Reports submitted to NHTSA by owners and drivers, shown in full
Data refreshed
Our database holds 26 NHTSA owner-reported complaints for the 2005 Chevrolet Silverado 1500 Hd. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Showing 1–25 of 26 · page 1 of 2
MY SON WAS DRIVING HOME FROM WORK ON THE HIGHWAY AND THE TRUCK STARTED SHAKING. HE PULLED OVER AND SAW THAT THE TIRE WAS COMING APART. THIS IS A SUMITOMO TIRE 285/50R20 115H. DOT V4JD 3MTR4910. THIS WAS A VERY DANGEROUS SITUATION ESPECIALLY BECAUSE ALL OF THE TIRES ARE THE SAME. THE TRUCK WAS PARKED UNTIL WE CAN FIGURE OUT WHAT TO DO.
THE TRANSFER CASE MODULE IS NOT WORKING IN THIS TRUCK I CHANGED THE BUTTONS UNIT BUT STILL THE SAME PROBLEM AND THE POWER GOES OUT IN THE MIDDLE OF MY DIVING. SEVERAL MECHANICS CHANGE SOME PARTS BUT STILL THE SAME. I CAN WON;T BE ABLE TO GET OUT IN A SITUATION WHERE I NEED THE 4X4 THE DASH DOESN'T SHOW THE CORRECT INFORMATION, ONLY THE FUEL AND RPM
BRAKE LINES RUSTING OUT NO WARNING NO BRAKES. ON HIGHWAY WITH MY GRANDCHILDREN WENT TO HIT THEE BRAKES WENT TO THE FLOOR I DID GET IT STOPPED AND TOWED HOME BUT COULD HAVE BEEN REAL BAD IF MY FAMILY WAS HURT. ONLY 100000 ON MY TRUCK AND WELL CARED FOR OIL AND EVERYTHING
TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500 HD. WHILE DRIVING UNDER 35 MPH, THE ABS WARNING INDICATOR ILLUMINATED AND THE BRAKES INDEPENDENTLY ENGAGED. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 136,800.
WHILE TRAVLING AT 3 MPH IN A CAMPGROUND AND TOWING A #7000 CAMPING TRAILER. I HIT MY BRAKES AND THE PEDDLE WENT TO THE FLOOR. IT TOOK SOME DISTANCE TO STOP. I GOT OUT AND FOUND THAT ONE OF MY BREAK LINES HAD A LEAK. UPON FURTHER INSPECTION . ALL THE BRAKES LINES HAVE HEAVY AND SEVERE RUST CAUSING THE BRAKE LINE WEAKEN AND THE BRAKES TO FAIL. ONLY BY THE GRACE OF GOD I WAS TRAVILNG AT 3 MPH AND STILL HAD NOT REACHED THE MAIN WINDING COUNTRY ROAD WHERE I WOULD OF WRECKED AND POSSIBLE DEATH OF ME OR OTHERS. . THE TOTAL WEIGHT OF TRUCK AND TRAILER WAS #14500 POUNDS.
MY 2005 SILVERADO THAT I BOUGHT BRAND NEW WAS BROUGHT IN FOR BODY WORK ON THE BED ON THE TRUCK. WHEN THE BODY SHOP REMOVED THE BED TO DO THE BODY WORK REPAIRS THEY DISCOVERED THAT THE FRAME, FRAME CROSS MEMBERS, LEAF SPRING SHACKLES, BRAKE LINES, SHOCK MOUNTS ARE RUSTED AND ROTTED THROUGH. NO UNDER COATING LEFT ANYWHERE ON MY FRAME OR UNDER MY GM SILVERADO. THE VEHICLE IS NOW DEEMED UNSAFE FOR THE ROAD AND GENERAL MOTORS KNOWING THE VEHICLE IS UNSAFE HAS SAID THEY CAN NOT HELP ME AND HAS NOT ASSISTED WITH REPAIRING THE TRUCKS FRAME AT THIS POINT.I AM STILL WORKING WITH GENERAL MOTORS TO ATTEMPT TO RESOLVE THIS ISSUE. THIS IS A KNOW ISSUE THAT GM DOES NOT WANT TO ADDRESS EASILY FOR US CONSUMERS. LONGEST LASTING TRUCKS ON THE ROAD IS THERE SLOGAN MY LASTED 8 YEARS. GUESS SILVER-ROT-O'S ARE DISPOSABLE TRUCKS AFTER 8 YEARS. GENERAL MOTORS WILL NEED TO STEP UP AND RESOLVE MY ISSUE OR I WILL NEVER BUY ANOTHER NEW GM PRODUCT EVER AGAIN. PLAN TO BRING THE TRUCK TO LOCAL DEALERS TO SHOW THEM THE DAMAGE WHILE THE BED IS OFF THE TRUCK. BOTTOM LINE IS THIS.... MY GM TRUCK IS UNSAFE FOR THE ROAD, GM NEEDS TO FIX MY TRUCK TO KEEP THIS LOYAL GM OWNER SATISFIED WITH THERE PRODUCT LINE. MIND YOU I OWN 5 GM VEHICLES MY WIFE'S GRANDFATHER SOLD PONTIAC'S FOR 50+ YEARS. THIS IS NOT THE WAY TO STAND BY YOUR PRODUCT GM AND THE EASIEST WAY TO LOSE A LIFE LONE LOYAL GM CUSTOMER. TOYOTA IS STANDING BY THERE TRUCKS BY FIXING FRAME ROT ISSUES FOR THEIR CONSUMERS YOU SHOULD TOO. MINE WAS BUILT IN CANADA JUST AS A SIDE NOTE. FIX MY 2006 SILVERADO TRUCK GM. STAND BY YOUR WORD AND HORROR YOUR SLOGAN AND MAKE MY SILVERADO THE LONGEST LAST TRUCK ON THE ROAD.
WHILE DRIVING HOME FROM THE BEACH AT THE END OF LABOR DAY WEEKEND I WAS COMING TO A COMPLETE STOP TO TURN ON TO RT 404, MY VEHICLE WAS THEN STRUCK IN THE REAR, I SAW IT COMING SO I APPLIED PRESSURE TO THE BRAKE AS TO NOT HIT THE CAR IN FRONT OF ME. AFTER THE ACCIDENT I NOTICED BRAKE FLUID RUNNING OUT UNDER ENGINE AREA. AND HAD NO BRAKES, VEHICLE WAS TOWED TO SHOP AND I WAS INFORMED THAT STEEL BRAKE LINE HAD RUSTED THROUGH. THIS WAS NOT A RESULT OF ACCIDENT JUST ADDITIONAL PRESSURE ON BRAKE, HAVING 2 OF MY 4 GRANDKIDS WITH ME IM GLAD IT HAPPEDED WHILE STOPPED AND NOT GOING 60 MPH ACROSS THE BAY BRIDGE, GM SHOULD RECALL ALL VEHICLES WITH THE SAME TYPE OF BRAKELINE ISSUE'S OR AGREE TO PAY FOR THE LINES THAT DO RUST THROUGH
MY TRUCK IS WELL MAINTAINED , AT APPROX 40,300 MILES, MY SERVICE AIR BAG LIGHT CAME ON FOR NO APPARENT REASON. I DROVE FOR A SHORT TIME KNOWING THAT MY AIR BAGS WERE DISABLED. A FRIEND AND I LOCATED AN IMPACT SENSOR THAT WAS BAD. I BELIEVE THAT IT WAS A SAFETY PROBLEM AND SHOULD HAVE BEEN CORRECTED BY GM. *TR
WHILE BACKING UP BRAKE LINE BLEW OUT CAUSING LOSS OF BRAKING. *TR
SPEEDOMETER AND OTHER GAUGES GIVE IMPROPER READINGS INTERMITTENTLY. *TR
BRAKE PEDAL WENT TO WITHIN 1/2 INCH OF FLOOR BRAKES CAUGHT AT LAST MINUTE AVOIDING A REAR END CRASH INTO CAR SITTING AT TRAFFIC LIGHT. INSPECTION REVEALED ALL STEEL BRAKE LINES ARE SEVERELY CORRODED AND LEAKING. ALL BRAKING WAS LOST WITH SEVERAL BRIEF PUMPS ON THE BRAKE PEDAL. NOTICE LOW MILEAGE. ALL BRAKE ROTORS WEE WARPED AND HAD TO BE REPLACED AT 13,000 MILES AND 4 YEARS OF SERVICED. BRAKE SYSTEM IS JUNK AND GM NEEDS TO REPLACE AT THEIR COST. UNCONSCIONABLE THAT GM HAS NOT BEEN CALLED TO TASK FOR THIS UNSAFE BREAK DESIGN. *TR
TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500 HD. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH, THE BRAKES FAILED TO RESPOND AFTER REPEATED PRESSURE WAS APPLIED TO THE PEDAL. THE EMERGENCY BRAKE WAS ENGAGED IN ODER TO STOP THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE FIVE BRAKE LINES WERE REPLACED DUE TO CORROSION. THE MANUFACTURER WAS NOTIFIED AND THEY INFORMED THE CONTACT THAT THERE WAS NOT A RECALL RELATED TO THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 110,000.
SPEEDOMETER ISSUE: READS AT LEAST 50 MPH SITTING STILL AND REGISTERS MORE THAN 140 MPG AT HIGHWAY SPEED. MY MECHANIC REPLACED THE SENSOR IN THE UNIT AND IT WORKED FOR ABOUT 2 WEEKS AND THEN IT MALFUNCTIONED AGAIN. COST TO REPAIR EXCEEDS $700.00 AS THE INSTRUMENT CLUSTER MUST BE REPLACED. THIS APPEARS TO BE A COMMON DEFECT WITH THESE VEHICLES. LACK OF A FUNCTIONING SPEEDOMETER IS A SAFETY ISSUE! TRANSMISSION ALSO REQUIRED REPLACEMENT AT ABOUT 80K MILES. *JS
WAS DRIVING ABOUT 60MPH AND SPEEDOMETER WENT TO ZERO THEN WOULDN'T GO PAST 15MPH AFTER THAT. SOMETIMES IT WORKS AND THEN NOT. *TR
TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500 HD. THE CONTACT STATED THAT WHILE MERGING ONTO THE HIGHWAY AT 10 MPH, THE VEHICLE LOST POWER WITHOUT WARNING. THE CONTACT MANAGED TO PUSH THE VEHICLE TO THE SHOULDER AND THE VEHICLE WAS TOWED TO THE DEALER WHO DIAGNOSED THAT THE HYBRID COMPONENTS FAILED. THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES BUT NO SUCCESSFUL REMEDY WAS DISCOVERED. IN ADDITION, THE VEHICLE WOULD SEIZE WHEN IN REVERSE AND THE CHECK POWER FLUID AND THE POWER STEERING WARNING LIGHTS WERE ILLUMINATED. THE CONTACT WAS ALSO EXPERIENCING THE FUEL GAUGE INDICATOR PROVIDING INACCURATE READINGS AND THE AIR CONDITIONER WAS ALSO FUNCTIONING ERRATICALLY. THE MANUFACTURER WAS NOTIFIED OF THE ISSUES BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 64,000 AND THE CURRENT MILEAGE WAS 65,000. ..UPDATED 01/16/2013 *BF THE CONSUMER STATED THE VEHICLE HAS BEEN AT THE DEALERSHIP FOR 10 MONTHS, WHERE THEY ARE UNABLE TO REPAIR IT. UPDATED 1/28/2013 *JS
AT LOW SPEEDS COMING TO A COMPLETE STOP, THE ABS BRAKING SYSTEM WILL FUNCTION AND PULSE CAUSING AN EXTENDED BRAKING DISTANCE. ALONG WITH IT BEING A SAFETY ISSUE IT IS ALSO AN ANNOYING NUISANCE ALWAYS HEARING THE LOUD PULSING OF THE ABS BRAKE. *TR
TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO1500 HD.THE CONTACT STATED THAT THE SPEEDOMETER GAVE INCORRECT SPEED INDICATIONS. THE CONTACT CALLED THE MANUFACTURER AND FILED A COMPLAINT. THERE WAS A SPECIAL MANUFACTURER'S RECALL FOR THE PROBLEM BUT THE VEHICLE WAS NOT INCLUDED. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 41,200 AND THE CURRENT MILEAGE WAS 41,374.
