2022 Chevrolet Suburban Owner Complaints

The contact owns a 2022 Chevrolet Suburban. The contact stated that while attempting to start the vehicle with the Push-To-Start button, the engine failed to turn over. The check engine warning light was illuminated. The contact's husband was notified of DTC: P129F, which was diagnosed by the OnStar App. The vehicle was towed to a local dealer where it was diagnosed with a defective fuel control module. The vehicle was scheduled to be repaired out-of-pocket. Upon further investigation, the contact associated the failure with General Motors Emissions Recall: N252516900; however, the VIN was not included. The manufacturer was made aware of the failure. The failure mileage was approximately 39,000.

NHTSA ID

11754534

Incident

Aug 3, 2026

Mileage

39,000 mi

Driving down XXX going back home was driving normal when suv shut off on freeway with no warning what so ever i was 12 hours away from home almost crashed into bridge side wall was stranded on side of freeway with my whole family n my new born baby in the heat motor locked up per dealer 74k miles had to pay tow truck n a rental to get back home INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11749284

Incident

Jul 7, 2026

I own a 2022 Chevrolet Suburban with approximately 115,000 miles. While driving, the check engine light illuminated and the vehicle suddenly entered limp mode. The transmission lost normal operation, including reverse gear, significantly limiting the vehicle’s ability to operate. The failure occurred without warning and created a potential safety concern because the vehicle could no longer respond normally to driving conditions. The vehicle was inspected by a Chevrolet dealership, where technicians diagnosed a failed transmission control valve body and confirmed the valve body required replacement. I paid to have the repair completed. After the repair, I learned that GM issued Special Coverage N242454441 for certain 2021-2022 Chevrolet Suburban vehicles equipped with the same transmission. The bulletin describes premature transmission control valve wear that can cause a service engine light, reduced engine performance, harsh shifting, and requires replacement of the transmission control valve body. My vehicle experienced the same failure and required the same repair, but my VIN was not included in the covered population. I contacted GM before authorizing the repair and requested assistance, but my request was denied because my VIN was not included in the special coverage. I am submitting this complaint because my vehicle experienced the same transmission valve body failure identified by GM despite not being included. I request that NHTSA document this failure and determine whether additional vehicles equipped with the same transmission should be included in any current or future safety investigation.

NHTSA ID

11747576

Incident

Apr 7, 2026

Vehicle was recalled for loss of propulsion.Pico test was done ,changed oil.6,000 miles later engine locked up on freeway.Engine is in for replacement.2022 suburban 6.2 liter 66,000 miles

NHTSA ID

11747008

Incident

Jun 15, 2026

UNKNOWN TRANSMISSION ISSUES MENTIONED IN OTHER RECALLS FOR SAME PERIOD/MAKE MODEL AS LISTED YET MY VIN was not, as a mother 4 little ones I need my vehicle to perform as it was design to, the cost for this repair is over 6,000.00 I have already invested over 40,000 since I brought it. I feel they ought have included my car on this recent recall they had to have known this problem was of their why else would there recalls. I still must pay monthly for a vehicle that does perform as it should. This impacts my ability to provide for the needs of my children. I hope relief is on the way.

NHTSA ID

11741887

Incident

May 15, 2026

The telecommunications module for vehicle GPS and OnStar emergency services failed after a factory software update. Now the vehicle has no GPS location, information emergency OnStar services or the ability to access vehicle Telematic via cell signal or an app. Dealer refused to cover the item under the 36 month bumper-to-bumper warranty leaving the consumer stuck with a $2000 cost just to have GPS in the vehicle and maintain contact with emergency services through OnStar.

NHTSA ID

11739446

Incident

Jun 14, 2025

The contact owns a 2022 Chevrolet Suburban. The contact stated that the vehicle was taken to the local dealer for painting services. Upon retrieval of the vehicle, the service drive assist message was displayed. The doors failed to lock. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. Additionally, the contact contacted a lawyer. The failure mileage was approximately 28,000.

NHTSA ID

11738482

Incident

Jul 1, 2025

Mileage

28,000 mi

While driving down the high way with the check engine light on, a message appeared on the screen and said “unable to shift soon. Service transmission immediately.” After driving a few more miles the vehicle shifted to neutral, and then as soon as I got on the shoulder of the highway and slowed to approximately 5 mph, the vehicles wheels locked up and the car jerked aggressively into park. This exact issue has occurred multiple times while driving. It is unsafe to drive the vehicle.

NHTSA ID

11733683

Incident

Mar 21, 2026

Having reviewed online your safety recall number N252536750, I am experiencing the same issue (right rear wheel occasionally locks when starting from a standstill and turning right). It only lasts about 1 or 2 seconds while accelerating. However, when I discussed this with my Chevrolet Dealer, I was told that according to the VIN for my 2022 Suburban 3.0L Diesel, I am not part of that recall. I plan to take it to the Chevrolet Dealer very soon for more analysis. However, I wanted to bring this to your attention, as it could be hazardous. I have not gotten any dash warning messages. Thank you.

NHTSA ID

11733082

Incident

Apr 12, 2026

My 6.2L engine failed on 1/6/26 due to a OEM bearing issue. The vehicle was inspected and engine had to be replaced after the recall and service were done. The vehicle stalled while doing 30 mph on a local road. No warning lights or problems were observed or detected prior to the incident.

NHTSA ID

11732647

Incident

Jan 5, 2026

6.2l engine was losing power in Oct 2025. Took to dealership to address L87 recall. Oil change was completed and recall was closed. In March 2026, vehicle lost full power while driving on highway with other traffic. Vehicle was towed to dealership. Battery replaced. April 2026, vehicle lost power again on highway with traffic. Vehicle towed back to dealership. Both incidents inbolved children in the car and the vehicle was unresponsive and two crashed were narrowly avoided. GM notified. Case No.XXX This is related to NHTSA Recall Query XXX. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11731826

Incident

Apr 17, 2026

The contact owns a 2022 Chevrolet Suburban. The contact stated that while driving at an undisclosed speed, the instrument cluster failed to function as intended. The instrument cluster displayed a screen with lines. In addition, the contact stated that while attempting to start the vehicle, the instrument panel displayed a blank screen. The vehicle was taken to the dealer, where it was diagnosed with a failed instrument cluster. The contact was informed that the instrument cluster needed to be replaced. The vehicle was not repaired. The contact stated that on March 03, 2026, the vehicle was serviced at the dealer. The contact stated that four unknown recall repairs were performed, and the failure occurred a week after the recall repairs were performed. The manufacturer was made aware of the failure. The failure mileage was approximately 46,448.

NHTSA ID

11730249

Incident

Jan 26, 2026

Mileage

46,448 mi

2/24/2026 Sitting at red light, very busy road, vehicle cut off and said push to start. Vehicle would not start and would not shift out of park to push out of road. Very dangerous to be stranded in moving traffic. Had to be towed to dealer and it's still there waiting on engine replacement.

NHTSA ID

11729076

Incident

Feb 24, 2026

The contact owns a 2022 Chevrolet Suburban. The contact stated that while driving 50 MPH, the transmission unexpectedly shifted to neutral(N) and the vehicle shut off. The driver was able to coast safely to the side of the road. The vehicle failed to restart. There were no warning lights illuminated. The vehicle was towed to the local dealer, where it was determined that the engine needed to be rebuilt or replaced. The vehicle was not repaired. The vehicle was previously taken to the same dealer for a prior recall repair. The dealer had provided a loaner vehicle. The manufacturer was not notified of the failure. The failure mileage was approximately 58,166.

NHTSA ID

11726724

Incident

Mar 5, 2026

Mileage

58,166 mi

The contact owns a 2022 Chevrolet Suburban. The contact stated that while changing the oil and filter, there were metal shavings found in the oil filter. The vehicle was not taken to the dealer; however, the dealer was notified of the failure over the phone. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The approximate failure mileage was 115,000.

NHTSA ID

11726410

Incident

Mar 2, 2026

Mileage

115,000 mi

camshaft failure cylinder 7

NHTSA ID

11725419

Incident

Mar 15, 2026

Check engine light with rough shifting and vehicle wouldn’t go in reverse. For safety reasons we had the vehicle towed to our local Chevy Dealership. Transmission needed a valve body rebuild. This is a known issue with this transmission but our VIN wasn’t under that recall.

NHTSA ID

11724686

Incident

Mar 5, 2026

In several separate unreplicable instances, the vehicle has turned off while driving, once on the highway, once on my street, once turning across heavy traffic, and others. I've almost died a couple times and I've taken it to the dealership several times, they have Not been able to find anything wrong with it and have been unable to replicate the issue. The engine has been replaced, and it was happening before and since. My 2023 is also doing the same thing.

NHTSA ID

11722195

Incident

Jul 1, 2024

Unmodified 2022 Chevrolet Suburban with 53K mi, driving 25 mph on paved county road. Without warning the upper ball joint on the right front side sheared off. There were no sounds, no bumps or grinding, truck is routinely maintained, cleaned and inspected - this was out of the blue. If we had been going faster it could have been a disaster. The dealer confirmed it is the upper ball joint. Significant mechanical damage has included the upper control arm and drive line (4wd). We are working with GM to get this repaired. It certainly seems like a Serious Safety issue. I have seen many reports of this problem.

NHTSA ID

11721959

Incident

Mar 2, 2026

The contact owns a 2022 Chevrolet Suburban. The contact stated that while his wife was driving at an undisclosed speed, the rear wheels seized. There were several unknown warning lights illuminated. The message "Reduced Acceleration, Drive with Caution" was displayed. The contact's wife pulled into a parking lot, but the transmission failed to shift into reverse(R). The vehicle was towed to the dealer, where it was determined that the transmission control valve needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 26V085000 (Power Train); however, the VIN was not included in the recall. The manufacturer was made aware of the failure, and a case was opened. The failure mileage was approximately 86,000.

NHTSA ID

11721692

Incident

Feb 24, 2026

Mileage

86,000 mi

Vehicle accelerated while driving. The RPMs gage turned red; however, the vehicle stopped in the middle of the road with other cars coming. After the vehicle came to a full stop it would not move. Finally it started moving slowly and I was able to get off the road. When the tow truck arrived the vehicle would only go forward. No reverse. Error message on dashboard picture attached

NHTSA ID

11721068

Incident

Feb 27, 2026

Engine locked up going 75mph on highway. The vehicle's 6.2L V8 engine was recalled in 2025. Result of recall inspection was to change oil type to 0w-40. The vehicle is in the process of being inspected by dealer.

NHTSA ID

11720149

Incident

Feb 20, 2026

My vehicle was subject to a GM recall involving inspection of the 6.2L engine. The recall inspection was completed by an authorized GM dealership at 58,581 miles. The vehicle was cleared as passing the recall criteria and returned to me. Within fewer than 10 miles after leaving the dealership following the recall inspection, at approximately 58,590 miles, the vehicle experienced a sudden loss of propulsion while traveling at highway speed (approximately 65 mph) on a divided U.S. highway while ascending an incline. The vehicle shifted into neutral and lost engine power without warning. Steering and braking remained functional, but the vehicle lost forward motive power in the left lane of traffic. Attempts to restart the engine resulted in a loud mechanical thud, and the engine would not restart. The vehicle was towed to the dealership. The engine is now being replaced. Prior to this incident, the vehicle had previously undergone an oil consumption test related to engine concerns before the recall campaign. This failure occurred shortly after the vehicle was inspected and cleared under the recall procedure. I am reporting this due to the sudden loss of propulsion at highway speed following recall inspection and the subsequent need for complete engine replacement.

NHTSA ID

11719442

Incident

Feb 3, 2026

I own a 2022 Chevrolet Suburban RST that has experienced ongoing mechanical and safety issues over several years. I first began reporting drivability concerns to General Motors and the dealership in 2023 and continued contacting them throughout 2024 and 2025. During one dealership visit, a sales advisor rode in the vehicle with me and stated they did not observe any issues, despite my continued reports. The vehicle later suffered a loss of propulsion and required a full engine replacement. The radiator and cooling components were also replaced by a Chevrolet dealership. Due to ongoing concerns for my safety, I contacted General Motors multiple times, requested an executive buyback, and asked about Lemon Law options. GM advised that the engine had been replaced and that I needed to take ownership of the vehicle. After picking up the vehicle last Wednesday, I immediately noticed a persistent sweet coolant/radiator odor inside the cabin and outside the vehicle that continued for nearly a week. I also experienced engine hesitation/stuttering when stopped at traffic lights as the auto start/stop feature reengaged. I attempted to contact GM again regarding these concerns prior to today’s incident. Today, while driving, the vehicle displayed an engine overheating warning instructing me to turn the car off immediately. I safely pulled over and shut the vehicle down and am currently stranded roadside. Given the repeated failures, history of loss of propulsion, multiple repair attempts, denied buyback requests, persistent coolant odor, drivability issues, and now overheating shortly after engine and radiator replacement, I believe this vehicle presents an ongoing safety risk and request formal investigation.

NHTSA ID

11718467

Incident

Jan 8, 2026

My 2022 Chevrolet Suburban 6.2L, approximately 96,000 miles. Vehicle was taken to dealership for transmission warning message and returned as “repaired” with a software update. The following day, February 12th, while driving at highway speed on the expressway, the vehicle suddenly lost power without warning. A message appeared instructing me to press start, and the vehicle shifted into neutral and stalled. No warning lights were illuminated prior to the stall. This created a serious safety risk due to sudden loss of power at highway speed.

NHTSA ID

11718227

Incident

Feb 12, 2026