Reports submitted to NHTSA by owners and drivers, shown in full
Data refreshed
Our database holds 261 NHTSA owner-reported complaints for the 2004 Chevrolet Trailblazer Ext. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Showing 1–25 of 261 · page 1 of 11
"TAKATA RECALL" I WAS RECENTLY IN A CAR ACCIDENT THAT WAS LISTED IN THE POLICE REPORT AS A HEAD ON COLLISION AND NOT ONE AIRBAG DEPLOYED. THE IMPACT AS I WAS TOLD WAS HARD ENOUGH THAT THE AIRBAGS SHOULD HAVE DEPLOYED.
RUSTED FUEL LINES- GARAGE CHECKED STRONG FUEL SMELL AND DISCOVERED RUSTED FUEL FILLER AND LINES
PART # 19120564 RUBS ON TAILGATE WHEN OPENING . DOES SECURE PROPERLY. EVENTUALLY, FLEW OFF WHILE DRIVING.
WHEN DRIVING THE HEADLIGHTS ALL OF A SUDDEN JUST SHUT OFF. IT IS EXTREMELY SCARY AT NIGHT. I FOUND THAT I CAN HOWEVER USE THE BRIGHTS. THEY EVENTUALLY COME BACK ON. THIS HAS BEEN HAPPENING FOR YEARS. I KEPT HOPING FOR A RECALL AND JUST FOUND THIS SITE TO REPORT IT. THIS HAS HAPPEN ON CITY STREETS AND HIGHWAYS. IT HAS HAPPENED WHEN THERE ARE STREET LIGHTS AND VEHICLE LIGHTS AND WHEN IT IS PITCH BLACK. THE 1ST TIME IT HAPPENED, I WAS DRIVING WITH MY CHILD IN THE VEHICLE ON THE FREEWAY.
MY FAMILY WAS DRIVING HOME ON THE FREEWAY WHEN THE COMPLETE THIRD TAILLIGHT COVER BLEW OFF. IT APPEARS THAT THE ADHESIVE THAT ATTACHES THE REAR SPOILER TO THE GLASS OF LIFT GATE HAS LOOSENED DUE TO A MANUFACTURER DEFECT.
INSTRUMENTAL PANEL/ GAGE CLUSTER. ALL GAGES CONTINUE TO FAIL SPIKING ALL OVER THE PLACE PRIOR TO FAILING. AIR BAG LIGHT CONTINUES TO BLINK ON THEN OFF RANDOMLY
STALLS - I HAVE TAKEN THIS TRAILBLAZER INTO THE DEALER FOR THIS STALLING PROBLEM AND I AM TOLD NO PROBLEM FOUND. VEHICLE STALLS AFTER COMING TO A STOP OR WHEN MOVING SLOWLY. THIS IS AN INTERMITTENT.
CRACKED EXHAUST MANIFOLD
FUEL GAUGE NOT WORKING ALONE WITH ALL THE OTHER GAUGES AND TURNING SIGNAL NOT WORKING
VEHICLE'S REDUCED ENGINE POWER LIGHT COMES ON, AND VEHICLE LOSES POWER IN DANGEROUS PLACES. LOST OF PROBLEMS CONSIST OF SEVERAL PARTS HAVING TO DO WITH ACCELERATION. THIS PROBLEM HAPPENED SUDDENLY, ANDNIS A DANGER TO HIMAN SAFETY BECAUSE OF IT HAPPENING SEVERAL TIMES INCLUDING O N THE HIGHWAY.
AUTOMATIC TRANSMISSION SLIPS WHEN IT TRIES TO SHIFT INTO 3RD OR 4TH GEAR, I READ THAT THERE WAS A REPORT ON THIS HAPPENING BUT THERE WAS NOT A RECALL AS FAR AS I KNOW, I RECENTLY PURCHASED THIS VEHICLE FROM THE ORIGINAL OWNER WHO SAYS THEY NEVER RECEIVED ANY PAPER WORK FROM GM ABOUT DOING REPAIRS. MY QUESTION IS WILL GM REPAIR THIS CONDITION AT NO COST TO ME?
TL* THE CONTACT OWNS A 2004 CHEVROLET TRAILBLAZER EXT. WHILE DRIVING IN THE RAIN, THE MOISTURE SENSITIVE WIPER SYSTEM DID NOT DETECT MOISTURE. AS A RESULT, THE WIPERS STARTED TO MALFUNCTION AND OPERATED UNCONTROLLABLY. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V046000 (VISIBILITY/WPIER). THE FAILURE MILEAGE WAS 65,000.
TL* THE CONTACT OWNS A 2004 CHEVROLET TRAILBLAZER EXT. THE CONTACT STATED THAT THE ENTIRE INSTRUMENT PANEL FAILED TO OPERATE. IN ADDITION, THE SPEEDOMETER, TACHOMETER, AND FUEL GAUGE FAILED TO FUNCTION PROPERLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE INSTRUMENT PANEL CLUSTER WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 98,000. THE VIN WAS UNAVAILABLE.
SPEEDODOMETER AND RPM CLUSTERS MALFUNCTIONS,WHY
THE INLET CHECK VALVE IS FRACTURED AND CHEVY WILL NOT DO ANY REPAIRS DUE TO THE MILEAGE BEING OVER 150000
MY FUEL TANK HAS A HOLE IN IT. I HAVE FILED A PREVIOUS COMPLAINT WITH NHTSA AND ALSO WITH GM. AN NHTSA WORKER HELPED ME A LOT AND WHEN I CALLED GM AND CHEVY BACK I WAS TOLD SEVERAL TIMES SOMEONE WOULD GET BACK IN TOUCH WITH ME. I HAVE TRIED TO GET IT FIXED BUT NO ONE IS ABLE TO HELP. I HAVE TRIED MANY PLACES FOR USED FUEL TANKS BUT EVERYONE SAYS THAT THE ENVOYS AND TRAILBLAZERS THAT THEY HAVE ALL HAVE THE SAME EXACT ISSUE. I CANNOT GET ANY HELP FROM GM OR CHEVY.
THE TRANSMISSION COOLING LINES CORRODED AND CAUSED A TRANSMISSION FLUID LEAK. THE ENGINE RPMS INCREASED AND THE VEHICLE LOST POWER WHILE GOING DOWN INTERSTATE 86. WHEN THE FLUID LEAKED OUT OF THE TRANSMISSION COOLING LINES, IT SPRAYED ALL OVER THE EXHAUST PIPES, WHICH CAUSED A SEVERE FIRE HAZARD. DUE TO THE LOSS OF TRANSMISSION FLUID, IT CASED SIGNIFICANT DAMAGE TO THE TRANSMISSION INTERNALS. *TR
STARTING ABOUT A FEW WEEKS AGO MY 2004 CHEVY TRAILBLAZER EXT HAS REEKED OF UNSPENT GASOLINE, AND THIS SMELL CONSUMES THE ENTIRE INTERIOR AND EXTERIOR OF THE VEHICLE. THE VEHICLE ALSO HAS SMALL LEAK BELOW RESERVOIR WHICH APPEARS TO BE LEAKING UNSPENT FUEL. CHEVY OFFERED A "SPECIAL COVERAGE" TO CORRECT THIS ISSUE (CORROSION ON TOP OF FUEL TANK RESERVOIR), HOWEVER IT ONLY COVERS VEHICLES UNDER 10 YEARS OF AGE AND UNDER 120K MILES. MY VEHICLE IS UNDER THAT MILEAGE, HOWEVER THIS REPAIR WILL NOT BE COVERED DUE TO AGE OF VEHICLE (MINE WAS ASSEMBLED IN MARCH). THIS ISSUE IS A MAJOR SAFETY CONCERN, AS ANY SMALL SPARK COULD CAUSE THIS VEHICLE TO IGNITE. I CANNOT CONTINUE TO DRIVE MY VEHICLE, AND FEEL THIS NEEDS TO BE RECTIFIED BEFORE IT CAUSES CATASTROPHIC LOSS (EITHER BUILDING OR PERSONAL). *TR
WHEN HAD THE CRASH WHICH WAS VERY HARD LOUD AND SCARY THE AIR BAGS DIDN'T DEPLOY NOR DID THE AIR BAGS ON THE SIDE OF SEAT. THE CRASH WAS VERY SERIOUS AND THE ELECTRICAL SYSTEM AND POWERTRAIN TO WINDOWS. *TR
SPEEDOMETER DROPPED TO ZERO. STOPPED VEHICLE AND RESTARTED. SPEEDOMETER STARTED BUT WOULDN'T GO ABOVE 35 MPH. I HAD A GPS SPEEDOMETER ON MY PHONE AND IT WAS REGISTERING 55-60 MPH AND THE VEHICLE SPEEDOMETER WOULD DISPLAY 25-30. AFTER A COOL NIGHT IT MIGHT WORK CORRECTLY FOR 4 OR 5 MILES THEN IT EITHER DROPS TO ZERO OR FALLS TO THE 10-25MPH RANGE. SOMETIMES RESTARTING THE VEHICLE WILL GET IT TO WORK AGAIN FOR A SHORT TIME. WHEN IT IS FAILING THE NEEDLE DROPS BELOW THE 0 MPH TOWARDS THE MILEAGE. WHEN IT SEEMS TO BE WORKING SOMEWHAT IT STOPS AT 0 MPH OR JUST ABOVE IT. THIS SHOULD REALLY BE A RECALL ! THANK YOU *TR
DRIVING HOME FROM WORK BRAKES STARTED LOCKING UP DROVE HOME TOOK APART FRONT AN REAR BRAKES FOUND FRONT CALIPERS LOCKED UP CHANGED CALIPERS AN BRAKE PADS FRONT AN REAR TRIED TO BLEED BRAKES HAD A SPONGY PEDAL FILLED MASTER CYLINDER AN NOTICED BRAKE FLUID LEAKING UNDER MASTER CYLINDER CONNECTOR BEHIND FRONT DRIVER SIDE WHEEL NO PART TO FIX NO LISTING . CANNOT DRIVE CAR. THAT'S JUST ONE PROBLEM TRANSMISSION LINES ROTTED AN CHANGED 2 YEARS AGO . POWER STEERING COOLER ROTTED OUT LOST ALL POWER STEERING FLUID 1 MONTH AGO AN PUT AFTER MARKET COOLER IN . ALSO AIR CONDITIONER LINES ROTTED OUT CANNOT HOLD R34 COOLANT ANYMORE. *TR
THE FIRST TIME I WAS IN A CAR WASH AND HEARD A LOUD BANGING NOISE. I LOOKED BACK AND COULD SEE THE UPPER TAILGATE MOLDING FLOPPING IN THE WIND OF THE CAR WASH DRYER BEING HELD ON BY ONLY THE BRAKE WIRES. AT THAT TIME IT WAS REPLACED UNDER WARRANTY. 2ND REPLACEMENT ABOUT 3 YEARS LATER SAME THING. NOW RECENTLY I NOTICED AGAIN THAT ON THE DRIVERS SIDE SCREW ATTACHMENT ON THE MOLDING HAS BROKEN AWAY AGAIN AND IT'S MY RESPONSIBILITY TO SHELL OUT THE $500+ TO HAVE IT REPLACED AGAIN. I HAVE BEEN TOLD BY A GM DEALER IT IS PROBABLY CAUSED BY OUR WISCONSIN WINTERS WITH ACCUMULATION OF ICE & SNOW BUILD UP GETTING UNDER THE MOLDING AND ALSO WINDS USED TO DRYING VEHICLES IN CAR WASHES. CHEAP PLASTIC FOR THE MOUNTING SCREW TO GO THROUGH TO ATTACH IT TO THE VEHICLE. *TR
THE HEADLIGHTS INTERMITTENTLY WILL NOT WORK (LOWBEAM ONLY). IT HAPPENS AT NIGHT MANY TIMES AND I WILL HAVE TO DRIVE WITH THE BRIGHT LIGHTS OR FOG LIGHTS. SOMETIMES THE ENTIRE DASH LIGHTING WILL GO OUT AS WELL INCLUDING THE SPEEDOMETER. IT'S ALMOST AS IF THE ELECTRICAL PORTION OF THE IGNITION HAS FAILED. IT HAS BEEN HAPPENING INTERMITTENTLY FOR ABOUT A YEAR. *TR
INSTRUMENT PANEL/ SPEEDOMETER NO LONGER WORKS, FIRST INCIDENT HAPPENED MARCH OF 2010. AS OF 12/2013 THE VOLTAGE METER, RPM GAUGE, SPEEDOMETER HAVE COMPLETELY STOPPED WORKING. *TR
LIGHTS STARTED FLASHING, GAS GAUGE WENT TO EMPTY, CAR DIED. RESTARTED DROVE 1/4 MILE DIED. STEREO SYSTEM COMPLETELY FAILED (WHOLE UNIT). KEEPS POPPING CIRCUITS CHANGED OUT STILL DOING. CANNOT SHUT OFF HEAT DUE TO BANGING SOUND. CAR SPEEDS UP AND DOWN ON OWN. CANNOT READ GAS GAUGE CORRECTLY, NOT SURE HOW FULL TANK IS. *TR
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .