Owner-reported complaints naming the fuel system system, filed with NHTSA
Data refreshed
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks. Every record below is an owner-reported complaint about the 2002 Chevrolet Silverado 3500 submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 8 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Shown in the owner’s own words, exactly as filed
2002 CHEVROLET SILVERADO. CONSUMER WRITES IN REGARDS TO SEVERAL FUEL INJECTOR FAILURES AND OEM UNCOATED CARBON STEEL BRAKE LINES. *M THE CONSUMER STATED GM WITHHELD MATERIAL FACTS CONCERNING DURAMAX LB7 DIESEL FUEL INJECTOR FAILURES IN VIOLATION OF MISSOURI MERCHANDISING PRACTICES ACT AT THE TIME OF SALE AND DELIVERY. *JS
WHILE DRIVING THE VEHICLE JUST COMPLETELY SHUTS OFF, I HAVE REPLACED EVERYTHING & 1 YEAR LATER AND 25,000 MILES LATER & 5 ACCIDENTS THE VEHICLE STILL DOES IT NOW IT WONT EVEN START. THIS IS VERY DANGEROUS AND THERE SHOULD BE A RE-CALL ON THIS I'VE READ THAT THIS IS VERY COMMON IN THIS VEHICLE AND THERE ARE VARIOUS RECALLS ON THE WIRING HARNESS, TRANSMISSION, FUEL LINE, FILTER, HEADLIGHTS, TOWING PACKAGE, BRAKE SYSTEM, BRAKE LIGHTS, BRAKE WARNING LIGHTS. EVERYBODY WHO IS EXPERIENCING THIS ISSUE SHOULD FILE A COMPLAINT TO RESOLVE THIS ISSUE. I ALMOST LOST MY LIFE MANY TIMES AND I LOST ALOT OF MONEY ON THIS VEHICLE GM SHOULD TAKE THIS TRUCK BACK THAT'S FOR SURE 2002 C3500 EXPRESS / CUTAWAY DURAMAX DIESEL *TR
TL* THE CONTACT OWNS A 2002 CHEVROLET SILVERADO 2500. THE FUEL INJECTOR THAT CONNECTS TO THE MOTOR HAS FAILED. THE VEHICLE DEALER AND MANUFACTURER WERE NOTIFIED. HE WAS ADVISED TO THAT HE WOULD HAVE TO BEAR THE EXPENSE OF THE REPAIR. THE FAILURE MILEAGE WAS 87,000. UPDATED 2/17/10 *CN UPDATED 02/22/10
TL*THE CONTACT OWNS A 2002 CHEVROLET SILVERADO 3500. THE CONTACT NOTICED THAT SMOKE WAS RISING FROM THE REAR OF THE VEHICLE, THE EXHAUST PIPE. THE VEHICLE WAS BROUGHT TO THE DEALER FOR A DIAGNOSTIC TEST, AND THE DEALER DETERMINED THAT THE FUEL INJECTOR FAILED. THE FUEL INJECTOR WAS PREVIOUSLY REPLACED THREE TIMES. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 152,927.*AK
THE CONSUMER PURCHASED A 2002 CHEVROLET 1 TON TRUCK IN 2003, EVER ONCE IN A WHILE IT HAS A COLD START. THIS BEGAN THE SAME MONTH THE VEHICLE WAS PURCHASED. FOUR TIMES SINCE DECEMBER THE VEHICLE HAS BEEN TO DEALER WHO CAN NOT FIND OUT WHAT IS WRONG WITH THE VEHICLE, BUT STARTS BACK AND QUITS OFTEN ON ROAD. HAS BEEN TOWED, WHICH GMC HAS REIMBURSED BUT NOT REPAIRED. THIS VEHICLE IS USED FOR WORK. COLD WEATHER RELATED, 30+ DEGREES NO PROBLEMS.*AK
WHILE DRIVING THE CONSUMER NOTICED THAT THE VEHICLE WAS LEAKING FUEL. THE FUEL CAUSED POOR VISIBILITY TO MOTORIST DRIVING BEHIND HIS VEHICLE. THE DEALERSHIP DETERMINED THAT THE FUEL INJECTION NEEDED TO BE REPLACED. THE VEHICLE IS NOW ON IT'S FOURTH REPAIR. *NM THE FUEL LEAK COULD CAUSE TO PUSHED PAST THE PISTON RINGS INTO THE CRANKCASE, AND A HAIRLINE CRACK IN THE FUEL RAIL ALSO CAUSED FUEL INTO THE CRANKCASE. ALSO, THE LEAK OF FUEL AND OIL HAS CAUSED CHECK ENGINE LIGHT TO TURN ON. GENERAL MOTORS WON'T REPLACE FUEL INJECTOR OR FUEL RAIL UNTIL IT HAS FAILED. *LA
MY TRUCK HAS THE NEW "DURAMAX" ENGINE IN IT. AND IT HAS HAD THE FUEL INJECTORS GO OUT 4 TIMES. I FEEL LIKE I LIVE AT THE CHEVROLET DEALERSHIP AT TIMES. THE BAD THING ABOUT THIS ENGINE IS WHEN THE MOTOR HAS A PROBLEM IT SHUTS DOWN. AND IF YOUR ON A FREEWAY YOUR GOING TO BE RAN OVER. IT SHUTS DOWN ANYWHERE AT ANYTIME AND YOU CANNOT START IT. *JB
LOSS OF CONTROL DUE TO AN UNKNOWN JIGGLE/BOUNCE, OUT OF BALANCE CONDITION. CONSUMER FELT DEALERSHIP LACKED TECHNICAL ABILITIES TO DIAGNOSE PROBLEM. TO DATE VEHICLE HAD 14 DIFFERENT NEW TIRES ON THE REAR AXLE. VEHICLE HAD BEEN SERVICED 10 TIMES. THE TIRE PRESSURE WAS ADJUSTED, THE FRONT AND REAR SUSPENSION CHECKED. REAR SWAY BAR WAS UNHOOKED. TIRES WERE BALANCED. HOWEVER PROBLEM STILL EXISTED. THERE WAS ALSO POOR FUEL MILEAGE AND AN EXHAUST ODOR. DUE TO SAFETY ISSUES CONSUMER IS RELUCTANT TO DRIVE VEHICLE. *TT *JB
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .