2017 Chevrolet Silverado 2500 Owner Complaints

The contact owns a 2017 Chevrolet Silverado 2500. The contact stated that while driving approximately 15 MPH, the steering wheel became loose. The contact stated that there was an abnormal amount of slack in the steering wheel. The steering wheel failed to operate as intended. There were no warning lights illuminated. The vehicle was taken to the local dealer to be diagnosed and it was determined that the steering bushing needed to be replaced. The vehicle was repaired under the warranty, but the failure recurred three years later. The manufacturer was contacted and a complaint was filed. The failure mileage was approximately 105,000.

NHTSA ID

11675545

Incident

Jun 1, 2022

Mileage

105,000 mi

Driving down the road under 40mph and headliner airbags deployed without an accident. The dash and steering wheel bags DID NOT deploy however the headliner bags deployed for no reason.

NHTSA ID

11631884

Incident

Dec 20, 2024

Vehicle will crank but will not start. Throws code u0109. Fuel pump control module is on backorder with no estimated time frame. I am not the only person this is happening to with a truck that we are making payments on and will not run.

NHTSA ID

11621141

Incident

Oct 11, 2024

Engine shut off while driving on the freeway (70mph), lost steering and braking capacity. lucky to make it to shoulder, The failure is the Fuel pump control module, second time(first failure at 48k miles, second at 98k miles) this has failed (part # 13558813). once this fails part is impossible to find. repair technicians at dealer says this is a very common failure. To my knowledge part has not been inspected. Dealer is not an option for repair due to the length of time they will keep vehicle (in key west was going to ve 3 months before they could look at it,) this failure the local dealer in Athens Ga, did not have a diesel mechanic to repair (not sure why this needed a diesel mechanic), Warning lights/message is : Reduced engine power....but did not say why reduced, engine just slowed and shut down in very heavy traffic.

NHTSA ID

11616334

Incident

Sep 19, 2024

Power steering has failed. Truck drives stiff without power steering.

NHTSA ID

11613373

Incident

Sep 5, 2024

“Service Trailer Brake System” warning on DIC. Vehicle undriveable, INOP, Safety Issue! Start truck, the above warning will flash off and on, Code C1117 DTC.

NHTSA ID

11612457

Incident

Aug 30, 2024

SOLVED my U029E with "Exhaust Fluid Service" and "Reduced Speed". For the past month I have been working on this issue on my 2017 Silverado 2500HD LT 6.6L. Tonight I purchased my 3rd NOX2 (downstream) sensor and IMMEDIATELY EVERYTHING WAS FIXED. So, what happened? Why did the previous 2 NOX sensors NOT work? A clue came from GM Parts Direct as the original part number was listed as "DISCONTINUED". Previously we had purchased 2 numbers matching NOX2 sensors 12676706. So why did these sensors not work when the one see image below immediately worked? CHEVY! They programmed out part number 12676706 from the computer and programmed in 12718676. 12718676 CURED OUR U029E and "Exhaust Fluid Service" and "Reduced Speed" issues. Companies are still selling NOX2 part number 12676706 because it was the original device DO NOT PURCHASE THE DISCONTINUED NOX2 SENSOR 12676706. INSTEAD PURCHASE THE 12718676 PART NUMBER.

NHTSA ID

11600634

Incident

Jul 9, 2024

2017 CHEVY SILVERADO 2500HD LT 6.6L It all started on June 15, 2024 with a TRAILER BRAKE CONTROLLER (chafing wire that was grounding and shorting against the frame and bumper) resulted in a barrage of issues. Our truck being down over a month and throwing (so far) 16 codes just on the first 2 scanners. It has also taken out the TPMS too. U0137 Trailer Brake Control Module P1050 Reductant Level Sensor P11DB NOX SENOR 1 U0076 CONTROL MODULE COMMUNICATION POWERTRAIN SENSOR U101E LOST COMMUNICATIONS WITH DEDUCTANT CONTROL MODULE U029D LOST COMMUNICATIONS WITH NOX SENSOR 1 U029E LOST COMMUNICATIONS WITH NOX SENSOR 2 U02A3 LOST COMMUNICTIONS WITH PARTICULATE MATTER SENSOR U18A2 LOST COMMUNICATIONS WITH FUEL PUMP P203C REDUCTANT LEVEL SENSOR CIRCUIT LOW P204C REDUCTANT PRESSURE SENSOR CIRCUIT LOW U029E LOST COMMUNICATION WITH NOX SENSOR 2 P20B9 REDUCTANT HEATER 1 CONTROL CIRCUIT OPEN P0307 CYLENDER 7 MISFIRE P1488 TP MOTOR CONTROL CIRCUIT P0097 INSTAKE AIR TEMPORATURE (IAT) SENSOR 2 Upon having an advanced system scan there was an ADDITIONAL 128 CODES. Most of the codes referring to voltage to high and voltage to low. The entire truck is shutting down electrically and we can only assume that this will result in one of two options. First is that the vehicle will catch fire because of the system wide KNOWN WIRE CHAFING electrical issues. Second is that the vehicle is totaled / junked since Chevy will neither recall the KNOWN issues and is too busy changing customers for FRAUDULENT repairs that their vehicles do not need. Take for example P0307 which Chevy wanted $165 for the diagnostic fee and over $650 to replace cylinder 7 injector along with time for the repairs (over $1,000) for a $14 KNOWN wire connector issue that Chevy is performing fraudulently. Chevy CANNOT continue to lock the center information screen. That information is vital to our driving.

NHTSA ID

11599344

Incident

Jul 5, 2024

Another day another code. P11DB (NOX upstream). Now I am at NOX downstream, NOX upstream, DEF pump, cylinder 7 wire connector, Trailer Brake Controller wire harness, temperature sensor, and a dozen chafing wire harnesses because they are pulled to tight, have extreme bends in them or are rubbing against the frame, bumper, etc. Chevy recommended that I replace the cylinder 7 injector which was not the issue. At this rate if I paid Chevy to diagnose and repair this vehicle I would easily be $5,000+ in repairs since Chevy wants to do cab-off maintenance on everything now. This is manufacturer defects and consumer fraud and NTHSA is not holding Chevy accountable for. My Dad has a 1978 Pinto that he can start up and run to town but my 2017 Silverado can't even leave the farm.

NHTSA ID

11596526

Incident

Jun 25, 2024

This is my 3rd complaint within 6 days. The entire electrical system in this 2017 Silverado 2500HD LT 6.6L appears to be committing suicide. First it was the Brake Controller Unit, Diesel Injector Connector (cylinder 7), P1050 DEF Level Sensor, U029E NOX Sensor Module 2 Communication Lost, U02A3 Lost Communication With Particulate Matter Sensor Module, and now P018B Code: Fuel Pressure Sensor "B". At what point will the manufacturer be held accountable for manufacturer defects on this vehicle (including the Dorman 603-009 Coolant Reservoir)? Every pump and sensor on the truck is failing within a week of the trailer brake controller failure? WHY is every wire harness on this vehicle (like so many others) failing? I cannot trust that I can even drive this vehicle without either STABILITRAC shutting it down or the defective wire harnesses catching fire.

NHTSA ID

11595734

Incident

Jun 21, 2024

Engine wiring harness failure on my 2017 Silverado 2500HD LT 6.6. This time it is the cylinder 7 connector which is a very common complaint by Chevy owners. The wiring harness was installed with wires that were to short for the rear cylinders causing them to fail prematurely. This connector is snapped into position forcing the wires to bend at a tight 90 degree angle. Chevy is trying to force owners to replace the entire wiring harness instead of replacing just the defective connectors (GM 19368140, ACD PT3739). This failure causes the engine to idle and operate so rough that it engages STABILITRAC and forces reduced power mode.

NHTSA ID

11595390

Incident

Jun 19, 2024

On [XXX], I was driving our 2017 Silverado 2500HD LT 6.6, with my family in Ohio when the trailer brake controller error started flashing on the dash and would not shut off, go silent nor correct itself. It almost caused an accident initially because it was distracting me by making me look down to READ the message. Then we were almost in a dozen accidents as we were traveling too slow for conditions, unable to get off the highway safely, and issues with steering and braking. In 10 minutes, the error sounded 50+ times. We were towing a 36’ 5th wheel trailer suddenly STABILITRAC also kicked on, REDUCED POWER (another message to look down and read), the engine started running so rough (another issues to look down at the gauges) that I thought the engine had blown. We were not in a safe place to pull over and power was cut dropping our speed from 70 to 45 in a 70 zone. Just after going up the hill, we had to continue down other side which we discovered that the trailer brakes were NOT operational. As we were burning our truck brakes going down the other side. The only reset is to shut off the key (which would lock the steering wheel, lose power steering and power brakes while driving). When STABILITRAC appears vital drivers data is BLOCKED. We removed the trailer brake fuse and the trailer battery charger fuse, but the TRAILER BRAKE CONTROLLER messages continued. Even with the trailer disconnected the the messages continued. The trailer brake wire under the truck had exposed wires. Did the exposed wire cause other systems to malfunction? 1.Are the defective wiring harness(es) causing other systems to fail too, and/or can cause electrical fires? 2.Defective trailer braking unit needs to give one warning and STOP. This defect poses a serious issue for anyone towing (or not). 3.STABILITRAC is going to KILL someone because I believe it already has killed. If STABILITRAC throughs the right code it WILL shut down the engine. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C.

NHTSA ID

11594544

Incident

Jun 15, 2024

I was driving with my front and rear motoried window defrost on because its cold outside right now when I started smelling something burning. I turned down the defrost knob. I opened the driver side window to air our the smell when suddenly the rear motorized window defrost sparked up into flames while I was driving. It was in full on burning up in flames. I pulled over and luckily I was able to put out the fire. I have contacted GM because when I google this issue it states GM put out a recall on 2014-2019 Silverado HD trucks but upon speaking with a GM customer representative my truck there is no such recall on these trucks. I could have been killed or worse killed someone else on the road. I am considering getting a lawyer involved with this issue.

NHTSA ID

11568772

Incident

Jan 28, 2024

The capless fuel filler has failed. The door is stuck halfway open. This is a fire hazard if the truck were in an accident. My son has the same year model truck. Same exact specifications just a different color and hus has also failed. This should be recalled immediately because it's a fire hazard not to mention the emissions of the vehicle.this picture is looking straight down on the filler you can see it is not closed.

NHTSA ID

11551259

Incident

Oct 22, 2023

Transmission failure for the second time. the first time it happened it had 51,984 miles after I got it back, it happened again after an additional 41 thousand miles.

NHTSA ID

11513253

Incident

Mar 22, 2023

The engine glow plugs keep failing, I have replaced 4 already and 2 more are now failed. The vehicle only has 66K miles on it currently and the failures started around 50K. I do not understand why this hasn't been recalled like the 2018 trucks, they share the exact same engine.

NHTSA ID

11512491

Incident

Mar 17, 2023

When transiting between airport and home in very remote area in subzero temps the DEF warning system suddenly came on limiting vehicle speed progressively. No services were available both at this time of day and in this very remote area. There needs to be some way to override this system in the case of potential life and death. There were no warnings that this system was going to activate, it simply came on. The system had plenty of fluid but it appears the DEF heater failed. A vehicle should have an override for life and safety matters. Vehicle is going to a diesel mechanic for service now.

NHTSA ID

11495697

Incident

Nov 27, 2022

At about 62,000 miles the vehicle check engine light came on with codes P0700 and P0741, the RPMs go up as you accelerate but will not shift unless you let off the gas pedal. Reaching 5-6000 RPMs. Had mechanic drop transmission pan no metal found. Reading several TSBs on this issue the transmission should be recalled. Also when towing camper there was some electrical issues when the trailer was contacted the truck would not recognize trailer connected, had to shut the truck off for few minutes and restart to recognize the connection. Truck also lost power when trailer was connected and ran very sluggish, also experienced the shifting issues.

NHTSA ID

11491745

Incident

Sep 16, 2022

I was on a 2 hour drive hauling my 8000lbs trailer when the service trailer brake alarm went off. It constantly dinged the whole 2 hour trip and caused my trailer brakes not to work putting me and my family in danger hauling such a load with no brakes. Not only do I have no brakes but the truck is deemed undrivable due to the constant distractions of the dinging. It also inoperates the message screen to see my speed or to use any other functions like voice commands and radio. I have numerous shops look at it and wasted a few hundred bucks in parts and labor to find this problem with no resolution insight. This is due to a faulty wiring harness somewhere in the truck.

