Reports submitted to NHTSA by owners and drivers, shown in full
Data refreshed
Our database holds 52 NHTSA owner-reported complaints for the 2018 Chevrolet Silverado 2500. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Showing 1–25 of 52 · page 1 of 3
Vehicle displays airbag deployment codes, airbag sound was heard, airbag agent smell is present yet no airbags were deployed in the vehicle. Yes it is available for inspection on request, it will be inspected by insurance adjusters in the next week.
2018 Chevy Silverado 2500Diesel Duramax (63,000 miles & Garage kept) While pulling 37' camper on flat terrain, Push Rod bent and broke in half - violently shaking and missing; Engine was ruined. Engine light did not appear until after it started shaking. Luckily this happened before crossing over steep mountain where we would not have been able to get off road or control vehicle and camper behind us. Truck was towed to Chevy dealership; had to wait until 10 days to learn extent of damage. Repair cost was going to be $26,000 and though our truck's trade in value was $37000 before this event, we were offered just $12000 for trade in. Though we had been led to believe that a Chevy Duramax was highly regarded for durability and longevity, we decided to purchase a RAM Truck. NO MORE CHEVYS for us! Contacted Chevy Customer Assistance but because we traded, they would not offer any financial assistance because we took the dealership's offer and traded the next day. We just couldn't stand a $26000 hit on an 8 year old vehicle and had to absorb that amount with our trade in.
Frontal driver airbag deployed spontaneously while vehicle was stopped at a stop sign. No collision or impact occurred. Deployment produced excessive smoke and heat. Minor burn to hand resulted from deployment.
The truck kept going into limp mode and when taken to the dealership it was found to have metal in the fuel. According to the report from the dealership they stated that this indicated the injection pump had come apart internally and sent metal throughout the system. It has since been repaired at a high cost to myself. The generation of truck made before mine had a recall for the same thing and I feel that they have not fixed the problem or it wouldn't have happened to my truck. Seems like a manufacturing defect. When in limp mode the truck does not operate at the speed limit required for highway driving. There was no indication prior to the failure.
Rear defroster seemed to short circuit and over heated causing my back window to break. There was no warning, no light that alerted me to this going on. I had it inspected by a local Chevy dealership and they have indeed confirmed that it short circuited and caused the damage to my rear window. They also removed the fuse to prevent anything further from happening and told me it could have completely caught on fire.
Odometer Fraud. The contact purchased a 2018 Chevrolet Silverado 2500. The contact discovered a mileage discrepancy after the purchase. The vehicle was a private sale. At the time of purchase, the vehicle mileage was 92,985. While attempting to register the vehicle, it was discovered that the title mileage was approximately 215,000.
Odometer Fraud. The contact purchased a 2018 Chevrolet Silverado 2500. The contact stated that while having a State Emissions Test performed on the vehicle, it was discovered that there was a mileage discrepancy. The vehicle was a private sale. At the time of purchase, the mileage was 75,200; however, it was discovered that on January 17,2024, the mileage was 265,005.
tail light assembly falls out of the truck body due to faulty bolt connections that fail ( crumble and break off) due to heat from parking in the sun
2 low pressure fuel pumps have failed. truck stalls in traffic. currently in show with extremely large bill for repair.
Driving down the road in heavy traffic and had complete engine failure due to loss of fuel. Diagnosed as fuel control module. I have seen where GM recalls have been made for similar issues. This put me in danger of collision. Truck is at the dealer and will cost $957.00
70,000 mile complete transmission failure despite being serviced on-time, as per the guidance. Failure happened while driving and it became dangerous to try to maintain highway speed. Quoted $8390 to replace by the local Chevy dealership and quoted 4-6 weeks delivery for backordered parts. This is an unacceptable situation that GM and other manufacturers have artificially manufactured. They design everything to the bare minimum to save fractions of a cent per part, and then they intentionally make the parts unavailable and then the dealership pushes you to trade the broken vehicle in at a massive loss just so you can get back on the road in a newer, more expensive vehicle. This sort of behavior is causing immense financial harm to American families.
I’m have 1-2” dead space in steering. It is hard to stay in lane on highway as when a road dip takes extra movement keep straight. I was told this is normal but had dealer change steering box. Replacement helped a lot but truck is starting to get the 1-2” of play once again. Seems like similar issue to 2016 model year.
Dash Warning: Check Engine Light, "Engine Power is Reduced!" and Traction Control. Code Reader Results: P2138 (APP) Accelerator Pedal Position Sensors - Not Plausible. Replaced with NEW OEM Part(s) - APP, Electrical Throttle Body and M15 Fuse - which did NOT fix issues and now due to safety concerns (further damage to vehicle and personal preservation) will be towing to dealership for diagnosis. Believe to be a known WIRING issues most likely due to WATER exposure/ SHORT in Connectors. - See IP, ECM/PCM and possible false activation to the APP circuit. This should be a RECALL due to the severity of mechanical issues of the malfunctioning system.
Reductant heater fault
while driving i smelled burning electrical somewhere in the cab. looking in the rearview mirror i saw smoke ciming from the corner of the sliding rear window. i pulled over and opened my rear door and heard a crack type noise. the smoke stopped and the drivers side rear window was shattered. upon researching the issue i found a recall was done in canada and not in the usa .
Vehicle stalled then would not start
While hauling a trailer I received a warning tone and looked down to read the message, "reduced engine power", and the service engine light appeared all at the same time. The engine shutoff at the same time I received the warnings and didn't allow me to safely pull off the road.. I lost power steering, power braking, and controlling the vehicle and trailer while coasting to the sholder was difficult. Fortunately it was early in the morning and I was only traveling 35 mph on a straight road, and no other vehicles were on the road. If I was on an interstate traveling 55+ mph or on a curvy road it would have caused an accident or worse. I was very fortunate. This was the first time I experienced this problem and hadn't received prior warning messages or lights. The truck would not restart and the truck and trailer were towed to the dealership. The diagnosis was a failed "Fuel Pump Control Module." After waiting several weeks the replacement Fuel Pump Control Module did solved the problem. I kept the failed Fuel Pump Control Module and is available for inspection. Please investigate thoroughly! I was extremely fortunate the part failed when it did and I was able to walk away unharmed.
The contact owns a 2018 GMC Sierra 2500. The contact stated that while the vehicle was parked with the engine idling for approximately ten minutes, the rear crew cab window suddenly shattered. During the failure, the rear window defroster was activated. The cause of the failure was not yet determined, and the vehicle was not repaired. The local dealer and manufacturer were notified of the failure. The failure mileage was 30,000.
The contact owns a 2018 Chevrolet Silverado 2500. The contact stated that while the vehicle was turned off and parked in the driveway, the contact heard a loud explosion. Upon inspection, it was discovered that the rear passenger’s side side-curtain air bag erroneously deployed. The cause of the failure was not yet determined. The contact stated that during the failure, shrapnel and shards of metal pierced the roof and caused multiple holes in the roof of the vehicle. The local dealer was notified of the failure. The manufacturer was not yet contacted. The failure mileage was 72,500.
For the last year the vehicle has been in the shop at the dealer for a rancid chemical smell in the cab of the truck that causes a burning to the eyes and lungs. It gets worse when it's hot outside. The smell is there even when the vehicle is not running. The dealer cannot find the source of the smell and has turned the vehicle back over to us with no solution. It feels unsafe and is extremely uncomfortable to drive in with burning eyes and breathing issues.
keep getting message SERVICE TRAILER BRAKE SYSTEM. over and over going down the road,
Dashboard lights and audio system shut off randomly for one second while driving, and then turned back on. when shutting the truck off, all power was lost for one second
The contact's son owns a 2018 Chevrolet Silverado 2500. The contact stated that while driving at an undisclosed speed, the check engine and “Service Vehicle" messages was displayed. The vehicle was taken to a local dealer, where it was diagnosed that the diesel exhaust fluid (DEF) and catalytic converter needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 109,000. The VIN was not available.
The contact owns a 2018 Chevrolet Silverado 2500. The contact stated that while driving at various speeds, the vehicle lost motive power and stalled without warning. The contact took the vehicle to the dealer however, the mechanic was unable to determine the cause of the failure. The dealer replaced the negative battery cable; however, the failure persisted. The manufacturer was notified of the failure and a case was filed. The vehicle was not repaired. The failure mileage was approximately 36,000.
The contact's wife owns a 2018 Chevrolet Silverado 2500. The contact stated that while his wife was driving at 45 MPH, she crashed into another vehicle in an intersection. The air bags did not deploy upon impact. The contact was taken to the hospital by ambulance and was treated for pain on both sides of his ribs. The contact's wife did not sustain any injuries. The whereabouts of the other driver were unknown. A police report was filed. The vehicle was towed to an independent mechanic where it remained in their possession. The dealer nor the manufacturer had yet to be notified of the failure. The vehicle had yet to be respired. The failure mileage was approximately 44,000. The VIN was not available. The consumer stated the vehicle was totaled.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .