2019 Chevrolet Silverado 2500 Problems

The Variable Geometry Turbocharger Actuator failed on my 2019 2500HD Silverado. There was a significant decrease in power. This was most noticeable on uphill grades where speed would drop to between 35 and 40 mph on a 75mph speed limit highway. On several occasions, vehicles came close to hitting me because of my slow speed.

The contact owns a 2019 Chevrolet Silverado 2500. While driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed and it was determined that the injection pump needed to be replaced, and that the vehicle was not drivable. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The contact researched and became aware of an unknown recall; however, the VIN was not included. The failure mileage was approximately 194,000.

The brake lights do not work, the turn signals do not work, there is one tail light working at the lower right rear. Front parking lights work but front turn signals so not work. The cab brake light works. The turn signal flasher works and the dashboard turn arrows work but the flasher goes to hyper flash. The emergency lights do not work, the flasher switch works. The turn signal in the mirror left or right does not work. I really do not know how long this has been going on.

I was driving down the road at approximately 55 mph when all of a sudden, my truck decelerated and a warning signal displayed on my dash indicating my speed was being forcibly reduced to approximately 30 mph. Fortunately, I was on a rural road versus the interstate. I pulled over and had an OBD2 reader. The reader indicated I had a P-2138 error code from a "voltage correlation error between the two Accelerator Pedal Position (APP) sensors". I was able to limp along with emergency flashers to return home. After driving approximately 10 miles, the "issue" resolved itself. I have since replaced the gas petal assembly after learning this is a common failure on many years of the Chevy Silverado series.

I was driving my truck and lost full power to the truck. Which happened as I was pulling out of a parking. The truck went into a limp mode. With the truck losing full power, it put my child and I into a safety risk. The truck got repaired at the dealership. The dealer was able to reproduce the issue. The truck was inspected at the dealership. Warning system did come on saying speed would be limited if (roughly 150 miles to a max 65mph). When I called another dealership, they said this was a normal thing for these trucks and chevy hasn't fixed it. I feel like if its a known issue with the wiring becoming free, why would they not proactively fix this issue before someone gets hurts from thinking they have the power to drive. The dealership that I took this too knew where to look right away as this is common.

The Def system and turbo system. It will not let me tow nothing. And has started limited my speed to 65mph and says in 55 miles it will restrict to 55mph. I need my truck for work.

The DEF fill tube is under the hood on the opposite side of the fuel filling tube. To fill the DEF at a truck stop, one has to park really close to the pumps and stretch the hose across a hot engine. One has to be careful that hot engine does not burn a hole in the DEF hose and cause a spill.

Headlights are foggy causing less and less light to drive by. Transmission has a hesitation when going from P-D, P-R, D-R, and R-D. It does this most of the time but not all the time. Transmission makes loud popping noises at times. Seems to be mostly when almost stopped or from almost stopped and then accelerating. Seems to try and shift gears also when truck goes into Regen mode when stopped at traffic light or stop sign making loud popping noises. It does this sometimes but not all of the time.

The contact owns a 2019 Chevrolet Silverado 2500. The contact stated that while the vehicle was parked and started, the message "Service Trailer Brake System" was displayed on the instrument panel. The vehicle was drivable even though the message was displayed. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the issue. The approximate failure mileage was 139,000.

This has happened three times with the 2019 Chevrolet Silverado 2500HD LTZ truck. Each time, the failure was following a remote start in my driveway. It has occurred at the approximately 40K, 80K, and now at 128K mile mark. First two repairs were covered under the warranty and extended warranty, with the third time there was no warranty and the cost for repair was ~$2800. Each time, the vehicle was remote started in the January timeframe with cold (0 to 30°F) temperatures to allow the vehicle warm up prior to driving. I know two of those events occurred when we had a more significant temperature drop as there was snow on the ground. Upon getting into the driver seat and putting into Reverse to back out of the driveway, I discovered the brakes and power steering had failed. The dealer on this third time indicated a check valve somewhere was "sticky" resulting in the failure of a hose with a booster tied to either the brakes or power steering (not sure which) failing taking the other part out. In this third case, either power steering or brake fluid vapors had been sucked back into the heater as things had sprayed around the engine compartment. The cab of the vehicle presenting a haze/fog in the vehicle causing me to realize there was something wrong upon opening the truck door. All three times, the vehicle was towed to the dealer for service repair. I do not know if this could have presented a fire hazard or had I been driving down the highway or interstate how fast I would have lost braking or steering ability.

I was driving down the road at approximately 55 mph when all of a sudden, my truck decelerated and a warning signal displayed on my dash indicating my speed was being forcibly reduced to approximately 30 mph. Fortunately, I was on a rural road versus the interstate. I pulled over and had an OBD2 reader. The reader indicated I had a P-2138 error code from a "voltage correlation error between the two Accelerator Pedal Position (APP) sensors". I was able to limp along with emergency flashers to return home. After driving approximately 10 miles, the "issue" resolved itself. I have since replaced the gas petal assembly after learning this is a common failure on many years of the Chevy Silverado series.

Another driver illegally turned left in front of this vehicle. the vehicles collided on each of their right front corners. The airbags failed to deploy and the shoulder belt did not restrain the driver and keep him striking his head on the steering wheel, and breaking a bone in his hand. this was a serious head-on collision that totaled both vehicles. The truck is currently at the salvage yard and is available for inspection. The driver's safety was put at risk because the two primary safety restraint systems failed. the problem has not been reproduced. Chevrolet is sending someone to download the crash data which will then be provided to their engineering department for review and analysis. No warning lamps, messages or other symptoms of the problem were observed by the owner or driver before the accident.

This has happened three times with the 2019 Chevrolet Silverado 2500HD LTZ truck. Each time, the failure was following a remote start in my driveway. It has occurred at the approximately 40K, 80K, and now at 128K mile mark. First two repairs were covered under the warranty and extended warranty, with the third time there was no warranty and the cost for repair was ~$2800. Each time, the vehicle was remote started in the January timeframe with cold (0 to 30°F) temperatures to allow the vehicle warm up prior to driving. I know two of those events occurred when we had a more significant temperature drop as there was snow on the ground. Upon getting into the driver seat and putting into Reverse to back out of the driveway, I discovered the brakes and power steering had failed. The dealer on this third time indicated a check valve somewhere was "sticky" resulting in the failure of a hose with a booster tied to either the brakes or power steering (not sure which) failing taking the other part out. In this third case, either power steering or brake fluid vapors had been sucked back into the heater as things had sprayed around the engine compartment. The cab of the vehicle presenting a haze/fog in the vehicle causing me to realize there was something wrong upon opening the truck door. All three times, the vehicle was towed to the dealer for service repair. I do not know if this could have presented a fire hazard or had I been driving down the highway or interstate how fast I would have lost braking or steering ability.

component failed: Power steering pump and the power brake booster. Parts are available to inspect. When the component failed you begin to loose power steering and power brakes. This makes it hard to steer and brake. The vehicle was taken to the dealer who confirmed the failure of these parts and replaced them at the owner expense. No warning lights came on, components failed without any prior warning. A similar failure was part of recall # N-192268490 and detailed in GM service bulletin 23-NA-144 Dated August 2023.

The contact owned a 2019 Chevrolet Silverado HD Crew. The contact stated that while the vehicle was parked outside of the residence, unoccupied, the vehicle engine block heater was plugged in, the vehicle caught of fire under the hood on the passenger side. The fire department was called and extinguished the fire however the vehicle along with another vehicle in the driveway was deemed a total loss by the insurance company. The additional property damage due to the fire was siding, window, cause smoke damage to insulation in the attic. The dealer was not notified of the issue. The manufacturer was notified of the issue. The approximate failure mileage was 156,000.

The contact owns a 2019 Chevrolet Silverado 2500. The contact stated while driving at 30-35 MPH with a 2017 Heartland Bighorn trailer hitched to the vehicle, the message “Check Trailer Wiring” was displayed. The brake pedal was depressed, however, the trailer brakes failed to respond and the trailer did not slow down as intended. The contact stated that the failure had been reoccurring for an extended period of time while driving. The contact stated that the failure persisted for 4 hours while driving at 60 MPH. The contact stated that several unknown repairs had been completed on the trailer. However, the failure persisted. The vehicle was taken to the dealer where it was diagnosed that no issues were found. The vehicle was then taken to an independent mechanic who was unable to duplicate the failure. The vehicle was taken to a second dealer Graff Chevy Durand (9009 Lansing Rd, Durand, MI 48429), where it was diagnosed that no issues were found. The contact stated the Pollak 7-Way Plug Connector was installed on the vehicle under GM Technical Service Bulletin Number :PIT5311E. However, the failure persisted. The contact stated that the failure was intermittent, which made it difficult to diagnose. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 11,000. The contact stated that they paid for repairs on the trailer but feels that the issue is coming from the truck too.

Another driver illegally turned left in front of this vehicle. the vehicles collided on each of their right front corners. The airbags failed to deploy and the shoulder belt did not restrain the driver and keep him striking his head on the steering wheel, and breaking a bone in his hand. this was a serious head-on collision that totaled both vehicles. The truck is currently at the salvage yard and is available for inspection. The driver's safety was put at risk because the two primary safety restraint systems failed. the problem has not been reproduced. Chevrolet is sending someone to download the crash data which will then be provided to their engineering department for review and analysis. No warning lamps, messages or other symptoms of the problem were observed by the owner or driver before the accident.

TL* THE CONTACT OWNS A 2019 CHEVROLET SILVERADO 2500. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE DRIVER'S AND PASSENGER'S SIDE FRONT AND REAR SIDE CURTAIN AIR BAGS ERRONEOUSLY DEPLOYED, CAUSING THE DRIVER TO LOSE CONTROL OF THE STEERING AND DRIVE OFF THE ROADWAY. DURING THE INCIDENCE, THE DRIVER SUSTAINED AN INJURED NECK AND SKIN BURNS. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO THE LOCAL DEALER DANIELS CHEVROLET LOCATED AT 365 E MAIN ST, SWAINSBORO, GA 30401 WHO WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 19,000. THE VIN WAS NOT AVAILABLE.*DT

The contact owns a 2019 Chevrolet Silverado 2500. The contact stated that upon removing the front passenger’s side floor mat he noticed that there was water leaking underneath the dash onto the floorboard and floor mat. Additionally, the A/C button control light was flickering. There was no warning light illuminated. The vehicle was taken to the dealer, who informed the contact that the manufacturer's leak detection team would diagnose the vehicle. The vehicle was not diagnosed nor repaired. The manufacturer was notified of the failure and a case was opened. The failure mileage was approximately 71,800.

MY BRAND NEW, ONE MONTH OLD TRUCK HAS EXCESSIVE PAINT CHIPPING. MY TRUCK HAS ONLY 4500 MILES AND I HAVE OVER 20 SPOTS WHERE MY PAINT IS CHIPPED OR PEELING. I HAVE SEEN HUNDREDS OF OTHER PEOPLE ONLINE (SOME THAT WERE ABLE TO GET THE ISSUE RECALLED) WITH THE SAME PROBLEM. I DO NOT FIND IT ACCEPTABLE AS PAINT SHOULD LAST AT LEAST 4 YEARS WITHOUT THE AMOUNT OF CHIPPING AND PEELING I'M EXPERIENCING. I HAVE CALLED JUST ABOUT EVERY DEALER WITHIN 80 MILES OF ME, THEY ALL TELL ME THEY UNDERSTAND THERE IS A PAINT ISSUE, BUT NONE OF THEM WILL DO ANYTHING ABOUT IT.

The brake lights do not work, the turn signals do not work, there is one tail light working at the lower right rear. Front parking lights work but front turn signals so not work. The cab brake light works. The turn signal flasher works and the dashboard turn arrows work but the flasher goes to hyper flash. The emergency lights do not work, the flasher switch works. The turn signal in the mirror left or right does not work. I really do not know how long this has been going on.

Purchased new Aug 2019 in PA. Headlights had condensation behind them within the first month. Brought it into the service dept. in Bedford PA. Was told they wouldn't do anything with it because the issue would resolve with the air port in the back of the headlight assembly. The situation did not resolve, took it back multiple times and they refused to replace headlight assembly while it was under warranty. Now there is an inch of water in the headlight, and the bottom right blinker quit working. Of course now it is out of warranty, and the dealership in WI where I moved is quoting me $1500 to replace the headlight assembly and seal.

The contact owns a 2019 Chevrolet Silverado 2500 equipped with Cooper Tires, Tire Line: Discoverer A/T3 XLT, Tire Size: 265/70/R18, DOT Number: UP511NE. The contact stated that while driving approximately 65 MPH in inclement weather, the contact heard a loud explosion, and then the vehicle swerved. The contact checked the side door mirrors and saw that the rear passenger's side tire had detached, and the tire had struck two other vehicles. The contact nearly lost control of the vehicle but was able to pull over to the side of the roadway. Upon inspection, the contact discovered that half of the rear passenger's sidewall tire remained attached to the rim. AAA arrived on the scene and replaced the passenger's side tire with a spare tire. The spare tire was not replaced. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The tire manufacturer was made aware of the failure but informed the contact that there was no recall for the tire. The tire failure mileage was unknown. The vehicle failure mileage was 96,000. The VIN was unavailable.

On a trip from Southern California to Waco, TX, tire tread separation occurred on the driver's side front tire (Goodyear Wrangler ST-A LT265/60R20) on Sept 4, 2023 in Deming, NM. On the return trip from Waco, TX, to Southern California, on Sept 15, 2023 the tread on the passenger side rear tire (Goodyear Wrangler ST-A LT265/60R20)started separating in the same manner. The tire was replaced with the spare tire in Deming, NM, and the trip was resumed. On the same day, Sept 15, 2023 on arrival into Blythe, CA, the driver's side rear tire (Goodyear Wrangler ST-A LT265/60R20) in the same manner (tread separation). At that point, all the tires were replaced at a tire shop in Blythe, CA. In summary, within an 11 day period, three tires (Goodyear Wrangler ST-A LT265/60R20) failed from tread separation. All tires were the same make and model. They were purchased mounted when the new vehicle on Sept 11, 2018 (Chevrolet Silverado HD) was purchased. The three tires (Goodyear Wrangler ST-A LT265/60R20) failed from Sept 4, 2023 through Sept 15, 2023.

In May of 2023, the truck developed a significant shake when driving on moderate road bumps. We took it to the dealer and they replaced the pitman arm and idler arm assembly for over $2200. Recently, the shake started again. We took it to a local mechanic who told us that the upper ball joints were completely worn out and had been for some time, certainly since before the visit to the dealer in May. We had the ball joints replaced, and it is still shaking. We will continue to try to diagnose the problem but now we feel like we cannot drive it because it is unsafe. I’ve seen online that Chevy has a reputation of having this problem with our model (2019 Silverado). I’m filing this report to let you know that we are experiencing this problem.

TL* THE CONTACT OWNS A 2019 CHEVROLET SILVERADO 2500. THE CONTACT STATED THAT THERE WAS AN UNSTABLE CONDITION CONCERNING THE OEM TIRES. THE CONTACT WAS UNCERTAIN IF THE FAILURE WAS RELATED TO WHEEL DIMENSIONS OR THE SUSPENSION. THE CONTACT WAS UNABLE TO SCHEDULE A REPAIR WITHIN A REASONABLE TIMEFRAME WITH CHEAP CHEVROLET (714 W WATER ST, FLEMINGSBURG, KY 41041, (606) 845-2261) AND KERRY CHEVROLET (7500 ALEXANDRIA PIKE, ALEXANDRIA, KY 41001, (859) 474-2826); HOWEVER, THE CONTACT WAS INFORMED THAT THE TWO REAR TIRES AND FRONT DRIVER'S SIDE TIRE MAY NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.

The contact owns a 2019 Chevrolet Silverado 2500. The contact stated that after remote starting the vehicle, the contact entered the vehicle, and there was smoke coming from the rear window defroster. The contact turned off the defroster and discovered that the plastic cover had melted, and the metal tab had detached and was burned. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact related the failure to Customer Satisfaction Program: N192265660 (Rear Window Defroster Thermal Events - US Only); however, the VIN was not included. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 163,000.

Another driver illegally turned left in front of this vehicle. the vehicles collided on each of their right front corners. The airbags failed to deploy and the shoulder belt did not restrain the driver and keep him striking his head on the steering wheel, and breaking a bone in his hand. this was a serious head-on collision that totaled both vehicles. The truck is currently at the salvage yard and is available for inspection. The driver's safety was put at risk because the two primary safety restraint systems failed. the problem has not been reproduced. Chevrolet is sending someone to download the crash data which will then be provided to their engineering department for review and analysis. No warning lamps, messages or other symptoms of the problem were observed by the owner or driver before the accident.