2017 Chevrolet Malibu Brakes Problems

I have a 2017 Chevy Malibu 2.0 T. The incident involved the braking system. I was driving and as traffic came to a stop, I pressed the brake to stop and my brakes gave out. I immediately lifted my foot and press extremely hard on my brake pedal and was able to stop though the stopping distance was much further and nearly caused an accident. I have now taken the vehicle to a Chevy certified dealer and it has been identified as a brake vacuum pump failure. GM has had many issues with the brake vacuum pump across many of its models.

NHTSA ID

11748825

Incident

Jun 28, 2026

I was driving back home and stopped at a red light. When the light turned green I started driving, but my car was jerking a little too much. I pulled over and turned my car off. When I cut my car back on my brake became very hard to the point I had to push down extra hard to stop my car. I started back driving home once I realized my car needs to be turned completely off and sit. While I'm driving I see a message on my dashboard saying "Engine power reduced." Luckily I made it home safely with no wrecks, but when I had to brake my car was still moving jerking while in place. Also when I made it home and turned my car off I heard a fan like noise that eventually stopped.

NHTSA ID

11748133

Incident

Jun 30, 2026

In the last 6 months I’ve had to put 3 Brake Boosters on my 2017 Chevy Malibu and it’s NOT cheap…. I don’t know what else to do.

NHTSA ID

11718196

Incident

Jun 29, 2025

The GM Shift to Park recall has been an issue that has affected various General Motors (GM) vehicles. The primarily impacting Chevrolet models like the Malibu, Traverse, Volt, and the 2019 Chevrolet Blazer. It’s essential to be aware of the problem, its implications on vehicle’s safety, and the steps required to address it. In simple terms, the Shift to Park defect prevents drivers from shutting off and locking their vehicles, even after putting the car in park. This situation poses a potential safety concern, as drivers might mistakenly assume their cars are securely parked and powered off while walking away. The issue has been prevalent enough for the company to issue a Technical Service Bulletin (TSB) on June 7, 2021. The TSB specifically targets the 2017-2018 GMC Acadia, while also mentioning the Malibu, Traverse, Volt, and other 2016-2019 Chevrolet models. The bulletin provides guidance on diagnosing and addressing the “Shift to Park” problems, although it does not present a definitive solution to the underlying issue. GM CUSTOMER SERVICE REFUSES TO FIX IT

NHTSA ID

11713855

Incident

Jan 1, 2025

Was driving on highway and starting to exit and my engine light came on and it alerted reduced engine power. I had to slam on my brakes but they were very hard to press and almost non existent and steering was also difficult. Managed to get car to side of road but due to very hard to non existent brakes I did graze a truck and damaged my rear drivers side fender. I am very lucky I didn’t get injured and was able to mostly miss the cars stopped in front of me. I also have the shift to park issue happen at least 4 times a week.

NHTSA ID

11704980

Incident

Dec 5, 2025

When I accelerate and try to stop brakes goes down to the floor. I’ve had my rotors. Brakes changed and it’s impossible to stop at times. Purchase vehicle. 2018 and the check engine light came on shortly after I purchased it. It’s been on. I’ve got diagnostics. It’s unknown why! Tire sensors has been changed, including with new tires and none of them work and the airbag light is illuminated. I am concerned about my safety in this vehicle. I reported many times and I’m unaware of any recalls. Please help.

NHTSA ID

11699188

Incident

Nov 1, 2018

I was driving my car on the highway doing 65 mph when all of a sudden my car started rapidly jerking losing the power to accelerate and entering “limp mode“ there was multiple cars behind me when my car lost the power to accelerate. I was in the far left lane and couldn’t even go higher than 7 miles an hour and had to cross across three lanes at 7 mph on a 65mph highway to pull over. I had my children in the car and almost caused a huge accident dude to this issue. The issue in hand is the vacuum pump. It completely shattered in my engine, causing severe engine damage. And it caused my brake pedal to become hard as a rock. I couldn’t break without using my emergency break. I had no brake power at all. My car had to be towed.

NHTSA ID

11685667

Incident

Aug 23, 2025

Shift to park issue. While is in park after driving. I turn vehicle off and action required message pops up on dash stating shift to park but it’s in park.

NHTSA ID

11685198

Incident

Aug 11, 2025

the brakes failed the vacuum pump went work while driving the car

NHTSA ID

11667657

Incident

Nov 4, 2024

Vacuum pump came apart inside the engine causing metal pieces to enter the engine

NHTSA ID

11664183

Incident

May 31, 2025

Vacuum pump failure caused engine damage.

NHTSA ID

11661631

Incident

Jul 17, 2024

Breaks are locked up, car won't start due to faulty Vaccum pump and brake booster!

NHTSA ID

11655635

Incident

Apr 18, 2025

Yes, my brakes have failed twice with my children in my car both coming to a stop sign almost causing us injury or death. I have contacted Chevrolet several times about this issue. It has happened again costing me close to $4000 in repairs.

NHTSA ID

11654403

Incident

Apr 14, 2025

I was driving in my neighborhood I tried to park at my house and my car wouldn’t stop I had to step down on my break hard for it to finally stop my vacuum pump broke into pieces and made my timing chain break

NHTSA ID

11647738

Incident

Sep 20, 2024

The brake booster and vacuum pump keep failing. I’ve replaced the booster 3 times and the pump 2 times the first time the pump went it broke off and broken pieces of metal had to be taken out of the engine. I’m making payments on a vehicle that is in the shop repairing the same issue every 3 to four months.

NHTSA ID

11634739

Incident

Apr 10, 2024

I am writing to report a persistent issue with my Chevy Malibu, specifically related to the Stabilitrak system. The Stabilitrak light intermittently flickers on and off while driving, which raises significant safety concerns. This malfunction has been ongoing, and despite efforts to diagnose the problem, my local auto mechanic has been unable to pinpoint the exact cause. Services Performed: Initial diagnostic checks were conducted to identify any fault codes related to the Stabilitrak system. The mechanic found no definitive issues but noted that the warning light's behavior indicated a potential underlying problem. Each visit has led to additional uncertainty, with suggestions from the mechanic to proceed through the GM flow chart for further diagnosis. However, this approach may lead to extensive labor costs with no guaranteed resolution. Financial Burden: The recommendation to follow the GM flow chart for diagnosis is concerning, as it may result in significant and unnecessary expenses without a clear outcome. As a consumer, I believe that a properly functioning diagnostic system should provide clarity on such issues without incurring exorbitant costs. The erratic behavior of the Stabilitrak system poses a serious safety risk while driving. This system is critical for maintaining vehicle stability, particularly in adverse conditions, and its failure could lead to loss of control of the vehicle. I have been made aware of other drivers experiencing similar issues with their Chevy Malibu vehicles. It raises the question of whether there is a known defect in the Stabilitrak system that warrants a recall. I urge the NHTSA to investigate this matter further, as it seems that GM has not taken the necessary steps to address these concerns

NHTSA ID

11616780

Incident

Sep 11, 2024

The contact owns a 2017 Chevrolet Malibu. The contact stated while driving approximately 65 MPH, the instrument panel displayed the message “Reduce Engine Power” with the check engine warning light illuminated. The vehicle immediately decelerated independently. The contact continued to depress the accelerator pedal; however, the vehicle failed to exceed 35 - 40 MPH before decelerating again. The contact pulled over to the side of the roadway and waited for approximately 15 minutes before continuing to drive; however, the failure persisted. The vehicle was taken to a certified mechanic where it was diagnosed and determined that the ABS, Power Train, and Throttle Sensor all had failed and needed to be replaced. The vehicle was not repaired by the mechanic. The vehicle was taken to the dealer but was not yet diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was 70,000.

NHTSA ID

11609986

Incident

Aug 14, 2024

Mileage

70,000 mi

On Thursday, [XXX] my [XXX] son was driving my chevy malibu coming down the hill to get home when the brakes went out. He could not stop the vehicle and had to pass our neighborhood and let the vehicle slow itself down. He was able to get stopped and turned around and made it home. Saturday, [XXX] we decided maybe it needed new brakes and took it for new brakes. New brakes and rotors all the way around did NOT fix the problem. The brake was like hitting a brick and would not stop the vehicle. I had the vehicle towed to a repair shop and they found that the vacuum system for the brakes went out. He also noticed that cam shaft was cracked. Upon research through the internet I found that this problem is common and a class action suit has been filed against GM for the same problem. I am unsure why this is not a recall as its a safety issue and my son could have been injured or injured someone else. This has been an EXTREMELY expensive repair for us! When they went to replace the cam shaft there were several parts of the cam shaft just blown all over the engine. We still have not found all of the missing parts. This has caused most of the seals to have to be replaced as well. I do not have a repair receipt yet as the vehicle is still in the shop INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11606954

Incident

Aug 1, 2024

Vacuum Pump exploded, my breaks went out on the freeway. Metal pieces from the pump went into engine. Broke the camshaft. Now having to pay hundreds and hundreds of dollars to repair. I am missing out on work u til this can be fixed.

NHTSA ID

11604929

Incident

Jul 25, 2024

The Power Brake Vacuum Assist Failure nearly caused a wreck. The part failed while we were driving on [XXX] going 65 miles per hour on a busy highway. As the breaks gave out the engine light said “Reduced Power”. Moments later, the breaks stopped working and the engine stopped running. We were able to coast off the highway and into an HEB parking lot and have the vehicle towed. The mechanic took the part off and found that it was in pieces causing further examination of the engine to look for the missing metal. Pictures are available to see the damage. Even after completing the repairs the vehicle is showing reduced power. We are still trying to get it fixed but understand that the Chevrolet company is aware of the issue but never issued a recall. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11572743

Incident

Feb 9, 2024

1, break vacuum pump. I have the defective unit available 2. My safety, my passengers and all other drivers were put at high risk 3. Defective vacuum pump verified my independent mechanic 4. Inspected by mechanic. Have not had anyone else inspect. 5. No warning of complete break failure

NHTSA ID

11544206

Incident

Sep 10, 2023

1) brake system failed , yes it’s available for inspection 2) the brakes became very hard not being able to push down to use brakes , had to go to the right into ditch to avoid many vehicles that were ahead of me , this was very scary for my family and I , I’ve had nightmares since . 3) brake booster has been confirmed by the dealership as the problem 4)inspected at the hm dealership 5) There was no warning lights before incident happen

NHTSA ID

11528989

Incident

Feb 23, 2023

Engine reduced while on the highway.

NHTSA ID

11528633

Incident

Jun 22, 2023

Shift to park warning continues to come on daily when I go to put my car in park. I have to fidget with the shifter to get the computer to recognize that my car is in park and the car will then shut off. Recently I was stopped at a red light, tried to accelerate at the green light and my car completely shut off, while I was still in drive. I could not accelerate and had to place my car in park. Then my stabilitrak sensor came on, along with a notice that my battery saver was on. I had to call a police offer to help me off the road. The car was then able to turn on and I drove it home but this is not safe.

NHTSA ID

11527915

Incident

Jun 20, 2023

The contact owns a 2017 Chevrolet Malibu. The contact stated that upon cleaning her rear windshield, she noticed that the third rear brake light plastic housing had cracked on both sides. The vehicle was taken to the dealer where the contact was informed that the third brake light needed to be replaced to avoid future water intrusion that might enter through the roof of the vehicle. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was advised to call the NHTSA Hotline. The failure mileage was approximately 78,000.

NHTSA ID

11526584

Incident

Mar 12, 2023

Mileage

78,000 mi