2006 Chevrolet Malibu Maxx Brakes Problems

TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU MAXX. THE CONTACT STATED THAT THE VEHICLE WOULD JERK UPON DEPRESSION OF THE BRAKE PEDAL WITHOUT WARNING. THE CONTACT TOOK THE VEHICLE TO JIM KERAS CHEVROLET (2000 COVINGTON PIKE, MEMPHIS, TN 38128) WHERE THEY PERFORMED SERVICES TO THE BRAKE BOOSTER, MASTER CYLINDER, HYDRAULIC BRAKE SYSTEM, LOWER CONTROL ARMS, AS WELL AS SEVERAL OTHER UNKNOWN SERVICES. THREE WEEKS AFTER THE REPAIRS, THE VEHICLE WOULD NOT START AND THE VEHICLE WAS TOWED TO THE RESIDENCE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 241,404.

NHTSA ID

11413026

Incident

Jul 6, 2020

Mileage

241,404 mi

RIGHT AFTER I BOUGHT THE VEHICLE I WAS DRIVING DOWN A GRAVEL ROAD AND MY TRACTION CONTROL, ABS AND BRAKE LIGHT ALL CAME ON AT THE SAME TIME AND WILL NOT SHUT OFF. MY TRACTION CONTROL NO LONGER WORKS NOW.

NHTSA ID

11165760

Incident

Jan 15, 2017

Mileage

211,344 mi

BRAKE LIGHTS STAY ON ALL OF THE TIME EXCEPT WHEN FOOT IS RESTING ON THE BRAKE PEDAL. HAVE TRIED TO CHANGE OUT THE BRAKE SENSOR AND THAT DOESN'T SEEM TO RESOLVE THE PROBLEM. BRAKE LIGHTS ARE ONE BOTH IN MOTION OR WHEN CAR IS JUST SITTING

NHTSA ID

11162283

Incident

Dec 3, 2018

Mileage

158,000 mi

TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU MAXX. WHILE DRIVING APPROXIMATELY 50 MPH, THE CONTACT DEPRESSED THE BRAKE PEDAL TO STOP THE VEHICLE, BUT THE BRAKES FAILED AND THE VEHICLE SLID. IN AN EFFORT TO AVOID REAR ENDING THE PRECEDING VEHICLE, THE CONTACT TURNED TO THE LEFT. THE ABS, TRACTION CONTROL, AND BRAKE WARNING INDICATORS ILLUMINATED. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED, BUT THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 200,200.

NHTSA ID

11104256

Incident

Jun 15, 2018

Mileage

200,200 mi

I HAVE HAD PROBLEMS WITH MY POWER STEERING OVER THE YEARS. BUT THIS WAS THE WORST IT HAS EVER BEEN. I WAS DRIVING 55 MPH ON THE HIGHWAY. THE ROADS WERE CLEAR ON THIS SPRING DAY. MY TRACTION CONTROL, BRAKE LIGHT AND CHECK ENGINE LIGHT CAME ON. THEN THE POWER STEERING WAS CHIMING AND THE ALERT CAME ON FOR THAT WHICH EFFECTED MY POWER STEERING. THE INSTRUMENT CLUSTER WAS FLASHING ON AND OFF ALONG WITH THE GAUGES NOT WORKING CORRECTLY. THEN THE INSTRUMENT CLUSTER WENT COMPLETELY OUT. SO THE INSTRUMENT CLUSTER WAS REPLACED. A COUPLE OF WEEKS LATER, THIS ALL REPEATED AGAIN. SO THIS TIME THE IGNITION WAS REPLACED. AFTER ALL THAT, THE POWER STEERING STILL CHIMES AND ALERTS STILL COME ON WHICH MAKES IT HARDER TO STEER. THEN I HAVE TO STOP THE CAR, TURN IT OFF, WAIT AND RESTART IT. THEN IT IS FINE FOR A WHILE. MY MECHANIC SAYS THE ONLY CODE THAT SHOWS UP IS FOR THE 14772 RECALL. BUT MY CAR IS NOT PART OF THAT RECALL SINCE IT WAS MANUFACTURED IN JANUARY OF 2006. PLEASE DO SOME RESEARCH AND EXPAND THE CURRENT RECALL TO INCLUDE ALL 2006-2007 CHEVROLET MALIBU AND MALIBU MAXX VEHICLES. REPAIRS NEED TO BE DONE ON THESE VEHICLES ASAP TO ANY FATAL OR POTENTIAL CRASHES.

NHTSA ID

10749604

Incident

May 23, 2012

Mileage

151,000 mi

AS I DROVE FROM RACINE, WI TO MILWAUKEE, WI. TO VISIT FAMILY FOR THE 4TH OF JULY WEEKEND AS I WAS TO TURN CAR OFF TO PARK I WASNT ABLE TO PRESS DOWN ON THE BREAKS, COULDNT GO INTO PARK, GEAR SHIFT WAS STUCK COULDNT MOVE IT IN TO PARK HAD TO PUT ON EMERGENCY BREAK IN ORDER TO KEEP CAR IN PARK! IT LEFT ME STRANDED WAS VERY UPSET & CONFUSED!!!

NHTSA ID

10734971

Incident

Jul 4, 2015

Mileage

173,000 mi

2006 CHEVROLET MALIBU. CONSUMER WRITES IN REGARDS TO BODY CONTROL MODULE CONNECTION SYSTEM RECALL NOTICE AND CUSTOMER REIMBURSEMENT REQUESTS FORM ISSUES. *SMD

NHTSA ID

10703668

Incident

Oct 23, 2013

END OF JULY 2014, EARLY MORNING, WHILE DRIVING 70MPH ON THE INTERSTATE WITH CLEAR DRY CONDITIONS, MY BRAKES BEGAN TO PULSE ON THEIR OWN AND THE TRACTION CONTROL LIGHT BEGAN LIGHTING UP IN CORRESPONDENCE WITH THE BRAKE PULSE.. THE CRUISE CONTROL SHUT ITSELF OFF. THE CHECK ENGINE LIGHT AND BRAKE LIGHT CAME ON REMAIN ON AND CRUISE CONTROL NO LONGER WORKS. THIS CONTINUES TO HAPPEN THROUGHOUT THE ENTIRETY OF MY 60MILE ONE WAY DAILY DRIVE. I WAS NOTIFIED OF RECALL13036 WHICH INCLUDES ALL OF THESE ISSUES., I TOOK THE VEHICLE IN FOR A SCHEDULED SERVICE FOR THIS 12/12/14. AFTER WAITING MORE THAN 2 HOURS TO GET MY VEHICLE BACK (WITHOUT THE RECALL WORK BEING DONE), I RESCHEDULED FOR 12/16/14. AFTER COMPLETING THE RECALL WORK THE VEHICLE WAS RETURNED TO ME WITH ALL ERROR CODES CLEARED. LESS THAN 3 MILES DOWN THE ROAD, ALL OF THE ISSUES RETURNED. NO CRUISE CONTROL, PULSING BRAKES AND T/C LIGHT, CHECK ENGINE LIGHT AND BRAKE LIGHT CAME ON AND REMAIN ON. I CONTACTED THE DEALERSHIP AND THEY TOLD ME THAT THEY SIMPLY ADDED LUBRICANT TO CONNECTIONS AND THAT ALL OF THESE ISSUES ARE NOT ASSOCIATED WITH THE RECALL. I READ THE RECALL NOTICE TO THEM, IT CLEARLY STATES ALL OF THESE ISSUES ARE RELATED TO THE RECALL. THE DEALERSHIP (PETE HARKNESS/MORRISON,IL) RECOMMENDS THAT I BRING IT BACK IN AGAIN AND PAY $90.00 FOR A DIAGNOSTIC CHECK AND THEN I WILL NEED TO PAY FOR ANY REPAIRS NEEDED. *TR

NHTSA ID

10664845

Incident

Jul 30, 2014

Mileage

147,000 mi

TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU MAXX. THE CONTACT STATED THAT SHE ATTEMPTED TO HAVE HER VEHICLE REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 14V224000 (POWER TRAIN) AND NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM , ELECTRONIC STABILITY CONTROL , EXTERIOR LIGHTING , SERVICE BRAKES, HYDRAULIC , VEHICLE SPEED CONTROL) BUT WAS INFORMED THAT THE PARTS WERE NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIRS. THE MANUFACTURER WAS NOTIFIED OF THE DELAY. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

NHTSA ID

10626098

Incident

Aug 18, 2014

I HAVE RECEIVED TWO RECALL NOTICES IN THE PAST TWO MONTHS, ONE FOR THE ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL; AND THE OTHER FOR THE TRANSMISSION SHIFT CABLE, WHICH MAY FRACTURE AT ANY TIME. BOTH NOTICES INFORMED ME THAT THE DEALER WOULD PERFORM REPAIRS AT NO COST, BUT THAT PARTS ARE NOT CURRENTLY AVAILABLE. AM I TO CONTINUE DRIVING MY DEFECTIVE CAR AND HOPE THAT I WON'T GET INTO AN ACCIDENT CAUSED BY THE ABOVE PROBLEMS? I AM VERY LOW INCOME AND CAN'T AFFORD TO RENT A CAR. *TR

NHTSA ID

10625887

Incident

Aug 16, 2014

Mileage

56,000 mi

CRUISE CONTROL STOPPED WORKING, REMOTE START STOPPED WORKING, BRAKE LIGHTS COME ON WHEN PEDAL IS NOT PRESSED AND GO OFF WHEN PEDAL IS PRESSED. VEHICLE SHOWS STOPPING WHEN DRIVING AND DRIVING WHEN STOPPING. WILL GET REAR-ENDED SAME THING HAPPENED 3 YEARS AGO. GM TECHNICAL SERVICE BULLETIN #08-05-22-009C ISSUED IN 2008. *TR

NHTSA ID

10607147

Incident

Jun 26, 2014

Mileage

51,000 mi

LETTER FROM SENATOR NELSON ON BEHALF OF CONSTITUENT REGARDING STEERING PROBLEMS ON HER 2006 CHEVROLET MALIBU; PLEASE SEND RESPONSE DIRECTLY TO SENATOR OFFICE AND REFERENCE CONSTITUENT. *SMD THE CONSUMER STATED THE FRONT BRAKE CALIPERS FAILED TO RETRACT CAUSING THE BRAKES TO OVERHEAT AND CATCH FIRE. THE MECHANIC STATED IT MAY HAVE BEEN DUE TO A FACTORY FLAW AS HE HAD NEVER SEEN BOTH CALIPERS FAIL TOGETHER. THE BRAKE CALIPER SEALS WERE MELTED FROM HEAT AND THEY WERE CRACKED/DRY ROTTED LETTING THE CALIPER SLEEVE RUST. A MONTH PRIOR, THE CONSUMER NOTICED THE POWER STEERING SEEMED STIFF AND THE VEHICLE BECAME DIFFICULT TO STEER, THE CONSUMER DID RECEIVE A RECALL NOTICE REGARDING A POTENTIAL PROBLEM WITH THE STEERING. ON DECEMBER 20, 2011 THE CONSUMER EXPERIENCED ANOTHER STEERING FAILURE, SLOW ACCELERATION, AND OVERHEATING OF THE BRAKES. THE VEHICLE WAS TOWED TO THE DEALER, WHERE THE MECHANIC BELIEVED THERE WAS PROBABLY CONTAMINATION IN THE BRAKE FLUID, AS IT WAS MILKY. THE MECHANIC RECOMMENDED THAT ALL THE RUBBER COMPONENTS IN THE BRAKE AND ABS BE REPLACED DUE TO THE CONTAMINATION. *JB

NHTSA ID

10587989

Incident

Oct 4, 2010

Mileage

8,759 mi

TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU MAXX. THE CONTACT STATED THAT THE POWER STEERING WARNING LIGHT ILLUMINATED THEN THE VEHICLE BECAME DIFFICULT TO STEER. THE CONTACT ALSO MENTIONED THAT THE IGNITION WARNING LIGHT SPORADICALLY ILLUMINATED AT VARIOUS SPEEDS AND THERE WAS AN ABNORMAL METAL ODOR IN THE CABIN. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS FOUND THAT THE STEERING COLUMN AND RACK AND PINION WAS REPLACED. THE CONTACT WAS ALSO INFORMED THAT THE REAR BRAKE CALIPERS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 128,000. UPDATED 7/7/14*CN UPDATED 07/14/2014 *JS

NHTSA ID

10587210

Incident

May 6, 2009

Mileage

128,000 mi

DRIVING FROM SCHOOL SAW A CAR AHEAD PERSON HAD TURN SIGNAL ON TO GO LEFT. TOOK FOOT OFF GAS WENT TO BRAKE AND TURN WHEEL COULD NOT DO EITHER. THE CAR WAS TOTALED. *TR

NHTSA ID

10576892

Incident

Nov 14, 2013

Mileage

135,000 mi

WE PURCHASED OUR 2006 MAILBU MAXX IN NOVEMBER 2005. TWO MONTHS LATER THERE WAS A VIOLENT SHAKE IN THE FRONT END, THE DEALERSHIP TURNED THE ROTORS BECAUSE THEY WERE WARPED. THEN WE STARTED HAVING TROUBLE WITH THE ELECTRICAL SYSTEM RIGHT AFTER THE WARRANTY RAN OUT.THE REAR WIPER COMES ON BY ITSELF, INTERIOR LIGHTS BLOW CONSTANTLY AS WELL AS HEADLIGHTS. DOOR LOCKS WORK WHEN THEY WANT TO. KEYLESS HAS NOT WORKED FOR THREE YEARS EVEN WITH NEW REMOTE BATTERIES. SINCE THE CAR HAS HAD 40,000 MILES ON IT THE POWER STEERING HAS BEEN ACTING UP. MY WIFE HAS HIT OUR GARBAGE CANS AND EVEN MY TRUCK PULLING INTO THE DRIVEWAY. WE CANT EVEN TRADE THIS PIECE OF CRAP IN BECAUSE EVERYBODY KNOWS THE PROBLEMS WITH THIS CAR. OUR MALIBU HAS 78,000 MILES ON IT AND WE HAVE PUT 4 SETS OF BRAKES ON THE FRONT WITH HEAVY DUTY ROTORS AND THREE SETS ON THE REAR. GM IS NOT CONCERNED WITH THE SAFETY OF THEIR CUSTOMERS. THIS CAR IS CRAP AND THEY KNOW IT. WE SHOULD AT LEAST GET 200 PERCENT OVER TRADE IN VALUE TO PURCHASE ANOTHER VEHICLE. LIKE A ROCK....MORE LIKE A TURD!!!!! *TR

NHTSA ID

10463333

Incident

Jun 10, 2006

Mileage

6,000 mi

STEERING- WHEN MAKING LEFT TURNS STEERING COLLUMN POPS AS IF LINKAGE IS SLIPPING. APPARENTLY A KNOWN DEFECT AT CHEVROLET. STEERING COLUMN SHOULD BE REPLACED. LOSS OF POWER STERRING IN THE PAST AT HIGHER SPEEDS, ONE COMPLETE LOCKUP OF STEERING WHEEL WHILE VEHICLE WAS IN MOTION. BRAKES- INCREASINGLY DIFFICULT OVER TIME TO SLOW VEHICLE TO A STOP SAFELY. BRAKES WERE COMPLETELY REPLACED AT 51K MILES DUE TO AN ISSUE OF WEAR AT RATES EXCEEDING MECHANICAL ESTIMATES. DEALERSHIP INSPECTION YIELDS NO DAMAGES OR PROBLEM YET TEST DRIVE SHOWS HOW DIFFICULT VEHICLE IS TO STOP EFFECTIVELY.

NHTSA ID

10429733

Incident

Oct 1, 2011

Mileage

69,789 mi

2006 CHEVROLET MALIBU MAXX. CONSUMER STATES BRAKE FAILURE AND INCREASED ACCELERATION *TGW THE CONSUMER STATED AS SHE MADE A RIGHT TURN INTO A PARKING SPACE, SHE APPLIED THE BRAKE PEDAL, AND IT WENT ALL THE WAY TO THE FLOOR WHICH RESULTED IN THE HER CRASHING INTO A CONCRETE PILLAR. THE CONSUMER ALSO STATED THE AIR BAGS DID NOT DEPLOY. THE CONSUMER STATED SHE HAD A SECOND ACCIDENT WHERE SHE APPLIED THE BRAKES AND THEY FAILED TO RESPOND WHICH CAUSED HER TO CRASH INTO ANOTHER VEHICLE. *JB

NHTSA ID

10334869

Incident

Nov 22, 2006

FILING A COMPLAINT REGARDING MY 2006 CHEVY MALIBU MAXX...WHAT IS A SAFETY-RELATED DEFECT? THE UNITED STATES CODE FOR MOTOR VEHICLE SAFETY (TITLE 49, CHAPTER 301) DEFINES MOTOR VEHICLE SAFETY AS ?THE PERFORMANCE OF A MOTOR VEHICLE OR MOTOR VEHICLE EQUIPMENT IN A WAY THAT PROTECTS THE PUBLIC AGAINST UNREASONABLE RISK OF ACCIDENTS OCCURRING BECAUSE OF THE DESIGN, CONSTRUCTION, OR PERFORMANCE OF A MOTOR VEHICLE (THE STEERING COLUMN IS A GENUINE GM DEFECTIVE PART(S), AND AGAINST UNREASONABLE RISK OF DEATH OR INJURY IN AN ACCIDENT, AND INCLUDES NONOPERATIONAL SAFETY OF A MOTOR VEHICLE.? A DEFECT INCLUDES ?ANY DEFECT IN PERFORMANCE, CONSTRUCTION, A COMPONENT, OR MATERIAL OF A MOTOR VEHICLE OR MOTOR VEHICLE EQUIPMENT.? GENERALLY, A SAFETY DEFECT IS DEFINED AS A PROBLEM THAT EXISTS IN A MOTOR VEHICLE OR ITEM OF MOTOR VEHICLE EQUIPMENT THAT: POSES AN RISK TO MOTOR VEHICLE SAFETY, AND MAY EXIST IN A GROUP OF VEHICLES OF THE SAME DESIGN OR MANUFACTURE, OR ITEMS OF EQUIPMENT OF THE SAME TYPE AND MANUFACTURE. EXAMPLES OF DEFECTS CONSIDERED SAFETY-RELATED STEERING COMPONENTS THAT BREAK SUDDENLY CAUSING PARTIAL OR COMPLETE LOSS OF VEHICLE CONTROL. * THE ABOVE LISTED UNITED STATE VEHICLE SAFETY CODE IS THE REASON FOR THIS COMPLAINT BEING FILE. I UNDERSTAND THAT CHEVY USED THE SAME COLUMN UNIT IN ITS 2004, 2005 AND 2006 MALIBU MODELS AND ALL THREE YEARS ARE EXPERIENCING THE SAME PROBLEM. ONCE ODOMETER REACHES A CERTAIN MILEAGE READING THE STEERING COLUMN ELECTRONIC ASSISTED STEERING COLUMN FAILS, IT TURNS OFF, LEAVING THE DRIVER AT THE MERCY OF A MANUALLY HARD TO STEER VEHICLE, IN MY WIFE AND MINE'S CASE IT IS A METAL DEATH TRAP ON THE ROAD WHEN MAKING A RIGHT HAND TURN. I HAVE WRITTEN DIRECTLY TO CHEVY/GM MOTOR CORPORATION WITH OUT RECOGNITION OF MY COMPLAINT. THIS CAR IS A LARGE ROAD SAFETY ISSUE AND NEEDS TO BE ADDRESSED IMMEDIATELY. I WANT CHEVY TO BUY MY CAR BACK OF REPLACE THIS VEHICLE. PLEASE HELP!! I DON'T WANT TO DIE IN THIS VEHICLE, NOR LOOSE MY WIFE. *TR

NHTSA ID

10266158

Incident

Feb 1, 2009

WE HAD THE BRAKES SERVICED . IT INCLUDED THE CHANGING OVER THE BRAKE PADS AND THE ROTORS TURNED. AND IN LESS THAN 8MONTHS LATER WE WENT BAKE TO GET THE BRAKES INSPECTED DUE TO A VERY HIGH PITCHED NOISED THAT GREW SINCE THE BRAKES WE REPLACED WITH NEW ONES. THE MECHANIC INFORMED US THAT THE BACK BRAKES VERSES THE FRONT BRAKES WE NOT WEARING EQUALLY AND THAT HE WAS SHOCKED TO DISCOVER THAT BOTH FRONT AND BACK BRAKES WERE REPLACED AT THE SAME TIME. I KNOW FOR A FACT THAT THEY WERE REPLACED AS I SAT AND WATCHED THE PREVIOUS MECHANIC INSTALL OUR NEW BRAKE PADS/SHOES JUST AFTER 7 MONTHS OF BUYING THE VEHICLE. THE FRONT BRAKES HAD A WEARING OF 30% AND THE REAR WORE DOWN TO 70%. THIS IS BECOMING A NIGHTMARE AND IT'S ALSO BECOMING VERY EXPENSIVE.. I JUST WANT TO KNOW HOW IT IS POSSIBLE TO NEED NEW BRAKES ON AVERAGE OF HALF A YEAR BETWEEN CHANGES. THIS IF NOT LOOKED INTO COULD BECOME EXTREMELY DANGEROUS AND IS DANGEROUS IF THE BACK BRAKES A WEARING OUT FASTER THAN THE FRONT. THEN I HAVE TO CHANGE THE BRAKES OUT EVERY 6-7-MONTHS JUST TO KNOW THAT I WILL BE ABLE TO STOP THE CAR WHEN NEEDED! THE HORRIBLE SCREECHING SOUND I DISCOVERED IS THE ROTORS AND THE MECHANIC VERY SHOCKED TO SEE THAT THEY ARE WARPED AND IN SUCH BAD SHAPE AFTER SUCH A SMALL AMOUNT OF TIME BETWEEN THE BRAKE CHANGES WITHIN A 6-7 MONTH TIME PERIOD. WE HAVE ONLY ONE WORKING VEHICLE AND FEEL THAT IS ISSUE IS TO BE ADDRESSED AS IT IS A HUGE SAFETY CONCERN. I CAN NOT KEEP CHANGING THE BRAKE SYSTEM EVERY 6-7MONTHS YET I HAVE NO CHOICE IF WE ARE TO BE SAFE AND WOULD LIKE TO STOP THE CAR. PLEASE FIND OUT IF THE PROBLEM CAN BE CORRECTED ONCE AND FOR ALL TO WHERE WE ONLY HAVE TO CHANGE THE BRAKES ON THE CAR LONGER THAN A YEAR OR MORE ESPECIALLY WHEN WE DRIVE THE CAR EASY... WE ARE NOT BAD DRIVERS YET WE ARE TERRIFIED THAT WE WILL NOT BE ABLE TO STOP AT ANY GIVEN MOMENT AS I AM SURE WE WILL NEED A BRAKE CHANGE AGAIN IN JUST A FEW MONTHS AGAIN! BATTERY IN THE KEYPAD OPENS,LOCKS & STARTS CAR NEVER WORKS RIGHT... *TR

NHTSA ID

10255923

Incident

Nov 10, 2007

Mileage

40,000 mi

I HAD TO REPLACE BRAKES AND ROTORS TWICE WITH IN THE LAST YEAR. *TR

NHTSA ID

10234233

Incident

Mar 22, 2008

Mileage

28,000 mi

2006 CHEVROLET MALIBU MAXX SS, ALL FOUR ROTORS HAD TO BE RESURFACED/TURNED TO WARPING AT 10,000 MILES. CAR CURRENTLY HAS 18,500 MILES. *TR

NHTSA ID

10234154

Incident

Apr 10, 2007

Mileage

10,000 mi

HAVE OWNED THE VEHICLE FOR 14 MONTHS AND I AM GETTING READY TO REPLACE THE ROTORS AND BRAKE PADS FOR THE THIRD TIME. AFTER ONLY A FEW MONTHS, YOU CAN FEEL THE BRAKES PULSING, WORSE AT SOFT BRAKING THAN HARD. I'VE ALSO HAD THE ROTORS TURNED AND PUT BACK ON ONCE AND THE PROBLEM RETURNED IN LESS THAN A MONTH. *TR

NHTSA ID

10231402

Incident

Jun 10, 2008

Mileage

53,000 mi

BRAKE PADS WORN OUT (ALL 4) AFTER ONLY 17,000 MILES, ROTORS WARPED. CHEVROLET WARRANTY WILL NOT COVER THIS EVEN THOUGH IT WAS LOW MILEAGE (LESS THAN 2 YEARS OLD OF VEHICLE). CONTINUE TO WORK WITH LOCAL DEALER FOR REPAIR WORK. *TR

NHTSA ID

10206583

Incident

Sep 7, 2007

Mileage

17,300 mi