2004 Chevrolet Trailblazer Ext Fuel system Problems

RUSTED FUEL LINES- GARAGE CHECKED STRONG FUEL SMELL AND DISCOVERED RUSTED FUEL FILLER AND LINES

NHTSA ID

11176132

Incident

Feb 8, 2019

Mileage

171,000 mi

THE INLET CHECK VALVE IS FRACTURED AND CHEVY WILL NOT DO ANY REPAIRS DUE TO THE MILEAGE BEING OVER 150000

NHTSA ID

10806350

Incident

Oct 1, 2015

Mileage

190,000 mi

MY FUEL TANK HAS A HOLE IN IT. I HAVE FILED A PREVIOUS COMPLAINT WITH NHTSA AND ALSO WITH GM. AN NHTSA WORKER HELPED ME A LOT AND WHEN I CALLED GM AND CHEVY BACK I WAS TOLD SEVERAL TIMES SOMEONE WOULD GET BACK IN TOUCH WITH ME. I HAVE TRIED TO GET IT FIXED BUT NO ONE IS ABLE TO HELP. I HAVE TRIED MANY PLACES FOR USED FUEL TANKS BUT EVERYONE SAYS THAT THE ENVOYS AND TRAILBLAZERS THAT THEY HAVE ALL HAVE THE SAME EXACT ISSUE. I CANNOT GET ANY HELP FROM GM OR CHEVY.

NHTSA ID

10744125

Incident

Jul 28, 2015

STARTING ABOUT A FEW WEEKS AGO MY 2004 CHEVY TRAILBLAZER EXT HAS REEKED OF UNSPENT GASOLINE, AND THIS SMELL CONSUMES THE ENTIRE INTERIOR AND EXTERIOR OF THE VEHICLE. THE VEHICLE ALSO HAS SMALL LEAK BELOW RESERVOIR WHICH APPEARS TO BE LEAKING UNSPENT FUEL. CHEVY OFFERED A "SPECIAL COVERAGE" TO CORRECT THIS ISSUE (CORROSION ON TOP OF FUEL TANK RESERVOIR), HOWEVER IT ONLY COVERS VEHICLES UNDER 10 YEARS OF AGE AND UNDER 120K MILES. MY VEHICLE IS UNDER THAT MILEAGE, HOWEVER THIS REPAIR WILL NOT BE COVERED DUE TO AGE OF VEHICLE (MINE WAS ASSEMBLED IN MARCH). THIS ISSUE IS A MAJOR SAFETY CONCERN, AS ANY SMALL SPARK COULD CAUSE THIS VEHICLE TO IGNITE. I CANNOT CONTINUE TO DRIVE MY VEHICLE, AND FEEL THIS NEEDS TO BE RECTIFIED BEFORE IT CAUSES CATASTROPHIC LOSS (EITHER BUILDING OR PERSONAL). *TR

NHTSA ID

10628406

Incident

Aug 12, 2014

Mileage

111,000 mi

LIGHTS STARTED FLASHING, GAS GAUGE WENT TO EMPTY, CAR DIED. RESTARTED DROVE 1/4 MILE DIED. STEREO SYSTEM COMPLETELY FAILED (WHOLE UNIT). KEEPS POPPING CIRCUITS CHANGED OUT STILL DOING. CANNOT SHUT OFF HEAT DUE TO BANGING SOUND. CAR SPEEDS UP AND DOWN ON OWN. CANNOT READ GAS GAUGE CORRECTLY, NOT SURE HOW FULL TANK IS. *TR

NHTSA ID

10576687

Incident

Mar 11, 2013

Mileage

83,000 mi

TL* THE CONTACT OWNS A 2004 CHEVROLET TRAILBLAZER EXT. THE CONTACT STATED HE BEGAN TO SMELL FUEL INSIDE OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION WHERE THEY STATED THAT THE FUEL TANK NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 86,000. THE VIN WAS UNAVAILABLE.

NHTSA ID

10551366

Incident

Dec 20, 2012

Mileage

86,000 mi

I HAVE A 2004 CHEVROLET TRAILBLAZER EXT WITH 161,000 MILES ON IT. A FEW WEEKS AGO I GOT TO NOTICING A REAL STRONG GAS ODOR IN AND AROUND THE VEHICLE. I HAVE DONE A LOT OF RESEARCH AND HAVE HAD THE VEHICLE CHECKED OUT AND CAME TO THE CONCLUSION THAT IT IS THE COMMON PROBLEM THAT IS AFFECTING MANY OTHER TRAILBLAZER EXT OWNERS. IT IS THE FUEL TANK INLET CHECK VALVE AT THE TOP OF THE FUEL TANK. IN DOING MY RESEARCH I HAVE NOTICED THAT MANY PEOPLE HAVE HAD THIS ISSUE FIXED BY SOME RECALLS THAT HAVE BEEN ISSUED SO I TOOK THE VEHICLE TO MY LOCAL CHEVROLET DEALER TO FIND OUT ABOUT IT ONLY TO BE INFORMED THAT MINE IS 41,000 MILES PAST THE RECALL MILEAGE AND WILL COST UPWARDS OF $1,000 TO FIX. I AM WORRIED ABOUT A POSSIBLE FIRE OR EXPLOSION WITH THIS ISSUE. I AM AFRAID TO DRIVE IT TO WORK EVERY DAY AND TO USE IT TO TAKE MY CHILDREN TO SCHOOL. I JUST WISH THAT CHEVROLET WOULD FIX THIS SO I DON'T HAVE TO WORRY EVERY DAY ABOUT DRIVING IT. I DON'T FEEL THAT THERE SHOULD BE A MILEAGE RESTRICTION ON A SAFETY ISSUE THAT COULD RESULT IN DEATH OR GREAT INJURY. *TR

NHTSA ID

10549713

Incident

Sep 30, 2013

Mileage

161,000 mi

SEVERAL MONTHS THE SMELL OF GASOLINE WAS VERY STRONG IN THE INTERIOR OF MY SUV. I DROVE IT ABOUT FIVE MILES FROM MY HOME WITH A FULL TANK, AS I DROVE IT THE SMELL BECAME MUCH STRONG, WHEN I REACHED MY DESTINATION A PERSON POINTED OUT TO ME THAT GASOLINE WAS POURING FROM THE BOTTOM OF MY TRUCK LIKE A WATER HOSE. I IMMEDIATELY RETURNED HOME TO PARK THE VEHICLE. AS I TRIED TO RECALL WHAT MAY HAVE OCCURRED, I REMEMBERED THAT TWO DAYS PRIOR TO THE INCIDENT I GOT AN OIL CHANGE; I ASSUMED THAT MAYBE THEY HAD DONE SOMETHING TO AGGRAVATE AN ALREADY EXISTING PROBLEM. AFTER THEY REVIEWED THEIR WORK, I WAS TOLD IT WAS A MANUFACTURES PROBLEM. I LATER TOOK THE VEHICLE TO WOLF CHEVROLET (NOW DEFUNCT DEALER). A DIAGNOSTIC WAS DONE AND IT WAS DETERMINED THAT THE GAS TANK MUST BE REPLACED WITH A COST OF $1192. AND THE SUV IS CONSIDERED "TOO DANGEROUS TO DRIVE". I THEN WENT TO ANOTHER AUTOMOTIVE ESTABLISHMENT AND WAS GIVEN THE SAME DIAGNOSIS. AFTER TAKING IN CONSIDERATION BOTH ESTIMATES AND MY NEED FOR TRANSPORTATION, I CONTACTED GM AND SPOKE WITH A CUSTOMER SERVICE REPRESENTATIVE WHO INFORMED ME THAT I NEEDED TO TAKE THE VEHICLE TO A CERTIFIED GM DEALER. I TOOK THE VEHICLE TO LOU BACHRODT IN CHERRY VALLEY, ILLINOIS AND WAS GIVEN THE SAME DIAGNOSIS. AFTERI RELAYED THE IINFORMATION TO THE GM REP, HE SAID THAT DUE TO THE AGE OF THE VEHICLE AND THE MILEAGE, GM WOULD NOT BE ABLE TO OFFER ME ANY COMPENSATION. HE SUGGESTED I PHONE LOU BACHRODT AND SEE IF THEY COULD ASSIST ME IN THE COST, THE SERVICE TECHNICIAN GAVE ME THE SAME STATEMENT; AGE AND MILEAGE. I AM WRITING BECAUSE FROM ALL INDICATIONS THIS PROBLEM IS NOT ONLY PREVALENT IN MY SUV BUT AFTER DOING RESEARCH, SEVERAL 2004 CHEVROLET TRAILBLAZER OWNERS HAVE EXPERIENCED SIMILAR PROBLEMS. IT IS MY BELIEF THAT CHEVROLET GM SHOULD TAKE OWNERSHIP FOR ALL OR SOME OF THIS PROBLEM. *TR

NHTSA ID

10535221

Incident

Jan 21, 2013

Mileage

165,454 mi

I BEGAN SMELLING GAS FROM THE VEHICLE AND NOTED THAT THERE IS GAS DRIPPING FROM AROUND THE GAS TANK. I CONTACTED MY MECHANIC AND WAS TOLD THAT THIS IS THE THIRD TRAILBLAZER HE HAS SEEN IN 2 WEEKS WITH THE SAME PROBLEM. CHEVROLET ADVISES THAT THERE WAS A FIX WHICH WAS GOOD ONLY UNTIL 120,000 MILES. HOW AM I SUPPOSED TO KNOW TO TAKE IT AND HAVE IT FIXED BEFORE 120,000 MILES IF I AM NOT NOTIFIED BY GM? THIS OBVIOUSLY IS A SERIOUS SAFETY ISSUE INVOLVING THE TRAILBLAZER WHICH GM IS AWARE OF BUT HAS THUS FAR RESISTED RECALLING. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ID

10532784

Incident

Jul 28, 2013

Mileage

156,000 mi

WE WERE DOING OUR NORMAL FILL-UP (TRUCK WAS OFF) AND AFTER WE FILLED IT UP & TURNED IT OVER, THE FUEL GAUGE SHOT WAY OVER THE 'FULL' MARK. EVERY TIME WE TURNED THE VEHICLE ON, THE FUEL GAUGE WAS READING DIFFERENTLY, I HAVE NO IDEA HOW MANY TIMES IT WAS RIGHT. THE OIL PRESSURE AND BATTERY CHARGE GAUGE HAVE ALSO BEEN GIVING FALSE/SPORADIC READINGS AS WELL. AFTER MUCH SEARCHING, I FOUND THE ROOT CAUSE OF THIS TO BE A VERY COMMON PROBLEM NOT ONLY IN THE TRAILBLAZERS BUT THE TAHOES AND SEVERAL OTHER OF THEIR VEHICLES (THE INSTRUMENT CLUSTERS ARE FAULTY). GIVEN THE EXPANSIVE NATURE OF THIS ISSUE, AND THE POTENTIAL DANGERS OF NOT KNOWING YOUR SPEED, FUEL LEVEL, OIL PRESSURE OR RPMS, I'M HAVING PROBLEMS SEEING WHY THIS ISN'T A RECALL ALREADY. IT SEEMS TO HAPPEN MORE IN THE 2003-2006 MODELS MORE THAN OTHERS FROM WHAT I'VE FOUND AS WELL. *TR

NHTSA ID

10515530

Incident

May 6, 2013

Mileage

103,000 mi

DUE TO A SERVICE ENGINE SOON WARNING LIGHT AND SMELLING GAS INSIDE MY VEHICLE, I TOOK MY VEHICLE TO MY LOCAL MECHANIC. HE STATED THERE WAS A CRACK IN THE NECK OF MY FUEL TANK. THE TANK NEEDS TO BE REPLACED. HE ALSO STATED THAT THIS IS A COMMON PROBLEM WITH TRAILBLAZERS. I LOOKED UP ANY RECALLS. FOUND SPECIAL COVERAGE ADJUSTMENT - FUEL TANK INLET CHECK VALVE FRACTURE#07099A. I CALLED A LOCAL DEALER WHO CONFIRMED THAT WAS RIGHT. HOWEVER MY VIN # DOES NOT FALL UNDER VIN #'S LISTED. THE DEALER CALLED A LOCAL GM REP. AND I WAS OFFERED 40% COVERED BY GM MEANING I WOULD HAVE TO COVER THE OTHER 60%. I DO NOT UNDERSTAND WHY ONLY SOME VIN#'S ARE IN THIS AND NOT ALL OF THEM. IT SEEMS THAT THIS A PROBLEM THAT IS VERY COMMON IN THESE TRAILBLAZERS. I DO NOT FEEL SAFE DRIVING MY FAMILY OF 5 AROUND IN THIS TRAILBLAZER WITH A FRACTURE FUEL TANK INLET CHECK VALVE AND THE STRONG SMELL OF GAS IN THE TRUCK AND RISK OF FIRE FROM GAS LEAKING OUT. THIS SHOULD BE A RECALL ITEM SO THAT THOSE OF US THAT HAVE TRAILBLAZERS NOT WITH IN THE VIN #'S COVERED CAN GET THIS FIXED AND BE SAFE. CHEVROLET/GM SHOULD STEP UP AND MAKE THIS A RECALL THIS IS A HUGE SAFETY ISSUE. *TR

NHTSA ID

10509610

Incident

Mar 28, 2013

DUE TO A SERVICE ENGINE SOON WARNING LIGHT AND SMELLING GAS INSIDE MY VEHICLE, I TOOK MY VEHICLE TO MY LOCAL MECHANIC. HE STATED THERE WAS A CRACK IN THE NECK OF MY FUEL TANK. THE TANK NEEDS TO BE REPLACED. HE ALSO STATED THAT THIS IS A COMMON PROBLEM WITH TRAILBLAZERS. I THEN TOOK THE VEHICLE TO THE GM DEALER WHERE IT WAS PURCHASED. THEIR INITIAL DIAGNOSIS WAS THE FUEL CAP NEEDED TO BE REPLACED. AT THAT POINT I ASKED THEM TO CHECK FOR A CRACK. THEY DID AND VERIFIED THERE IS A CRACK. I MENTIONED GM CAMPAIGN 07099A - A RECALL FOR TRAILBLAZER EXT'S TO REMEDY THIS PROBLEM BY REPLACING THE FUEL TANK AT NO CHARGE. UNFORTUNATELY, THIS RECALL ONLY AFFECTED CERTAIN VIN #'S AND MINE IS NOT WITHIN THE AFFECTED NUMBER RANGE. I BELIEVE THIS IS A VERY DANGEROUS SAFETY DEFECT THAT SHOULD BE REMEDIED BY THE DEALER AT NO COST TO ME. THE DEALER OFFERED A 50/50 RESOLUTION WHICH TO ME ONLY SERVES TO PROVE THEIR CULPABILITY IN THE MATTER. I DO NOT FEEL SAFE DRIVING THE VEHICLE AND AM VERY CONCERNED FOR MY SAFETY AND THE SAFETY OF MY TWO YEAR OLD GRANDDAUGHTER WHOM I REGULARLY TRANSPORT IN THIS VEHICLE. *TR

NHTSA ID

10497980

Incident

Feb 12, 2013

Mileage

95,115 mi

I WAS DRIVING DOWN THE ROAD WHEN I RAN OUT OF GAS. IT STILL SHOWED OVER 100 MILES LEFT ON THE GAUGE. THAT WAS ABOUT 3 MONTHS AFTER I PURCHASED THE VEHICLE. ABOUT TWO MONTHS LATER, I HAD THE SAME PROBLEM. I STARTED KEEPING THE GAS ON 3/4 OF A TANK AT ALL TIMES TO MAKE SURE THERE WAS FUEL IN IT. THE PROBLEM KEPT HAPPENING. TODAY, IT WAS ON 200+ MILES AND I RAN OUT. THIS IS RIDICULOUS! DO I REALLY HAVE TO KEEP TRACK OF HOW MANY MILES I PUT ON IT SO I KNOW WHEN I NEED TO REFILL? *TR

NHTSA ID

10477964

Incident

Nov 24, 2011

Mileage

52,582 mi

I JUST GASED THE CHEVROLET TRAILBLAZER AND WAS DRIVING DOWN THE ROAD AND WE COULD SMELL GAS DID NOT THINK MUCH OF IT BECAUSE WE JUST GOT GAS THEN THE CHECK ENGINE LIGHT CAME ON IT WAS A PO442 CODE EVAPORATIVE EMISSION CONTROL SMALL LEAK DETECTED SO I HAVE BEEN SMELLING GAS OFF AND ON AND KEEP GETTING THE PO442 CODE. SO I GO BUY A VENT VALVE SOLENOID AND PUT IT ON CLEAR THE CODE I NOTICE GAS AROUND THE INTAKE PIPE ON THE GAS TANK SO I TAKE A CLOSER LOOK AND ITS BROKE HALF WAY AROUND THE FILLER NECK AND THIS IS A RECALL ON CERTAIN VIN #S BUT MINE IS NOT INCLUDED IN THIS RECALL I THINK IT SHOULD BE WHEN YOU ARE DEALING WITH FUEL AND THE AMOUNT OF FUEL THAT CAN LEAK OUT THIS CAN BE A FIRE HAZARD FOR SURE I THINK GM NEEDS TO STEP UP AND TAKE CARE OF THIS PROBLEM ON ALL VEHICLES THAT HAVE THIS PROBLEM INSTEAD OF PICKING AN CHOOSING CERTAIN VIN #S. *TR

NHTSA ID

10473288

Incident

May 8, 2012

Mileage

96,000 mi

TANK IS SUBJECT TO CRACKING CAUSING ROUGH IDLE VEHICLE SPEED SURGES AND GAS VAPORS IN THE VEHICLE AND AROUND THE VEHICLE. VEHICLE WILL FAIL EMISSIONS. MANUFACTURE RECALL WAS PUT OUT BUT VEHICLE HAS TO BE MADE AT A CERTAIN FACULTY AND MINE WASN'T, BUT HAS THE SAME PROBLEM AS THE RECALLED CARS. *JS

NHTSA ID

10453643

Incident

Jul 13, 2011

MY VEHICLE IS CURRENTLY PARKED IN MY FAMILY'S GARAGE, AS I AM EXPERIENCING A STRONG GAS SMELL. THERE IS NO VISIBLE LEAK, BUT I DO NOT DARE TO TRANSPORT MY CHILDREN IN THE VEHICLE UNTIL I CAN FIND WHAT THE GAS SMELL IS ORIGINATING FROM. *TR

NHTSA ID

10441453

Incident

Dec 26, 2011

Mileage

144,000 mi

TL* THE CONTACT OWNS A 2004 CHEVROLET TRAILBLAZER. WHILE THE VEHICLE WAS PARKED, THE CONTACT NOTICED A SIGNIFICANT AMOUNT OF FUEL LEAKING ONTO THE GROUND. THE CONTACT INSPECTED THE VEHICLE AND DISCOVERED THE FUEL TANK WOULD NEED TO BE REPLACED. THE MANUFACTURER ISSUED A VOLUNTARY RECALL PERTAINING TO THE FUEL TANK FILLER NECK. THE DEALER WAS NOTIFIED AND THEY STATED THE VIN WAS INELIGIBLE UNDER THE RECALL DEFECT. THE MANUFACTURER WAS NOT MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 88,000.

NHTSA ID

10436772

Incident

May 31, 2011

Mileage

88,000 mi

NOTICED GASOLINE ODORS INSIDE THE VEHICLE ON OCT. 2011. PERSONAL AUTO MECHANIC TOLD ME LAST WEEK THAT THERE'S A CRACK ON THE FUEL FILL NECK AREA WHERE THE GAS NOZZLE IS INSERTED. *TR

NHTSA ID

10436557

Incident

Oct 4, 2011

THE FUEL TANK IS LEAKING. THE FILL TUBE SEPARATED FROM THE TANK AND IS LEAKING FUEL ONTO THE TANK. THERE IS A STRONG FUEL ODOR AS WELL. CALLED CHEVROLET THEY STATED THAT VEHICLES ARE ONLY BEING REPAIRED FOR THIS ISSUE IN NORTHERN, EASTERN AND MIDWESTERN STATES. STATED THEY WILL NOT FIX MY ISSUE THOUGH IT HAS THE SAME ISSUES COVERED UNDER THE SPECIAL COVERAGE, DUE TO MY GEOGRAPHIC LOCATION. *TR

NHTSA ID

10405954

Incident

Mar 7, 2011

Mileage

113,000 mi

I OWN A 2004 CHEVY TRAILBLAZER. I AM HAVING CONSTANT PROBLEMS WITH THE GAS GAUGE INDICATING THAT EITHER THERE IS LESS GAS THEN ACTUAL, OR MORE GAS THEN ACTUAL. I KNOW THERE IS AN INVESTIGATION GOING ON WITH THESE VEHICLES BUT ONLY FOR THE YEARS 2005-2007, MINE IS A 2004. THIS INVESTIGATION SHOULD ALSO INCLUDE THIS YEAR SINCE THE SAME PROBLEMS ARE HAPPENING. *TR

NHTSA ID

10402557

Incident

Dec 15, 2010

Mileage

60,000 mi

ON SEVERAL OCCASION OVER THE PAST YEAR MY FUEL GAUGE IN MY 2004 CHEVROLET TRAILBLAZER LT HAS READ INACCURATELY LEADING TO BREAKING DOWN DUE TO THE VEHICLE RUNNING OUT OF GAS WHILE THE GAUGE WAS STILL READING AT LEAST 1/4 TANK MOMENTS BEFORE THE ENGINE STALLS. ON ALL OCCASIONS I WAS DRIVING ON THE FREEWAY THE GAUGE SHOWED 1/4 TANK AND THEN ALL OD A SUDDENLY DROPPED TO E WITH THE FUEL WARNING LIGHT COMING ONE. WITHIN A FEW MILES OF THIS SUDDEN DROP AND THE WARNING LIGHT COMING ON THE ENGINE WOULD STALL DUE THE VEHICLE BEING OUT OF GAS. I HAVE COMPLAINED TO MY LOCAL DEALER ON SEVERAL OCCASIONS AND ALL THEY HAVE OFFERED TO ME IS TO REPLACE THE SENDING UNIT, WHICH IN THIS MODEL IS INTEGRATED WITH THE FUEL PUMP AT THE COST OF ALMOST $800. THIS SEEM WRONG TO ME. NOW THAT I HAVE READ THAT THIS SEEMS TO BE A PROBLEM ON THESE TYPES OF VEHICLES I AM EVEN MORE UPSET THAT THE LOCAL DEALERSHIP TOLD ME MY ISSUE IS AN ISOLATED ISSUE AND THEY HAVE NEVER HEARD OF ANY PROBLEMS WITH THE FUEL GAUGES IN THESE VEHICLES. *TR

NHTSA ID

10398564

Incident

Mar 10, 2011

Mileage

69,582 mi

I OWN A 2004 CHEVY TRAILBLAZER. I PURCHASED IT USED FROM A DEALER IN DECEMBER OF 2010. I NOTICE SINCE I HAVE OWNED IT THAT THERE IS SOMETHING WRONG WITH THE GAS GAUGE. IT WILL SHOW A DECENT AMOUNT OF GAS IN THE TANK THEN BY THE TIME I GET OUT OF MY DRIVEWAY IT IS SHOWING EMPTY. IT WILL GO UP AND DOWN ALL THE TIME. I KNOW I AM NOT OUT OF GAS, BECAUSE I MAKE SURE TO PUT GAS IN EVERY DAY BECAUSE I AM NOT SURE WHAT IS IN THE TANK BECAUSE OF THIS PROBLEM. I WAS GOING TO TAKE IT TO A MECHANIC TO HAVE THEM LOOK AT IT AND FIX THE PROBLEM. SINCE SEEING THAT AN INVESTIGATION IS BEING DONE FOR THE SAME EXACT PROBLEM, I DECIDED TO WRITE HERE FIRST. I AM REQUESTING THAT THE YEARS INVESTIGATED ALSO INCLUDED 2004, SINCE IT IS THE SAME PROBLEM THAT IS BEING INVESTIGATED BY YOUR AGENCY. *TR

NHTSA ID

10398243

Incident

Dec 15, 2010

NOT SURE WHAT TO FILE THIS UNDER, SO I PUT IT UNDER UNKNOWN AND OTHER. ABOUT 4 MONTHS AGO MY SERVICE ENGINE SOON LIGHT CAME ON. IT STAYED ON FOR A FEW DAYS THEN WENT OFF, A FEW DAYS LATER IT WAS BACK ON, THEN A FEW DAYS LATER WENT OFF, THEN IT CAME ON FOR A LONGER PERIOD OF TIME AND DO THE SAME THING, EVENTUALLY IT STAYED ON. TOOK IT TO THE CHEVY DEALERSHIP WHERE I BOUGHT IT AND THEY SAID THE GAS TANK HAD A CRACK IN IT AND NEEDED TO BE REPLACED. SAID IT WAS PROBABLY FROM THE GAS NOZZLE HITTING THE TANK WHEN FILLING IT UP. DON'T SEE HOW THAT IS POSSIBLE, WHEN IT IS ONLY ME OR MY HUSBAND FILLING IT UP & HOW HARD WOULD YOU HAVE TO HIT IT FOR IT TO CRACK? HAD IT REPLACED THE NEXT MONTH. NOW THE SERVICE ENGINE SOON LIGHT IS DOING THE SAME THING. HAVEN'T TAKEN IT BACK IN YET. *TR

NHTSA ID

10393761

Incident

Nov 11, 2010

Mileage

98,000 mi

NOT SURE WHAT TO FILE THIS UNDER, SO I PUT IT UNDER FUEL SYSTEM, GASOLINE. SAME DAY I WAS HAVING PROBLEMS WITH SPEEDOMETER I WAS HAVING PROBLEMS WITH THE GAS GAGE. THE ARROW WOULD GO WAY PAST FULL, WHEN I KNEW I ONLY HAD ABOUT HALF A TANK. THE GAS GAGE HAS BEEN ACTING UP EVER SINCE, I JUST HAVE TO KEEP TRACK OF MY MILEAGE TO KNOW WHEN TO FILL IT UP. HAVE NOT HAD THE PROBLEM FIXED YET. *TR

NHTSA ID

10393757

Incident

Oct 22, 2010

Mileage

90,000 mi

1. FUEL TANK FAILURE, WITH GAS SMELL AFTER FILL UP. 2. SPEEDOMETER STOPPED WORKING 3. TEMPERATURE GAGE STOPPED WORKING

NHTSA ID

10375968

Incident

Dec 21, 2010

Mileage

80,000 mi