Reports submitted to NHTSA by owners and drivers, shown in full
Data refreshed
Our database holds 155 NHTSA owner-reported complaints for the 1996 Chevrolet Monte Carlo. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Showing 1–25 of 155 · page 1 of 7
TL* THE CONTACT OWNS A 1996 CHEVROLET MONTE CARLO. WHILE DRIVING APPROXIMATELY 45 MPH, THE ENGINE SEIZED WITHOUT WARNING. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 50,000.
TL* THE CONTACT OWNS A 1996 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT WHILE MAKING A LEFT TURN, THE VEHICLE CRASHED INTO ANOTHER VEHICLE AND THE FRONT AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED. THE DRIVER AND THE REAR PASSENGER SUSTAINED UNKNOWN INJURIES THAT REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. THE VIN WAS UNAVAILABLE.
THE FUEL PRESSURE REGULATOR IN THE ENGINE COMPARTMENT DEVELOPED A SEVERE LEAK. THE LEAK CAUSED FUEL TO BE RELEASED IN LARGE QUANTITIES DIRECTLY INTO THE UPPER INTAKE MANIFOLD AND OUT THE THROTTLE BODY. FUEL CONTINUED TO FLOW OUT INTO THE AIR CLEANER HOUSING AND EVENTUALLY THE ENGINE COMPARTMENT AND ONTO THE GROUND. SEVERAL GALLONS OF FUEL WERE DISCHARGED IN THIS FASHION. THE VEHICLE WAS RUNNING POORLY BUT GAVE NO INDICATION THAT THERE WAS A LEAK UNTIL THE AIR CLEAN WAS OPENED. THE PART THAT FAILED WAS A STANDARD MOTOR PRODUCTS PART NUMBER PR216T PURCHASED FROM ROCKAUTO.COM ON 5/15/2013 AND INSTALLED SHORTLY THEREAFTER. VEHICLE MILEAGE AT INSTALLATION WAS APPROXIMATELY 131000. THE PART FAILED ON 10/20/2014 AT VEHICLE MILEAGE148243 MILES. THE PART WAS INSTALLED TO CORRECT A SIMILAR SITUATION INVOLVING A MUCH LESS SEVERE LEAK IN AN OLDER PART. THE FUEL LEAKAGE WITH THE OLDER PART DID NOT ESCAPE THE UPPER INTAKE MANIFOLD. AGE AND ORIGIN OF THE OLDER PART ARE NOT KNOWN. THE OLDER PART MAY HAVE BEEN ORIGINAL TO THE VEHICLE. GIVEN THE SIGNIFICANT QUANTITY OF FUEL DISCHARGED AND THE REPEATED NATURE OF THE FAILURE, I FEEL AN INVESTIGATION IS WARRANTED. *TR
TL*THE CONTACT OWNS A 1996 CHEVROLET MONTE CARLO. WHILE DRIVING 25 MPH, THE TRANSMISSION GEARS SLIPPED OUT OF PLACE. A LOCAL MECHANIC ATTEMPTED TO REPLACE THE TRANSMISSION AND DID NOT HAVE ALL OF THE NECESSARY COMPONENTS TO DO SO. THE MANUFACTURER COULD NOT IDENTIFY OR LOCATE THE CORRECT TRANSMISSION FOR HIS MODEL. NO REPAIRS WERE MADE. THE FAILURE MILEAGE WAS 80,000. THE CURRENT MILEAGE WAS 100,000.
DT*: THE CONTACT STATED THE VEHICLE STALLED IMMEDIATELY UPON STARTING THE ENGINE. THE VEHICLE WAS RESTARTED BUT IMMEDIATELY STALLED AGAIN. THE ABS LIGHT ALSO ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR SERVICE.
1996 CHEVROLET MONTE CARLO Z34, POWER DRIVER SEAT FRAME DEFECT. BOTTOM OF SEAT DETACHED FROM FRAME, WHICH MADE DRIVER FALL BACKWARD TOWARD REAR SEATS. *NM
I HAVE BEEN HAVING PROBLEMS WITH THE AUTOMOBILE HAVING A TICKING NOISE AFTER I START IT UP IN THE MORNING SO I BROUGHT IT TO THE DEALER TO FIND OUT WHAT WAS WRONG WITH IT. IT WAS THE HEAD GASKET. THE AUTO ONLY HAS 75000 MILES ON IT. I WOULD LIKE TO KNOW WHAT YOU CAN DO FOR ME. THERE WAS A TSB #57-61-24A JUN98 ON THIS PROBLEM. *NM
1996 CHEVROLET MONTE CARLO EXPERIENCED PROBLEMS WITH THE FUEL REGULATOR.*MR THE CONSUMER DROVE ABOUT 7 MILES AND NOTICED THAT THE FUEL TANK NEEDLE MOVED FROM FULL TANK TO HALF TANK DURING THE SHORT RIDE AND SAW SMOKE COMING FORM UNDER THE HOOD. THE NEXT DAY A STRONG SMELL OF GASOLINE COULD BE SMELLED. THE CONSUMER OPENED THE HOOD AND NOTICED FUEL WAS LEAKING ONTO THE GROUND. IT WAS LATER DETERMINED THAT THE FUEL REGULATOR HAD FAILED. THE CONSUMER HAS THE FAULTY REGULATOR. *NM
1996 CHEVROLET MONTE CARLO EXPERIENCING PROBLEMS WITH FUEL REGULATOR.*MR THE CONSUMER DROVE ABOUT 7 MILES AND NOTICED THAT THE FUEL TANK NEEDLE MOVED FROM FULL TANK TO HALF TANK DURING THE SHORT RIDE AND SAW SMOKE COMING FORM UNDER THE HOOD. THE NEXT DAY A STRONG SMELL OF GASOLINE COULD BE SMELLED. THE CONSUMER OPENED THE HOOD AND NOTICED FUEL WAS LEAKING ONTO THE GROUND. IT WAS LATER DETERMINED THAT THE FUEL REGULATOR HAD FAILED. *BF *NM
THE PROBLEM DESCRIBED BELOW HAS OCCURRED ON 3 PREVIOUS OCCASIONS.(1) EVENTS LEADING UP TO THE FAILURE - "DEX COOL" COOLANT LEAK FROM INTAKE MANIFOLD GASKET. 2) FAILURE AND ITS CONSEQUENCES - LOSS OF COOLANT LEADING TO ENGINE OVERHEATING OR FAILURE. (3) WHAT WAS DONE TO CORRECT THE FAILURE; I.E, PARTS REPAIRED OR REPLACED (AND IF OLD PART IS AVAILABLE) - GM STARTED USING "DEX-COOL" EXTENDED LIFE COOLANT IN 1996 IT DIDN'T TEST THE LONG TERM AFFECTS ON IT'S EXISTING GASKET TECHNOLOGY. ONE ARTICLE I READ STATED "IT APPEARS THAT ON SOME ENGINES, THE USE OF CONVENTIONAL PLASTIC-AND-RUBBER GASKETS IN COMBINATION WITH MORE AGGRESSIVE OAT (ORGANIC ACID TECHNOLOGY) ENGINE COOLANTS HAS CAUSED A SIGNIFICANT NUMBER OF SEALING RELATED ISSUES FOR CONSUMERS AND AUTOMOTIVE SERVICE PROVIDERS", SAID FEL-PRO CHIEF ENGINEER JERRY ROSENQUIST -- PER P://WWW.THEAUTOCHANNEL.COM/NEWS/2004/10/14/252583.HTML. DEX-COOL IS AN OAT COOLANT MANUFACTURED BY TEXACO FOR GM. OVER THE PAST FEW DAYS I'VE READ MANY COMPLAINTS ABOUT GM INTAKE GASKET LEAKS AND IT SEEMS MORE LIKELY THAT THE COOLANT, RATHER THAN THE GASKET ITSELF, IS CAUSING THE PROBLEM.*AK
ROUGH IDLE, RANDOM MISFIRES, STRONG ODOR WHEN MISFIRE OCCURS, FLUCTUATING GAS GAUGE. *AK
DUE TO INTAKE MANIFOLD GASKET LEAK (THIS IS THE FOURTH TIME FOR THIS PROBLEM ON THIS VEHICLE) I HAD TO STOP TO ADD COOLANT IN ORDER TO SAFELY DRIVE THE VEHICLE. HAD I NOT NOTICED THE PROBLEM THIS POTENTIALLY COULD HAVE LEFT ME STRANDED ON THE SIDE OF THE HIGHWAY. AFTER GETTING TO A SAFE LOCATION I HAD THE VEHICLE TOWED TO A DEALER FOR REPAIR. ALSO, AS I STATED ABOVE THIS IS MY FOURTH TIME DEALING WITH THIS ISSUE; IN ADDITION, I KNOW OF PERSONALLY 3 OTHER VEHICLES WITH THE SAME ENGINE THAT HAVE HAD THE SAME PROBLEM AND THEY TOO HAVE CHANGED THE INTAKE GASKET SEVERAL TIMES.*AK
I HAD TO REPLACE THE LOWER INTAKE MANIFOLD GASKET DUE TO ANTIFREEZE LEAK, AND NOW THE HEAD GASKET IS LEAKING ANTIFREEZE.*AK
BRAKES DO NOT WORK DURING INCLIMATE WEATHER. LOSES A QUART OF OIL PER 500 MILES. BLOWS BY SMOKE THROUGH EXHAUST WHEN STARTING.
RACK AND PINION HAVE HAD TO BE REPLACED 5 TIMES. EACH TIME CAUSES METAL SHAVINGS IN THE POWER STEERING PUMP CAUSING LOSS OF STEERING. *CB
THE RADIATOR LOOKED DIRTY AND SLIMY AFTER HAVING IT FLUSHED. SINCE THEN THE ENGINE STARTED RUNNING HOT AND LEAKING ANTIFREEZE. TOOK IT TO MECHANIC AND HE STATED THE "HEAD GASKET WAS BLOWN."*AK
DEFECTIVE TIMING BELT - TIMING BELT FAILS COMPLETELY AT 25,700 MILES, LESS THAN HALF THE MILEAGE LISTED IN OWNER DOCUMENTATION (60000 MILES, NO TIME GIVEN). FAILURE AT HIGHER SPEEDS COULD RESULT IN LOSS OF ENGINE POWER, RESULTING IN LOSS OF CONTROL DUE TO LOSS OF POWER STEERING AND BRAKE FUNCTION. *LA
WHILE DRIVING AT NORMAL SPEED STEERING GEAR BOX WAS LEAKING AND VEHICLE CAUGHT ON FIRE. DEALER NOTIFIED. *AK
REOCURRING ELECTRICAL PROBLEMS. THE CAR HAS NOT BEEN DRIVEN EVEN 100 MILES THE LAST YEAR AND A HALF BECAUSE IT WONT PASS INSPECTION. THE EMISSION SYSTEM HAS GONE OUT. SINCE WE'VE HAD THE CAR WE'VE HAD TO REPLACE THE IGNITION SYSTEM AND THE WINDOWS KEPT GOING OFF TRACK. AS OF NOW THE PASSENGER SIDE WINDOW WILL NOT GO UP. I CANT AFFORD TO GET IT FIXED SINCE I WAS DIAGNOSED WITH "CONGESTIVE HEART FAILURE" AND I'M ON PERMANENT DISABILITY THROUGH SOCIAL SECURITY.
THE INTAKE MANIFOLD GASKET LEAKED FLUID WHICH RESULTED IN THE ENGINE OVER HEATING. *JB
I OWN A 1996 Z34 WITH 78000 MILES ON IT. IN THE LAST MONTH MY ANTI LOCK LIGHT KEPT COMING ON IN THE DASH ALSO THE LOW TRACK WOULD COME ON SOMETIMES I TOOK IT TO THE DEALER YESTERDAY 5-2-03 TO HAVE IT CHECKED OUT, THEY FOUND COMPUTER SCAN BRAKE LIGHT SWITCH OPEN. LEFT REAR SENSOR, LEFT REAR EXCESSIVE SPEED VARIATION, LEFT REAR OPEN SHORT THEY ORDERED A LEFT REAR HUB AND SENSOR AT MY COST I HAD TO PAY UP FRONT 469.19 FOR THE PART TO BE ORDERED ALSO 65.00 FOR THE LABOR PLUS WHEN THE PART COMES IN I HAVE TO PAY ANOTHER 130.00 FOR R/R THE LEFT REAR HUB . ABOUT A MONTH AGO WHILE PULLING OUT OF THE PARKING LOT AT WORK THE LEFT REAR WHEEL LOCK UP AND STARTED TO SKIP MY FELLOW EMPLOYEES CAME OVER TO MY CAR AND ASK WHAT HAD HAPPENED AN IF I WANTED THEM TO FOLLOW ME HOME AFTER MOVING ANOTHER 10 FEET IT UNLOCKED IT SELF IF THIS WOULD HAVE HAPPENED WHILE DRIVING DOWN THE HIGHWAY WHO KNOWS WHAT WOULD HAVE HAPPENED HAS ANYONE ELSE HAD THIS EXPERIENCE WITH THE 1996 CHEVROLET Z34 ABS. *JB
BRAKING PROBLEMS: I OWN A 1996 CHEVY MONTE CARLO AND I HAVE RECENTLY BEEN EXPERIENCING BRAKING PROBLEMS. THE LOW TRACK LIGHT COMES ON PERIODICALLY AND I LOSE ALMOST ALL OF MY BRAKES. IT IS VERY DIFFICULT TO STOP AND I FEEL THIS NEEDS TO BE INVESTIGATED, IT SEEMS THAT I AM NOT THE ONLY CONSUMER WITH BRAKING CONCERNS AND PROBLEMS. SOMEONE IS GOING TO GET KILLED. *JB
THE TIMING BELT WAS REPLACED TWICE.*JB
I WAS RECENTLY DRIVING MY 1996 CHEVROLET MONTE CARLO LS (VIN # [XXX]) ON THE HIGHWAY DURING A HEAVY RAINSTORM. I KEEP NOTICING THAT THE BRAKES FELT LIKE THEY WERE NOT WORKING WHEN I APPLIED BRAKE PRESSURE. AFTER A SHORT WHILE THE BRAKES WOULD BEGIN TO FEEL AS THOUGH THEY WERE FUNCTIONING AND THE CAR WOULD SLOW DOWN. AFTER NOTICING THIS PROBLEM, I SEARCHED FOR RECALLS ON MY VEHICLE AND CONTACTED MY DEALER. THE DEALER'S RECORDS SHOWED THAT THERE WERE NO RECALLS ON MY VEHICLE. HOWEVER, THE NHTSA WEB SITE INDICATED TWO PROBLEMS. ONE WAS A RECALL, WHICH APPLIES ONLY TO VEHICLES MANUFACTURED DURING A SPECIFIC TIME PERIOD. THE OTHER NOTICE WAS FOR A SAFETY IMPROVEMENT CAMPAIGN (APPARENTLY DIFFERENT FROM A RECALL). THE NHTSA NUMBER FOR THIS CAMPAIGN IS 011014000. THE NHTSA WEBSITE STATES THAT THIS CAMPAIGN ONLY APPLIES TO THE Z34 VERSION OF THE 1996 MONTE CARLO. THE PROBLEM THAT IS DESCRIBED IS EXACTLY WHAT I HAVE EXPERIENCED WHEN DRIVING MY LS MONTE CARLO IN WET CONDITIONS. IT APPEARS TO ME THAT THE Z34 AND THE LS VERSIONS OF THE 1996 MONTE CARLO HAVE IDENTICAL FENDER WELLS AND LINERS AND WOULD EXPERIENCE IDENTICAL WET BRAKING PROBLEMS, THEREBY REQUIRING THE SAME FENDER LINER MODIFICATION. THUS, THIS SAFETY PROBLEM IS NOT LIMITED TO THE ONLY Z34 MODEL AND THIS CAMPAIGN SHOULD BE EXTENDED TO ALL 1995-1999 CHEVROLET MONTE CARLO VEHICLES. I WOULD LIKE THE MANUFACTURER TO MODIFY MY VEHICLE SO THAT I WILL NOT EXPERIENCE WET BRAKE FADING AND BE ABLE TO PROPERLY STOP MY CAR WHEN DRIVING IN WET CONDITIONS. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
MY INTAKE MANIFOLD IS LEAKING. I UNDERSTAND FROM THE DEALERSHIP THAT THIS IS EXTREMELY COMMON BUT UNFORTUNATELY HAS NOT LEAD TO A RECALL YET. TS
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .