RoadVitals

2000 Damon Daybreak

Recalls, owner-reported complaints, investigations and safety data

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
5
Latest May 17, 2010
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
3
Latest Mar 20, 2007
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

Overview

Our database contains 5 NHTSA owner-reported complaints for the 2000 Damon Daybreak, most frequently naming the brakes category. 3 safety recalls have been issued covering this model year.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

What owners report

Complaints grouped by the component NHTSA recorded

  • Brakes5100.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Safety recalls

3 campaigns cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
07V130000

EQUIPMENT:RECREATIONAL VEHICLE/TRAILER

Mar 20, 2007
25,128 units potentially affected
The defect: CERTAIN TRAVEL TRAILERS AND MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.
The risk: RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.
The remedy: DAMON WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST YOU IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR DAMON AT 1-800-860-3812.
DAMON CORPORATIONView on NHTSA.gov
00V273008

SEAT BELTS:FRONT:BUCKLE ASSEMBLY

Mar 28, 2001
494 units potentially affected
The defect: VEHICLE DESCRIPTION: CERTAIN MOTOR HOMES BUILT ON DODGE VAN CHASSIS AND EQUIPPED WITH SAFETY BELT ASSEMBLIES PRODUCED BY AM-SAFE BETWEEN JANUARY 28 AND AUGUST 15, 2000. ON SOME SEAT BELTS, THE BUCKLE AND CONNECTOR MAY UNLATCH DURING A COLLISION.
The risk: SERIOUS INJURY OR DEATH COULD OCCUR IF THE VEHICLE OCCUPANT IS NOT PROPERLY RESTRAINED.
The remedy: AM-SAFE NOTIFIED DAMON'S CUSTOMERS TO RETURN THEIR VEHICLE TO AN AUTHORIZED DEALER TO HAVE THE SEAT BELTS REPAIRED FREE OF CHARGE.
DAMON CORPORATIONView on NHTSA.gov
01V091002

EQUIPMENT:RECREATIONAL VEHICLE/TRAILER

Mar 20, 2001
923 units potentially affected
The defect: VEHICLE DESCRIPTION: MOTOR HOMES AND TRAVEL TRAILERS EQUIPPED WITH NORCOLD REFRIGERATOR COOLING UNITS MODEL NUMBERS N841, N821, N641, AND N621. THESE REFRIGERATORS CAN EXPERIENCE A COOLING SYSTEM LEAK CAUSED BY OPERATION IN THE AC ELECTRIC MODE. IF A LEAK OCCURS, THE COOLING PERFORMANCE OF THE REFRIGERATOR WILL DETERIORATE, REQUIRING IMMEDIATE REPLACEMENT OF THE COOLING UNIT.
The risk: EXTENDED OPERATION OF A LEAKING COOLING UNIT IN THE AC ELECTRIC MODE CAN RESULT IN A FIRE.
The remedy: NORCOLD WILL INSPECT AND REPLACE THE REFRIGERATOR COOLING UNITS. NORCOLD WILL CONDUCT THE OWNER NOTIFICATION. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NORCOLD SERVICE CENTER AT 1-800-767-9101 OR DAMON AT 1-937-497-3080.
DAMON CORPORATIONView on NHTSA.gov

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

Brakes
Filed May 17, 2010

TL*THE CONTACT OWNS A 2000 DAMON DAYBREAK MOTOR HOME. THE CONTACT STATED THAT THE BRAKE CALIPER WAS OVERHEATING WHICH CAUSED THE BRAKE PADS TO BECOME SPONGY AND THE BRAKE FLUID TO OVERHEAT. THE VEHICLE HAD NOT BEEN INSPECTED OR REPAIRED AT THE TIME OF THE COMPLAINT. THE CONTACT STATED THAT THERE WAS A RECALL FOR THE NEXT YEAR MODEL RELATED TO THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 46,400. UPDATED 7/16/10 *CN UPDATED 07/22/10*JB

NHTSA ID
10330868
Incident
May 16, 2010
Mileage
46,400 mi
Brakes
Filed Nov 23, 2009

BRAKES OVERHEAT IN HEAVY TRAFFIC AND LOSE STOPPING POWER. THEY WEAR PREMATURELY. I REPLACED THEM AT 30000 MILES. 3000 MILES LATER PROBLEM HAS RETURNED. MOST RECENTLY OCCURRED LAST WEEK WHEN I TOTALLY LOST BRAKING ABILITY AFTER ABOUT AN HOUR OF RUSH HOUR TRAFFIC. *TR

NHTSA ID
10293324
Incident
Nov 19, 2009
Mileage
33,000 mi
Brakes
Filed Aug 18, 2009

TL*THE CONTACT OWNS A 2000 DAMON DAYBREAK MOTOR HOME WITH A WORKHORSE P32 BRAKING SYSTEM. WHILE DRIVING 45 MPH HE APPROACHED A RED LIGHT AND ATTEMPTED TO ENGAGE THE BRAKE PEDAL WHICH EXTENDED TO THE FLOOR AND FAILED TO STOP THE VEHICLE. IF THE TRAFFIC LIGHT DID NOT CHANGE TO GREEN IT COULD HAVE CAUSED A CRASH. THE VEHICLE BEGAN TO LOSE SPEED EVEN AFTER HE ATTEMPTED TO ENGAGE THE BRAKE PEDAL. AFTER APPLYING EXTREME FORCE TO THE BRAKE PEDAL, THE CONTACT WAS ABLE TO STOP THE VEHICLE AND DRIVE TO A LOCAL REPAIR FACILITY. THE MECHANIC STATED THAT THE RIGHT FRONT AND RIGHT REAR CALIPER WERE FROZEN WHICH CAUSED THE BREAKS TO OVER HEAT, THE BRAKE FLUIDS TO BOIL AND CAUSED HIM TO LOSE THE ABILITY TO STOP THE VEHICLE. THE TWO RIGHT FRONT AND REAR BRAKE CALIPERS, ROTORS AND HOSES WERE REPLACED. THE CONTACT WAS ADVISED THAT THE FAILURE IS COMMON ON WORK HORSE TRAILERS. NHTSA CAMPAIGN ID NUMBER: 09V110000 EA07016 NHTSA ACTION NUMBER: EA07016 COMPONENT: SERVICE BRAKES, HYDRAULIC) IS RELATED TO THE FAILURE. THE CURRENT AND FAILURE MILEAGES WERE 21,900. UPDATED 09/18/09. *LJ UPDATED 09/21/09. *JB

NHTSA ID
10280808
Incident
Aug 9, 2009
Mileage
21,900 mi
Brakes
Filed Feb 12, 2008

TL*THE CONTACT OWNS A 2000 DAMON DAYBREAK. WHILE DRIVING APPROXIMATELY 35 MPH IN DRY WEATHER, THE BRAKES FAILED. THE FAILURE OCCURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THEY COULD NOT DETERMINE THE CAUSE OF THE FAILURE. THE CURRENT AND FAILURE MILEAGES WERE LESS 17,000. UPDATED 03-04-08 *BF

NHTSA ID
10217835
Incident
Feb 2, 2008
Mileage
17,000 mi
Brakes
Filed May 9, 2006

DT*: THE CONTACT STATED WHILE DRIVING 25MPH ON LEVEL ROADS THE BRAKES WERE APPLIED SEVERAL TIMES BEFORE THE VEHICLE STOPPED. THE PARKING BRAKE LIGHT ILLUMINATED AFTER THE FAILURE. THE BRAKES RESUMED NORMAL OPERATION ONCE THE VEHICLE WAS PARKED FOR AN HOUR. THE BRAKES FAILED PREVIOUSLY IN OCTOBER 2005. THE MANUFACTURER AND DEALER WERE NOT ALERTED FOLLOWING EITHER INCIDENT. UPDATED 05/23/06. *JB

NHTSA ID
10157075
Incident
Oct 1, 2005
Mileage
20,000 mi

Compare model years

Complaint and recall counts across every year of this model

Damon Daybreak by model year
YearComplaintsRecallsInvestigationsIssue Index
2011030—
2010130—
2009040—
2008140—
2007440—
2006140—
2005130—
2004540—
2003230—
2002620—
2001320—
2000Viewing530—
1999331—
1998131—
1997220—

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.