2023 Chevrolet Suburban Engine Problems

6.2 V8 while operating threw multiple error codes, went into crawl mode unexpectedly.

NHTSA ID

11755148

Incident

Sep 3, 2023

The contact owns a 2023 Chevrolet Suburban. The contact stated that while driving approximately 65 MPH, the transmission erroneously shifted to neutral(N), and the vehicle decelerated unexpectedly. The vehicle was pulled off the freeway and parked on the shoulder of the road, and the police were contacted and arrived at the scene and assisted with removing the small children from the vehicle. The vehicle was later towed to a nearby towing lot. The contact later received messages on the App for transmission and engine failures. The cause of the failures was not yet determined. The local dealer was notified of the failure. The manufacturer was not yet contacted. The contact stated that the vehicle was previously serviced under the NHTSA Campaign Number: 25V274000 (ENGINE AND ENGINE COOLING); even though the vehicle had experienced the failure listed in the recall. The failure mileage was 25,300.

NHTSA ID

11754537

Incident

Aug 2, 2026

Mileage

25,300 mi

I brought my Chevrolet Suburban High Country in to the dealer pursuant to a recall for engine issues due to a manufacturing defect in connecting rods and crankshafts that can cause catastrophic engine failure. The service center changed the oil viscosity and fill cap and stated that the change should eliminate the issue. I have had persistent engine knocking upon acceleration since then and it is getting louder and more prominent. A suspension warning intermittently flashes as well. Please advise, thank you

NHTSA ID

11752309

Incident

Feb 4, 2026

We purchased a 2023 Chevy Suburban in January of 2026. In May the vehicle shut off on me at a stop light. The check engine light flashed after I was able to restart it. I took it to the dealer and they said they "couldn't recreate the issue" even though there was an engine misfire code on all cylinders. They told me to come pick it up and bring it back if I had further issues. The second time this happened I had issues getting the vehicle started. This was June 2026 Once I finally got it started and was driving all the service lights started going off and the check engine light started flashing. I took it to a different chevy dealer and was told the same thing. This time I had 23 different service codes that showed up. Including the engine misfire code. So we picked it up and continued to drive it. On July 10th we were towing a 7k lb camper home when we lost all power. Thankfully we weren't driving fast and we're able to stop. This left us stranded at a busy intersection for 2 hours. The car would not go out of neutral. Had we been going 70 on an interstate we could have very seriously been hurt. The car had to be towed back to the dealership where we were told the engine locked up and needed to be replaced. My husband and I had our [XXX] child in the backseat with us. This was a family car that we purchased and told twice that they couldn't find anything wrong with it. The vehicle has been at the dealership waiting on a motor since July 11th. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11751691

Incident

Jul 10, 2026

The engine of this car has been under recall for multiple issues during the time we have owned it. The most recent issue that was experienced was total engine failure and electrical malfunction while driving on a busy street near train tracks. The vehicle was making a loud banging sound moments before this occurred. I wasn't even given time to get to a safe spot to investigate the issue. When it shut down, a quick message flashed across the dash board--stating ability to shift had been lost (or something to that effect)--the vehicle then flipped into neutral and immediately lost power. My safety was put at great risk due to the fact that the entire vehicle shut down moments after I crossed over a very busy railway track. The vehicle had to be towed to a nearby Chevrolet dealership where it has been confirmed there was total engine failure as well as blown main electrical fuse.

NHTSA ID

11744096

Incident

Jun 6, 2026

My 2023 Chevrolet Suburban Premier is covered under GM recall 25V-274 for the 6.2L L87 engine defect (loss of propulsion from connecting rod and crankshaft failure). In XXX, the dealer notified me my vehicle required a full engine replacement under this recall. Wareing Sheridan Chevrolet in [XXX] replaced the engine, and the vehicle was out of service approximately 12 to 14 days. Approximately 6,000 miles later, on XXX, the replacement engine failed while I was driving on the interstate highway near Billings, Montana. There were no warning indicators of any kind until I suddenly lost power. Only at the moment power was lost did the check engine light come on and a low oil pressure warning appear. I was barely able to get the vehicle off the interstate before it died. I had my family in the vehicle, and losing power on the interstate with no warning created a serious risk of a crash. The vehicle had to be towed to Denny Menholt Chevrolet in Billings, MT. On June 13, 2026, the dealer confirmed the vehicle needs a second complete engine replacement under the same recall. This is the second L87 engine failure and second full engine replacement on this vehicle under recall 25V-274. No crash or injuries occurred. I have an open case with GM (#XXX). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11743908

Incident

Jun 12, 2026

The engine siezed up due to the issues that are related to the recall. Currently waiting for a new engine, it has been almost 5 weeks and no time frame on when it will be fixed.

NHTSA ID

11738983

Incident

Apr 20, 2026

After performing all preventative, regular, and even proactive maintenance, the vehicle started shaking and shutting down with 2 miles. We are now being told (by 3 separate mechanics) that it needs an entirely new engine.

NHTSA ID

11738667

Incident

May 8, 2026

The contact owns a 2023 Chevrolet Suburban. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. Additionally, the messages “Coolant Control Valve” and “Acceleration Reduced – Stop Vehicle” were displayed. The vehicle was taken to the dealer, where it was diagnosed and determined that the coolant control valve had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 104,849.

NHTSA ID

11734824

Incident

Apr 30, 2026

Mileage

104,849 mi

While driving on interstate XXX on 4/17/2026 my vehicle lost power I had to pull over on the shoulder thankfully I was able to do so. Restarted the vehicle for just a short bit and it said loss of engine oil pressure and died. would not restart. Ultimately had to be towed to a GM dealership Lynch Chevrolet in [XXX] . Was told the engine was shot and was covered under the safety recall. There was a recall on the motor I had brought it in to get rectified sept 2025.a heavier weight oil was added and filler cap replaced with 40 weight oil identification. . I just had an oil change the day before the incident on 4/16. What is concerning I'm worried about the long wait plus plus online blogs that indicate the engine failed numerous times even after replacement. I was told from the dealership that the engine was on back order and they cannot give me a time on when it's going to be available. But again I'm worried about this vehicle in general in moving forward or trying to anyway. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11733473

Incident

Apr 17, 2026

The contact owns a 2023 Chevrolet Suburban. The contact stated that the engine and oil warning lights were displayed. The vehicle was taken to the local dealer, and the vehicle was diagnosed with engine failure. The vehicle was not repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 100,000.

NHTSA ID

11729595

Incident

Feb 22, 2026

Mileage

100,000 mi

I purchased a 2023 Suburban on March 6, 2026 with 52,980 miles. I drove it home to my house and parked it. On March 7, 2026 about 6pm, I started the vehicle and heard a loud engine noise. I called the dealership and let them know about the noise. On March 9, 2026 I towed it back to the dealership. The vehicle has been in service since then and was told it needs an engine. Metal spun threw the engine block and has to replaced. I just purchased this vehicle and drove it one day.

NHTSA ID

11727603

Incident

Mar 7, 2026

Regarding a catastrophic engine failure involving my 2023 Chevrolet Suburban equipped with the 6.2L L87 engine. There is an active GM service bulletin that we never received from either Crabtree or GM. Vehicle details: • Purchased in North Carolina in 2024 • Approximately 4,000 miles at purchase (used, still under factory warranty) • Currently at approximately 60,000 miles • Within the 5yr/60k powertrain warranty at the time of failure Incident details: On Friday 2/20, the engine experienced a confirmed catastrophic failure while my wife was driving on the interstate at highway speed. The vehicle abruptly lost power, creating a significant safety hazard. She was able to maneuver to safety, but the situation presented a serious risk of injury. GM has since towed the vehicle and confirmed catastrophic engine failure. We have been provided a rental vehicle - not a comparable one either (they refuse to address that also). Given the safety exposure and warranty status, I am evaluating potential potential claims including breach of warranty, implied warranty of merchantability, and any product liability considerations. I am also interested in understanding leverage for buyback, diminished value, risk of serious injury to my wife, or extended warranty resolution. I have preserved documentation, service records, and a written account of the incident.

