2007 Chevrolet W3500 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2007 Chevrolet W3500, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Engine266.7%
- Transmission133.3%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2007 CHEVROLET W3500. AFTER THE VEHICLE WAS STARTED, THE CHECK ENGINE WARNING LIGHT ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. IN ADDITION, THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V704000 (FUEL SYSTEM, GASOLINE); HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 100,000.
THIS 07 TRUCK GET HOT AND THE TRANS SLIPS. I HAVE HAD IT TO MANY DEALERS WITH NO ONE FIXING THE PROBLEM. ITS BACK IN THE SHOP NOW. GM REP SAYS DON'T DO ANYTHING TO IT UNTIL IT DOES IT IN THE SHOP. IT ONLY DOES THIS WHEN I AM PULLING A RV WITH THE TRUCK. I BOUGHT THIS TRUCK TO PULL RVS TO CAL EVERY WEEK AND I SPENT MORE TIME IN SHOPS THAN WORKING. NOW I AM GETTING BEHIND ON MY PAYMENTS BECAUSE I CAN'T KEEP IT RUNNING. I KNOW THERE JUST WAITING FOR THE WARRANTY TO RUN OUT THEN THEY WILL TELL ME WHAT'S WRONG. THEY HAVE PUT ONE INJECTOR IN IT AND A EGR VALVE SO FAR AND IT HAS NOT FIXED IT I HAVE ASK THEM TO BUY IT BACK AND THEY SAY THEY DON'T BUY BACK AUTOS THAT ARE LEASED. I NEED SOME HELP ON THIS. *JB
Too few reports in this category for a page of its own — they appear in the full complaint list.
Transmission
Reports naming the automatic or manual transmission, including shifting behaviour, shudder, slipping and transmission control modules.
From owner reports, verbatim
THIS 07 TRUCK GET HOT AND THE TRANS SLIPS. I HAVE HAD IT TO MANY DEALERS WITH NO ONE FIXING THE PROBLEM. ITS BACK IN THE SHOP NOW. GM REP SAYS DON'T DO ANYTHING TO IT UNTIL IT DOES IT IN THE SHOP. IT ONLY DOES THIS WHEN I AM PULLING A RV WITH THE TRUCK. I BOUGHT THIS TRUCK TO PULL RVS TO CAL EVERY WEEK AND I SPENT MORE TIME IN SHOPS THAN WORKING. NOW I AM GETTING BEHIND ON MY PAYMENTS BECAUSE I CAN'T KEEP IT RUNNING. I KNOW THERE JUST WAITING FOR THE WARRANTY TO RUN OUT THEN THEY WILL TELL ME WHAT'S WRONG. THEY HAVE PUT ONE INJECTOR IN IT AND A EGR VALVE SO FAR AND IT HAS NOT FIXED IT I HAVE ASK THEM TO BUY IT BACK AND THEY SAY THEY DON'T BUY BACK AUTOS THAT ARE LEASED. I NEED SOME HELP ON THIS. *JB
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .