2000 Chevrolet Silverado 3500 Problems

DURING OPERATION OF VEHICLE, POWER BRAKING AND STEERING IS LOST. VEHICLE FAILS TO STOP OR STEER EASILY AND THEREFORE WILL NOT STOP IN SAFE DISTANCE. OCCURS USUALLY AT SLOW SPEEDS BUT INCREASES STOPPING DISTANCE AND REQUIRES EXTREME STRENGTH TO TURN. MAY HAPPEN SEVERAL TIMES DURING SHORT TRIP. VEHICLE HAS HYDRAULIC ASSIST (STEERING PUMP) BRAKE SYSTEM. DEFINITELY UNSAFE AND APPEARS CANADA HAS ALREADY ACTED ON.

DEPRESSED BRAKE PEDAL AND BRAKE PEDAL WENT TO FLOOR, HAD VERY HARD TIME STOPPING VEHICLE

LEFT REAR TIRE BECAME "LUMPY" TIRE DEALER INSPECTED AND SAID CORDS HAVE SEPARATED REPLACED TIRE WITH DIFFERENT MANUFACTURER. FAILED TIRE WAS AN ADVENTURER FUTURA 265/75 R16 LOAD RANGE E. TIRE WAS ON CHEVY 3500 SINGLE AXLE 2WD. *TR

TL*THE CONTACT OWNS A 2000 CHEVROLET K3500. THE TIRE MANUFACTURER IS NANKANG, BRAND NAME IS GEO TRAC, AND TIRE LINE IS LT/225/75/R16 (NA). UPON INSPECTION OF THE TIRES, THE CONTACT NOTICED THAT FOUR OUT OF THE SIX HAD CRACKS ON THE EXTERIOR OF THE SIDEWALL. HE IS IN THE PROCESS OF NOTIFYING THE MANUFACTURER. THE CONTACT STILL HAS POSSESSION OF THE TIRES. THE TIRE FAILURE MILEAGE WAS 1,300. THE VEHICLE FAILURE MILEAGE WAS 72,803.UPDATE 09/10/08 *CW UPDATED 09/19/08. *JB

DURING OPERATION OF VEHICLE, POWER BRAKING AND STEERING IS LOST. VEHICLE FAILS TO STOP OR STEER EASILY AND THEREFORE WILL NOT STOP IN SAFE DISTANCE. OCCURS USUALLY AT SLOW SPEEDS BUT INCREASES STOPPING DISTANCE AND REQUIRES EXTREME STRENGTH TO TURN. MAY HAPPEN SEVERAL TIMES DURING SHORT TRIP. VEHICLE HAS HYDRAULIC ASSIST (STEERING PUMP) BRAKE SYSTEM. DEFINITELY UNSAFE AND APPEARS CANADA HAS ALREADY ACTED ON.

TL* THE CONTACT OWNS A 2000 CHEVROLET SILVERADO 3500. THE CONTACT STATED THAT THE VEHICLE WAS BEING REPAIRED FOR UNRELATED BODY DAMAGES WHEN HE WAS INFORMED THAT THE DRIVE SHAFT WAS BROKEN. THE CONTACT WAS INFORMED THAT THE POWER STEERING PUMP AND FILTER WOULD HAVE TO BE REPLACED. THE CONTACT WAS ALSO INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 05V005000 (POWER TRAIN: DRIVE LINE: DRIVE SHAFT). THE FAILURE AND CURRENT MILEAGES WERE 117,000. UPDATED 9/10/12 *CN UPDATED 09/18/12

HAD MULTIPLE BRAKE LINE FAILURES IN THE LAST 2 MONTHS. FIRST BEING THE MAIN LINE TO THE REAR BRAKES, THEN BRAKE LINE TO THE RIGHT FRONT WHEEL, THEN LINE TO LEFT FRONT WHEEL. WHILE TRUCK WAS BEING WORKED ON IT WAS NOTICED THAT THE FRONT FRAME RAIL WAS STARTING TO RUST THROUGH NEAR WHERE THE FRONT BUMPER MOUNTS, ALSO NOTICED RUST ON THE FRAME AT FRONT OF CAB AREA, THIS IS NOT SURFACE RUST, THIS IS RUSTED THROUGH THE FRAME AND HAS LARGE RUST SCALES. IT IS PRIMARILY IN THE AREA OF THE CAB AND FORWARD. FRAME SEEMS TO BE OKAY FROM THE CAB BACK, PROBLEM IS WHERE THE FRAME IS ENCLOSED. *TR

TL* THE CONTACT OWNS A 2000 CHEVROLET K3500. THE CONTACT STATED THAT THERE WAS RUST ON THE FRAME OF THE VEHICLE. THE DEALER WAS CONTACTED BUT ADVISED THAT THEY WERE UNFAMILIAR WITH THE FAILURE AS THE CONTACT DESCRIBED. THE VEHICLE WAS NOT INSPECTED FOR THE FAILURE NOR REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 56,000.

TL* THE CONTACT OWNS A 2000 CHEVROLET SILVERADO 3500. WHILE DRIVING AT VARIOUS SPEEDS, THE REAR PASSENGER SIDE TURN SIGNAL FAILED WITHOUT WARNING. THE FAILURE RECURRED FOUR TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE REAR PASSENGER SIDE SOCKET FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 79,000. ...UPDATED 01/20/16 *BF *CN

WE HAVE PURCHASED A CHEVY 3500HD DUMP TRUCK. WE HAVE KNOWN THIS TRUCK FOR A FEW YEARS AND THE BRAKE LIGHTS HAVE BEEN STUCK ON AND NO SIGNALS FOR TWO YEARS. WE WERE TOLD ABOUT THE RECALL FOR THE MULTI-FUNCTION SWITCH FOR OTHER 2000 TRUCK MODELS, I.E. THE 2000 BLAZER, BECAUSE OF THIS SITUATION. WE FEEL THAT OUR TRUCK SHOULD BE INCLUDED IN THE RECALL BECAUSE IT HAS THE SAME PROBLEMS AS THE OTHER TRUCKS MADE BY CHEVY IN THE SAME YEAR AND SUSPECT IT IS THE SAME PART. WE HAVE BEEN TOLD THAT THE PART IS $400 AND $250 TO REPLACE IN LABOR. WE DON'T FEEL THAT WE SHOULD HAVE TO GO THROUGH THE COST AND THEN GET REIMBURSED FOR THE COST WHEN IT IS FINALLY RECALLED. IN THE PROCESS OF FINDING OUT WHAT THE PROBLEM WAS, HUNDREDS OF DOLLARS HAVE BEEN SPENT ON USELESS "FIXES" BECAUSE THERE IS NO RECALL FOR THIS PARTICULAR TRUCK AND NO ONE THOUGHT ABOUT THAT PARTICULAR SWITCH BEING BAD UNTIL WE WERE TALKING TO A BLAZER OWNER OF THE SAME YEAR THAT TOLD US ABOUT THE RECALL ON HIS TRUCK. WE INVESTIGATED A LITTLE MORE AND THERE ARE MORE THAN THE 2000 BLAZER WITH THIS PART BEING RECALLED. *TR

Vehicle regularly stalls while driving, going down hills and any random time at highway speeds, while in traffic, while stopped at traffic controls. This problem happens repeatedly and is apparently related to the “pump mounted driver”, which is prone to failure due to inadequate design for the use and environment. It creates random failures Of the pump to deliver fuel.

TL* THE CONTACT OWNS A 2000 CHEVROLET SILVERADO 3500. WHILE DRIVING AT VARIOUS SPEEDS, THE REAR PASSENGER SIDE TURN SIGNAL FAILED WITHOUT WARNING. THE FAILURE RECURRED FOUR TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE REAR PASSENGER SIDE SOCKET FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 79,000. ...UPDATED 01/20/16 *BF *CN

WHILE DRIVING 5 MPH THE RIGHT FRONT OF THE VEHICLE COLLASPED. THE TIE ROD AND BALL JOINT FAILED. *AK *JB

CONSUMER STATES VEHICLE PULLS TO THE RIGHT AND LEFT WHEN BRAKING, IN ADDITION, THERE WAS A RATTLE NOISE IN THE LEFT FRONT END WHEN GOING OVER BUMPS. *LA THE LEFT REAR TAIL LIGHT BULB WAS INOPERATIVE. THE LEFT FRONT WHEEL COVER CAME OFF. THE TAIL PIPE MADE A RATTLE NOISE, THE DEALER REPLACED THE TAIL PIPE. THE FOG LIGHT BULB WAS INOPERATIVE. THE FRONT BRAKES MADE A GRINDING NOISE WHEN THEY WERE APPLIED. THE AIR CONDITION WAS NOT COOLING PROPERLY. THE WOOD TRIM ON THE DASH WAS LOOSE. THE RIGHT REAR AXLE SEAL LEAKED. THE PLASTIC COMPARTMENT ABOVE THE GLOVE BOX WAS CRACKED. THE BASE OF THE WINDSHIELD WAS CRACKED. *JB

THIS INFORMATION PERTAINS TO A CHEVY CK 3500 CREW CAB 4X4 DULLY PURCHASED NEW IN 2000. AT 1,923 MILES THE ORIGINAL FACTORY FRONT BRAKE PADS WERE WORN OUT AND REPLACED UNDER WARRANTY. AT 3,108 MILES THE ROTOR ASSEMBLY WAS REPLACED. AGAIN, AT 7,709 MILES THE FRONT DISC PADS HAD TO BE REPLACED. AT 11,596 MILES FRONT DISC PADS, REAR SHOES AND LININGS. AT 20,317 MILES FRONT PADS AGAIN ALONG WITH REPLACEMENT OF H1320 BOOSTER ASSEMBLY. AT 24,977 MILES FRONT PADS AND H0780 BRAKE VALVE REPLACED. AT 35,000 MILES ONE MORE SET OF FRONT DISC BRAKE PADS BEFORE THE WARRANTY RAN OUT AND THE GENERAL CUT ME LOOSE. SINCE THE WARRANTY EXPIRED, IT HAS CONTINUED TO BE A FRONT BRAKE JOB BETWEEN EVERY 6,000-10,000 MILES. *NM

WHILE DRIVING SMOKE BEGAN TO EMIT FROM THE WHEELS. *NLM

NO INCIDENT..,HOWEVER WHILE IN ALASKA IN 2005. I WAS TOLD BY A STATE TROOPER THAT MY VEHICLE SIDE MIRRORS DO NOT MEET DOT STANDARDS, THEY ARE TOO SMALL TO PROPERLY VIEW THE SIDE OF THE VEHICLE. MY VEHICLE: 2000 CK3500, CREW CAB, 4X4, DUEL REAR WHEELS..,PULLING A 29' TRAVEL TRAILER. THE TROOPER IS RIGHT, MY MIRRORS DON'T EVEN VIEW BEYOND THE REAR FENDERS MUCH LESS THE TRAILER. MY QUESTION IS; HOW CAN THE VEHICLE INDUSTRY PUT A PRODUCT ON SALE IF IT DOES NOT MEET THE REQUIREMENTS IT WAS MADE TO DO? NOBODY BUYS A VEHICLE AS DESCRIBED WITHOUT USING IT TO PULL SOMETHING AND THE VEHICLE SHOULD MEET THOSE REQUIREMENTS PER THE STANDARDS SET BY DOT NATIONALLY AND BY STATES. *TR

CONSUMER STATES VEHICLE PULLS TO THE RIGHT AND LEFT WHEN BRAKING, IN ADDITION, THERE WAS A RATTLE NOISE IN THE LEFT FRONT END WHEN GOING OVER BUMPS. *LA THE LEFT REAR TAIL LIGHT BULB WAS INOPERATIVE. THE LEFT FRONT WHEEL COVER CAME OFF. THE TAIL PIPE MADE A RATTLE NOISE, THE DEALER REPLACED THE TAIL PIPE. THE FOG LIGHT BULB WAS INOPERATIVE. THE FRONT BRAKES MADE A GRINDING NOISE WHEN THEY WERE APPLIED. THE AIR CONDITION WAS NOT COOLING PROPERLY. THE WOOD TRIM ON THE DASH WAS LOOSE. THE RIGHT REAR AXLE SEAL LEAKED. THE PLASTIC COMPARTMENT ABOVE THE GLOVE BOX WAS CRACKED. THE BASE OF THE WINDSHIELD WAS CRACKED. *JB

Vehicle regularly stalls while driving, going down hills and any random time at highway speeds, while in traffic, while stopped at traffic controls. This problem happens repeatedly and is apparently related to the “pump mounted driver”, which is prone to failure due to inadequate design for the use and environment. It creates random failures Of the pump to deliver fuel.

CONSUMER STATES VEHICLE PULLS TO THE RIGHT AND LEFT WHEN BRAKING, IN ADDITION, THERE WAS A RATTLE NOISE IN THE LEFT FRONT END WHEN GOING OVER BUMPS. *LA THE LEFT REAR TAIL LIGHT BULB WAS INOPERATIVE. THE LEFT FRONT WHEEL COVER CAME OFF. THE TAIL PIPE MADE A RATTLE NOISE, THE DEALER REPLACED THE TAIL PIPE. THE FOG LIGHT BULB WAS INOPERATIVE. THE FRONT BRAKES MADE A GRINDING NOISE WHEN THEY WERE APPLIED. THE AIR CONDITION WAS NOT COOLING PROPERLY. THE WOOD TRIM ON THE DASH WAS LOOSE. THE RIGHT REAR AXLE SEAL LEAKED. THE PLASTIC COMPARTMENT ABOVE THE GLOVE BOX WAS CRACKED. THE BASE OF THE WINDSHIELD WAS CRACKED. *JB

HAD APPLIED GAS TO SPEED UP AND IT WOULD GO BACK. ENGINE KEPT REVVING, BUT REMAINED AT SAME SPEED. ABS WOULD KICK IN ON ANY SLIPPERY SURFACE. RIGHT FRONT TIRE GRABBED, HARD, AND THEN LOCKED UP WHEN BRAKES WERE APPLIED. AT DEALERSHIP ALL BRAKE PARTS WERE REPAIRED OR REPLACED. *AK