NHTSA ID

11453146

Incident

Feb 1, 2022

The contact owns a 2017 Chevrolet Silverado 2500. The contact received notification of NHTSA Campaign Number: 21V496000 (Equipment) however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced the failure. VIN tool confirms parts not available.

NHTSA ID

11447041

Incident

Jan 1, 2022

On 09/30/2020, I purchase a used 2017 Chevrolet 2500HD work truck. Since the day I started driving, I been replacing tires every 2-3 months. I was told by different people, it’s normal because of weight. I took the truck to, suspension specialist, he said it was axle and wanted to charge 4000, didn’t have that money and decided to change tires, instead. I called dealer and explain, he said that maybe I cause it. This people are no help. Today, 11/18/2021- 5:18 pm, the center of the truck, between cab and rear bed, is sunken, it looks like the body frame got bent. It’s bad. I call dealer and spoke to Mr. Arbi, he said there’s nothing he can do and it’s my problem. I’m not going to start arguing and just told him thank you and decide to report him. When I bought it, I was told it was on a minor accident, nothing major. I don’t think so. I’m no expert, and I can see the body frame, bent. This dealer got me upset, just thinking that I’m stuck with this problem, and now I need to figure out how to fix, is the body frame. Please, help me, advise, what can I do, since I finance this truck. I, can’t drive it, I need to tow. I wish I can send picture. Thank you, any information will be appreciated. Miles when I bought, approx. 75000+. Miles today 11/18/2021. 143764

NHTSA ID

11440973

Incident

Nov 18, 2021

The contact owns a 2017 Chevrolet Silverado 2500. The contact received a notification for NHTSA Campaign Number: 21V496000 (Equipment) however, the part to do the recall repair was unavailable. The dealer had been notified about the recall; however, the contact was informed that parts were not yet available. The manufacturer had been notified of the recall. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. VIN tool confirms parts are not available.

NHTSA ID

11440927

Incident

Aug 1, 2021

I recently began getting “service trailer brakes” on my screen. This only occurs when towing trailers and not a single trailer. These trailer do not cause the alarm on similar vehicles either. I took it to the shop who didn’t look at my vehicle for a week. During this time my cell booster was plugged in the whole time, which drained the battery. The tech called and said it was a low voltage issue. I told him to disconnect the cell booster and charge the battery. He did and no more low voltage. Then he stated that there was no problem with the trailer brakes. I asked how that system was tested and he said they didn’t ave a way to test it. Hmmm. There are number of these complaints all over the internet with the same “code” and GM is not able to, and unwilling to diagnose it and correct it.

NHTSA ID

11440559

Incident

Oct 30, 2021

The contact owns a 2017 Chevrolet Silverado 2500. The contact received notification of NHTSA campaign number: 21V496000 (Equipment) however, the part to do the recall repair was unavailable. The vehicle was taken to the local dealer who stated that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not notified of the issue. The contact had not experienced a failure. Vin tool confirms parts are not available.

NHTSA ID

11431098

Incident

Aug 1, 2017

TL* THE CONTACT OWNS A 2017 CHEVROLET SILVERADO 2500. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30-35 MPH, THE VEHICLE FAILED TO SHIFT GEARS CORRECTLY. THE VEHICLE WAS TAKEN TO SHERRELL CHEVROLET INC; (2258 N 1ST ST, HERMISTON, OR 97838, (541) 567-6487) WHERE THE MECHANIC CLEANED THE TRANSMISSION SENSOR AND THE FUEL INJECTORS HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN BACK TO THE SAME DEALER TO BE DIAGNOSED. THE MECHANIC STATED THAT THE VEHICLE NEEDED TO BE SEEN BY A SPECIALIST FROM CHEVROLET. THE CONTACT STATED THAT THE DEALER REASSEMBLED THE TRANSMISSION HOWEVER, THE TRANSMISSION FAILURE WORSENED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 28,044 AND WAS UNDER ALL NEW WARRANTIES .*DT Consumer contacted Chevy Customer Assistance and case number [XXX] was issued and case worker Dalea, phone number 866-790-5600 on 8/18/20. Consumer contacted another dealer and was told the same thing transmission needs to replaced. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).”

NHTSA ID

11403549

Incident

Dec 1, 2019

Mileage

28,044 mi