2019 Chevrolet Silverado 2500

The brake lights do not work, the turn signals do not work, there is one tail light working at the lower right rear. Front parking lights work but front turn signals so not work. The cab brake light works. The turn signal flasher works and the dashboard turn arrows work but the flasher goes to hyper flash. The emergency lights do not work, the flasher switch works. The turn signal in the mirror left or right does not work. I really do not know how long this has been going on.

NHTSA ID

11755921

Incident

Jul 28, 2026

Purchased new Aug 2019 in PA. Headlights had condensation behind them within the first month. Brought it into the service dept. in Bedford PA. Was told they wouldn't do anything with it because the issue would resolve with the air port in the back of the headlight assembly. The situation did not resolve, took it back multiple times and they refused to replace headlight assembly while it was under warranty. Now there is an inch of water in the headlight, and the bottom right blinker quit working. Of course now it is out of warranty, and the dealership in WI where I moved is quoting me $1500 to replace the headlight assembly and seal.

NHTSA ID

11753922

Incident

Aug 17, 2019

The contact owned a 2019 Chevrolet Silverado HD Crew. The contact stated that while the vehicle was parked outside of the residence, unoccupied, the vehicle engine block heater was plugged in, the vehicle caught of fire under the hood on the passenger side. The fire department was called and extinguished the fire however the vehicle along with another vehicle in the driveway was deemed a total loss by the insurance company. The additional property damage due to the fire was siding, window, cause smoke damage to insulation in the attic. The dealer was not notified of the issue. The manufacturer was notified of the issue. The approximate failure mileage was 156,000.

NHTSA ID

11739234

Incident

Jan 25, 2026

Mileage

156,000 mi

The contact owns a 2019 Chevrolet Silverado 2500. The contact stated that after remote starting the vehicle, the contact entered the vehicle, and there was smoke coming from the rear window defroster. The contact turned off the defroster and discovered that the plastic cover had melted, and the metal tab had detached and was burned. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact related the failure to Customer Satisfaction Program: N192265660 (Rear Window Defroster Thermal Events - US Only); however, the VIN was not included. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 163,000.

NHTSA ID

11733605

Incident

Apr 23, 2026

Mileage

163,000 mi

The contact owns a 2019 Chevrolet Silverado 2500. The contact stated that while the vehicle was parked and started, the message "Service Trailer Brake System" was displayed on the instrument panel. The vehicle was drivable even though the message was displayed. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the issue. The approximate failure mileage was 139,000.

NHTSA ID

11731680

Incident

Mar 25, 2026

Mileage

139,000 mi

The Variable Geometry Turbocharger Actuator failed on my 2019 2500HD Silverado. There was a significant decrease in power. This was most noticeable on uphill grades where speed would drop to between 35 and 40 mph on a 75mph speed limit highway. On several occasions, vehicles came close to hitting me because of my slow speed.

NHTSA ID

11724249

Incident

Mar 5, 2026

This has happened three times with the 2019 Chevrolet Silverado 2500HD LTZ truck. Each time, the failure was following a remote start in my driveway. It has occurred at the approximately 40K, 80K, and now at 128K mile mark. First two repairs were covered under the warranty and extended warranty, with the third time there was no warranty and the cost for repair was ~$2800. Each time, the vehicle was remote started in the January timeframe with cold (0 to 30°F) temperatures to allow the vehicle warm up prior to driving. I know two of those events occurred when we had a more significant temperature drop as there was snow on the ground. Upon getting into the driver seat and putting into Reverse to back out of the driveway, I discovered the brakes and power steering had failed. The dealer on this third time indicated a check valve somewhere was "sticky" resulting in the failure of a hose with a booster tied to either the brakes or power steering (not sure which) failing taking the other part out. In this third case, either power steering or brake fluid vapors had been sucked back into the heater as things had sprayed around the engine compartment. The cab of the vehicle presenting a haze/fog in the vehicle causing me to realize there was something wrong upon opening the truck door. All three times, the vehicle was towed to the dealer for service repair. I do not know if this could have presented a fire hazard or had I been driving down the highway or interstate how fast I would have lost braking or steering ability.

NHTSA ID

11722493

Incident

Jan 12, 2026

I was driving down the road at approximately 55 mph when all of a sudden, my truck decelerated and a warning signal displayed on my dash indicating my speed was being forcibly reduced to approximately 30 mph. Fortunately, I was on a rural road versus the interstate. I pulled over and had an OBD2 reader. The reader indicated I had a P-2138 error code from a "voltage correlation error between the two Accelerator Pedal Position (APP) sensors". I was able to limp along with emergency flashers to return home. After driving approximately 10 miles, the "issue" resolved itself. I have since replaced the gas petal assembly after learning this is a common failure on many years of the Chevy Silverado series.

NHTSA ID

11722483

Incident

Mar 3, 2026

This PI provides information to repair the door water deflector which is not sealed properly allows water into the door jam/sill area.

PI to help diagnose A/C concern

This PI provides diagnostic tips for diagnosing electric trailer brakes issues.

This Preliminary information communicates information on a hydraulic rush type noise from the power steering gear. This noise is a characteristic of the new Active Hydraulic Assist System RPO NV8 and no repairs should be made.  The noise is most noticeable in the cab at idle, in park, with all accessories turned off.

This document restricts dealers from ordering an engine assembly. The technician must contact GM Technical Assistance to have diagnostics verified and that an engine assembly is needed.

This PI provides diagnostic tips for diagnosing electric trailer brakes issues.