2003 Chrysler Pt Cruiser Suspension Problems

MY EXTERIOR FRONT LIGHTS ARE VERY DULL AND AREN'T BRIGHT WHEN TURN THEM ON.

NHTSA ID

11183941

Incident

Jan 18, 2019

I HAD PURCHESED A USED 2003 PT CRUISER AND ON THE HWY HOME SHORT TIME LATER I HEARD CLUNKING SOUND THREE TIMES FIRST WHEN MERGING ONTO HWY FROM CAR DEALERSHIP. FUTHERMORE, ABOUT 10 MIN INTO MY HWY DRIVE HOME I BECAME FRIGHTEND WHEN MY CAR ENDED UP HAVING A MIND IF ITS OWN AND STARED GOING TO THE LEFT SO I TRIED TO TURN STEARING WHEEL TOWARDS RIGHT AND I WAS UNABLE TO CORRECT IT FOR FEW SECONDS AND ENDED ON THE OTHERIDE OF WHITE LINE JUST ABOUT OFF HWY AND INTO GRAVEL BUT AT THAT POINT I SEENED TO REGAIN CONTROL OF MY CAR STEARING AND PROCEEDING BACK BETEEEN YELLOW AND WHITE LINE ON THE HWY, FOLLOWING WAS ANOTHER INCIDENT WAS WHEN I CAME TO COMPLETE STOP FOLLOWING WITH LEFT TURN (STARTED TO MAKE A CLUNKING SOUND EVEN LOUDER).DURNING MY ROUTE I MADE A RIGHT TURN THE SOUND AGAIN. I ENDED UP TAKING IT TO A DEALERSHIP TO TAKE A LOOK AT . THE MECHANIC SAID HE KNEW AT ONE POINT THEY HAD A SAFTY RECALL ON THE SUSPENSION FOR PT CRUSIERS BECAUSE THEY COULD CAUSE INJURY WITH MOTOR VEHICLE ACCIDENTS DUE TO LOSS OF CONTROL AS A RESULT OF LOWER CONTOL ARM /SWAY BAR / AND BAD BALL JOINTS WHICH I PERSONALLY PROB EXPERICEND ON MY WAY HOME FOLLOWING MY PURCHESE OF THE CAR. THE MECHANIC I SPOKE TO CHECKED MY VIN NUMBER AND IT DID NOT HAVE A RECALL ON IT HOWEVER THERE WAS RECALLS FOR A SET AMOUNT AND THAT MINE WASNT ONE OF THEM BUT SHOUKD HAVE BEEN AND THAT I SHOULD INFORM " NHTSA "ABOUT MY SITUATION BECAUSE THERE COULD BE OTHERS EXPERIENCING SAME SITUATION DUE TO MALFUNCTIONING PARTS BECAUSE A MALFUCTION CAN HAPPEN TO EVEN AFTER MARKET PARTS CAN LEAD TO DEADLY ACCIDENTS EVEN DEATH BECAUSE OF LOSS OF CONTROL. I STRONGLY AGREE WITH MECHANIC THAT THE RECALL SHOULD BE UPDATED EVEN ON THE AFTER MARKET PARTS FOR THE SUSPENION SUCH AS CONTROL ARM AND CALLED FOR EVERY 2003 PT CRUSIER GT BECAUSE OF LOSS OF CONTROL THAT ALMOST CAUSED ME TO BE IN ACCIDENT EVEN COULD OF BEEN FATAL. THANK YOU

NHTSA ID

11079804

Incident

Mar 14, 2018

Mileage

155,000 mi

THE LOWER CONTROL BUSHINGS HAVE BEEN REPLACED 3 TIMES IN 46,197 MILES OVER 12 YEARS. THE LAST TIME CONTROL ARM AND BUSHING WERE REPLACED. FIRST TIME WAS 5-21-07 WITH 20,204 MILES ON THE CAR. SECOND TIME WAS 5-21-08, ONLY ONE YEAR LATER, 22,309 MILES ON THE VEHICLE, JUST OVER 2000 MILES FROM A YEAR AGO WHEN IT WAS DONE. THE DEALER COVERED IT BECAUSE IT WAS WARRANTY FROM A YEAR AGO. WONDER IF IT WAS EVER DONE THE FIRST OR SECOND TIME. WE JUST HAD THE CONTROL ARM AND BUSHINGS REPLACED 5-27-2015 AT 46,197 MILES. NOW THE DEALER ORIGINALLY TOLD MY WIFE THIS DOES NOT HAPPEN UNTIL THE VEHICLE HAS ABOUT 80,000. WOW LOOKS LIKE A MAJOR ISSUE FOR THEM.

NHTSA ID

10725509

Incident

May 21, 2007

I PURCHASED THE CAR AND RIGHT FROM THE START I'VE HAD TO REPLACE THE WHEEL BEARINGS , I HAVE HAD TO DO SO 3 TIMES ALREADY WITHIN THE SHORT AMOUNT OF TIME I HAVE HAD THE CAR , THERE HAS BEEN NO UNUSUAL STRESS ON THE BEARINGS TO MAKE THEM WEAR OUT , NOW IN MY EXPERIENCE I HAVE NEVER HAD TO REPLACE A WHEEL BEARING ON A CAR WITH ANYTHING LESS THAN 100K MI ON IT , LET ALONE 3 TIMES , I DON'T KNOW WHAT TO MAKE OF IT, ALSO IM HAVING STALLING/ROUGH IDLE PROBLEMS THAT NO ONE CAN SEEM TO FIGURE OUT IT HAS STALLED 5 TIMES ALREADY AND REGULARLY IDLES ROUGH, THESE PROBLEMS ARE NOT NORMAL AND CANNOT BE FIGURED OUR ,I'VE REPLACES SEVERAL PARTS INCLUDING THE ERG VALVE PVC VALVE SPARK PLUGS AND WIRES THE IAC CLEANED THE THROTTLE BODY AND THE CARB AND IM STILL HAVING THESE ISSUES. *TR

NHTSA ID

10676314

Incident

Apr 26, 2013

Mileage

47,897 mi

2003 P T CRUISER WITH 44000 MILES AM TOLD IT NEEDS FRONT BEARINGS ON THE FRONT. *TR

NHTSA ID

10346931

Incident

May 1, 2010

Mileage

41,500 mi

LOWER CONTROL ARM BUSHINGS ARE BAD AT 60,000 MILES AND THE CAR IS WANDERING ON THE ROAD. CHRYSLER NEEDS TO ADDRESS THIS KNOWN ISSUE BEFORE SOMEONE IS HURT OR KILLED. *TR

NHTSA ID

10329522

Incident

May 5, 2010

Mileage

60,000 mi

2003 CHRYSLER PT CRUISER. CONSUMER STATES DEFECT INVOLVING THE LOWER CONTROL ARM BUSHINGS IN THE FRONT SUSPENSION *TGW IN AUGUST 2007 THE BUSHINGS HAD DETERIORATED AFTER ONLY 30,620 MILES. THE DEALER REPLACED THEM AT A COST OF $414.84 WHICH THE CONSUMER HAD TO PAY SINCE THE VEHICLE WAS BEYOND THE 36 MONTH WARRANTY. IN JUNE 2009, THE DEALER INFORMED THE CONSUMER THEY NEEDED TO BE REPLACED EVEN THOUGH IT HAD ONLY BEEN 12,292 MILES SINCE THEY WERE INITIALLY REPLACED. THE CONSUMER WENT TO AN INDEPENDENT MECHANIC AND HAD THEM REPLACED AGAIN. *JB

NHTSA ID

10328504

Incident

Aug 1, 2007

Mileage

30,620 mi

THIS IS THE SECOND TIME, CONTROL ARMS HAVE TO BE REPLACED ON MY CAR. MAY 2007, MILEAGE 40,054, BOTH LOWER CONTROL ARM BUSHINGS WORN OUT/CONTROL ARM HOLE OBLONG: BOTH REPLACED. AGAIN TODAY, APRIL 2009, MILEAGE 55,000, CAR IS IN SHOP FOR SAME SERVICE. ALSO, APRIL 2008, MILEAGE 46,856 FRONT LEFT HUB BEARING FAILED, HAD TO BE REPLACED. *TR

NHTSA ID

10265725

Incident

Apr 17, 2009

Mileage

40,054 mi

TWO PT CRUISERS, 02-03, BOTH NEEDING TIE RODS, CONTROL ARMS, WATTS LINKAGE, WHEEL BEARINGS AT AROUND OR LESS THEN 50,000 MILES. BASICALLY THE ENTIRE SUSPENSION NEEDED TO BE REPLACED. THIS IS UNHEARD OF. *TR

NHTSA ID

10264781

Incident

Apr 3, 2009

Mileage

49,000 mi

WE BOUGHT OUR 2003 PT GT CRUISER IN JAN.2004 WITH 600 MILES ON IT. AT 36,000 MILES THE FRONT WHEEL BEARINGS HAD TO BE REPLACED ( AT OUR EXPENSE) FOR THE FIRST TIME. DEALER ( PRESTON OF WARREN, OHIO ) SAID IT WASN'T COVERED UNDER WARRANTY. THEY WERE REPLACED AGAIN AT 45,000 MILES, AND 6 MORE TIMES SINCE THEN. THEY ARE AGAIN NEEDING REPLACED FOR THE NINTH TIME.I ALSO REPLACED TIERODS AND BUSHINGS ONCE, AND HUBS TWICE. I HAVE READ HUNDREDS OF ONLINE POSTS FROM OTHER PT OWNERS WITH STRIKINGLY SIMILAR STORIES WHICH PROMPTED ME TO FILE THIS COMPLAINT. *TR

NHTSA ID

10262026

Incident

Apr 10, 2004

I HAVE A 2003 PT CRUISER, I HAVE 53,000 MILES ON THIS CAR, AND THE CONTROL ARMS NEED TO BE REPLACED. I HAVE GONE TO THE CHYRSLER FORUMS, AND THERE IS A LOT OF COMPLAINTS BY ALOT OF OWNERS OF CHRYSLER HAVING THE SAME EXACT PROBLEMS. SOME WITH LESS MILES THAN MINE. CHRYSLER NEEDS TO STEP UP TO THE PLATE AND RECALL THIS PART. THANKS, DARLENE SMITH *TR

NHTSA ID

10261489

Incident

Feb 26, 2009

Mileage

53,000 mi

LOWER FRONT CONTROL ARM BUSHINGS AND FRONT WHEEL BEARINGS WENT BAD AT 38,000 MILES. 2 WATER PUMPS WENT BAD ON THE CAR AND CAR ONLY HAS 38,000 MILES ON IT. CAMSHAFT SENSOR WENT BAD WITH ONLY 25,000 MILES ON IT. OIL PAN ON ENGINE STARTED LEAKING WHEN CAR HAD 17,000 MILES ON IT. *TR

NHTSA ID

10260879

Incident

Dec 4, 2008

Mileage

38,000 mi

I OWN TWO PT CRUISERS, BOTH HAVE HAD CONTROL ARM BUSHING FAILURES AT 45K MILES. THIS IS A KNOWN PROBLEM TO CHRYSLER, ALL OVER INTERNET, FAILURES AT EARLIER MILEAGE AS WELL. THEY DO NOTHING. $650/CAR TO REPLACE CONTROL ARM. *TR

NHTSA ID

10256065

Incident

Dec 17, 2008

Mileage

45,000 mi

I JUST FOUND A RECALL ON MY PT CRUISER ON THE WEB AND I HAVEN'T GOTTEN A NOTICE TO DATE. I TOOK MY CAR BACK TO THE DEALER MANY TIMES TO COMPLAIN ABOUT THE PROBLEM AND I THINK THEY KNEW ABOUT THE RECALLS. MY PROBLEMS WITH MY CAR ARE PROBLEMS RELATED TO THE RECALL ISSUES. *TR

NHTSA ID

10250778

Incident

Mar 26, 2006

Mileage

30,000 mi

TL*THE CONTACT OWNS A 2003 CHRYSLER PT CRUISER. THE CONTACT CONTINUED TO HEAR A CLUNKING NOISE AND STATED THAT THE VEHICLE WOULD "GET AWAY FROM HER" WHILE DRIVING VARIOUS SPEEDS ON THE HIGHWAY. THE DEALER REPAIRED THE TIRE, BUT AN INDEPENDENT MECHANIC STATED THAT CONTROL ARM BUSHINGS AND TIE ROD END REPAIRS WERE COMMON. THE DEALER OFFERED TO REPAIR THE VEHICLE AT THE COST OF MORE THAN $600. THEY ALSO STATED THAT A FRONT END ALIGNMENT WOULD BE NEEDED FOLLOWING THE REPAIRS. THE FAILURE MILEAGE WAS 60,000 AND CURRENT MILEAGE WAS 65,000. UPDATED 11/17/08 *CN UPDATED 11/24/08. *JB

NHTSA ID

10246495

Incident

Aug 10, 2008

Mileage

60,000 mi

TL*THE CONTACT OWNS A 2003 CHRYSLER PT CRUISER. WHILE DRIVING APPROXIMATELY 40 MPH, THE CONTACT FELT ROUGHNESS AND VIBRATING. THE VEHICLE WAS NOT OPERATING PROPERLY. THERE WERE NO PRIOR WARNINGS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND IT WAS DISCOVERED THAT THE FRONT END CONTROL ARM BUSHINGS FAILED. THE VEHICLE WAS REPAIRED FOR THE MALFUNCTION. THE FAILURE MILEAGE WAS 39,300 AND CURRENT MILEAGE WAS 39,330.

