2019 Chrysler Pacifica Engine Problems

As I pulled up to stop, in electric mode, at a stop light, the display screen pulled up a message to pull over safely because the engine would stop soon, within about 10 seconds the screen showed the engine stopped. I was still at the light. I tried restarting the vehicle, moving the shifter from drive to park and back, pressing the park button several times with no success. With cars honking behind me, I got out of the car, told them my car had died and asked them to drive around me. I got back in the car, repeated the actions a few times and the car started in electric mode. I drove home (about 5 miles) without incident. Check engine light was on. I pulled 2 codes U0412 and U029a. I have had the U0412 code a few times before with only the check engine light coming on. It would go away in a day or two (no check engine light and no code). U029a is new.

NHTSA ID

11756324

Incident

Aug 11, 2026

While driving, the vehicle began to sputter and the check engine light illuminated. A scan at a franchised dealership showed a stored code for a cylinder 4 misfire. Further diagnosis found coolant intrusion into cylinder 4, indicating internal failure of the left cylinder head and/or head gasket, allowing coolant into the combustion chamber. Upon removing the left valve cover and camshafts, the technician found a broken head gasket and a warped left cylinder head. The dealership replaced the left cylinder head, head gasket, cylinder head cover gasket, and oxygen sensor, refilled coolant, and replaced the PCV valve as a maintenance item. After repair, the vehicle was test driven and no further misfire was detected. This failure occurred at approximately 72,000 miles, low mileage for a major internal engine component, shortly after the factory powertrain warranty expired, leaving the owner responsible for the full repair cost. A misfire caused by coolant entering a cylinder can cause sudden, unexpected loss of engine power and rough running while driving, a safety concern in traffic, on highways, or when merging and passing, since reduced power can make it hard to maintain speed or accelerate out of a hazardous situation. Continued driving with undiagnosed coolant intrusion can also cause secondary engine damage, including hydrolock. The failed cylinder head and gasket were not retained by the owner; the dealership performed the repair as part of the invoiced order. The manufacturer has not independently inspected the vehicle beyond the dealership's diagnosis, photographs, and repair documentation, available on request. This appears to be a recurring issue on this engine platform, as similar cylinder head/gasket coolant intrusion failures, with matching misfire codes, have been reported by other owners of similar model-year minivans with the same engine, typically presenting in the 60,000-85,000 mile range, shortly after the factory powertrain warranty expires.

NHTSA ID

11755670

Incident

Jul 23, 2026

The vehicle intermittently displays a "Stop Safely – Vehicle Will Shut Off Soon" warning message accompanied by a turtle icon while driving, most often at highway speeds above approximately 50 mph. There is no consistent pattern or condition that triggers the warning. When the warning appears, I must immediately attempt to pull off the roadway because the vehicle indicates it will shut down. This creates a significant safety hazard, especially on interstate highways or roads without a safe shoulder. If the vehicle is turned off and restarted, the warning message disappears, but the check engine light remains illuminated. After the next ignition cycle, the check engine light also disappears, leaving no visible indication of the problem. The issue began occurring approximately once per year but has become progressively more frequent. It now occurs almost daily. During a recent 300-mile trip, the warning appeared four separate times. It also commonly occurs twice during a 60-mile drive. The increasing frequency has made the vehicle unreliable and unsafe to operate on highways. The vehicle has been taken to an authorized Chrysler dealership. However, the dealer stated they cannot diagnose or repair the problem unless the warning is actively displayed when the vehicle arrives. Because the warning clears after restarting the vehicle, the dealer has been unable or unwilling to identify the cause or perform a repair. I also contacted Chrysler customer service. I was informed that because there is no recall related to this issue, they could only refer me back to the dealership for diagnosis under any applicable warranty coverage. This defect poses a serious safety risk because the vehicle may lose propulsion while traveling at highway speeds, requiring an emergency maneuver to reach the shoulder while surrounded by fast-moving traffic. I am concerned that this could result in a rear-end collision or other serious crash if the warning occurs where there is no safe place

NHTSA ID

11749513

Incident

Jul 3, 2026

A misfire code came up. Had plugs done.. didn’t solve problem now blowing white smoke burning antifreeze. Head gaskets bad. We just bought this 2019 7 months ago. And it only had 68,000 miles on it now 71000 miles on it. We thought we would get the newer better vehicle and having engine problem in a car that we paid 22000 dollars for. Going to be an expensive fix on a problem that shouldn’t be occurring on a car with that mileage.

NHTSA ID

11748610

Incident

Jul 6, 2026

While driving the car is unable to switch gears from D to L gear and has no power to accerlerate up hill.

NHTSA ID

11724661

Incident

Mar 16, 2026

The vehicle has no power going up hills or accelerating and just stops and doesn't move. To get the car to move again you have to turn the car off and back on. Even if you put the car in L it can still just go back in regular drive on its own an cut out with no acceleration.

NHTSA ID

11724582

Incident

Mar 11, 2026

Bad engine at 67,000 miles for a blown head gasket. Service records up to date,

NHTSA ID

11723248

Incident

Mar 9, 2026

This has been ever since I got my van. Sometime when I drive my lights come on and it goes into limp mode. Most of the time. When I start my van my lights will turn on. I have to turn my car off . Then start again to get my van riding correctly. The other day I was making a U-turn and my engine stalled and I was almost hit by a truck.

NHTSA ID

11713341

Incident

Jan 24, 2026

A slow coolant leak is draining the coolant from the reservoir into the engine. This has happened twice now and no external leaks can be found. The first instance in June 2021 was on a trip from Goldsboro, NC to Antigo, WI. We made it to Chicago and noticed the engine temp climbing. We thought it was due to the trip and heat but had just stopped in Ohio the day prior. We took the vehicle to a local shop and they told us the coolant was nearly gone. The second time happened just [XXX] when I took my Pacifica in for an oil change. The shop stated my coolant was very low and they had to fill it up. They again found no visible external leak. I had noticed that it was low as well the day prior after getting home and knowing the shop is less than 2 miles away I knew I could get the van there safely. I did notice the temperature going up quickly even though it has been bitterly cold the last few days. I've been doing research and found many Pacifica and other online forums stating this issue had led to engine failures totaling repair costs in excess of $5,000 as of 2023 before continued inflation. This poses a huge safety risk for motorists if the engine fails while in transit as well as during extreme weather both cold and hot. Please hold the manufacturer accountable to fix this common defect for those of us who cannot afford a new vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11704873

Incident

Jun 11, 2021

We bought our brand-new Chrysler van in 2019. On [XXX] the oil filter housing needed to be replaced due to cheap manufacturing parts. It cost us $918.78. In October of 2025, we were experiencing some shaking in our van. Upon investigation, it was diagnosed with a blown head gasket. The repair was estimated at $3000 - $4000. The mileage on our van was a little over 93,000 miles. We were meticulous with the maintenance of our van. This, according to Chrysler Pacifica owner online forums, is not uncommon. There is a general outrage at the obvious manufacturing error. Is there any class action lawsuit ongoing? Is there any recourse available? Chrysler should pay out due to their shoddy work. [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11699753

Incident

Nov 1, 2025

The vehicle jerked, stopped and would not start again. After a while it started, people were honking to move. This happened about 3 years ago. The vehicle jerks often and afraid it will leave us on the street. About 2 years ago, the auxiliary battery ran down the main battery. The car would not start. Had to buy both batteries. The lights come on, engine, traction and auxiliary battery light. This happens often on a weekly basis.

NHTSA ID

11699301

Incident

Sep 21, 2023

The contact owns a 2019 Chrysler Pacifica. The contact stated that the message “Engine would Shutoff Soon” was displayed. The START/STOP, engine, Forward Collision Avoidance, and 4WD warning lights were illuminated. The contact stated that the power steering functionality had become inoperable. The vehicle had stalled on several occasions. The contact related the failure to NHTSA Campaign Number: 19V348000 (Electrical System). The contact called the local dealer, but the vehicle was not diagnosed or repaired. The vehicle was taken to an independent mechanic who scanned the vehicle and determined there was a code that “Voltage-too-High” was displayed. The manufacturer was not notified of the failure. The failure mileage was approximately 129,000.

NHTSA ID

11690589

Incident

Sep 30, 2025

Mileage

129,000 mi

While driving light came on that car was hot. Immediately pulled over and had the van towed. Was told the head gasket was blown which damaged the engine. Engine now needs to be replaced. Cheapest estimate has been $9,000 at a dealership, van isn’t even paid off yet. My 5 children were in the car when this happened I was afraid the vehicle was going to stop in the middle of the rd. No other warnings or anything. Also when we first purchased van was idle and then go silent like it’s supposed to we have noticed it doesn’t even get quiet anymore. Very disappointed family of 7 with no way to have our van repaired.

NHTSA ID

11676736

Incident

Jul 8, 2025

There was a battery safety recall (72B) letter sent to me for potential fire danger. On the letter, in bold, "a vehicle fire can result in increased risk of occupant injury and/or injury to persons outside the vehicle as well as property damage" 3/25 - 3/29 - 72B Recall work at Autonation Dealership completed Since the recall repair, my “service engine” light will intermittently turn on/off. 5/30 - Mile High Hybrid Diagnostic Code - U0412 “Invalid data received from battery energy control module” 6/12 - 6/18 - at AutoNation Dealership. U0412 - only software upgrade completed 7/1 - 7/8 at AutoNation Dealership - p0D57. They suggested it's a charger issues and to only use Mopar charger 7/24- O'Malley Diagnostic Code - U0412 - have ONLY been using Mopar charger. (NOT a charger issue) Waiting to hear back from Chrysler on path forward. I want answers to get this hybrid battery issue fixed. Days at the Shop: 3/25 - 3/29 - 4 5/30 - 1 6/12 - 6/18 - 6 7/1 - 7/8 - 7 Total - 18 days

NHTSA ID

11676038

Incident

May 30, 2025

While stopped at a red light my van alerted me that the start/Stop feature was not working, turned itself off and put the van in Park causing much confusion and my almost getting reended as I was unsure what to do.

NHTSA ID

11668697

Incident

Jun 21, 2025

Vehicle Incident Summary – 2019 Chrysler Pacifica [XXX] is the orginal owner Initial Incident – [XXX] At 50,779 miles, my 2022 Chrysler Pacifica lost all power while driving on Mound Road in Sterling Heights, MI. Officer Nathan Sears from the Sterling Heights Police Department assisted, and the vehicle had to be towed. The diagnosis at the time was complete battery failure—both batteries were replaced. Current Ongoing Issue – [XXX] At 86,000 miles, the vehicle once again became completely inoperable. It was towed to Jim Riehl’s Chrysler Dodge Jeep Ram in Warren, MI. I was initially told the issue was the starter, and I paid $1,200 for the repair. However, the vehicle still does not start. I have now been told the issue may be a blown head gasket or engine failure. The dealership is requesting an additional $2,000–$3,000 just to disassemble the vehicle to determine the exact cause. If it is indeed an engine failure, I’ve been informed that repairs could cost up to $12,000. Concerns: I paid for a starter replacement and the car remains undrivable. There was no resolution or refund offered despite a misdiagnosis. Now I am being asked to pay thousands more just to identify the problem. If this is engine failure, it occurred at only 86,000 miles. I have since found many other Pacifica owners reporting similar failures—battery, engine, and complete loss of power—raising concerns of a potential manufacturing defect. Why I’m Reporting This: This vehicle has experienced major, potentially dangerous failures twice—first a complete power loss while driving, and now possible engine failure without warning. If this had happened at higher speeds or on the highway, it could have been catastrophic. I am requesting this issue be investigated for possible safety defects and design flaws. VIN: [XXX] 3.6 liter VG engine Location: Sterling Heights/Warren, MI Dealership: Jim Riehl’s Chrysler Dodge Jeep Ram INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11667028

Incident

Apr 21, 2025

As I'm driving down the road my MIL comes on and tells me to pull over the engine will shut off. My vehicle has had the recall completed. This happened to me on the interstate with my family in the van. This is our only vehicle for the family and need it everyday. Now my dealership is telling me that it isn't a recall issue and I might have to pay for the repairs. This light started coming on about a week ago, and doesn't always come on. But it started to happen more frequently.

NHTSA ID

11650271

Incident

Mar 23, 2025

The contact owns a 2019 Chrysler Pacifica. The contact stated while driving at various speeds, the transmission skipped gears. Additionally, the vehicle was experiencing erratic transmission shifts and unintended deceleration. The check engine warning light was illuminated. Additionally, the contact stated that upon attempting to shift to drive(D), the gear shifter failed to respond and remained stuck in park(P). The contact researched the failure online and found information on how to override the gear shifter failure. The contact pressed the Push to Start button twice, without depressing the brake pedal, depressed the accelerator for ten seconds, and pressed the Push to Start button to turn off the vehicle. The contact stated that upon restarting the vehicle minutes later, the vehicle responded as needed and the gear shifter became operable. The contact stated that the failure had been recurring intermittently. The dealer was notified of the failure. The vehicle was not diagnosed or repaired. The contact related the failure to NHTSA Action Number: RQ24004 (Electrical System). The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 20,000.

NHTSA ID

11645498

Incident

Feb 28, 2019

Mileage

20,000 mi

The contact owns a 2019 Chrysler Pacifica. The contact stated that while driving at 55 MPH on the highway, the A/C vents started blowing cold air; causing the vehicle to become extremely cold. There was water coming from the wheels. There were no warning lights illuminated. The contact parked the vehicle and noticed that the radiator was cracked. The contact who is an independent mechanic, determined that the torque on the radiator caused the radiator to crack. The vehicle was towed to the local dealer, where it was diagnosed that a radiator replacement was needed. The vehicle was not repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 99,970. The VIN was not available.

NHTSA ID

11642727

Incident

Feb 12, 2025

Mileage

99,970 mi

The head gasket leaks, full engine replacement is recommended. No accidents, only 79k miles on the engine.

NHTSA ID

11640856

Incident

Feb 1, 2025

My vehicle suddenly lost power driving down the road at approximately 20MPH. I rolled to the side and the vehicle engaged the electronic parking brake. It's been at Chrysler dealership for over a week and is now a STARS case according to my service rep. .

NHTSA ID

11637930

Incident

Jan 13, 2025

I’m having trouble with my start stop. Sometimes it works and sometimes it doesn’t. Sometimes my motor goes into limp mode for no reason.

NHTSA ID

11637073

Incident

Jan 15, 2025

While driving down the road and slowing down the van put itself into park and shut off. Had to then restart the van.

NHTSA ID

11634781

Incident

Dec 21, 2024

The contact owns a 2019 Chrysler Pacifica. The contact stated that while driving at various speeds on several occasions, there was a clicking noise emanating from the engine compartment and the vehicle began shaking. The vehicle was taken to an independent mechanic, and the contact was informed that the control arm and bushings needed to be replaced. The vehicle was not repaired. The vehicle was then taken to a dealer who was unable to replicate the failure on one occasion; however, on another occasion, the vehicle was taken to the same dealer where it was diagnosed and determined that the alternator needed to be replaced. The failure persisted. The vehicle was taken to the same dealer where it was determined that the sway bar link needed to be replaced. The vehicle was repaired but the failure persisted. The manufacturer was not notified of the failure. The failure mileage was approximately 100,000.

NHTSA ID

11633604

Incident

Nov 22, 2024

Mileage

100,000 mi

The transmission shifts/jerks hard and hesitates/struggles to accelerate at times. It has even shutdown numerous times while I was at a traffic light.

NHTSA ID

11633562

Incident

Jun 16, 2024