WHEN COMING TO A COMPLETE STOP, VEHICLE ACCELERATED SUDDENLY AND UNEXPECTEDLY AND WITHOUT WARNING. THE DEALER HAS NOT BEEN ABLE TO DUPLICATE THE PROBLEM. *AK *ML

THE VEHICLE HAS ALWAYS BEEN HARD TO SHIFT. WHILE SHIFTING FROM REVERSE TO DRIVE THE AUTOMATIC TRANSMISSION CONTROLLER( METAL PIECE INSIDE STEERING COLUMN ATTACHED TO LINKAGE) BROKE IN HALF, ALSO THE THREADED PIECE THAT IT WAS BOLTED TO BROKE, IT IS ALL MADE OF A SOFT TYPE METAL. *JB

VEHICLE DOESN'T HOLD WHEN BACKING DOWN HILLS IN 4 WHEEL DRIVE. IT HAS NO HOLD FROM THE TRANSMISSION. *AK THE OWNER OF THE VEHICLE DENIES THAT HE WAS AWARE OF THE PROBLEM EVENTHOUGH HE REMEMBER TEST DRIVING IT. *YH

TL* THE CONTACT OWNS A 2000 CHEVROLET SILVERADO 3500. THE CONTACT STATED THAT THE VEHICLE WAS BEING REPAIRED FOR UNRELATED BODY DAMAGES WHEN HE WAS INFORMED THAT THE DRIVE SHAFT WAS BROKEN. THE CONTACT WAS INFORMED THAT THE POWER STEERING PUMP AND FILTER WOULD HAVE TO BE REPLACED. THE CONTACT WAS ALSO INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 05V005000 (POWER TRAIN: DRIVE LINE: DRIVE SHAFT). THE FAILURE AND CURRENT MILEAGES WERE 117,000. UPDATED 9/10/12 *CN UPDATED 09/18/12

THE CLUTCH MADE A LOUD POPPING NOISE WHEN LET OUT, AND SLIPPING UNDER LOAD, THE DEALER FOUND THAT THE SLAVE CYLINDER SHAFT WAS WORN CAUSING THROW OUT BEARING TO WOBBLE AND MAKE NOISE, THROUGH OUT BEARING ALSO SCORED, DEALER REPLACED PRESSURE PLATE, CLUTCH DISC ASSEMBLY AND SLAVE CYLINDER ASSEMBLY, CONSUMER ALSO STATES VEHICLE WILL NOT SHIFT FROM REVERSE.NLM

TL*THE CONTACT OWNS A 2000 CHEVROLET K3500. THE CONTACT STATED THEY HAD TO REPLACE THE INTERIOR DOOR HANDLE FIFTEEN TIMES AND THE PASSENGER SIDE HANDLE TWICE. THE CONTACT STATED THE BARREL WHERE THE SPRING MOUNTED AROUND THE HANDLE BROKE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE ENTIRE DOOR LOCKING MECHANISM AND DOOR HANDLE WERE REPLACED. THE DEALER STATED THAT THE PART WAS FRAGILE AND WOULD CONTINUE TO BREAK. THE FAILURE MILEAGE WAS 35,000 AND THE CURRENT MILEAGE WAS 161,000. UPDATED 5/9/11 *CN

CONSUMER STATES VEHICLE PULLS TO THE RIGHT AND LEFT WHEN BRAKING, IN ADDITION, THERE WAS A RATTLE NOISE IN THE LEFT FRONT END WHEN GOING OVER BUMPS. *LA THE LEFT REAR TAIL LIGHT BULB WAS INOPERATIVE. THE LEFT FRONT WHEEL COVER CAME OFF. THE TAIL PIPE MADE A RATTLE NOISE, THE DEALER REPLACED THE TAIL PIPE. THE FOG LIGHT BULB WAS INOPERATIVE. THE FRONT BRAKES MADE A GRINDING NOISE WHEN THEY WERE APPLIED. THE AIR CONDITION WAS NOT COOLING PROPERLY. THE WOOD TRIM ON THE DASH WAS LOOSE. THE RIGHT REAR AXLE SEAL LEAKED. THE PLASTIC COMPARTMENT ABOVE THE GLOVE BOX WAS CRACKED. THE BASE OF THE WINDSHIELD WAS CRACKED. *JB

DT: THE CONTACT STATES THE FUEL INJECTION PUMP STOPS WORKING WITHOUT WARNING. THIS CAUSES THE BRAKES AND STEERING NOT TO WORK. THE PUMP HAS BEEN REPLACED TWICE AND HE FEELS THIS HAPPENS EVERY 18,000 MILES. THE VEHICLE HAS BEEN TAKEN TO THE DEALERSHIP FOR THE REPAIRS. THE MANUFACTURER OFFERED HIM $800 TOWARD A NEWER VEHICLE. *NM