Owner-reported complaints naming the brake system, filed with NHTSA
Data refreshed
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake. Every record below is an owner-reported complaint about the 2021 Chevrolet Silverado 1500 submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 44 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
The 25 most recent of 44, in the owner's own words
Turned from [XXX] into my street, about 9 houses down, i could not brake or turn steering wheel. Ended up hitting 2 cars, the problem was that the air bags did not deploy and the seat belt did not lock. truck was totalled. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that while driving at an undisclosed speed, the message that the rear seats were occupied and that the windows were rolled down was displayed, which required the contact to press the OK button. The vehicle was taken to the dealer where it was purchased, but no assistance was provided. The traction control and the ABS warning lights were illuminated while depressing the brake pedal. Additionally, the cruise control mode was inoperable. The contact replaced the brake pedal position sensor independently, and the vehicle was taken to an independent mechanic, who reprogrammed the sensor. The contact stated that after the repair, the brake lights erroneously illuminated while the vehicle was turned off, causing the battery to drain. The contact disconnected and reconnected the battery, which reset the vehicle; however, the failure recurred. The vehicle was not further diagnosed or repaired. The manufacturer was not contacted. The failure mileage was 110,881.
I was on the highway doing 70 MPH with my family driving down I-40 through western NC (mountainous terrain) when my brakes went out and the vehicle went into limp mode. I was able to safely pull over thank God and then had my vehicle towed to the dealer. The dealer just informed me that a software update is needed, and not covered under warranty. There are multiple safety bulletins coming out for related years and issues related to the braking system of this make/model and I would like this documented as well as Chevy to cover the cost of repairing this defect.
Loud ticking noise and power loss. Transmission shift slips from 2nd to 3rd . Called factory and dealership for check up. Said no problem… Told to Change oil. Did this, NO CHANGE.
While driving my 2021 Chevrolet Silverado 1500 Trail Boss, multiple warning lights and messages suddenly appeared related to the ABS and brake system. The brake pedal became extremely difficult to press and the truck became unsafe to drive. The issue happened unexpectedly while the vehicle was in operation, creating a serious safety hazard and risk of accident or injury. After the incident, the truck was inspected by a mechanic who advised that the brake booster had essentially fallen apart and that I effectively had little to no braking capability. I was also informed that the condition and quality of the braking components were not acceptable for a vehicle of this age. This vehicle is only five years old and has been regularly maintained. For approximately the last three years, routine maintenance including oil changes, tire rotations, and inspections were performed at a Chevrolet dealership. At no time was I warned of any brake-related issue or safety concern. A major brake system failure should not occur suddenly on a properly maintained vehicle, especially without warning. This incident was extremely dangerous and could have resulted in a serious crash. I am submitting this complaint because I am concerned there may be a defect involving the brake system, brake booster, ABS system, or related components on this vehicle.
Once I disengaged the auto stop on my vehicle, I would accelerate from a stop and I would loose my brakes. This happened several times. I took it to the shop and was told it was fine. Finally, one day I was descending on an overpass, disengaged my auto stop and my brakes were complete failure, even my emergency brakes, my check engine light engaged (the code read emissions issue). Was able to stop in a field, get it back to the dealership to find out I lost the master break cylinder but no indication on prior visits. The truck, check engine light will spontaneously start blinking but hold no codes. I have had it routinely serviced and it will overheat and oil will run hot but mechanics find no issues
Two grounding straps failed on my 2021 Silverado Trail boss lt. GM has a recall for this exact problem under N252515590, model years 2019-2024. Apparently my vin number is not associated with this recall, yet my dealer just did the recall repair. They said my truck did not qualify for the GM recall and I was forced to pay for the repair. The failing grounding straps caused my power steering to go out and my brake system and safety traffic sensors to fail as well. This was very dangerous as it would fail randomly while driving the truck. There were no warning signs or lights on the the truck to indicate any problems.
The contact owns a 2021 Chevrolet Silverado 1500. The contact stated while driving at various speeds, the vehicle started shaking abnormally. The Service Electronic Stability Control (ESC) warning light, Parking Brake warning light, a wrench warning symbol, and the check engine warning light were illuminated. The vehicle was not taken to the dealer to be diagnosed or repaired. The manufacturer was informed of the failure and confirmed that there was no recall associated with the VIN. The contact was referred to the NHTSA Hotline to report the failure. The failure mileage was approximately 125,000.
Master Brake Cylinder failed according to dealership. This however is the second time this issue has occurred. This system failure caused brakes to not respond correctly leading to risk of collision. My safety and my kid's safety was put at risk due to issue happening while vehicle was in drive. Part was initially replaced in April of 2025 and issue has occurred two more times since then in December of 2025 and February of 2026. Vehicle has been inspected by dealership multiple times but has not been fixed. Symptoms of issue included clicking sound when pressing brake pedal and becomes stiff. There were warning in the dash and lights: "Brake System Failure", "43MPH Top Speed", "Service ESC" and "Service Brake System". Along with Check Engine light, Brake light and Traction Control light.
The contact owns a 2021 Chevrolet Silverado 1500. While driving 43 MPH, the message "Brake Failure" was displayed. The contact then lost control of the vehicle, and the vehicle drove from the right side to the left side of the road, the vehicle drove off the road and crashed into a ditch before coming to a stop. The driver had not sustained any injuries. There was no property damage. The air bags did not deploy. The check engine, the ABS and several unknown warning lights were illuminated after the failure. A tow truck driver who was also a mechanic inspected the vehicle and informed the contact that the driver's side front suspension had fractured from the upper ball joint and the wheel was folded in underneath the vehicle. The vehicle was towed to the dealer, where it was being diagnosed. A Police Report was filed. The manufacturer was not notified of the failure. The failure mileage was approximately 98,000.
The brake stopped working. I just bought the car two months ago.
The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that while driving approximately 65 MPH and attempting to decelerate, the brake pedal extended to the floorboard while depressed, and the vehicle failed to immediately decelerate. During the failure, the message "Brake Failure" was displayed. The vehicle was later towed to the local dealer. The cause of the failure was not yet determined. The manufacturer was notified of the failure. The failure mileage was 94,000.
I have this pick up I was on a hill heading down to stop sighn pressed on brake and went to the floor no resistance nothing luckily it was a rural rd went thru stop sigh coasted to a stop was 1/4 from home lifted hood the brake reservoir was full all brakes were in top shape it was like something shut off the brakes electrically I have driven many large trucks and buses and vehicles never felt this no spongey at all it is at the dealership they are looking at but my concern this could be a far worst circumstance if in heavy traffic or at cross walk can’t even think of it. Scary I would think gm would have some type of secondary for electric malfunction the vehicle is at Cerrone gmc south Attleborough mass. My vehicle is 2021 Chevy Silverado 75000 miles well maintained. In short I believe the mechanics will diagnose and fix it but my concern. That these vehicles need safety checks
2021 Silverado 1500 TrailBoss LT Brake Sensor Monitor failure causes you not to be able to see brake pad wear/life remaining on dash information. Brake Pads (front and rear) replaced with sensor on 12/14/2023 and was unable to reset the brake pad monitor on dash (would not reset passed 51%) at approx 32K miles 01/2024, Front Left Sensor Monitor replaced again by dealership for $293 06/2025 Truck prompting if brake pads were replaced recently on dashboard 06/13/25 Brake Pad Life showing at 71% Front and 77% Rear at approx 50K miles 06/14/25, Brake Pad Sensor Monitor Error Message
First my engine light came on and as I was in my way to the dealership I lost my brakes. It stayed at the shop for a week before I was contacted only for them to tell me that there was metal shaving in my engine oil and they recommend full replacement, meanwhile haven’t even made it to my brakes. GM offered me 3K toward replacing the 13K+ engine. That’s so unacceptable!
I am reporting a safety concern that I believe should be included in an existing or expanded recall for the Chevrolet Silverado. The issue involves engine replacement due to metal shaving being found in oil & brake failure, which occurred on 05/01/2025 The problem with the brakes occurred while I was in heavy traffic in Dallas, Texas multiple times, resulted in multiple near-accident experiences that day. The truck has been diagnosed by a mechanic, at the Chevy dealership and I believe this defect poses a serious safety risk and may be affecting other Silverado vehicles outside the current recall scope. I have driven the vehicle to Chevy and stayed in constant contact with the dealership, had diagnostics done, but the issue has not been resolved. am requesting that the NHTSA investigate whether this issue warrants inclusion in the current recall or a new safety campaign. I have on had this vehicle less than 2 years and I put less than 70K miles on it. I purchased it from vandergriff Chevrolet in Arlington, TX
Metal shavings were found in my oil after the check engine light came on a day before I took it in. The day that I took it in my brakes limited the speed of my truck to 43 mph due brake malfunction. The dealership called and told me that they recommend engine replacement due to the metal shavings found in the oil. I can give more in depth info as I receive it but I just wanted to alert Chevy that my vehicle is doing the same thing that the others are getting recalled for.
