2004 Chevrolet Malibu Brakes Problems

The Grumman LLV was hit by the driver of the Chevy Malibu. The Grumman LLV had seatbelt issues with impact. The LLV was forced over on two wheels with left side impact from the driver of Chevy Malibu. [XXX] was the driver of the USPS Grumman LLV at the time of accident sustaining neck injuries requiring medical attention. Multiple medical procedures paid out of pocket followed to include surgeries The driver of Chevy Malibu was injured and received coverage by State Farm insurance. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11579145

Incident

Jan 5, 2013

POWER STEERING UPON IGNITION LIGHTS UP AND LOCKS POWER STEERING. TURN OFF AND RESTART SEVERAL TIMES BEFORE OPERATIONAL. ABS LIGHT INTERMITTENTLY COMES ON WHILE DRIVING. ELECTRIC ASSIST POWER STEERING. BOTH IN STATIONARY AND WHILE DRIVING IN CITY AND HIGHWAY.

NHTSA ID

11408197

Incident

Apr 12, 2019

Mileage

50,000 mi

TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS, THE BRAKE PEDAL WAS DEPRESSED HOWEVER, THE BRAKE LIGHTS FAILED TO ILLUMINATE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE MECHANIC DETERMINED THAT THE BRAKE MODULE NEEDED TO BE REPLACED. PORTER CHEVROLET (414 E CLEVELAND AVE, NEWARK, DE 19711) WAS CONTACTED AND INFORMED THAT THE FAILURE NEEDED TO BE REPAIRED OUT OF POCKET. THE VEHICLE WAS NOT REPAIRED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 14V252000 (SERVICE BRAKES, HYDRAULIC, ELECTRICAL SYSTEM, EXTERIOR LIGHTING, VEHICLE SPEED CONTROL, ELECTRONIC STABILITY CONTROL) AS A POSSIBLE SOLUTION TO THE FAILURE HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT SUBJECTED TO ANY RECALLS. THE FAILURE MILEAGE WAS APPROXIMATELY 169,000.

NHTSA ID

11353046

Incident

Aug 5, 2020

Mileage

169,000 mi

ON FRIDAY, FEBRUARY, 8, 2019 MY 2004 CHEVROLET MALIBU, VIN [XXX] HAD TO BE TOWED OFF OF THE ROAD AND HOME BECAUSE THE FRONT BRAKES WERE LOCKING AND THE VEHICLE WAS SMOKING FROM THE SAME ORIGINAL LOCATION. ON SUNDAY, FEBRUARY 10, 2019 THE VEHICLE WAS TOWED TO THE SOUTH CHARLOTTE CHEVROLET, THE NEAREST DEALERSHIP. ON MONDAY, FEBRUARY 11, 2019 KB FROM SOUTH CHARLOTTE CHEVROLET INFORMED ME THAT THE FRONT CALIPERS, BRAKES AND ROTORS NEEDED TO BE REPLACED. I EXPLAINED THAT THE WORK WAS DONE ONLY THREE AND A HALF MONTHS AGO BY LANCASTER MOTOR COMPANY. KB INFORMED ME THAT THE PREVIOUS TECHNICIAN AT LANCASTER MOTOR COMPANY INSTALLED THE PARTS INCORRECTLY AND AS A RESULT THE SAME PROBLEM WAS OCCURRING AND THAT I NEEDED TO CONTACT CHEVROLET/GMC REGARDING MY WARRANTY. CHEVROLET/GMC IS NOT HONORING THEIR WARRANTY AND THE FAILED ROTORS ALMOST CAUSED MY DAUGHTER TO BE IN A CAR ACCIDENT ON FEBRUARY 8, 2019. THE SAME VEHICLE WAS TAKE TO LANCASTER MOTOR COMPANY, SC FOR A FRONT BRAKE CONCERN; SMOKE AND SCREECHING ON SATURDAY, OCTOBER 6, 2018. I RECEIVED A FOLLOW UP CALL FROM THE LANCASTER MOTOR COMPANY, SC SERVICE DEPARTMENT ON OCTOBER 6, 2018 THAT THE CAR COULD NOT BE DRIVEN UNTIL THE BRAKES WERE REPAIRED AND THAT THEY COULD NOT RETURN IT ME BECAUSE IT WAS "UNSAFE TO DRIVE". THE TECHNICIAN; TOLD ME THAT THEY WERE KEEPING THE CAR AND THAT THEY WOULD FOLLOW UP WITH ME ON MONDAY, OCTOBER 8, 2018. DURING A DISCUSSION WITH LANCASTER MOTOR COMPANY THE WEEK OF OCTOBER 8, 2018 I WAS INFORMED BY [XXX] THAT MY FRONT CALIPERS HAD TO BE REPLACED ALONG WITH THE BRAKES AND ROTORS. THE INVOICE NUMBER [XXX] TOTALED $1114.29 FOR THE 2004 CHEVROLET MALIBU AND I WAS INFORMED THAT THE PARTS WERE COVERED UNDER WARRANTY FOR TWELVE (12) MONTHS. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ID

11216999

Incident

Oct 6, 2018

Mileage

182,000 mi

CLUNKING SOUND THAT YOU CAN FEEL IN THE FOOT PEDAL AND WHEN YOU ROCK STEERING WHEEL BACK IN FORTH AND CLUNKING NOISE COMING FROM FRONT ENDIN STEERING WHEEL AND UNABLE TO CONTROL VEHICLE FELLING OVER LOOSING CONTROL OF CAR

NHTSA ID

11196854

Incident

Apr 15, 2019

THERE WAS A RECALL ON FUEL SYSTEM MY ENGINE LIGHT IS ON AND HAD IT DIAGNOSED AND ITS READING I NEED A FUEL PUMP CANT UNDERSTAND WHY WHEN WORK WAS ALREADY DONE SOMETIMES WHEN I ACCELERATE TO 25-30 STUTTERS AND PUTTS

NHTSA ID

10888863

Incident

Jun 5, 2016

Mileage

140 mi

TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. WHILE DRIVING AT VARIOUS SPEEDS, THE BRAKES ENGAGED INDEPENDENTLY AND WITHOUT WARNING. THE CONTACT MENTIONED THAT THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE HYDRAULIC ANTI-LOCK CONTROL WAS FAULTY AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 120,000.

NHTSA ID

10824033

Incident

Apr 1, 2015

Mileage

120,000 mi

BRAKES FAILED WHILE DRIVING, CAUSING ME TO CRASH INTO ANOTHER CAR.

NHTSA ID

10722689

Incident

May 28, 2015

Mileage

116,000 mi

TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. WHILE THE VEHICLE WAS BEING SERVICED BY AN INDEPENDENT MECHANIC, IT WAS DISCOVERED THAT THE TIE ROD AND FRONT BRAKES NEEDED TO BE REPLACED.THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 89,000.

NHTSA ID

10714033

Incident

Feb 2, 2015

Mileage

89,000 mi

THE DRIVER WAS TRAVELING ON A TWO LANE ROAD AND CAME TO A CURVE IN THE ROAD AT WHICH TIME SHE REPORTED THAT THE BRAKES WOULD NOT SLOW OR STOP THE CAR AND THE CAR BEGAN TO VEER IN AN UNINTENDED (AND UNSTEERED) DIRECTION. THE DRIVER ATTEMPTED TO CORRECT THE CAR'S PATH AND SPEED AND IT WENT OUT OF CONTROL STRIKING FOUR CARS, CROSSING A DIVIDER AND IMPACTING HEAD ON WITH A 4 X 4 TRUCK. THE DRIVER COMMENTED THAT THE "CAR WENT WILD". *TR

NHTSA ID

10678511

Incident

Jan 20, 2015

Mileage

54,000 mi

2004 CHEVROLET MALIBU. CUSTOMER STATES THAT HE HAS RECEIVED THREE RECALL NOTICES FOR VEHICLE IN JUNE 2014 AND JULY 2014. ALL THREE NOTICED INDICATED THE PARTS ARE NOT AVAILABLE AND HASN'T HEARD ANY RESPONSE SINCE. *TA

NHTSA ID

10659530

Incident

Jun 2, 2014

2004 CHEVROLET MALIBU EXPERIENCING POWER STEERING PROBLEMS, ABS AND SHIFT CABLE, ALL REPLACED. *CW THE CONSUMER STATED THE VEHICLE WAS TAKEN TO THE REPAIR SHOP SEVEN TIMES, DUE TO POWER STEERING FAILURE, WHICH RESULTED IN THE STEERING LOCKING UP. THE CONSUMER WAS INVOLVED IN TWO ACCIDENTS, IN WHICH THE AIR BAGS FAILED TO DEPLOY. THE CONSUMER RECEIVED A TRANSMISSION, STEERING AND BRAKE RECALL. HOWEVER, THE PARTS WERE NOT AVAILABLE. *JB

NHTSA ID

10653277

Incident

May 1, 2014

THE TRACTION CONTROL SENSOR LIGHT KEEPS GOING ON AND OFF. I'M NOT EVEN SURE THAT IT IS WORKING AT ALL I HAVE A RECALL NOTICE ON THIS ISSUE BUT ONCE AGAIN NO ONE SEEMS TO HAVE ANY PARTS TO CORRECT THE ISSUE. *TR

NHTSA ID

10651749

Incident

Sep 12, 2014

Mileage

156,000 mi

WITH THE SHAKING STEERING WHEEL AND THE POWER STEERING GOING IN AND OUT MY FRONT TIRES WHERE FEELING OUT OF BALANCE SO I PULLING INTO WAL-MART AND HAD THEM LOOK AT IT. BOTH OF MY FRONT TIRES HAD BUSTED BELTS IN THEM AND MY BREAKS WERE PRETTY MUCH GONE AND THE ROTORS WERE TORN UP. THE ALIGNMENT WAS WAY OFF CAUSING THE CAR TO NOT STEER . I WAS TOLD ALL THIS IS BECAUSE OF THE POWER STEERING GOING OUT. THIS CAR IS NOT SAFE TO DRIVE, HOWEVER ITS MY ONLY MEANS OF TRANSPORTATION AND WITH SO MANY OF THESE PROBLEMS I HAVE NO MONEY TO HAVE HE PROBLEMS FIXED. SOMETHING NEEDS TO BE DONE . THERE ARE SO MANY OTHERS WITH THE SAME PROBLEM. *TR

NHTSA ID

10651747

Incident

Jul 18, 2014

Mileage

1,530,000 mi

2004 CHEVROLET MALIBU. CONSUMER WRITES IN REGARDS TO GM RECALL #13036* LD THE CONSUMER STATED THE RECALL FIX, DID NOT FIX THE PROBLEM. THE CONSUMER STATED HE DID NOT KNOW, IF THE BRAKE LIGHTS WORKED AND THE CRUISE CONTROL RARELY WORKED. THE TRACTION CONTROL AND ABS LIGHT WAS ON. THE CONSUMER RETURNED TO THE DEALER. AN INSPECTION REVEALED A PROBLEM WAS SPEED SENSOR ON THE RIGHT FRONT WHEEL, WHICH WAS NOT RELATED TO THE RECALL. THE COST TO REPLACE THE SENSOR WAS $460. *JB

NHTSA ID

10649128

Incident

Oct 1, 2014

TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 30 MPH, THE BRAKE PEDAL WAS DEPRESSED AND FAILED TO RESPOND. AS A RESULT, THE CONTACT CRASHED INTO A TREE STUMP AND THE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED A CHEST INJURY THAT DID NOT REQUIRE MEDICAL ATTENTION. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS NOT DIAGNOSED HOWEVER, THE BODY DAMAGE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. THE VIN WAS NOT AVAILABLE.

NHTSA ID

10648225

Incident

Oct 3, 2014

THE TRACTION LIGHT, ABS BRAKE LIGHT, AND SERVICE LIGHT ARE COMING ON AND DO NOT GO OUT. THE SHIFT GEAR ALSO HAS A PROBLEM. *TR

NHTSA ID

10644969

Incident

Oct 6, 2014

WHEN I APPLY MY BRAKES TO STOP OR SLOW DOWN MY BRAKES SEEM TO GO OUT OR NOT WORK INTERMITTENTLY. MY HUSBAND THINKS IT HAS TO DO WITH THE ABS. THIS HAS ALMOST CAUSED ME TO HIT THE VEHICLES IN FRONT OF ME SO I MUST LEAVE A RATHER LARGE STOPPING DISTANCE BETWEEN MYSELF AND THE FRONT CAR WHICH IS FINE BUT WHEN I MUST MAKE A QUICK STOP TO AVOID AN ACCIDENT MY BRAKES CUT OUT. *TR

NHTSA ID

10639811

Incident

May 1, 2014

Mileage

130,000 mi

TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. WHILE DRIVING 70 MPH, THE BRAKES ACTIVATED INDEPENDENTLY AND THE ENGINE STALLED. THE VEHICLE WAS ABLE TO RESTART AFTER SEVERAL ATTEMPTS. THE FAILURE OCCURRED ON MULTIPLE OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL), BUT THE PART WAS NOT AVAILABLE TO PERFORM THE REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 140,000.

NHTSA ID

10639251

Incident

Sep 18, 2013

Mileage

140,000 mi

TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STATED THAT THE BRAKES, STEERING, AND ELECTRICAL WIRING FOR THE HEADLIGHTS FAILED. THE FAILURES HAVE OCCURRED SINCE 2004. WHILE MAKING LEFT TURNS, THE STEERING WHEEL WAS DIFFICULT TO MANEUVER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT HAD BEEN SUBMITTING COMPLAINTS TO THE MANUFACTURER SINCE 2004. THE FAILURE MILEAGE WAS 35,000. UPDATED 10/23/14*CN UPDATED 4/13/2015 *JS

NHTSA ID

10632715

Incident

Mar 1, 2004

Mileage

35,000 mi

TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL); HOWEVER, THE PARTS NEEDED FOR THE REPAIRS WERE UNAVAILABLE. THE MANUFACTURER WAS NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

NHTSA ID

10629073

Incident

May 14, 2014

TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE STOP IN A PARKING LOT, ANOTHER VEHICLE CRASHED INTO CONTACT VEHICLE AND THE HORN MALFUNCTIONED. AS RESULT, THE CONTACT WAS UNABLE TO ALERT THE OTHER VEHICLE AND THE AIR BAGS FAILED TO DEPLOY. IN ADDITION, THE CONTACT STATED THE BRAKE LIGHTS BECAME INOPERABLE INTERMITTENTLY. A POLICE REPORT WAS FILED AND NO INJURIES WERE REPORTED. THE MANUFACTURER WAS NOT NOTIFIED ABOUT THE FAILURES. THE FAILURES RECURRED NUMEROUS TIMES. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC. THE VEHICLE WAS NOT DIAGNOSE OR REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS UNKNOWN.

NHTSA ID

10628522

Incident

Oct 27, 2013

TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 45 MPH, HE DEPRESSED THE BRAKE PEDAL AND THE VEHICLE WOULD NOT RESPOND. THE CONTACT HAD TO USE THE EMERGENCY BRAKE IN ORDER TO STOP THE VEHICLE. THE FAILURE WAS NOT DIAGNOSED NOR WAS THE VEHICLE REPAIRED. THE CONTACT ALSO STATED THAT THE POWER STEERING WARNING LIGHT ILLUMINATED AND WHEN MAKING A RIGHT OR LEFT TURN THE STEERING WHEEL SEIZED. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V153000 (STEERING); HOWEVER, THE PART WAS UNAVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

NHTSA ID

10628349

Incident

Aug 2, 2010

Mileage

100,000 mi

TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. WHILE DRIVING APPROXIMATELY 30 MPH, THE VEHICLE STALLED AND MULTIPLE WARNING INDICATORS ILLUMINATED. THE VEHICLE STALLED WHILE DRIVING OVER SPEED BUMPS OR ANY OTHER TERRAIN. THE CONTACT ATTEMPTED TO REMOVE THE KEY FROM THE IGNITION, BUT THE KEY WOULD NOT EJECT. THE KEY WOULD CONTINUOUSLY BECOME STUCK BETWEEN THE OFF POSITION AND AUXILIARY POSITION AND WOULD NOT RESTART THE VEHICLE. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSTIC TESTING AND THE MECHANIC STATED THAT THE LOCK ASSEMBLY NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED AND INFORMED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM). THE APPROXIMATE FAILURE MILEAGE WAS 79,000. UPDATED 01/12/15*LJ UPDATED 08/28/2017*CT

NHTSA ID

10628187

Incident

Aug 2, 2013

Mileage

79,000 mi

TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS, THE STEERING WHEEL SEIZED AND EXCESSIVE FORCE ON THE STEERING WHEEL WAS REQUIRED. THE SERVICE SOON WARNING LIGHT ILLUMINATED PRIOR TO THE FAILURE. THE VEHICLE WAS TAKEN TO THE DEALER FOR A DIAGNOSIS. THE TECHNICIAN STATED THAT THE POWER STEERING SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT RECEIVED A NOTIFICATION FOR RECALL NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL), NHTSA CAMPAIGN NUMBER: 14V153000 (STEERING) AND NHTSA CAMPAIGN NUMBER: 14V224000 (POWER TRAIN). HOWEVER, THE PARTS NEEDED WERE UNAVAILABLE TO SERVICE THE VEHICLE UNDER THE RECALL. THE DEALER WAS UNCERTAIN WHEN THE PARTS WOULD BE AVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 62,000.

NHTSA ID

10627522

Incident

Jun 1, 2006

Mileage

62,000 mi