2003 Chevrolet Malibu Brakes Problems

TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE HIS WIFE WAS DRIVING 25 MPH AND APPROACHING A RED TRAFFIC LIGHT, THE BRAKE PEDAL WAS DEPRESSED HOWEVER, THE VEHICLE CONTINUED TO ACCELERATE. THE VEHICLE WENT THROUGH THE INTERSECTION. THE CONTACT'S WIFE PLACED THE VEHICLE IN NEUTRAL, ALLOWING THE VEHICLE TO SLOW DOWN AND EVENTUALLY STOP. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 52,481.

NHTSA ID

11395774

Incident

Dec 31, 2020

Mileage

52,481 mi

TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. WHILE DRIVING 25-30 MPH, THE BRAKE PEDAL WAS DEPRESSED AND TRAVELED TO THE FLOORBOARD. THE VEHICLE CAME TO A STOP AFTER AN EXTENDED PERIOD OF TIME. AFTER THE VEHICLE WAS PARKED OVERNIGHT, THE CONTACT NOTICED EXCESSIVE BRAKE FLUID LEAKING UNDERNEATH THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE BRAKE LINES WERE RUSTED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. NEITHER THE DEALER NOR THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 95,000. THE VIN WAS NOT AVAILABLE.

NHTSA ID

11093615

Incident

May 11, 2018

Mileage

95,000 mi

TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. THE CONTACT STATED THAT THE BRAKE SYSTEM FAILED. WHILE THE BRAKE PEDAL WAS DEPRESSED, THE BRAKE SYSTEM FAILED TO ENGAGE AND THE VEHICLE VIBRATED. THE CONTACT HAD TO ENGAGE THE EMERGENCY BRAKE TO BRING THE VEHICLE TO A STOP. THE CONTACT ALSO MENTIONED THAT THE KEY HAD TO BE RELEASED FROM THE IGNITION WITH FORCE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES AND STATED THAT THERE WERE NO OPEN RECALLS. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 37,000.

NHTSA ID

11019279

Incident

Aug 22, 2017

Mileage

37,000 mi

100% OF BRAKE LINES FAILED VIA RUST ALSO, CONTROL ARMS FRONT/REAR SEVERELY RUSTED.

NHTSA ID

10819334

Incident

Jun 17, 2014

Mileage

84,000 mi

THIS HAS HAPPENED FIVE TIMES NOW, I AM DRIVING AND THE ENGINE JUST SHUTS OFF, I CAN NOT BRAKE I CAN NOT STEER, I STILL HAVE LIGHTS ON THE DASHBOARD. IT HAPPENS WHEN I AM GONG ABOUT 20 TO ABOUT 35 MILES PER HOUR. I AM AFRAID TO DRIVE ON THE HIGHWAY. I DO NOT KNOW IF IT WILL HAPPEN AT A HIGHER SPEED! IT DID IT THE FIRST TIME BACK IN JUNE 2015 MY DAUGHTER WAS DRIVING, THEN AGAIN LAST FRIDAY AUGUST 7TH FOUR MORE TIMES WITH IN 10MINUTES AND A FEW MILES APART. IT IS LIKE SOMEONE JUST TURNED THE CAR OFF WHILE I AM DRIVING?

NHTSA ID

10748075

Incident

Aug 7, 2015

Mileage

59,480 mi

TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. THE CONTACT STATED THAT THE VEHICLE FAILED TO START AND THE KEY WOULD NOT EJECT FROM THE IGNITION. THE DEALER REPAIRED THE VEHICLE ACCORDING TO A RECALL FOR THE IGNITION SWITCH, BUT THE FAILURE RECURRED. THE CONTACT ALSO STATED THAT THE BRAKE LIGHTS FAILED TO ILLUMINATE AND THE AIR CONDITIONER DID NOT FUNCTION. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES. THE NHTSA CAMPAIGN NUMBER WAS UNKNOWN. THE FAILURE MILEAGE WAS 33,345.

NHTSA ID

10733789

Incident

Jul 13, 2015

Mileage

33,345 mi

COMPUTER PROBLEM 2003 CHEVY IMPALA 6 CYL FRONT WHEEL DRIVE AUTOMATIC 130000 MILES THIS RECENTLY STARTED, THE TRACTION ON LIGHT AND THE ABS YELLOW LIGHTS ON DASH STAY ON. RARELY DO THEY GO OFF, ONLY A FEW TIMES. THE SQUARE INDICATOR LIGHT SAYS "SERVICE TRACTION CONTROL" LIGHT COMES ON WHEN I START THE VEHICLE, STAYS ON FOR 1-2 MINUTES THEN GOES OFF. BUT THE TRACTION CONTROL LIGHT AND THE ABS LIGHT REMAINS ON. HOW CAN I RESET THIS OR WHAT TO NOT HAVE A TRIP TO THE EXPENSIVE AUTO REPAIR SHOP. I HAVE NO PROBLEM WITH THE ABS BRAKES TO OPERATE CORRECTLY, NO DELAYS OR BRAKE HESITATION WHEN I PRESS THE BRAKE PEDAL IN USE. HELP ME OUT WITH A GOOD SOLUTION. I WILL GREATLY APPRECIATE YOUR RESPONSE.

NHTSA ID

10726120

Incident

Jun 18, 2015

Mileage

130,000 mi

CAR WILL NOT START. SOLID "THEFT" LIGHT COMES ON DASHBOARD AND CAR WILL NOT TURN OVER, OR IF IT TURNS OVER, WILL CUT OUT SHORTLY AFTER. THIS ANTI-THEFT ISSUE CAUSES THE POWER STEERING AND BRAKES TO DISABLE, AND AM NOT ABLE TO TURN THE STEERING WHEEL. HAVE ALSO HAD CAR STALL OUT IN TRAFFIC AND LOSE ALL POWER. HAD TO HAVE CAR TOWED SEVERAL TIMES DUE TO THE ISSUE. I HAVE TRIED SEVERAL FIXES AND MECHANICAL REPAIRS, BUT THIS ISSUE CONTINUES TO GET WORSE. NO MATTER WHAT I TRY AND DO, AT RANDOM TIMES, MY CAR WILL NOT START, WHILE THE "THEFT" LIGHT COMES ON AND COMPLETELY DISABLES MY VEHICLE. AND SOMETIMES WHILE DRIVING, THE CAR JUST SHUTS OFF. I AM THE ORIGINAL OWNER OF THE VEHICLE, AND AM USING AN ORIGINAL KEY TO START THE CAR. I DO NOT HAVE ANY TYPE OF SECURITY SYSTEM INSTALLED IN MY CAR. THERE IS NO REASON FOR THE "THEFT" LIGHT TO COME ON WHEN I AM JUST TRYING TO START MY VEHICLE, NOT STEAL IT. THE IGNITION RECALL FOR MY SPECIFIC VEHICLE ONLY INVOLVES REPLACING THE KEYS, BUT THIS ANTI-THEFT ISSUE, WHICH I AND OTHER CHEVROLET MALIBU OWNERS ARE EXPERIENCING, IS A SERIOUS SAFETY ISSUE THAT COULD CAUSE A CRASH OR OTHER ACCIDENT TO OCCUR IF IT CAUSES THE CAR TO CUT OUT (LOSE POWER) FOR NO REASON WHILE DRIVING, AND AT THE SAME TIME DISABLING THE STEERING AND BRAKING SYSTEMS. THIS SHOULD DEFINITELY BE A SAFETY RECALL. *JS

NHTSA ID

10690707

Incident

Nov 10, 2014

Mileage

76,300 mi

THE CAR SHUT OFF WITH NO WARNING WHILE DRIVING ON THE ROAD. THIS WAS A TOTAL SHUT-DOWN OF THE CAR; INCLUDING THE LOSS OF POWER STEERING AND THE FUNCTIONALITY OF THE BRAKE BOOSTER. THE CAR AFTERWARDS BECOMES DIFFICULT TO START. IT MAY TAKE SEVERAL TRIES OR A PROLONGED WAITING PERIOD UNTIL THE CAR WILL WANT TO START. AFTER IT DOES START THERE'S NO TELLING IF IT WILL SHUT OFF AGAIN WHILE DRIVING. IT HAS SHUT OFF WHILE GOING THROUGH TURNS, AND PULLING OUT INTO TRAFFIC. *TR

NHTSA ID

10678177

Incident

Jun 5, 2014

Mileage

110,000 mi

I TELL DEALER CHECK ENGINE LIGHT ON "HE SAYS NOT TO BE CONCERNED THERE IS WHITE SMOKE COMING FROM TAILPIPE IGNITION CAN TAKE UP TO 5 MIN TO GET ON CODE SAYS CAR NEEDS EGR VALVE CAR NEEDED BRAKES AND ROTORS ALL THE WAY AROUND AND TYROD DEALER WILL NOT RESPOND TO CALLS CAR WAS RECALLED FOR IGNITION SWITCH NEVER REPAIRED I NEED TO KNOW IF I CAN TAKE IT IN TO CHEVY DEALER ONY HAD 1 MONTH VEHICLE IS NOT SAFE AND I AM 76 THERE IS A WARANTY ON ENGINE AND TRANSMISSION. *TR

NHTSA ID

10664000

Incident

Nov 4, 2014

Mileage

264,000 mi

2003 CHEVROLET MALIBU. CONSUMER STATES VEHICLE STALLS. *TGW THE CONSUMER STATED THE FUEL PUMP, BATTERY AND REMOTE CONTROL WERE ALL REPLACED. HOWEVER, THE STALLING CONTINUED. THE IGNITION SWITCH WAS EVENTUALLY REPLACED. ALSO, T HE BRAKES AND STRUTS NEEDED TO BE REPLACED. *JB

NHTSA ID

10648098

Incident

Apr 1, 2014

I WAS DRIVING NEAR MY HOME WHEN A TURKEY RAN OUT IN FRONT OF MY VEHICLE FROM THE LEFT. I WAS LOOKING TO THE RIGHT AS I APPROACHED MY DRIVEWAY. I SAW THE TURKEY OUT OF THE CORNER OF MY EYE AND I STEPPED HARD ON MY BRAKES BECAUSE I WAS UNABLE TO IMMEDIATELY IDENTIFY THE ANIMAL. MY BRAKE PEDAL WENT STRAIGHT TO THE FLOOR AND, AFTER STOPPING COMPLETELY, I DISCOVERED THAT MY DRIVER SIDE BRAKE LINE HAD RUPTURED. I TOOK THE VEHICLE TO A REPAIR SHOP AND WAS INFORMED THAT ALL OF MY BRAKE LINES NEEDED TO BE REPLACED. I WAS TOLD THAT THIS BRAKE LINE FAILURE OCCURRED BECAUSE THE LINES WERE SUSCEPTIBLE TO CORROSION CAUSED BY ROAD SALT. *TR

NHTSA ID

10639892

Incident

Jul 2, 2014

Mileage

110,000 mi

TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. WHILE DRIVING VARIOUS SPEEDS, THE ENGINE RPMS SUDDENLY INCREASED AND THE DRIVER WAS UNABLE TO APPLY THE BRAKES. THE DRIVER HAD TO CRASH INTO A CURB IN ORDER TO STOP THE VEHICLE. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNAVAILABLE.

NHTSA ID

10637574

Incident

Sep 19, 2014

TL* THE CONTACT OWNS A 2003 CHEVROLET MALIBU. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 35 MPH, THE BRAKES FAILED WITHOUT WARNING. THE VEHICLE CONTINUED TO ACCELERATE WHILE THE BRAKES WERE APPLIED, CAUSING THE CONTACT TO CRASH INTO ANOTHER VEHICLE. THERE WERE NO INJURIES AND A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 29,332. UPADATED 06/24/14 MA UPDATED 06/30/2014 *JS

NHTSA ID

10579556

Incident

Apr 12, 2014

Mileage

29,332 mi

WHEN IT RAINS THE TAIL LIGHTS FILL UP WITH WATER AND THE LIGHTS DO NOT WORK CORRECTLY. AND SOMETIMES THEY DO NOT WORK AT ALL. IT HOLDS WATER AND THE LIGHTS FLASH IN A CHRISTMAS TREE LIGHT MANNER. ALSO WHEN THE BREAKS ARE STEPPED ON THE BLINKERS DO NOT WORK. ALSO WHEN YOU STEP ON THE BREAK THE BLINKER INDICATORS ON THE INSTRUMENT PANEL REMAIN LIT UP GREEN. I HAVE REPLACE BULBS AS WELL AS THE WHOLE LIGHT HOUSING. EVEN DRILLED WHOLES IN THE BOTTOM OF THE LIGHT HOUSING UNITS SO THE WATER CAN DRAINED. NOTHING CAN REMEDY THIS PROBLEM IT IS VERY DANGEROUS. *TR

NHTSA ID

10532045

Incident

Feb 12, 2013

Mileage

87,001 mi

AFTER MY 2003 CHEVROLET MALIBU HAD BEEN PARKED IN THE SUN FOR A WHILE, ON A SHORT TRIP OF 4 MILES, THE CAR STARTED REVVING UP AND TAKING OFF ON IT'S ON. IT ALSO CAUSED MY A/C HOSE TO BURST (I AM CONVINCED IT IS RELATED). I TOOK IT TO DEALER FOR REPAIR AND THEY CLEANED THE THROTTLE AND REPLACED THE A/C HOSE. THERE IS STILL THE SAME PROBLEM. IT SEEMS AS THOUGH IT HAPPENS WHEN IT IS VERY HOT WEATHER AND I AM MAKING SHORT TRIPS RUNNING ERRANDS WHICH CALLS FOR TURNING ENGINE OFF AND RESTARTING. I DROVE BACK HOME WITH MY FOOT ENTIRELY ON THE BRAKES WHILE TRYING TO KEEP THE CAR FROM RUNNING OUT OF CONTROL. I AM VERY RELUCTANT TO DRIVE IT NOW, UNTIL I CAN FIND SOMEONE TO "REALLY" FIX THE PROBLEM (AS I WAS STUCK WITH A $487 REPAIR BILL). *TR

NHTSA ID

10525974

Incident

Aug 1, 2012

Mileage

61,000 mi

THE BRAKES DEVELOPED POOR BRAKING AT SPEEDS OVER 35 MPH THE FRONT END WOULD SHIMMY WHEN APPLIED. TWICE REPLACING THE BRAKE PADS AND RESURFACING OF THE ROTORS FAILED TO CORRECT THE PROBLEM. REPLACEMENT OF THE FRONT DISK ROTORS THAT WOULD NOT WRAP WITH USE CORRECTED THE PROBLEM GM FAILED TO COVER THE REPAIRS UNDER WARRANTY. *TR

NHTSA ID

10449326

Incident

May 5, 2004

Mileage

3,500 mi

TL*THE CONTACT OWNS A 2003 CHEVROLET MALIBU. WHILE DRIVING APPROXIMATELY 10 MPH, THE CONTACT STATED THAT HE APPLIED PRESSURE TO THE BRAKES; HOWEVER, HE RECEIVED NO RESPONSE. THE BRAKES WOULD MAKE A SQUISHING NOISE WHEN PRESSURE WAS APPLIED, AS IF AIR WAS ESCAPING. THE MANUFACTURER INFORMED THE CONTACT THAT THEY WOULD REVIEW HIS COMPLAINT AND HE WAS WAITING FOR A RESPONSE. THE VEHICLE WAS NOT REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 69,000.

NHTSA ID

10382798

Incident

Feb 1, 2011

Mileage

69,000 mi

TL*THE CONTACT OWNS A 2003 CHEVROLET MALIBU. ON MAY 25, 2008, WHILE DRIVING 40 MPH, THE VEHICLE BEGAN ACCELERATING FASTER THAN NORMAL. THE CONTACT HAD TO MERGE OUT OF TRAFFIC. SHE COULD NOT FEEL THE BRAKES WORKING AND SPED THROUGH A STOP SIGN. SHE DROVE INTO A PARKING LOT TO AVOID CRASHING INTO OTHER VEHICLES. THE VEHICLE FINALLY STOPPED WHEN IT CRASHED INTO AN EMBANKMENT. THE FRONT DRIVER'S SIDE AIR BAG FAILED TO DEPLOY. THE VEHICLE WAS TAKEN TO THE BODY SHOP TO REPLACE THE DRIVER'S SIDE DOOR AND HEADLAMP. THE MANUFACTURER STATED THAT AN INVESTIGATOR WOULD INVESTIGATE THE FAILURE. THEY ARE CURRENTLY STATING THAT DUE TO THE BODY WORK THAT WAS PERFORMED ON THE VEHICLE, THEY WILL NOT INVESTIGATE THE ACCELERATION FAILURE, ONLY THE AIR BAG FAILURE. THE CONTACT HAS A BACK INJURY THAT WAS AGGRAVATED DUE TO THE CRASH. A POLICE REPORT WAS FILED. THE FAILURE AND CURRENT MILEAGES WERE 24,000.

NHTSA ID

10230863

Incident

May 25, 2008

Mileage

24,000 mi

I HAD TO REPLACE THE BRAKES ON THIS CAR AT 6,000 MILES. SINCE THEN, I HAVE HAD TO REPLACE THEM ON A YEARLY OCCURRENCE, AS WELL AS ROTORS AND WHEEL BEARINGS. THE BREAKS ALWAYS SOUND LIKE THEY ARE GRINDING AND VIBRATING. I HAVE HAD ISSUES WITH THE ABS LIGHT COMING ON. IT HAS BEEN 7 MONTHS SINCE I HAD THE ROTORS REPLACED, AND I NEED NEW BREAKS AGAIN. *TR

NHTSA ID

10229680

Incident

Apr 23, 2004

BRAKE LIGHTS WERE NOT WORKING. *AK

NHTSA ID

10185605

Incident

Dec 27, 2005

I BOUGHT MY MALIBU NEW IN SEPTEMBER 2003. IN JANUARY 2005, I BEGAN TO NOTICE THE CAR SHUDDERING WHILE BRAKING, I TOOK THE CAR IN AND THEY MACHINED BOTH ROTORS, I TOOK IT IN AGAIN ON FEBRUARY 8TH BECAUSE THE BRAKES WERE MAKING A CHATTER AND CLANK SOUND, THEY TOLD ME THE CALIPERS NEEDED TO BE LUBRICATED, I BROUGHT IT BACK ON FEBRUARY 18 FOR THE LUBRICATION. NEXT I TOOK THE CAR IN FOR A OIL CHANGE ON MARCH 29TH AND ASKED THE TECHNICIAN TO CHECK THE BRAKES AND WAS TOLD THEY WERE FINE. ON JULY 1ST 05 I TOOK THE CAR IN AGAIN BECAUSE OF A BRAKE SQUEAL AND FOUND THE RETAINING BOLT /PIN ON THE LEFT FRONT CALIPER WAS MISSING. IT WAS REPLACED AS WELL AS THE BOLT/PIN ON THE UPPER BOLT/PIN DUE TO THE INTEGRITY OF THE ORIGINAL BOLT/PIN. ON SEPTEMBER 30TH 05 I TOOK THE CAR IN AGAIN FOR BRAKE NOISE, AND WAS TOLD THAT BOTH ROTORS WERE RUSTED, BOTH ROTORS WERE TURNED AND CLEANED AT THAT TIME. ON OCTOBER 12TH 05 WHICH WAS ONLY 8 DAYS LATER I TOOK THE CAR BACK AGAIN BECAUSE THE CAR WAS STILL MAKING A GRINDING NOISE. WHEN INSPECTED THE FRONT ROTORS WERE AGAIN FOUND TO BE RUSTY, PITTED AND WORN, THIS TIME THEY REPLACED BOTH THE ROTORS AND THE BRAKE PADS. I TOOK THE CAR IN ON NOVEMBER 23RD 05 FOR RECOMMENDED 15 MAX SERVICE WHICH INCLUDED A REAR BRAKE ADJUSTMENT, I ASKED THEM TO CHECK THE FRONT BRAKES AGAIN, BECAUSE THEY WERE STILL SQUEAKING AND THEY SAID THEY WERE FINE. MAY 25TH,06 I TOOK THE CAR IN AGAIN FOR BRAKE NOISE, THEY FIRST TOLD ME THE CALIPERS AGAIN NEEDED TO BE LUBRICATED , BUT THEN CAME BACK AND SAID THEY NEEDED TO BE REPLACED. NOW IT IS JULY OF 06 AND I AM STILL HAVING PROBLEMS WITH THE BRAKES. ALSO ON JULY 5TH, 06 I HAD TO TAKE THE CAR IN BECAUSE THE A/C AND THE RECIRCULATION MODE STOPPED WORKING, THEY REPLACED A BAD HVAC CONTROL MODULE. *NM

NHTSA ID

10161775

Incident

Jan 3, 2005

DT*: THE CONTACT STATED THE ABS WARNING LIGHT ILLUMINATED AND THE DEALERSHIP REPLACED THE DRIVER SIDE WHEEL SPEED SENSOR. SIX MONTHS LATER, THE ABS WARNING LIGHT ILLUMINATED AGAIN, THE DEALERSHIP DETERMINED THE PASSENGER SIDE WHEEL SPEED SENSOR NEEDS TO BE REPLACED. UPDATE 2/24/2006 - THE CONSUMER PREVIOUS VEHICLE, A 2000 CHEVROLET MALIBU, ALSO HAD THE SAME BRAKE WHEEL SPEED SENSOR FAILURE. *NM

NHTSA ID

10148838

Incident

Jan 25, 2006

Mileage

65,000 mi

2003 CHEVY MALIBU HAS HAD RECURRING BRAKE PROBLEMS FOR THE LAST 10,000 MILES IT HAS 33,000 MILES . BRAKES WOULD GRAB AND VIBRATE THE FRONT END. FINALLY WAS TOLD THAT IT NEEDED NEW ROTORS AND PADS, IT IS DRIVEN ON A REGULAR BASIS AND FROM ALL THE OTHER BRAKE COMPLAINTS I READ ABOUT THIS NEEDS TO BE INVESTIGATED. *JB

NHTSA ID

10143523

Incident

Nov 23, 2005

Mileage

22,600 mi

ANTI -LOCK BRAKE LIGHT (ABS) IS ON AND THE ABS SOMETIMES ACTIVATES WHEN THE USING THE BRAKES AT A SLOW SPEED. *JB

NHTSA ID

10134810

Incident

Aug 24, 2005

Mileage

42,000 mi