2003 Chevrolet Malibu Body & structure Problems

100% OF BRAKE LINES FAILED VIA RUST ALSO, CONTROL ARMS FRONT/REAR SEVERELY RUSTED.

NHTSA ID

10819334

Incident

Jun 17, 2014

Mileage

84,000 mi

TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. THE CONTACT STATED THAT THE KEY WAS ABLE TO TURN TO THE ON POSITION IN THE IGNITION, BUT WOULD NOT TURN COMPLETELY TO START THE VEHICLE. THE FAILURE OCCURRED ON SEVERAL OCCASIONS. AN INDEPENDENT MECHANIC REPLACED THE IGNITION SWITCH, BUT THE FAILURE RECURRED. THE VEHICLE STALLED. THE VEHICLE WAS ABLE TO RESTART AFTER SEVERAL ATTEMPTS. THE CONTACT WAS LATER INFORMED THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM), BUT THE PART NEEDED FOR THE REPAIR WAS UNAVAILABLE. THE DEALER DID NOT PROVIDE A SPECIFIC DATE FOR WHEN THE REMEDY WOULD BECOME AVAILABLE. THE MANUFACTURER WAS NOTIFIED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 57,000. UPDATED 11/05/14*LJ *JS

NHTSA ID

10633268

Incident

May 1, 2014

Mileage

56,586 mi

I WAS TRAVELING ON A SNOWY/ICY ROAD WHEN I LOST CONTROL OF MY VEHICLE AT ABOUT 50 MPH. MY VEHICLE WENT SIDEWAYS UNTIL TRAVELING INTO A DITCH AT WHICH POINT THE VEHICLE COLLIDED WITH A TREE. THE FRONT END WAS COMPLETELY DESTROYED AND PUSHED THE MOTOR BACK A GOOD 2 FEET. MY HEAD SLAMMED INTO THE WINDSHIELD AND AIRBAGS WERE NOT DEPLOYED. THE IMPACT OF THE FRONT END WAS JUST A LITTLE OFF CENTER TO THE PASSENGER SIDE. *TR

NHTSA ID

10558124

Incident

Dec 15, 2013

Mileage

130,000 mi

WHILE DRIVING ON THE FREEWAY I WAS REAR ENDED AND PUSHED INTO THE CENTER DIVIDER AND BOUNCED OFF ONLY TO BE STRUCK AGAIN FROM THE REAR. THE FRONT AND REAR QUARTER PANELS WERE DAMAGED THE FRAME WAS COMPROMISED. MY COMPLAINT IS THAT THE AIRBAGS NEVER DEPLOYED. I SUFFERED BACK, ARM, LEG & KNEE INJURIES IN THE COLLISION. THE CAR HAS BEEN TOTALED BY MY INSURANCE COMPANY BUT I AM STILL CURIOUS AS TO WHAT HAPPENED TO THE SAFETY AIR BAGS. *TR

NHTSA ID

10485916

Incident

Oct 31, 2012

Mileage

123,000 mi

TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. WHILE DRIVING APPROXIMATELY 25 MPH, THERE WAS A LOSS OF CONTROL IN THE STEERING. THE CONTACT WAS ABLE TO REGAIN FULL CONTROL OF THE VEHICLE AND CONTINUED TO DRIVE WITH CAUTION. THERE WAS A NEARBY INDEPENDENT MECHANIC WHO INSPECTED THE VEHICLE AND STATED THE SUB FRAME WAS FRACTURED DUE TO CORROSION. IN ADDITION, BOTH FRONT COIL SPRINGS FRACTURED. THE VEHICLE WAS IN THE PROCESS OF BEING REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

NHTSA ID

10425608

Incident

Sep 11, 2011

Mileage

100,000 mi

TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START INTERMITTENTLY. IN ORDER TO START THE VEHICLE, THE CONTACT WOULD HAVE TO TURN THE KEY TO THE ON POSITION AND ALLOW IT TO SIT IN THE IGNITION FOR APPROXIMATELY 10 MINUTES WHILE THE VEHICLE WOULD RESET ITSELF. IN ADDITION, THE REAR TAIL LIGHTS WOULD BECOME FILLED WITH WATER WHENEVER IT WOULD RAIN, CAUSING THE BULBS TO BLOW. THE MANUFACTURER WOULD NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE CURRENT AND FAILURE MILEAGE WAS APPROXIMATELY 100,000.

NHTSA ID

10351537

Incident

May 9, 2010

Mileage

100,000 mi

WHEN DRIVING AFTER A RAIN NOTICED THERE WAS WATER IN RIGHT REAR TAILLIGHT. WHEN TRYING TO START THE CAR THE ONLY WAY TO GET IT STARTED WAS TO DISCONNECT THE NEGATIVE BATTERY TERMINAL AND RESET THE COMPUTER . WELL THAT WAS GREAT EXCEPT YOU MIGHT NOT WANT THE CAR STARTED THEN BECAUSE EVERYTIME YOU STEP ON THE BRAKE THE RADIO SHUT OFF, GAUGES WOULD PEG OUT AND NOT BE ABLE TO BE RESET. THEN CAR WOULD DIE IN THE MIDDLE OF HIGHWAY DRIVING . IF IT TAKES THE NHSTA TO HAVE A DEATH FOR SOMEONE I AM NOT THE ONE IF IT IS WATER THE CAR DOESN'T LIKE I WILL SEND IT BACK TO DETROIT WHERE THEY CAN PUT IT IN IT'S FINAL RESTING PLACE, LAKE MICHIGAN. LET OUR VOICES BE HEARD BECAUSE THESE SMALL INCONVENIENCES TO THEM ARE MAJOR EXPENSES TO US ALL . AND THEY WONDER WHY THE CAR INDUSTRY IS STRUGGLING OWN UP TO THE PROBLEM GENERAL MOTORS. *NM

NHTSA ID

10168213

Incident

May 23, 2006

Mileage

70,000 mi

DRIVER SIDE ARM REST CRACKED WITHOUT WARNING. THE PART HAD BEEN REPLACED ONCE BEFORE. *AK PLASTIC THAT HELD THE ARM REST WAS DEFORMED AND WEAK INSIDE THE ARM REST. DEALER REPLACED DRIVER'S DOOR ARM REST ASSEMBLY. *LA

NHTSA ID

10067293

Incident

Apr 5, 2004

Mileage

35,500 mi

WATER LEAKED INSIDE THE REAR TAIL LIGHT INTO THE TRUNK AREA AND CAUSED A BAD ODOR AND MOLD TO GROW INSIDE THE TRUNK. PLEASE PROVIDE ANY ADDITIONAL INFORMATION. THE DEALER IS AWARE OF THE PROBLEM. *NLM

NHTSA ID

10012043

Incident

Mar 18, 2003