RoadVitals

1991 Chevrolet S10 Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Data refreshed

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
9
Newest Aug 11, 2008
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
7 investigations on file

Recall campaigns

9 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

08E050000

EXTERIOR LIGHTING:HEADLIGHTS

Aug 11, 2008
1,921 units potentially affected
The defect: K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
The risk: WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
The remedy: K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
K2 MOTOR CORPORATIONView on NHTSA.gov
06E049000

EXTERIOR LIGHTING

May 24, 2006
27,176 units potentially affected
The defect: CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
The risk: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
The remedy: CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
CK MOTORSPORT, INC.View on NHTSA.gov
06E026000

EXTERIOR LIGHTING

Mar 23, 2006
61,944 units potentially affected
The defect: CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
The risk: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
The remedy: PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
PRO-A MOTORS, INC.View on NHTSA.gov
99V193000

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

Jul 19, 1999
1,125,749 units potentially affected
The defect: VEHICLE DESCRIPTION: CERTAIN 4-WHEEL DRIVE PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH ABS (ANTILOCK BRAKING SYSTEM) MANUFACTURED FROM SEPTEMBER 1989 THROUGH AUGUST 1996. UNDER CERTAIN DRIVING CONDITIONS THE SWITCH WHICH SIGNALS THE ABS SYSTEM WHETHER THE VEHICLE IS IN 2-WHEEL OR 4-WHEEL DRIVE CAN MALFUNCTION CAUSING INCREASED STOPPING DISTANCES DURING ABS STOPS WHILE IN THE TWO-WHEEL DRIVE MODE.
The risk: IF THIS OCCURRED AT A TIME WHEN MINIMUM STOPPING DISTANCE WAS REQUIRED, A VEHICLE CRASH COULD OCCUR WITHOUT PRIOR WARNING.
The remedy: DEALERS WILL REPLACE OR REPAIR THE 4-WHEEL/2-WHEEL DRIVE SWITCH.
GENERAL MOTORS CORP.Manufacturer number 99041View on NHTSA.gov
96V195000

STEERING:GEAR BOX:SHAFT SECTOR

Oct 8, 1996
144,598 units potentially affected
The defect: THE INTERMEDIATE STEERING SHAFT LOOSENS AT THE STEERING SHAFT TO STEERING GEAR COUPLING. WITH THIS LOOSENESS, THE YOKE PINCH BOLT CAN WEAR ON THE SPLINES OF THE SHAFT UNTIL THERE IS NO LONGER AN INTERFERENCE BETWEEN THE SPLINES AND THE BOLT.
The risk: THIS CONDITION CAN CAUSE BODY TO CHASSIS MOVEMENT ALLOWING THE STEERING SHAFT TO SEPARATE FROM THE STEERING GEAR WHICH CAN RESULT IN A LOSS OF STEERING CONTROL.
The remedy: DEALERS WILL RETORQUE THE UPPER AND LOWER BOLTS TO CORRECT SPECIFICATIONS.
GENERAL MOTORS CORP.View on NHTSA.gov
93V008000

ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN

Jan 14, 1993
215,052 units potentially affected
The defect: THE ENGINE COOLING FAN BLADES BREAK AS A RESULT OF FATIGUE AND/OR VEHICLE INDUCED STRESS.
The risk: IF THE BLADE BREAKAGE OCCURS WHILE THE HOOD IS OPEN, APERSON WORKING UNDER THE HOOD OR IN THE VICINITY OF THE VEHICLE COULD BE STRUCKAND INJURED BY THE BLADE SEGMENT.
The remedy: INSTALL A NEWLY DESIGNED FAN ASSEMBLY.
GENERAL MOTORS CORP.View on NHTSA.gov
91V108000

FUEL SYSTEM, GASOLINE:STORAGE

Jun 21, 1991
102,885 units potentially affected
The defect: VEHICLES HAVE BEEN SHIPPED WITH THE FUEL TANK SENDER SEAL OUT OF POSITION.
The risk: IN THE EVENT OF ROLLOVER ACCIDENT, AN OUT OF POSTIONSEAL COULD ALLOW FUEL SPILLAGE IN EXCESS OF THE AMOUNT PRESCRIBED BY FMVSS 301.SPILLED FUEL COULD IGNITE NEAR AN IGNITION SOURCE.
The remedy: REPLACE SENDER SEALS.
GENERAL MOTORS CORP.View on NHTSA.gov
90V193000

SUSPENSION:FRONT:CONTROL ARM:LOWER ARM

Nov 14, 1990
237 units potentially affected
The defect: NUTS USED TO ATTACH LOWER CONTROL ARMS, REAR SPRING AND SHACKLE, AND REAR SHOCK ABSORBERS DO NOT MEET SPECIFICATIONS AND COULD "STRIP".
The risk: STRIPPING OF THE NUTS IN THE REAR SUSPENSION COULD REDUCECLAMP LOAD ON LOWER CONTROL ARM, WHICH COULD ALLOW THE ARM TO DETACH, RESULTINGIN LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
The remedy: REPLACE LOWER CONTROL ARM ATTACHMENT NUTS AS WELL AS REAR SPRING AND SHACKLE, AND REAR SHOCK ABSORBER NUTS.
GENERAL MOTORS CORP.View on NHTSA.gov
90V107000

VISIBILITY:WINDSHIELD

Jun 4, 1990
181 units potentially affected
The defect: USE OF IMPROPER PRIMER ON METAL SURFACES OF WINDSHIELD AND SIDE WINDOW OPENINGS COULD CAUSE LOW ADHESION TO THE METAL SURFACE AND WOULD NOT PROVIDE RETENTION REQUIRED BY FMVSS 212.
The risk: WINDSHIELD AND SIDE WINDOW GLASS WOULD NOT PREVENT THEEJECTION OF VEHICLE OCCUPANTS DURING A VEHICLE CRASH, WHICH CAUSES SERIOUSINJURIES AND FATALITIES.
The remedy: REMOVE AND REINSTALL GLASS USING PROPER PRIMER.
GENERAL MOTORS CORP.View on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect, and it is not a recall.

EA99018ClosedEngineering Analysis

SPARE TIRE SEPARATION FROM VEHICLE

Opened Jun 30, 1999
Closed Oct 20, 2000
EQUIPMENT
PE99004ClosedPreliminary Evaluation

SEPARATION OF SPARE TIRE FROM VEHICLE

Opened Jan 15, 1999
Closed Jun 30, 1999

ALLEGED THAT WIRE CABLE/WINCH ASSEMBLY WHICH HOLDS THE SPARE TIRE/WHEEL ASSEMBLY UDER THE REAR OF THE VEHICLE MAY FAIL, ALLOWING THE TIRE TO FALL FROM THE VEHICLE WHILE IN MOTION

EQUIPMENT
EA94038ClosedEngineering Analysis

ABS BRAKING SYSTEM

Opened Oct 31, 1994
Closed Feb 28, 2000

THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.

SERVICE BRAKES, HYDRAULICLed to recall 99I006000
EA94029ClosedEngineering Analysis

ENGINE COMPARTMENT FIRES

Opened Jul 29, 1994
Closed Jul 31, 1996

AN ALLEGED MALFUNCTION IN THE ATLERNATOR RESULTING IN ENGINE COMPARTMET FIRES.

ENGINE AND ENGINE COOLING
PE94046ClosedPreliminary Evaluation

ABS BRAKING SYSTEM FAILS

Opened Jun 17, 1994
Closed Oct 31, 1994

There is no summary currently available

SERVICE BRAKES, HYDRAULIC
EA92015ClosedEngineering Analysis

HIGH IDLE FLARE

Opened May 22, 1992
Closed May 28, 1993

There is no summary currently available

VEHICLE SPEED CONTROL:LINKAGES

Showing 6 of 7 inquiries on file for this model year, open ones first. Every one of them is listed on NHTSA.gov.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .