2021 Chevrolet Silverado 2500

On April 9, 2021, the Office of Defects Investigations (ODI) opened PE21-010 to investigate instances of air bag malfunction indicator light (MIL) illumination and potential for frontal air bag non-deployment in several vehicles manufactured by General Motors (GM). The vehicles included model year (MY) 2020 through 2021 CT4 and CT5 passenger cars, Sierra and Silverado trucks (1500/2500/3500 models), XT4 and MY 2021 Escalade, Suburban, Tahoe, Yukon SUVs.Technical Service Bulletin (TSB) 21-NA-005, issued in March 2021, addresses air bag MIL illumination with diagnostic trouble codes (DTCs) B0001-1B or B0012-0D. It cites rust particles in the connection terminal interface of the driver air bag inflator housing as the cause of the air bag MIL illumination. Illumination of the air bag MIL under these circumstances may result in a non-deployment of the frontal driver air bag during a frontal collision and increased risk of injury to the driver.GM stated a correlation exists between production delays due to the pandemic shutdown and premature corrosion initiation on the surface of the air bag inflator housing, which, in some cases, caused rust development during a seven (7) month period of vehicle production. In the rare instance when a rust particle dislodges from the driver air bag inflator housing and enters the air bag connector prior to assembly, an intermittent resistance spike at the air bag connector may result. The condition generates excessive resistance in the air bag electrical system when the steering wheel horn cover is manipulated or the steering wheel is turned. This excessive resistance is momentary. A crash commanding air bag deployment would need to occur exactly when the momentary excessive resistance occurs. Thus, there is a very low likelihood the hazard will present a risk during a crash of sufficient severity to warrant a commanded deployment. This failure mechanism occurs early in life and results in an air bag MIL illumination that corresponds to a DTC warning the driver that the vehicle requires service. The vehicle's air bag remains functional while the MIL is illuminated, and the DTC is present.Once the connection of the driver air bag module to the clockspring is made at the plant, or at the dealership for service, there is no longer an opportunity for rust migration into the connection point. The connector is sealed and has gold terminals, eliminating the expectation of fretting corrosion. All subject vehicles passed standard corrosion validation testing for extensive corrosion with no issue of air bag non-deployment.There is a low rate of occurrence: 1.41 incidents per thousand vehicles (IPTV) for all related occurrences, and 0.04 IPTV for occurrences with a mention of visible rust and/or corrosion on the air bag inflator housing. The average occurrence mileage for the subject vehicles is approximately 2,100. Every occurrence related to the alleged defect experienced an air bag MIL illumination and there are no verified allegations of air bag non-deployment within all data sources.To date, there have been no reported fires, crashes, injuries, or fatalities related to this issue. In view of the low rate, and the nature of early-life failure, the high detectability of failures, and low potential hazard to drivers, this Preliminary Evaluation (PE) is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.Review the ODI reports cited above at nhtsa.gov under the following identification numbers: 11537927, 11528888, 11525020, 11521401, 11506057, 11493107, 11486767, 11441525, 11433146, 11425658, 11423440, 11385267, 11376429, 11373466, 11366995.

When leaving work my truck would crank but not start. Started searching fixes on the internet. I found many people talking about a known issue with the fuel pump control module. Called the dealer and the dealer already knew of this issue in my year model truck. I purchased the fuel pump control module and fixed the problem. I purchased this module at full price because there is no recall on my VIN number. One week later a coworker had the same issue on his 2024 truck and his truck was covered under warranty.

NHTSA ID

11774121

Incident

Oct 20, 2026

Vehicle braking does not work- since new- dealer said it was funcitioning- sometimes you will get the warning and other times it does not and it never brakes. Transmission- i received a letter to bring truck in to have a software update for modulator valve wear....which was performed...since that time the stator and the torque converter were replaced in September/October of 2025. it was in dealership approx. 6 weeks for the repairs. Since that time i have had the vehicle roll forward when in reverse and pedal depressed, I have had hard shifts when shifting into gear at a stop, severe enough to lurch the truck forward and break traction....i have started having three to four downshifts very abrupt and very hard when decreasing speed. Dealership does not act like they want to do anything about it.

NHTSA ID

11769229

Incident

Aug 23, 2026

I opened my passenger front door to load and the tailgate opens and closes by itself but doesn’t and remains open. I physically shut the tailgate and it opened again by itself. I started my truck to see if it would stop. It didn’t stop until I put my truck in reverse to back out of the garage. After I backed out and the tailgate stopped open. I closed it and the tailgate will not open by pressing the button on the tailgate. It will open if I use my key fob.

NHTSA ID

11767859

Incident

Sep 27, 2026

The contact owns a 2021 Chevrolet Silverado 2500. The contact stated that while driving 15 MPH, there was a knocking sound coming from the engine. The vehicle was taken to the local dealer, and the contact was informed that the engine was blown causing complete engine failure. The engine was replaced under warranty, but the failure reoccurred. The warranty company inspected the vehicle. The failure mileage was approximately 121,000.

NHTSA ID

11767683

Incident

Jun 22, 2026

Mileage

121,000 mi

Pulling out from a stop sign, a loud bang came from the transmission, and rear wheels momentarily locked up then truck acted like it was in neutral. Truck was able to drift to side of road. We called our GM dealer, and they told us that our warranty had expired. We had the truck towed to our certified repair shop. After review of truck, the mechanic called and said the output shaft of the transmission broke. The mechanic called GM and asked if there was any financial assistance for this problem and they said no. He ordered a transmission through GM, and we had to pay for transmission upfront. The amount was 6627.05. Since then as we researched, we found out that GM has a Goodwill assistance program that would have helped us had we known to take it to a GM dealer. With two phone calls, no one guided us on doing that. Our truck has only 38,000 miles on it and when I called GM, they said they would have been able to assist us if we had sent it to a GM dealer. We tried to explain that no one gave us that direction and now it is currently being repaired at our local garage. Can we get any assistance at all with this claim? We would appreciate any assistance you could provide for us. Thank you [XXX] and [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11766354

Incident

Sep 11, 2026

My 10L1000 transmission had a catastrophic failure internally which caused it to rough shift, sudden down shifting, not want to shift into gear at all, and high engine rpm prior to roughly shifting. I took it to the Chevy dealers mechanic the very next business day, only to find out that from the mechanic that this is a common occurrence with Chevy transmissions in my truck and google also verified this to be a common problem. The mechanic from the Chevy dealership also stated that there was larger metal chunks than normal. My truck is available for inspection asap. The manufacturer and vin lookup contradicts the mechanic and google stating no issues or recalls for my transmission. After speaking with the manufacturer, I became highly concerned due to their unwillingness to address the obvious issues known by so many. If I wasn’t such a safe driver and immediately brought it to the mechanic, this could have caused a terrible accident leading to extreme bodily harm or death even. According to a quick google search of the 2021 Chevy 2500 transmission problems and my mechanic this is a well known problem even though Chevy manufacturers refuse to acknowledge the issue or implement a recall. There was zero warning lights or lamps to indicate this problem. I am extremely concerned with the manufacturer’s response to my concerns and their unwillingness to correct this issue before it cost someone their life. This catastrophic failure with the transmission having metal shavings throughout it and extreme damage to the transmission valve body and being well known and reported by many other customers has to be addressed. Chevy’s unwillingness to acknowledge people’s claims in this has left me with around $10,000 in monetary damages and could have lead to bodily harm or death if I would have been traveling on a main highway or interstate when it occurred. At the very least Chevy needs to be held responsible for this known and reported issue before it causes death or injury.

NHTSA ID

11752243

Incident

Jun 29, 2026

Wrangler Trailrunner AT LT275/65R20 were on the truck when I purchased my new 2021 Chevy 2500. I only have 25K miles on it. I was driving on the interstate and the tread came off the tire tore my wheel base apart and damaged back of truck along with scratches on the side by wheel also tore wheel trim off.

NHTSA ID

11750813

Incident

Jul 15, 2026

The contact owns a 2021 Chevrolet Silverado 2500. The contact stated that the electronic tailgate door had erroneously opened and closed and also, moments after turning the vehicle off the door had erroneously opened. The cause of the failure was not yet determined. The manufacturer was notified of the failure. The contact was informed that the VIN was not included in the NHTSA Campaign Number: 24V060000(LATCHES/LOCKS/LINKAGES). The contact indicated that the vehicle had experienced that same failure listed in the recall. The failure mileage was 47,000.

NHTSA ID

11740554

Incident

May 27, 2026

Mileage

47,000 mi

This Preliminary Information (PI) relays to dealer technicians to inspect the valve lifters during adjustment or repair for a rocker arm concern or an instance of low lift height.

This Preliminary Information communication provides information to the technician about vehicles that have an intermittent no crank, no start, or start stall concern with the security light coming on. Technician may find Diagnostic Trouble Codes B3055, B3

Beginning with 2026 model year production, the floor console/armrest lamp design was changed by removing the tilt-switch ball. As a result, the lamp remains illuminated when the floor console compartment lid is closed. The BCM turns the lamp off after the ignition is switched off to prevent battery rundown. This PI is to inform dealers of the change in the lamp and operation of the lamp following repairs.

This Preliminary information communicates that it is normal for the tailgate to drop faster than it used to after the GM Accessory Kicker Audio System is installed.

This PI communicates information that Engineering has released an updated Trailer Lighting Control Module to correct false Service Trailer Turn Signal Message when operating the power tailgate with no trailer connected.

• Improvements to OnStar functionality.