NHTSA ID

11721619

Incident

Feb 20, 2026

Engine rattles and noisy, now auto light and message board states "Add Engine Oil)

NHTSA ID

11716816

Incident

Feb 7, 2026

My 2023 Chevy Suburban High Country had the L87 Engine Loss of Propulsion (Related field action: See Special Coverage N252494003) recall performed on it and completed on August 15, 2025. Higher viscosity oil was put in. This was at approximately 55,000 miles. While driving on the highway at 60mph on December 29, 2025 the vehicle twice lost propulsion and indicated the vehicle needed to be restarted. I took it to a Chevy dealer to have looked at in early January 2026 and they could find no issues or codes. On January 31, 2026 while driving on the hwy at 75 miles per hour the vehicle started to rattle and it lost propulsion. The DIC indicatd "System Failure" and I had to pull off to the shoulder of the highway. The DIC repeated "System Failure" and that the vehicle needed to be restarted. The vehicle would not restart when attempting to press the brake and restart. This happened on a busy interstate and the safety and well being of my family inside was put at a risk that could have been avoided, likely if the engine would have been replaced in August of 2025. The temperature outside was in the single digits and there was no air pushing through the vehicle while we waited for a tow truck and another family member to pick us up off the highway. There was no warning lights or messages prior to this happening. The vehicle is currenlty undergoing diagnostic testing at a Chevy dealership. This happened at 69,000 miles. This is highly concerning that this could happen in a 95,000 dollar vehicle. This is absolutely a saftey risk. I'm lucky I was able to merge on the interstate in a vehicle that could not maintain the speed with traffic and pull off to the shoulder.

NHTSA ID

11715199

Incident

Jan 31, 2026

The code that originally came up was P0300 a (Engine Misfire). I had this truck for one year and it says my fuel injector went bad so I’m getting the whole Tune Up done. I have the My Chevrolet app connected to my vehicle and it’s saying: the Engine/Transmission system needs service and the Emissions system! Mind you I e only had this vehicle for one year i bought it in February 2024 and it’s a 2023! I bought it from Lindsay Ford in Wheaton MD. I feel as though all this should not be happening in a matter of one year l believe I was sold a defective truck.

NHTSA ID

11714801

Incident

Jan 16, 2026

The contact owns a 2023 Chevrolet Suburban. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed with a failed coolant control valve. The contact was informed that the coolant control valve needed to be replaced. The vehicle was not repaired. In addition, the contact referenced a Special Coverage Program: N252508341, however the VIN was not included. The manufacturer was made aware of the failure but provided no assistance. The contact was advised to contact the NHTSA Hotline to report the failure. In addition, the contact was informed that the NHTSA could add the VIN to the special Coverage Program. The failure mileage was approximately 134,943.

NHTSA ID

11708318

Incident

Dec 2, 2025

Mileage

134,943 mi

After just getting our vehicle back on 12/11/25 from our incident on 11/9/25 when my wife was driving at 70 MPH on the highway when the engine blew the first time. Approximately 1300 miles later and 15 days after we picked up the vehicle when I was merging onto the highway the vehicle had a sudden power loss and a smell that filled the cabin. We were able to drive to the next exit and while the vehicle was idling it sounded awful. The check engine light started to flash along with the TCS light and the collision warning lights. After getting to a parking lot when called OnStar to tow our vehicle to the closest dealer. I have not received any updates yet but it is very similar to what happened the first time when the engine needed replaced.

NHTSA ID

11707616

Incident

Dec 26, 2025

My 2023 Chevrolet Suburban High Country (VIN: [XXX] ) suffered a sudden and dangerous engine failure while my wife was driving 70 mph on the interstate returning from our child’s sled hockey tournament in Ohio. The vehicle gave no warning lights, alerts, or diagnostic messages before the failure. While driving in the right lane, the vehicle began losing power and making a loud noise. My wife exited the highway and contacted OnStar, who told her the tow would take over an hour and only cover three miles to closest dealer, leaving her stranded in an unsafe area. She attempted to carefully reach a nearby dealership. During this attempt, the vehicle completely shut off and she lost all engine power. The vehicle lost all power making the final turn into the dealership coming to rest in the middle of oncoming traffic of a four lane road. The Suburban would not restart. A tow truck arrived and transported the vehicle to a dealership. When they arrived, the tow driver noticed smoke and a strong burning odor coming from the engine compartment and told her to move away from the vehicle because it could potentially catch fire. The vehicle was left in the lot with the hood open and positioned away from the building for safety. The dealership has determined the engine suffered a catastrophic failure and requires complete replacement. Multiple related components may also be affected. This occurred on a vehicle with only 54,000 miles that was purchased three months earlier. This incident created a serious safety risk for my wife, who was nearly stranded on an interstate and had to maneuver a powerless vehicle across several lanes of traffic. I am reporting this to NHTSA due to the sudden failure at highway speed, lack of warning, and potential fire hazard. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11699730

Incident

Nov 9, 2025

I was driving the vehicle and without warning it just stopped shut off and immediately shot an error code that there was a critical issue with the engine and that the oil pressure was low, and the vehicle would not start and was not drivable. It had to be towed to a dealership.

NHTSA ID

11698254

Incident

Nov 6, 2025

My 2023 Chevrolet Suburban with the 5.3L V8 engine has experienced lifter failure twice within less than [20,000 miles]. Both times the vehicle developed a misfire, engine belt like noise and was diagnosed by the Chevrolet dealership as having collapsed AFM/DFM lifters. All oil changes have been done at the dealership using GM-approved oil. The issue appears to be a known problem on 2021–2023 GM vehicles with the 5.3L L84 engine. GM has a technical service bulletin (PIP5776H) regarding lifter collapse, but no permanent fix has been provided. I am concerned this could lead to engine failure or stalling while driving, creating a safety hazard.

NHTSA ID

11697887

Incident

Mar 11, 2025

The contact owns a 2023 Chevrolet Suburban. The contact stated that while driving at 10 MPH, there was an abnormal rumbling sound coming from the engine, with the check engine and traction control warning lights illuminated. Due to the failure, the contact restarted the vehicle and drove to an independent mechanic. The mechanic performed a diagnostic test on the vehicle and discovered a misfire in cylinder #3. The mechanic replaced the cylinder #3 ignition coil; however, the failure persisted. The contact then had another independent mechanic at the same shop inspect the vehicle, and the mechanic diagnosed the vehicle with engine failure. Neither the dealer nor the manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was approximately 52,000.

NHTSA ID

11694924

Incident

Oct 21, 2025

Mileage

52,000 mi

The contact owns a 2023 Chevrolet Suburban. The contact stated that while driving approximately 30 MPH, the vehicle suddenly shut off without warning. After restarting the vehicle, the vehicle operated normally. The contact stated that the failure had occurred on several occasions. The vehicle was taken to the local dealer, who was unable to determine the cause of the failure. The vehicle was not repaired. The manufacturer was not yet contacted. The failure mileage was approximately 20,000.

NHTSA ID

11687640

Incident

Sep 1, 2025

Mileage

20,000 mi

I am driving a 2023 Suburban Z71, continually on and of of the engine light and "reduction in acceleration, drive with care" this truck has the same issue and same engine as the recall, but is not included. Yesterday i was almost t boned at an intersection because the vehicle would not develop enough power to get across a street at a stop sign. one of the scariest and near disastrous occurrences of my life. this truck is deadly

NHTSA ID

11685274

Incident

Sep 4, 2025

What component or system failed or malfunctioned, and is it available for inspection upon request? - Initially, the vehicle began making loud 'clanking' sounds from the engine, which immediately affected the ability to drive the vehicle. Upon further inspection by a third-party mechanic, it was determined that the Crank Shaft had malfunctioned. This is a known recall for our vehicle type (model, year, engine), however, no recall notice has been received at this time. How was your safety or the safety of others put at risk? - The vehicle was slowing abruptly while in drive mode, potentially causing a vehicular accident. Has the problem been reproduced or confirmed by a dealer or independent service center? - Yes, we did not deliver the vehicle to a dealer, as no assistance was initially offered when we made an attempt to call and inquire. However, a third-party mechanic was able to determine the issue. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives, or others? - Not at this time, as the dealer we initially inquired with did not seem inclined to assist. We consulted with a third party. Were there any warning lamps, messages, or other symptoms of the problem prior to the failure, and when did they first appear? -No. Failure messages or icons came on after the engine failure began

NHTSA ID

11683929

Incident

Aug 22, 2025