RATTLING IN STEERING COLUMN. STARTED AT 23,000 MILES. GETTING PROGRESSIVELY WORSE. GETTING WORRIED ABOUT STEERING FAILURE. *CN
I HAVE A 2005 CHEVY 1500HD QUADRASTEER PICKUP TRUCK. THE REAR END STARTED MAKING A GRINDING SOUND IN THE REAR AXLE HOUSING AT 63000 MILES. I HAD A REPAIR OF $2178.1. I MAKE A LIVING AS A MECHANIC AND DO NOT BELIEVE THIS TO BE A WEARABLE DEFECT AFTER 4 YEARS AS I WAS TOLD IT TO BE THE LEFT REAR CV JOINT AXLE SHAFT. WHEN I CALLED CHEVY THEY WOULD NOT PROVIDE ANY ASSISTANCE FOR THE REPAIR. THIS IS UNSAFE DO TO IT CA CAUSE THE AXLE TO LOCK UP AND CAUSE AN ACCIDENT. I WAS LUCKY AND HAD IT REPAIRED BEFORE THAT COULD HAPPEN. *TR
2005 CHEVY SILVERADO THE SPEEDOMETER WORKS INTERMITENTLY. *TR
MY GAS GAUGE IS GOING CRAZY, I FILLED UP MY TANK AS USUAL AND WHEN I STARTED THE TRUCK IT WENT TO FULL THEN TO EMPTY. NOW THE GAUGE FLUCTUATES ALL THE TIME SO IM NOT SURE HOW MUCH I HAVE. *TR
PROBLEM WITH ABS BRAKES PREMATURELY ACTIVATING AS I AM COMING TO A STOP. I SLOW DOWN AND WHEN I'M ALMOST TO A STOP THE ABS KICKS IN AND THE PEDAL DROPS DOWN LOWER THAN ANTICIPATED. THIS ALMOST CAUSED AN ACCIDENT. THIS NOW HAPPENS ALL THE TIME AND I'M SENDING THE CAR IN FOR SERVICE ON 8/5/08 TO JOE ROMANO CHEVY IN SYRACUSE, NY. MY UNDERSTANDING IT THAT CHEVROLET HAD A RECALL FOR THIS IN EARLIER MODEL YEARS. IT APPEARS THAT THEY HAVE NOT CORRECTED THE PROBLEM AND THE RECALL SHOULD BE EXTENDED. *TR
TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500 HD. THE CONTACT STATED THAT THE SPEEDOMETER MODULE SENSOR IS FAILING. AS A RESULT, HE HAS BEEN UNABLE TO DETERMINE HOW FAST HE IS DRIVING AT TIMES. THE DEALER AND MANUFACTURER STATED THAT THERE WERE NO RECALLS FOR THE DEFECT AND NOTHING COULD BE DONE. THE FAILURE MILEAGE WAS 100,000 AND CURRENT MILEAGE IS 105,100. UPDATED 01-29-08. *KB
DT*: THE CONTACT STATED WHILE TRAVELING 30 MPH DOWN HILL ON NORMAL ROAD CONDITIONS AND ON TWO SEPARATE OCCASIONS CARRYING A LOAD SUCH AS A TRAVEL TRAILER IN ONE CASE AND A HORSE TRAILER ON ANOTHER, THE MANUAL TRANSMISSION LOCKED UP ALMOST CAUSING AN ACCIDENT. THE VEHICLE WAS TAKEN TO THE DEALER TWICE AND ON EACH VISIT THE TRANSMISSION WAS REPLACED BUT THE PROBLEM PERSISTED.
I PURCHASED MY CHEVROLET EXTENDED CAB SILVERADO TRUCK APPROXIMATELY 7 MONTHS AGO. TODAY MY BRIDGESTONE V-STEEL RLB265 RADIAL LT245/75R16 LOAD RANGE E MTS 120/116S TIRE BLEW OUT. THE BLOW OUT OCCURRED ON THE SIDE OF THE TIRE (ABOUT THE 'E' IN THE WORD BRIDGESTONE. THERE WAS NO FOREIGN OBJECT - IT APPEARS TO HAVE BEEN A WEAKNESS IN THE TIRE WALL. I ALMOST CAREENED INTO ANOTHER CAR - SINCE I WAS JUST BEGINNING TO MERGE ON FROM ONE EXPRESS WAY TO THE OTHER. THIS IS VERY DANGEROUS & NEEDS TO BE RECTIFIED BEFORE SOMEONE IS EITHER INJURED OR KILLED. IS THIS GOING TO KEEP OCCURRING WITH THESE TIRES? IF SO, I WANT ALL 4 REPLACED WITH SOMETHING DIFFERENT. *JB
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .