1995 Chevrolet Tahoe Electrical Problems

THE REAR DRIVER SIDE WINDOW BECAME INOPERABLE, FOLLOWED BY THE ENTIRE DOOR (IT WON'T OPEN AT ALL). THEN, THE REAR PASSENGER SIDE DOOR WOULDN'T OPEN FROM THE INSIDE, FOLLOWED BY THE DRIVER DOOR AND RECENTLY THE PASSENGER DOOR. THE DRIVER DOOR, FRONT AND REAR PASSENGER DOORS CAN ONLY BE OPENED BY ROLLING THE WINDOW DOWN AND OPENING THE DOOR FROM THE OUTSIDE HANDLE. WE NOTICED THAT AROUND THE SAME TIME THE DOORS WENT OUT, SO DID THE BACK BRAKE LIGHT PANELS (REPLACING THE BULBS AND HOUSING UNITS DON'T MAKE A DIFFERENCE). THE BACK BRAKE LIGHT PANELS ARE INTERMITTENT AND SEEM TO WORK ON OCCASION (IF WE HIT A BUMP OR SOMETHING). THIS IS A SEVERE SAFETY ISSUE AND I'M AFRAID WE WILL HAVE TO JUNK OUR TRUCK DUE TO IT. ARE THERE ANY OTHER TAHOE OWNERS WITH SIMILAR ISSUES? ANY RECALLS RELATED TO THESE ISSUES? THIS DOESN'T SOUND LIKE NORMAL WEAR AND TEAR RELATED ISSUES TO ME... *TR

NHTSA ID

10652251

Incident

Nov 1, 2011

Mileage

120,000 mi

TL* THE CONTACT OWNS A 1995 CHEVROLET TAHOE. WHILE DRIVING 55 MPH, THE VEHICLE DECELERATED AND STALLED. THE VEHICLE RESTARTED AND RESUMED NORMAL OPERATION. THE FAILURE OCCURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN STATED THAT THE SENSOR NEEDED TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS UNKNOWN.

NHTSA ID

10633389

Incident

Jan 21, 2013

WHILE DRIVING 65 MPH A FIRE STARTED UNDER THE HOOD. CONSUMER MANAGED TO PULL OVER.*AK

NHTSA ID

10040291

Incident

Sep 19, 2003

Mileage

115,000 mi

HORN WOULD SOUND WHILE DRIVING OR WHEN THE VEHICLE IS VIBRATED (EXAMPLE: DOOR IS SHUT, HOOD POPPED OPEN, ADJUSTMENT OF STEERING COLUMN). HAD THIS PROBLEM 2 TIME PREVIOUSLY, A GM AUTHORIZED DEALERSHIP LOOK AT SITUATION AND COULD NOT FIND A PROBLEM WITHOUT GOING INTO A DETAIL DIAGNOSTIC. PULLING THE FUSE FOR THE HORN WOULD NOT STOP THE HORN FOR SOUNDING. FINALLY HAD TO PULL THE HORN RELAY LOCATED IN THE FUSE BOX UNDER THE HOOD TO STOP HORN FROM SOUNDING. FINALLY HAD A DETAILED DIAGNOSTIC WAS PERFORMED AND THE ONLY THING THAT THE DEALERSHIP COULD FIND WAS A PROBLEM WITH THE AIRBAG. SUPPOSEDLY THE AIRBAG EXPANDS WHEN IT THE AREA AROUND IT HEATS UP, WHICH IN TURN APPLIES PRESSURE ON THE HORN RING, ERGO THE HORN GOES OFF EVEN WHEN THE FUSE WAS REMOVED. DEALERSHIP COULD NOT FIND AN ELECTRICAL PROBLEM DURING THEIR 2 HOURS OF DIAGNOTICS. RECOMMENDED SOULTION REPLACE AIRBAG / HORN RING $638.00 (PARTS ONLY). SUPPOSEDLY NEW AIRBAG HAS A NEW DESIGN TO PREVENT THIS FROM OCCURRING AGAIN.

NHTSA ID

758198

Incident

Feb 8, 2002

THERE IS AN ELECTRICAL SHORT CAUSING BREAKER TO OVERHEAT AND LOCKS AND SEATS TO BE INOPERATIVE.*YD

NHTSA ID

785754

Incident

Oct 10, 2001

AC DELCO BATTERY FAILURE RESULTED IN COMPLETE AND SUDDEN FAILURE OF THE ELECTRICAL SYSTEM. NLM

NHTSA ID

558681

IN NOV 1998, THE SAME INSTANCE OCCURED IN AS THE BATTERY + CABLES CRACKED THE SIDE MOUNT BATTERY CABLE ATTACHMENT. THIS CAUSES ACID LEAKAGE (UNDETECTED) TO LEECH INTO BOTH CABLES, WITH EVENTUAL CABLE FAILURE, POSSIBLE TOTAL POWER LOSS. IN MY 1ST REPORT (ODI # 724340) I PAID $405.95 TO THE DEALER + TOWING CHARGES TO HAVE THIS REPAIRED. THIS TIME I PURCHASED A NEW BATTERY WITH BOTH SIDE AND TOP MOUNT POSTS, 2 NEW CABLE ASSY'S, AND ATTACHED THE STARTER + CABLE TO THE SIDE MT, AND THE POWER CONTROL + CABLE TO THE TOP MOUNT TO ELIMINATE THE WEIGHT/PRESSURE ON THE SMALL SIDE MT 3/8" BOLT. THE WEIGHT OF BOTH CABLES ON A SINGLE SIDE MT POST IS EXCESSIVE, AND WITH VEHICLE VIBRATION DURING DRIVING THIS INCIDENT WILL CONTINUE TO OCCUR. I HAVE HOPEFULLY ELIMINATED THIS ISSUE BY SPLITTING THE CABLE MT LOCATIONS. HOPEFULLY CHEVROLET WILL RECALL THIS ISSUE BECAUSE IT IS A MAJOR PROBLEM COSTING CONSUMERS ALLOT OF CASH. AND THE KICKER, IT IS NOT COVERED UNDER A STANDARD OR EXTENDED WARRANTY DUE TO BATTERY FAILURE, WITH RESULTANT CABLE FAILURE IS NOT COVERED. FEEDBACK REQUESTED IF POSSIBLE.

NHTSA ID

736280

Incident

Nov 10, 2000

ON TWO OCCASIONS THE VEHICLE EXPERIENCED SUDDEN LOSS OF ELECTRICAL POWER WHILE DRIVING WHEN BOTH THE AC DELCO BATTERIES LEAKED ACID INTO THEIR ATTACHED POWER CABLES ALSO DAMAGING THE ALTERNATORS. NLM

NHTSA ID

556467

Incident

Nov 4, 1997

BATTERY LEAKED, CAUSING ACID TO DESTROY PAN AND BOLT THAT HOLDS BATTERY IN PLACE AND DESTROY WIRING AND FINISH BELOW BATTERY . *AK

NHTSA ID

731493

Incident

Jun 28, 1999

WHILE DRIVING WOULD EXPERIENCE HESITATION. TOOK TO DEALER & MECHANIC INDICATED THAT ACID HAD CORRODED SEVERAL OF BATTERY'S CABLE WIRES WHICH CAUSED THE PROBLEM. BATTERY WAS REPLACED WITH AN AC DELCO. PROBLEM WITH THE ORIGINAL BATTERY, CORRODED CABLE WIRES, HAPPENED WITH THE DELCO BATTERY. HAD TO GET DELCO BATTERY REPLACED. *AK

NHTSA ID

870397

REPORTED PROBLEM OF LEAKY BATTERY TO DEALER NOT COVERED BY WARRENTY. *AK

NHTSA ID

727018

NOTICED A SPOT ON GROUND. INVESTIGATING, I FOUND THE ORIGINAL DELCO BATERY LEAKING ACID ON THE INNER RIGHT FENDER, BRAKE PARTS, AND WIRING.*AK

NHTSA ID

725576

Incident

Jul 12, 2000

BATTERY LEAKS ACID AND CAUSED CORROSION OF SEVERAL ELECTRICAL COMPONENTS, BRAKE LINES, METAL, PAINT OFF ENGINE COMPARTMENT, ALL DAMAGED

NHTSA ID

9001670

Incident

May 1, 2000

EA 00 013 BATTERY LEAKS ACID: VEHICLE EXPERIENCING FIVE BATTERY ( 4 INTERSTATE AND 1 DELCO ) REPLACEMENT DUE TO ACID LEAKAGES FROM POSTIVE POST. PLEASE PROVIDE FURTHER DETAILS. *AK

NHTSA ID

864892

Incident

Jul 1, 2000

RE: INCIDENT AE00013 - THE AIRBAG LIGHT CAME ON INTERMITANTLY, TOOK IT TO DEALER, THEY COULDN'T FIND PROBLEM WITH IT. ABOUT A MONT LATER THE TAHOE STARTED INTERMITANTLY LOSING POWER WHEN TRYING TO ACCELERATE, CAUSING SEVERAL NEAR CRASHES. TOOK IT AGAIN TO THE DEALER THAT THEN DETERMINED THE BATTERY WAS LEAKING ACID ON TO THE AIRBAG SENSOR. HAD TO REPLACE THE AIRBAG SENSOR AND BATTERY. THEY CHARGED OVER $700 TO DO SO, INCLUDING $89 LABOR JUST TO INSTALL A NEW BATTERY! ABOUT A WEEK OR SO AFTER THAT SIMILAR LOSS OF POWER WAS OCCURRING. TOOK TAHOE TO A DIFFERENT CHEV DEALER WHO THE FOUND ALTERNATOR WAS NOW BAD, WHICH I SUSPECT MAY BE RELATED TO THE ONGOING BAD BATTERY PROBLEMS.*AK

NHTSA ID

724475

Incident

Aug 1, 1999

I RECENTLY READ OF YOUR INVESTIGATION OF TAHOE BATTERY LEAKAGE. I THINK THE PROBLEM IS BIGGER THAN POWER FAILURE. MY BRAKES FAILED ON THE HIGHWAY, AND WHEN I TOOK THE VEHICLE IN FOR REPAIR I WAS TOLD THAT ACID FROM THE BATTERY HAD LEAKED ONTO THE BRAKE LINE AND DESTROYED IT. ALL THE FLUID WAS LOST. THE BRAKE LINE, RIGHT FRONT HOSE AND (OF COURSE) BATTERY WERE REPLACED. SOMEONE SHOULD TELL GM THAT IT IS NOT TOO SMART TO PUT LEAKY BATTERIES OVER A BRAKE LINE. THE VEHICLE HAS BEEN (AND STILL IS) DEALER MAINTAINED AND SERVICED. *AK

NHTSA ID

724474

Incident

Oct 18, 1999

THE BATTERY LEAKED BATTERY ACID. THE POSITIVE BATTERY CABLE WAS CORRODDED BY THE ACID AND HAD TO BE REPLACED. ACID ALSO LEAKED ONTO THE INNER FENDER AND THE BRAKE LINE. THE ACID REMOVED THE PAINT FROM THE FENDER WHICH BEGAN TO RUST. THE BRAKE LINE APPEARS CORRODDED BUT HAS NOT FAILED YET.

NHTSA ID

724465

Incident

May 8, 2000

MY BATTERY FAILURE WAS SAME AS POWER FAILURE THAT NEWSPAPER SAID NHTSA WAS INVESTIGATING. I STILL HAVE BATTERY WHICH WILL SHOW WHY VEHICLE LOSES POWER. I ALSO KNOW OF ONE MORE EXACT SAME FAILURE WITH A SUBURBAN WHICH PROBABLY HAS'NT BEEN REPORTED. THE CARGO DOOR HINGES ARE ANOTHER FAILURE THAT GMC REFUSES TO ADDRESS AND BLAMES IT ON POOR MAINTINENCE BY THE OWNER. *AK

NHTSA ID

724440

Incident

Oct 15, 1999

BATTERY LEAKS HAS BEEN REPLACED SEVERAL TIMES. BUT BATTERY STILL LEAKS. *AK

NHTSA ID

858096

Incident

Feb 7, 2000

RECENTLY LEARND THAT THIS HAS HAPPEND WITH OTHER TAHOES. NO SAFETY DEFECT LISTED IN SUMMARY. *AK

NHTSA ID

719703

Incident

Dec 17, 1998

THE BRAKE MASTER CYLINDER IS LEAKING. *SLC

NHTSA ID

783658

2 BATTERIES HAVE LEAKED, BRAKES HAVE BECOME "SQUEAKY" SHORTLY THEREAFTER GOTH TIMES. I SAW AN ANNOUNCEMENT IN THE NY TIMES AND FELT I SHOULD GIVE YOU YHIS INFORMATION

NHTSA ID

718597

ORIGINAL MFG'S BATTERY SIDE TERMINALS LEAKED WITH PRESSURE AND SPEWED ACID OUT AND DOWN ON OTHER COMPONENTS OF THE ENGINE COMPARTMENT, INCLUDING THE RT SIR DEPLOYMENT SENSOR, ELECTRICAL WIRING, BRAKE LINES, TRANSMISSION COOLING LINES, AND OTHER ITEMS, WITH RESULTANT CORROSION. DEALER REFUSED TO FIX, OWNER CLEANED UP BEST POSSIBLE.*AK

NHTSA ID

718212

Incident

Aug 15, 1997

LEAKING BATTERY DRIPPED ONTO INNER RIGHT FRONT FENDER, BRAKE LINES AND HOSES. *MJS

NHTSA ID

550640

DURING ROUTINE MAINTAINANCE I NOTICED POSITIVE TERMINAL ON THE BATTERY WAS LEAKING. NOTIFIED DEALERSHIP AND WAS TOLD IT WAS NOT COVERED. I REPLACED IT WITH A SEARS BATTERY AND CLEANED UP TO BE BEST OF MY ABILITY THE LEAKAGE THAT OCCURRED (WHICH I WAS CONCERNED COULD AFFECT THE BRAKING, ANTI-LOCK SYSTEM, AND OTHER COMPONENTS.) I WAS NOT HAPPY WITH THE RESPONSE FROM THE DEALERSHIP, BUT I WAS NOT GOING TO BUY ANOTHER BATTERY THAT WOULD LEAK, FROM THE DEALERSHIP. I NOTICED THE ARTICLE IN THE NEWSPAPER REGARDING THIS SITUATION, RECENTLY, WHICH HAS PROMPTED MY REPORT. THANK YOU. *AK

NHTSA ID

718068

Incident

Mar 3, 1997