NHTSA ID

10240960

Incident

Jun 13, 2008

Mileage

38,300 mi

2003 PT CRUISER GT 2.4L 96K MILES STARTED TO NOTICE TIRE TREAD PROBLEMS AT 40K. THOUGHT IT WAS A BAD ALIGNMENT FROM NTB AND THEY DID ANOTHER ALIGNMENT FOR NOW CHARGE. 10K LATER AND I AM HAVING TIRES REPLACED AGAIN! ALSO HEAR ALIGNMENT PROBLEMS AND KNOCKING COMING FROM THE FRONT END. TOOK IT IN AND SERVICE TECH RECOMMENDED ALIGNMENT AND FRONT DRIVER SIDE BEARING BE REPLACED. HE ADD THE BUSHINGS ON THE DRIVER SIDE CONTROL ARM WAS GOING BAD BUT NOT NECESSARY FOR IMMEDIATE REPLACEMENT. I HAD THE FRONT BEARING REPLACED AND ALIGNMENT DONE. FRONT DRIVERS SIDE BEARING WENT BAD AGAIN BUT ON BOTH SIDES IN THE FRONT AT 88K. NOW I AM BEING TOLD FROM THE CHRYLSER DEALER THAT HUB AND BEARING IN THE FRONT ON BOTH SIDES NEED TO BE REPLACED. 600 BUCKS. JUST SPENT 500 ON NEW TIRES AND I STILL HEAR KNOCKING ON CONTROL ARM. LONG STORY SHORT....THE LOWER CONTROL ARMS WILL NEED TO BE REPLACE ON BOTH SIDES (FRONT), FOLLOWED BY HUB AND BEARING ON BOTH SIDES (FRONT), FOLLOWED BY AN ALIGNMENT OF THE VEHICLE. DOING RESEARCH ONLINE, THERE ARE HUNDREDS OF SPECIFIC COMPLAINTS DEALING WITH THE CONTROL ARM BUSHINGS AND/OR BEARINGS GOING BAD AT 15,000 MILES AND UP ON THE 03 GT PT CRUISER 2.4L. CHRYSLER DOES NOTHING FOR THE CONSUMER IN EVERY CASE HENCE THE COMPLAINTS TO FORUMS AND NHTSA.GOV. TO SAY THE LEAST, THIS SHOULD BE ADDRESSED DAIMLER CHRYSLER AND FIXED BY THEIR EXPENSE. *TR

NHTSA ID

10229461

Incident

Oct 1, 2006

Mileage

60,000 mi

PT CRUISER LOWER CONTROL ARM BUSHINGS NEED REPLACING AT 60K MILES. HAVE BEEN TOLD BY MECHANIC THAT THIS IS A COMMON PROBLEM WITH THIS MODEL AND COULD CAUSE LOSS OF CONTROL OF VEHICLE, ADDED WEAR TO BRAKES AND TIRES, SCRAPING OF FRONT END OF CAR ON PAVEMENT. *TR

NHTSA ID

10227143

Incident

May 7, 2008

Mileage

60,000 mi

I JUST FOUND OUT THAT I HAVE TO REPLACE BOTH THE RIGHT AND LEFT FRONT HUB BEARINGS ON MY 2003 PT CRUISER. THE DEALERSHIP IS CHARGING ME $600 TO DO THE JOB. I HAVE 69K MILES ON THE CAR AND CHRYSLER SAYS IT IS NORMAL WEAR AND TEAR AND IS NOT COVERED UNDER THE 7/70K WARRANTY....SO I SEARCHED THE INTERNET AND TO MY SURPRISE I FOUND OUT I AM NOT THE ONLY PT CRUISER OWNER WITH THIS PROBLEM....I SEARCHED FOR FRONT HUB BEARINGS FOR A PT CRUISER AND FOUND MANY COMPLAINTS ABOUT THE DEFECTIVE BEARINGS....THE BEARINGS ARE SUPPOSED TO BE A SEALED BEARING AND NEVER REQUIRE MAINTENANCE....THIS IS A SAFETY ISSUE AND NEEDS TO BE ADDRESSED BY CHRYSLER BY ISSUING A RECALL AND PAY TO FIXED THE PROBLEM...AND REPAY THE CUSTOMERS WHO HAD TO HAVE THE BEARINGS REPLACED.... THE DEALERSHIP EVEN STATED TO ME THAT IT WAS A SAFETY HAZARD AND THE BEARINGS NEEDED REPLACEMENT....WITH ONLY 69K MILES ON THE CAR AND OTHERS WITH FEWER MILES THIS SHOULD NOT HAPPEN ON A NEW CAR...MYSELF AND MY FAMILY WAS NOT INJURED BY AN ACCIDENT , BUT I WONDER HOW MANY PEOPLE HAVE BEEN INJURED FROM THIS DEFECT???....ANY HELP WOULD GREATLY BE APPRECIATED....THANK YOU MICHAEL G KELLY *TR

NHTSA ID

10218524

Incident

Feb 19, 2008

Mileage

69,000 mi

BOTH FRONT BEARINGS FAILING IN 2003 PT CRUISER...HAVE BEEN GETTING PROGRESSIVELY WORSE OVER THE PAST YEAR. *TR

NHTSA ID

10217461

Incident

Feb 8, 2008

I READ ON THE INTERNET THAT A GREAT DEAL OF OWNERS OF CHRYSLER PT CRUISERS HAVE HAD PROBLEMS SIMILAR TO MINE. MY 2003 HAS ONLY 50,000 KM. (NOT MILES) AND I HAVE TO REPLACE THE WHEEL BEARINGS. THIS SEEMS MUCH TOO SOON TO REPLACE SUCH AN ITEM. *TR

NHTSA ID

10216914

Incident

Jan 4, 2008

FRONT WHEEL BEARINGS FAILED AT 71,000 MILES. *TR

NHTSA ID

10215439

Incident

Jan 17, 2008

Mileage

71,375 mi

2003 CHRYSLER PT CRUISER WITH DEFECTED CONTROL ARM BUSHINGS. CONSUMER STATED THAT THE BUSHINGS ARE WEARING PREMATURELY. *KB THE CONSUMER STATED HE HAS HAD PROBLEMS WITH THE TRANSMISSION, STEERING COLUMN, FRONT BEARING AND WATER PUMP. *JB

NHTSA ID

10212754

Incident

Jan 1, 1901

Mileage

45,000 mi

I WENT TO HAVE MY BRAKES CHECKED AND WAS TOLD MY RIGHT AND LEFT LOWER CONTROL ARM BUSHINGS WERE BROKEN. I TOOK THE CAR TO THE DEALERSHIP (TOWED IN BECAUSE THE TRANSMISSION WENT OUT) AND THE BUSHINGS WERE REPLACED. THE MECHANIC SAID HE HAS VERY SELDOM SEEN BUSHINGS IN THE SUSPENSION BREAK WITH ONLY 60,000 MILES ON THE CAR. MY CAR IS A 2003 CHRYSLER PT CRUISER. I COMPLAINED NUMEROUS TIMES ABOUT THE TRANSMISSION BUT WAS NOT ACKNOWLEDGED UNTIL THE CAR WAS INOPERABLE. I AM QUITE HAPPY THAT THE MECHANIC WHO DOES MY BRAKES NOTICED THE CONTROL ARMS. I ASKED CHRYSLER TO CHECK THEM WHILE MY TRANSMISSION WAS BEING REPAIRED, IF NOT, THEY WOULD NEVER HAVE CHECKED. THE SUSPENSION IS OF COURSE, NOT COVERED BY THE WARRANTY ANY LONGER. REPAIR COSTS WERE NEARLY $600. *NM

NHTSA ID

10172488

Incident

Oct 24, 2006

Mileage

60,245 mi

PT CRUISER LOWER CONTROL ARM BUSHINGS SHOT WITH ONLY 32000 MILES. THIS IS A COMMON PROBLEM. A DEFECT IN THE BUSHING MATERIAL IS SUSPECT AND FAILURE CAN LEAD TO LOSS OF CONTROL. *NM

NHTSA ID

10170718

Incident

Oct 6, 2006

Mileage

20,000 mi