WHOLE CAR SHOULD BE RECALLED

NHTSA ID

11021561

Incident

Aug 30, 2017

Mileage

80,000 mi

TL* THE CONTACT OWNS A 2009 CHEVROLET HHR. THE CONTACT STATED THAT THE KEY FOB WOULD INADVERTENTLY FUNCTION WHEN SHE ATTEMPTED TO OPEN THE VEHICLE DOORS. ALSO, THE HYDRAULIC FOR THE HATCHBACK WOULD CAUSE IT TO INDEPENDENTLY OPEN. THE CONTACT HAD TO USE A STICK TO KEEP THE HATCHBACK FROM CLOSING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 46,000.

NHTSA ID

10944643

Incident

Nov 30, 2016

Mileage

46,000 mi

THE ESC HAS GONE OUT AND THE TURN SIGNALS WORK, BUT NOW I HAVE TO TURN THEM OFF MANUALLY. THE IGNITION HAS BEEN REPLACED TWICE. ONCE WHEN IT WAS NEW BECAUSE THE IGNITION WOULD NOT TURN OFF. THE SECOND TIME WAS A RECALL. THE DIGITAL DISPLAY WHICH INCLUDES THE RADIO, AND INFORMATION SYSTEM TURNS ON AND OFF INTERMITTENTLY.

NHTSA ID

10934299

Incident

Nov 29, 2015

Mileage

32,000 mi

TL* THE CONTACT OWNS A 2009 CHEVROLET HHR. WHILE DRIVING 65 MPH, THE VEHICLE STALLED AND THE ESC WARNING INDICATOR ILLUMINATED. THE CONTACT MENTIONED THAT THE SECURITY LOCK WARNING INDICATOR ALSO ILLUMINATED. THE CONTACT HAD TO MAKE MULTIPLE ATTEMPTS OF TURNING THE IGNITION KEY BACK AND FORTH BEFORE THE VEHICLE RESTARTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS APPROXIMATELY 110,000.

NHTSA ID

10917376

Incident

Oct 18, 2016

Mileage

110,000 mi

TL* THE CONTACT OWNS A 2009 CHEVROLET HHR. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED A COMPLETE LOSS OF POWER. AFTER ATTEMPTING TO MANUALLY RESTART THE VEHICLE, THE CONTACT STATED THAT THE KEY COULD NOT BE TURNED TO START THE VEHICLE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V171000 (ELECTRICAL SYSTEM); HOWEVER, THE RECALL COULD NOT BE PERFORMED BECAUSE THE TECHNICIAN COULD NOT REMOVE THE IGNITION CYLINDER. THE CONTACT WAS INFORMED THAT, IN ORDER TO REMEDY THE FAILURE, THEY WOULD HAVE TO FRACTURE AND DETACH THE HOUSING AT THE CONTACT'S EXPENSE. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE FAILURE MILEAGE WAS 138,000. PARTS DISTRIBUTION DISCONNECT. THE VIN WAS NOT PROVIDED.

NHTSA ID

10914511

Incident

Oct 5, 2016

Mileage

138,000 mi

TL* THE CONTACT OWNED A 2009 CHEVROLET HHR. THE CONTACT STATED THAT WHILE DRIVING AT 45 MPH, THE VEHICLE STALLED AND THE STEERING WHEEL SEIZED WITHOUT WARNING. AS A RESULT, THE CONTACT CRASHED INTO A TREE. THE CONTACT STATED THAT THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED INJURIES TO THE HEAD, A FRACTURED ARM, AND A FRACTURED FEMUR THAT REQUIRED MEDICAL ATTENTION. THE CONTACT ALSO STATED THAT ON SEVERAL OCCASIONS, THE VEHICLE FAILED TO START. THE CONTACT STATED THAT THE REVERSE GEAR FAILED TO ENGAGE WHEN THE SHIFT SELECTOR WAS PLACED INTO THE REVERSE POSITION. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 54,285.

NHTSA ID

10850291

Incident

Oct 10, 2009

Mileage

54,285 mi

TL* THE CONTACT OWNS A 2009 CHEVROLET HHR. WHILE DRIVING 45 MPH, THE CONTACT NOTICED THAT THE AIR BAG WARNING LIGHT BECAME ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 119,000.

NHTSA ID

10810471

Incident

Dec 13, 2015

Mileage

119,000 mi

TL* THE CONTACT OWNS A 2009 CHEVROLET HHR. ON SEVERAL OCCASIONS, THE VEHICLE WOULD NOT START AND A BURNING ODOR WAS PRESENT INSIDE THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHO WAS UNABLE TO DIAGNOSE THE CAUSE OF THE FAILURES. NO FURTHER INFORMATION WAS AVAILABLE. THE MANUFACTURER WAS NOTIFIED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 26,000.

NHTSA ID

10809391

Incident

May 1, 2015

Mileage

26,000 mi

MY 2009 HHR HAS WHAT IS REFERRED TO AS THE MAY 15, 2014 GM TAIL LIGHT MALFUNCTION. THE MALFUNCTION IS CAUSED FROM FAULTY WIRING AND CAUSES THE BRAKE LIGHTS ILLUMINATE WITHOUT TOUCHING THE BRAKE PEDAL AND THEY REMAIN ON WHILE DRIVING. THIS MALFUNCTION ALSO DISABLES SAFETY FEATURES LIKE ELECTRONIC STABILITY CONTROL ' WHICH TRIES TO CORRECT FOR SKIDS ' AND PANIC BRAKING ASSIST, WHICH IS DESIGNED TO MAKE SURE THE VEHICLE'S FULL BRAKING POWER IS BEING USED IN AN EMERGENCY. IT ALSO DISABLES THE CRUISE CONTROL AND THE TRACTION CONTROL. IN 2014 G.M. SAID IT KNEW OF HUNDREDS OF COMPLAINTS AND 13 ACCIDENTS ASSOCIATED WITH THE PROBLEM. I HAVE HAD SEVERAL NEAR ACCIDENTS AND SEVERAL ISSUES OF ROAD RAGE FROM OTHER DRIVERS SINCE MY HHR BEGAN THE MALFUNCTIONING IN FEBRUARY 2014 WHICH IS WHEN I FIRST CONTACTED GM TO GET IT FIXED. SINCE THEN I HAVE FILED COMPLAINTS WITH THE NHTSA, THE FEDERAL TRADE COMMISSION, THE STATE OF WISCONSIN CONSUMER PROTECTION AGENCY AND GM BUT HAVE NOT YET HAD ANYONE STEP UP AND FIX THE PROBLEM. SINCE THE MALFUNCTION CAUSES THE BCM TO LOSE MEMORY WITH THE BRAKE POSITIONING SENSOR I DID TAKE THE VEHICLE TO A CERTIFIED GM DEALERSHIP AND HAD THEM RE-LEARN THE MEMORY BETWEEN THE TWO. THIS SOLVED THE PROBLEM TEMPORARILY AND LASTED ABOUT TWO MONTHS. I CANNOT AFFORD TO HAVE THIS DONE EVERY TWO MONTH AS A SOLUTION. GM NEEDS TO BE ORDERED TO FIX THE ISSUES CORRECTLY BEFORE SOMEONE IS FATALLY INJURED.

NHTSA ID

10806821

Incident

Feb 1, 2014

CAR WOULD NOT CRANK, REPLACED BATTERY,HAD ALTERNATOR AND STARTER TESTED ALL GOOD. HAD TO HAVE VEHICLE TOWED TO VEHICLE REPAIR SHOP. NOW THE PART THAT IS NEEDED IS NOT AVAILABLE NEW SO NOW MY MECHANIC HAS WENT THROUGH THREE PARTS THAT HAVE NOT WORKED. IT HAS TO DO WITH THE FUSE BOX. WHY HASN'T THIS VEHICLE NOT BEEN RECALLED IF CHEVROLET NO LONGER MAKES THIS PART? I SEE A LOT OF HHRS ON THE ROAD AND SOONER OR LATER THESE CARS WILL HAVE THE SAME PROBLEM. THIS SAME VEHICLE HAD STALLED ON ME BEFORE AND THE CHEVROLET DEALERSHIP COULD NOT FIND THE PROBLEM .I STILL OWE FOR A VEHICLE THAT CANNOT BE FIXED. SOMEBODY PLEASE HELP GET THIS CAR RECALLED.

NHTSA ID

10784974

Incident

Oct 15, 2015

Mileage

120,000 mi

WHILE DRIVING THE CAR THERE ARE POWER/ELECTRICAL SURGES. I HAVE DOCUMENT THIS SEVERAL TIMES. THE LEFT REAR TAIL LIGHTS REPEATEDLY BURNS OUT, IT DOESN'T JUST BLOW, IT CRACKS AND MELTS. TO THE POINT IT LITERALLY MELTS THE HOLDER OF THE BULB. THE SURGES ARE MORE FREQUENT. I HAVE TO CHANGE BURNT/ LITERALLY EXPLODED BULBS EVER 3-4 DAYS. AND I HAVE CALLED THE CHEVY DEALER AND THEY HAVE TOLD ME THIS IS ELECTRICAL. THE POWER SURGES CAN HAPPEN ANYTIME WITH OUT NOTICE. I CALLED THE DEALERSHIP AND I WAS INFORMED THAT THERE WAS A RECALL ON ELECTRICAL SYSTEM FOR A CHEVY HHR BUT THAT MY VIN NUMBER WAS NOT LISTED IN THIS BATCH OF RECALLS FOR ELECTRICAL SYSTEM MALFUNCTIONS. I ALSO CALLED THE CHEVY HEADQUARTERS AND THEY INFORMED ME ITS MY ISSUE, THERE IS NO RECALL FOR MY CAR FOR THIS AND ITS NOT COVERED UNDER WARRENTY. SO I ASKED IM JUST TO KEEP DRIVING A CAR THAT HAS ELECTRICAL SURGES, WHAT IF IT SURGES TO THE GAS TANK OR SOMETHING. SHE SAID ITS NOT COVERED. SO, I WANT IT FORMALLY DOCUMENTED THAT A REPORT WAS ISSUED; SINCE IT IS HAPPENING ALL THE TIME. I HAVE GOTTEN PULLED OVER TWICE IN 2 MONTHS FOR THIS LIGHT. AND THERE IS NOTHING I CAN DO ABOUT IT. . THESE SURGES HAVE BEEN HAPPENING OVER THE PAST YEAR, I WAS TOLD THAT MAY BE THE REASON THAT MY PASSENGER SEAT BELT LOCKED UP ( CAUSING ME TO HAVE TO CUT MY DAUGHTER OUT OF IT) AND THE REASON THE WINDOWS WILL SOMETIME STOP OPERATING. BUT WILL EVENTUALLY START BACK.

NHTSA ID

10759055

Incident

Jun 20, 2015

Mileage

125,000 mi