2008 Chevrolet Silverado 2500

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

IN A LETTER DATED AUGUST 27, 2008, GENERAL MOTORS CORP. (GM) NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NUMBER 08V-441) TO ADDRESS A SAFETY RELATEDDEFECT THAT CAN RESULT IN ENGINE COMPARTMENT FIRE IN APPROXIMATELY 850,000 VEHICLES EQUIPPED WITH A HEATED WINDSHIELD WASHER FLUID OPTION.THE SUBJECT VEHICLES OF THIS INVESTIGATION COMPRISE OVER THREE-QUARTERS OF THE RECALL POPULATION. ACCORDING TO GM, A SHORT CIRCUIT ON THE PRINTED CIRCUIT BOARD FOR THE WINDSHIELD WASHER FLUID HEATER MODULE MAY OVERHEAT THE CONTROL-CIRCUIT GROUND WIRE. THIS MAY CAUSE OTHER ELECTRICAL FEATURES TO MALFUNCTION, CREATE AN ODOR OR CAUSE SMOKE AND IN RARE CASES IT MAY CAUSE A FIRE.AS A REMEDY, GM DEALERS WILL INSTALL A WIRE HARNESS WITH AN IN-LINE FUSE. IN ADDITION TO THE SUBJECT VEHICLES, SEVERAL OTHER GM MODELS WITH THE HEATED WINDSHIELD WASHER FLUID OPTION ARE INCLUDED IN RECALL 08V-441: MY 2006-2008 BUICK LUCERNE (MANUFACTURED AUGUST 2005 THROUGH NOVEMBER 2007); MY 2008 BUICK ENCLAVE (MANUFACTURED FEBRUARY 2007 THROUGH APRIL 2007); MY 2006-2008 CADILLAC DTS (MANUFACTURED MAY 2007 THROUGH NOVEMBER 2007); MY 2007-2008 SATURN OUTLOOK (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007); AND MY 2007-2008 GMC ACADIA (MANUFACTURED AUGUST 2006 THROUGH APRIL 2007) VEHICLES.GM IS INSTRUCTING OWNERS TO TAKE THEIR VEHICLE TO A DEALER FOR SERVICE IF THEY EXPERIENCE SYMPTOMS OF WINDSHIELD WASHER HEATER MODULE SHORT CIRCUITS. GM'S RECALL RESOLVES THE SAFETY DEFECT CONCERNS PURSUED BY THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED.

IN RESPONSE TO AN INFORMATION REQUEST LETTER SENT BY THE OFFICE OF DEFECTS INVESTIGATION(ODI) DURING PRELIMINARY EVALUATION PE08-010, GM PROVIDED ODI WITH 41 ALLEGATIONS OF NON-CRASH ENGINE COMPARTMENT FIRES INCLUDING 16 ALLEGATIONS OF FIRES ORIGINATING WITH THE IGNITION IN THE OFF POSITION.ONE OF THE FIRES WAS DETERMINED TO BE CAUSED BY AN ARSON EVENT.ODI HAS ALSO RECEIVED 5 REPORTS, 4 OF WHICH ARE OF DUPLICATIVE OF REPORTS PROVIDED BY GM, ALLEGING NON-CRASH ENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES.IN TOTAL, ODI IS AWARE OF 41 NON-CRASHENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES THAT ARE UNRELATED TO ARSON.EIGHT OF THE 41 FIRE ALLEGATIONS ALSO ALLEGE PROPERTY DAMAGE AS A RESULT OF THE FIRES.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA08-010) TO FURTHER ASSESS THE SCOPE, FREQUENCY, ORIGIN AND CAUSE OF THE ALLEGED NON-CRASH RELATED ENGINE COMPARTMENT FIRES IN THE SUBJECT VEHICLES.

Odometer Fraud. The contact purchased a 2008 Chevrolet Silverado 2500 at an auction. The contact stated that although the odometer indicated 89,671 miles at the time of purchase, there was a mileage discrepancy discovered during the vehicle registration. The title was marked exempt; there was no official documentation verifying the actual mileage. The discrepancy was attributed to an inoperable odometer or due to the condition of the frame of the vehicle.

NHTSA ID

11735088

Incident

Apr 27, 2026

Mileage

89,671 mi

The contact owns a 2008 Chevrolet Silverado 2500 equipped with Bridgestone Tires, Tire line: Dueler A/T Revo 3, Tire size: LT265/75/R16, DOT Number: 9BW8 RE3. The contact stated that the tires were purchased in California. The vehicle was driven back home to Idaho, where the TPMS alarm sounded. The vehicle was taken to the dealer for an oil change and the vehicle was inspected, and the contact was informed that the rear tire was flagged and was informed that the tire needed to be removed. The tire was not removed. The contact notified the manufacturer, and the contact was referred to a Firestone location for an inspection. The manufacturer was informed that there were no Firestone locations nearby. The manufacturer approved the contact to take the vehicle to a Commercial Tire shop for an inspection. The vehicle was taken to the Commercial Tire Shop, and the contact was informed that all four tires were dangerous and needed to be replaced. The tread on the rear passenger’s tire was worn, the sidewalls of another tire were falling apart, and the tread and sidewalls on the other tires were separating. All four tires were replaced. The manufacturer was notified that the tires were replaced, and a claim was filed. The vehicle failure mileage was 169,508.

NHTSA ID

11715677

Incident

Jun 16, 2025

Mileage

169,508 mi

The truck randomly shuts off whether just running or driving, the fuel pump fuse blows, as long as we switch the fuses it starts right up and runs again, sometimes it happens several times a day, other times it doesn't happen for a week or two. When driving it shuts down without warning and lose of everything.

NHTSA ID

11693755

Incident

Oct 15, 2025

I had my truck serviced for the airbag recall in 2021 at Clint Newell auto in Roseburg Oregon, they did not have a necessary part to complete the job at the moment and I had moved out of town by the time they got it in. I just today brought it in and they said they did the second half of the recall but the component was not communicating. I was informed they would charge me to investigate why. I am writing to complain and seek resources. I cant afford to have the airbag problem investigated especially since it is likely their fault/negligence. The airbag light remains on and it is still a danger to me, also they were super rude and disorganized. Please help

NHTSA ID

11670401

Incident

Jun 30, 2025

The contact owns a 2008 Chevrolet Silverado 1500. The contact stated while her husband was driving 55 MPH, the contact and her husband both heard an explosion coming from the vehicle and a white smoke was coming from the rear seat in the vehicle. The contact also stated the that the vehicle stalled and the seat belts locked up. Additionally, the hazard lights independently activated and the air bag warning light illuminated. The contact's husband was able to pull over and inspect the vehicle. The contact stated that the cruise control no longer operated as needed, the seat belts remaining locked; however, the vehicle resumed normal operation. Neither the dealer nor the manufacturer was notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was 224,752.

NHTSA ID

11459718

Incident

Apr 5, 2022

Mileage

224,752 mi

MY DASH IS CRACKED IN TWO PLACES. ONE BY THE AIR BAG AND ANOTHER ON THE LEFT SIDE. THIS SEEMS TO BE A VERY COMMON PROBLEM.

NHTSA ID

11388553

Incident

Aug 19, 2017

Mileage

125,000 mi

VEHICLE'S AIRBAG RECALLED IN 2016 9GM 49152). I CALLED DEALER- WIN KELLY- IN JULY, 2017 . KATHY SAID "NO UFLORIANREASONABLE DANGER' .. BE SAFE. GM SOLUTION BY AUGUST. CALLED NHTSA ON 9/12/17 TOOK COMPLAINT # 11022868. GOT A FILLED OUR COMPLAINT FORM 100148 NOTING MANUFACTURER "PARTS NOT AVAILABLE". !2/27/2020 SAME STORY.

NHTSA ID

11385103

Incident

Dec 27, 2020

MY DASH HAS CRACKED IN MULTIPLE LOCATIONS INCLUDING THE AIRBAG SURROUND. SHARDS OF THE DASH HAVE NOW BEGUN TO BREAK OFF - CLEAR INDICATION OF AN UNSAFE CONDITION. SHOULD THE AIRBAG DEPLOY SHARDS OF THE SHATTERING DASH COULD RUPTURE THE AIRBAG OR WORSE STRIKE AND IMPALE THE OCCUPANTS OF THE VEHICLE. THIS IS AN UNSAFE CONDITION. I AM IN THE AIRCRAFT MAINTENANCE BUSINESS AND THE FAA AND NTSB WOULD NEVER ALLOW SUCH AN OBVIOUS HAZARD IN AN AIRCRAFT. MY DASH STARTED CRACKING YEARS AGO AND DESPITE STOP DRILLING THE CRACKS AS WE DO IN AIRCRAFT MAINTENANCE ON LEXAN TRANSPARENCIES THE CHEAP PLASTIC THE DASH IS MADE FROM CONTINUES TO PROPAGATE NEW AND BIGGER CRACKS. ATTEMPTS TO USE A PLASTIC WELDING REPAIR KIT ALSO FAILED. A RECALL TO ADDRESS THIS DANGEROUS CONDITION IS WAY PAST DUE.

NHTSA ID

11375373

Incident

Nov 19, 2020

This Preliminary Information communication provides information to the technician that some owners of Heavy Duty Trucks and Utilities may ask if they can lower their tire pressures. Tire pressures being set to the "Tire and Loading Label" will ensure the safe handling and ride characteristics of the truck and should not be lowered.

New Vehicle Monitoring Programs Section in IVH

This Preliminary Information communication provides information to the technician about vehicles that have an intermittent no crank, no start, or start stall concern with the security light coming on. Technician may find Diagnostic Trouble Codes B3055, B3060, B3935, C0750, C0755, C0760, C0765, and/or C0775.

This Preliminary Information communication provides information to the technician about vehicles that may have a bump feel or clunk noise at a stop or on launch. Dealer should communicate to the customer this condition is a normal operating characteristic

This PI communicates the requirement to provide a pico file to receive diagnostic assistance from TAC.

This Preliminary Information communication provides information to the technician about the use of J-35616-64B and Mini 50 terminal test probe, replacement terminals, and terminated leads.