The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that while driving approximately 50 MPH, the engine started rumbling with the check engine, stability-trac, and the parking brake warning lights illuminated. The vehicle was taken to an independent mechanic who diagnosed a misfire in cylinder #1. The mechanic referred the contact to the dealer for assistance. The vehicle was taken to the dealer, who diagnosed that the lift valve had collapsed, and the right side of the block lifters needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure and referred the contact to the dealer for assistance. The failure mileage was 80,000.
When putting vehicle in PARK and releasing the foot brake it rolls back an excessive amount of space sometimes it rolls back so much we begin to get scared thinking we are still in DRIVE and jump back in vehicle just to learn we are in PARK. We have had this issue since the day of getting truck in August of 2024 and how much it rolls back is never consistent on the length of the roll back. Sometimes it feels like it make even slip out of gear and just keeping rolling. It’s very scary and we have almost knocked ourselves out when it happens trying to jump back in to stop it.
Mechanics said that they see this on all new chevy trucks that the bracket causes the rubber brake line to rub on the bracket holding it in place also causing it to stretch and tear. Resulting in a over 500 dollar fix. The brakes failed on the interstate causing them to lock up. Almost killing me and my daughter but was able to gain control of the vehicle and save it.
While leaving work I started the truck like normal and the dash lit up like a Christmas tree. Saying service ESC, service power steering,and service brake system. The ESC light was on as well as the check engine light. There was no forewarning about this.
I took my car to the dealership four times because the engine light and the ESC light kept coming on. It kept saying there was a misfire so they changed the spark plugs and did a gas treatment after I left the dealership the light came back on so I returned the next day. They change one wire that’s what they told me. The problem was so I left engine light came back on. I returned the next day then they changed the wires I left the facility again. The next day I got them started the car, the same problem, engine light, and the ESC light and now they have the car in the shop and they need to break the engine down to see what’s causing the misfire and to find out if I need a new engine or not. Who is all that shit right now?
I was driving along about 45 mph and the truck was cruising in overdrive so about 1500 rmp on tachometer. I hit the gas to climb a hill as truck started to lose speed and when it tried to shift out of od to pick up speed the brakes seemed to slam on and I skidded to almost a stop. This has happened several times when climbing a hill or anytime I have to pass a vehicle or accelerate from out of overdrive. The dealer could never seem to get it to reproduce during test drive. They recently said there is a service bulletin for this exact issue and are waiting for a new valve body for transmission. My service records show I had a new valve body installed last year due to transmission pump bearing coming apart internally. The valve body is only a year old. But this is a very dangerous situation. I have to drive my truck for work and I have to be really cognizant of how hard I touch the gas and what gear I am in. If this happens to anyone while on the freeway and a semi or another vehicle is too close their truck will downshift and lock brakes and it could cost a life. It only happens under these circumstances but it has to be a recall. A service bulletin doesn't get it as someone has to have it happen for it to even be looked at. I have to drive my truck as I do not have a choice. But a service bulletin shows that GM I'd aware of the issue but they are unwilling to do a recall. A lotnof silverados are on the road and inwould hate for anything to happen. It could ruin a lot of lives.
The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that while driving at approximately 25 MPH and traveling down a 5 percent grade hill, the brake pedal depressed to the floorboard on several attempts. The vehicle failed to slow down. The driver continued to pump the brake pedal. The contact engaged the parking brake. The service trailer brake system and the engine warning lights were illuminated. The contact had an independent mechanic reset the brakes. The vehicle was taken to the local dealer, where it was diagnosed that the brake master cylinder booster system needed to be replaced. The vehicle was not repaired due to parts not being available. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 49,400.
Started having a rubbing sound in rear end of vehicle. Took it to dealer. Brake calipers are a issue on this model and dealer says, “ found updated rear brake calipers with deflectors to help with dirt in rear calipers/not covered under warranty customer pay expense”, they are replacing rotors under warranty that got worn out. They want me to pay $2400 to purchase and have the “updated brake calipers” installed. If brake calipers are updated then that means there is a known issue with them. Spoke with the manufacturer and they said too bad.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .