1994 Dodge Grand Caravan Owner Complaints

INSTRUMENT CLUSTER DON'T WORK

NHTSA ID

10882847

Incident

Feb 15, 2015

Mileage

108,416 mi

WHEN I WAS TRYING TO TURN THE WHEEL TO GET OUT OF THE DRIVEWAY, MY STEERING WHEEL CAME OFF. I WAS ABOUT TO BACK UP AND IF I DID I WOULD HAVE LOST CONTROL AND CRASHED.

NHTSA ID

10824438

Incident

Feb 4, 2016

TL* THE CONTACT OWNS A 1994 DODGE GRAND CARAVAN. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 00V305000 (STEERING), 99V213000 (STRUCTURE), 99V113000 (AIR BAGS), AND 95I00100 (LATCHES/LOCKS/LINKAGES); HOWEVER, THE PARTS TO DO THE REPAIRS WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

NHTSA ID

10716533

Incident

Apr 17, 2012

TL* THE CONTACT OWNS A 1994 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE SERPENTINE BELT WOULD DETACH FROM THE VEHICLE WHEN IT WOULD RAIN OR WHEN THE VEHICLE WAS DRIVEN THROUGH A PUDDLE OF WATER. THE FAILURE WOULD CAUSE THE VEHICLE TO LOOSE POWER AND OVERHEAT. THE VEHICLE WAS REPAIRED SEVERAL TIMES AND THE PULLEYS WERE REPLACED, BUT THE FAILURE CONTINUED TO RECUR. THE DEALER AND SEVERAL MECHANICS WERE UNABLE TO DETERMINE WHAT CAUSED THE CONSISTENT FAILURE. THE FAILURE MILEAGE WAS 230,426 AND THE CURRENT MILEAGE WAS 241,625.

NHTSA ID

10434997

Incident

Aug 11, 2010

Mileage

203,426 mi

AIR BAGS DEPLOYED ON 1994 DODGE GRAND CARAVAN WITH BRAUN HANDICAPPED MODIFICATIONS WHILE IDLING IN THE DRIVEWAY DURING LOADING OF HANDICAPPED WOMAN. ATTENDANT WAS INJURED DUE TO PROXIMITY OF HEAD TO PASSENGER SIDE AIRBAG. *TR

NHTSA ID

10345168

Incident

Jul 18, 2010

Mileage

70,000 mi

TL* - THE CONTACT OWNS A 1994 DODGE CHRYSLER GRAND CARAVAN. WHILE DRIVING AROUND A MOUNTAIN THE STEERING LOCKED AND LOST POWER STEERING. THE CONTACT LET THE VEHICLE SIT FOR APPROXIMATELY 1/2 HOUR AND THE VEHICLE WAS DRIVABLE. THERE WERE NO WARNING INDICATORS. THE FAILURE MILEAGE WAS 66,000. THE DEALER DIDN'T TRY TO DUPLICATE THE FAILURE. THE CURRENT MILEAGE WAS 165,000.*AK THE CONSUMER STATED THAT HE REPLACED THE BELT IN 1996, BUT THE MECHANIC STATED THE BELT LOOKED FINE. UPDATE 05/10/07*TR

NHTSA ID

10187496

Incident

Jan 1, 1996

Mileage

66,000 mi

TL* -THE CONTACT STATED THAT THE 1994 DODGE GRAND CARAVAN WITH 150000 FAILURE MILEAGE WAS LEAKING GAS ON THE MANIFOLD. THE CONTACT A MECHANIC DISCOVERED THAT THERE WAS A FUEL LEAK. THERE WAS A RECALL # 00268000 ON THE 1996-2000 DODGE GRAND CARAVANS. THE VEHICLE WAS NOT DRIVABLE , AND THE VEHICLE HAD NOT BEEN REPAIRED. THE CURRENT MILEAGE WAS 150,000. *AK THE FUEL RAIL WAS LEAKING FUEL AT THE END OF THE RAIL WHERE A PIPE JOINED THE 2 RAILS TOGETHER, FUEL LEAKED ON THE MANIFOLD AND A SMALL FIRE WAS IGNITED. UPDATED 04/30/07. *JB

NHTSA ID

10184520

Incident

Feb 4, 2007

Mileage

150,000 mi

VEHICLE STALLS WHILE DRIVING, USUALLY WHEN WEATHER IS VERY WARM. NO INDICATION OF OVERHEATING. LET SET FOR 10-15 MINUTES AND VEHICLE STARTS AND RUNS FINE UNTIL NEXT TIME. HAS HAPPENED 6 TIMES IN THE LAST 3 YEARS, USUALLY ON THE INTERSTATE CAUSING A POTENTIALLY VERY DANGEROUS SITUATION. HAVE NOT HAD TO A DEALER TO CHECK OUT BUT HAVE SEEN OTHER COMPLAINTS ON THIS SITE BY PEOPLE WHO HAVE THIS SAME PROBLEM WHO HAVE TAKEN TO DEALER AND DEALER WAS NOT ABLE TO LOCATE THE SOURCE OF THE STALLING.

NHTSA ID

10128714

Incident

Jun 27, 2005

Mileage

125,000 mi

1994 DODGE GRAND CARAVAN, DRIVERS SIDE SEAT BACK BROKEN AT THE FIRST WELD ON THE VERTICAL PORTION OF THE SEAT BACK. CAR WAS BEING DRIVEN NORMALLY, NO ACCIDENT OR INCIDENT OCCURRED. THERE WAS NO WARNING, THE SEAT JUST WENT TO A RECLINED POSITION WHILE DRIVING. FURTHER INVESTIGATION REVEALED THAT IN ADDITION TO THE VERTICAL FRAME WELD FAILURE, A CASTING FAILURE OCCURRED ON THE HORIZONTAL PORTION OF THE SEAT FRAME IN THE VICINITY OF RECLINE LEVER. THE FRAME CASTING WAS COMPLETING SEVERED AND WOULD NOT HAVE RETAINED THE SEAT IN THE EVENT OF A SUDDEN DECELERATION. THE SEAT WAS UNSAFE BUT DID NOT REVEAL ITSELF UNTIL THE BACK FRAME WELD FAILURE. MY STATE OF RESIDENCE IS WISCONSIN, YOUR PROGRAM DID NOT ALLOW ME TO ENTER THIS STATE SO I CHOOSE ONE AT RANDOM. *NM

NHTSA ID

10107894

Incident

Jan 24, 2005

Mileage

190,890 mi

CONSUMER STATED THE SLIDING DOOR FELL OFF TRACK . THE PART HAD BEEN REPAIRED THREE TIMES, HOWEVER THE PROBLEM RECURRED. *AK THE CONSUMER STATED THAT THE PARTS SEEM TO WEAR TO EASY AND RUST WHEN THEY SHOULD NOT. *TC

NHTSA ID

10092039

Incident

Sep 10, 2004

Mileage

140,716 mi

(1) NO WARNING OF FAILURE.(2) SERPENTINE BELT TENSIONER BOLT FAILED CAUSING LOSS OF POWER STEERING DURING A TURN. NO CONSEQUENCES RESULTED FROM THIS PARTICULAR FAILURE BECAUSE THE FAILURE OCCURRED IN A PARKING LOT AT 5MPH. UNDER DIFFERENT CIRCUMSTANCES (DOWNHILL ON TIGHT CURVE) THE FAILURE WOULD HAVE BEEN EXTREMELY DANGEROUS AND PROBABLY RESULT IN TOTAL LOSS OF CONTROL.(3) ANTICIPATE REPLACING THE TENSIONER AND RETURNING VEHICLE TO SERVICE.*AK

NHTSA ID

10103069

Incident

Dec 15, 2004

AIR BAG. I OWN A 1994 GRAND CARAVAN. I HAVE NO OTHER COMPLAINTS ABOUT THIS VEHICLE. HOWEVER, THE AIR BAG HAS HAD A PROBLEM SINCE ALMOST DAY ONE. THE AIRBAG PANEL LIGHT IS ALWAYS ILLUMINATED. I RECEIVED A RECALL NOTICE SEVERAL YEARS AGO ABOUT THIS PROBLEM AND HAD THE VAN TO THE DEALERSHIP FOR RECALL SERVICE TO RECTIFY THE OBVIOUSLY WIDESPREAD PROBLEM. I BELIEVE IT WAS TIED TO A PROBLEM W/ THE REAR WINDOW WIPER CIRCUIT. THIS IS A PROBLEM THAT WAS FIXED FOR ALL BUT A COUPLE OF MONTHS AND TO THIS DAY I DON'T HAVE A WORKING AIR BAG OR REAR WINDOW WIPER. I CAN LIVE W/O THE WIPER, I'D LIKE TO HAVE WORKING SAFETY EQUIPMENT. *NM

NHTSA ID

10095590

Incident

Aug 9, 2000

Mileage

80,000 mi

TRANSMISSON FAILURE. *LA

NHTSA ID

10041738

Incident

Oct 13, 2003

WHEN THE CONSUMER CLOSED THE REAR HATCH THE HINGE ON THE UPPER RIGHT CAME OFF. UPON FURTHER INVESTIGATION IT WAS DISCOVERED THAT THE BOLT HAD BROKEN IN HALF AND ONE HALF OF THE BOLT WAS STILL ATTACHED TO THE DOOR WHILE OTHER HALF FELL TO THE GROUND. THE PRESSURIZED MECHANISM WAS LOCKED IN THE OPEN POSITION AND IN ORDER TO CLOSE THE DOOR THE CONSUMER HAD NO CHOICE BUT TO PUNCTURE THE ROOF. *NLM *CB *NLM

NHTSA ID

10020004

Incident

May 16, 2003

Mileage

120,000 mi

ENGINE HESITATES AS IF STARVING FOR FUEL AND STALLS WHILE TRAVELING,CHECK ENGINE LIGHT STAYS ON UNTIL YOU TURN OFF ENGINE AND RETSTART. TAKEN TO DEALER AND NO TROUBLE CODES FOUND. FUEL PUMP, FUEL FILTER, FUEL INJECTOR O-RINGS, REPLACED. HAS HAPPENED OVER LAST SIX YEARS, SOME 20 TIMES AND DEALER HAS NO CLUE. 125,000 MILES ON ENGINE.*AK

NHTSA ID

10028608

Incident

Jul 10, 2003

Mileage

80,000 mi

PURCHASED ON 5/2001 A USED 1994 DODGE GRAND CARAVAN WITH 93,000 MILES FROM CARMICHAEL AUTO EXCHANGE "AS IS". AFTER 1,000 MILES, TRANSMISSION FAILED. REPLACED @ $1875.60 WITH NEW MOPAR REBUILT AT 94,282. TOOK VEHICLE IN FOR TRANS SERVICE ON 3/8/2002 AT 109,252 TO DEALER. INSTALLED TRANSMISSION COOLER ON 4/2002. NOW REBUILT TRANSMISSION FAILED ON 7/7/2003 AT 150,325. THIS ADDED EXPENSE WILL COST $2600.00 AT MY EXPENSE. *AK

NHTSA ID

10026060

Incident

Jul 7, 2003

Mileage

150,310 mi

CONSUMER STATED THAT WHEN TURNING THE VEHICLE ON THE PASSENGER SIDE AIR BAG DEPLOYED. DEALER NOTIFIED . *AK

NHTSA ID

10026794

Incident

Jun 10, 2003

WHILE DRIVING 60 MPH THE AUTOMATIC TRANSMISSION FAILED AND FORCED THE CONSUMER TO PULL OFF THE ROAD. *NLM. *AK

NHTSA ID

10021629

Incident

May 27, 2003

GAS GAUGE SHOWS ERRATIC FUEL LEVEL - CAN END UP EMPTY BECAUSE OF FALSE READING SIMILAR TO NHTSA RECALL NO. 97V194 CHRYSLER CAMPAIGN NO. 755. *NLM

NHTSA ID

10018571

Incident

May 1, 2003

TRANSAXLE ON 1994 DODGE GRAND CARAVAN LE FAILED CAUSING DAMAGE TO AXLES. THE AXLES HAD TO BE REPLACED, ONE AXLE HAD TO BE REPLACED TWICE. THEY ARE NOW FAILING AGAIN. THE FRONT END WOBBLES AND SHAKES, ESPECIALLY WHEN ACCELERATING AND THE TRANSMISSION SHIFTS VERY HARSHLY, WITH A SLAM. THE TRANSMISSION HAS AN INTERNAL LEAK SO THAT WE HAVE TO CHECK THE FLUID CONSTANTLY, BUT NO FLUID IS DRAINING ONTO THE STREET. IT WILL COST US $2,500 TO REPAIR. WHEN WE BOUGHT THE CAR 2 YEARS AGO IT HAD JUST HAD THE TRANSAXLE REPLACED.

NHTSA ID

10003376

Incident

Dec 20, 2002

Mileage

110,000 mi

WHEN WE BOUGHT THE VAN IN APRIL OF 2001 THE TRANSAXLE WOULD NOT SHIFT INTO REVERSE WHEN COLD. THE VEHICLE HAS APPARENTLY BEEN WARMED UP BEFORE WE TEST DROVE IT. THE TRANSMISSION FILTER AND FLUID WERE REPLACED AND THE TRANSMISSION WAS FINE UNTIL THE NEXT COLD SEASON . THE FLUID AND FILTER WERE REPLACED AND THE TRANSMISSION WAS FINE UNTIL THE NEXT COLD SEASON. THE FLUID AND FILTER WERE REPLACED AGAIN BUT IT DID NOT HELP. THE TRANSMISSION STARTED OUT AT THE BEGINNING OF THIS YEAR'S COLD SEASON JUST NOT GOING INTO REVERSE WHILE COLD, THEN IT QUICKLY PROGRESSED TO NO FIRST GEAR OR REVERSE WHILE COLD. DURING THE TIME WHEN IT HAD NO FIRST OR REVERSE THE TRANSMISSION WOULD GO INTO LIMP MODE. (CHRYSLER A-604 ULTRADRIVE) DURING THIS TIME THE TRANSMISSION ONLY FUNCTIONS IN SECOND GEAR (WHILE THE GEAR SELECTOR IS IN OVERDRIVE). THE TRANSMISSION REPAIR SHOP ACTED VERY SURPRISED THAT OUR TRANSMISSION LASTED 135K MILES! UNFORTUNATELY OUR WARRANTY COMPANY IS NOT AWARE OF THE PROBLEMS WITH THIS TRANSMISSION OR JUST DOESN'T WANT TO LOSE MONEY BECAUSE OF IT, BUT THEY ONLY PAID FOR THE INSTALLATION OF A USED TRANSMISSION WITH 80K MILES. I USE THE ULTIMATE WARRANTY COMPANY (1-800-576-5113). *JB ***DIMSII IVOQ ENTRY AFTER 12/12/02 CUT-OVER TO ARTEMIS*****770786

NHTSA ID

10006629

Incident

Dec 10, 2002

Mileage

135,000 mi

I CAN'T KEEP IT RUNNING IN COLD WEATHER, NO MATTER WHAT THE SPEED OF DRIVING.**** DIMS 11 IVOQ ENTRY POSTED AFTER 12/12/02 CUT-OVER TO ARTEMIS****769757. *AK *JB

NHTSA ID

10008570

Incident

Nov 1, 2001

Mileage

100,000 mi

NHTSA RECALL 99V213000 LIFTGATE SUPPORT BRACKET; SHE HAD THIS RECALL REPAIRED TWO YEARS AGO. THE OWNER STATES THAT SHE HEARD SOMETHING, MOVED OUT THE WAY AND THE LIFTGATE SLAMMED SHUT ON ITS' OWN. PLEASE DESCRIBE DETAILS. NLM

NHTSA ID

8019401

Incident

Sep 20, 2002

VAN HAS PROBLEM WITH ILLUMINATION OF HEAD LIGHTS, DEALERSHIP HAS TRIED SEVERAL ATTEMPTS TO RECTIFY ILLUMINATION FAILURE. MANUFACTURER HAS NO MORE SUGGESTIONS ON HOW TO CORRECT PROBLEM. DEALERSHIP IS DECLINING PUTTING ON FOG LIGHTS, AND IS QUESTIONING NEXT STEP.*AK. CONSUMER'S SON ADJUSTED THE HEADLIGHTS AND CONSUMER CAN NOW SEE THE ROAD, CONSUMER ASSUMED IT WAS THE HEADLIGHTS THEMSELVES, BUT IT SEEMS THEY WERE JUSE MISALIGNED.*JB

NHTSA ID

8017017

ENGINE SPORADICALLY DIES WHEN SLOWING DOWN FOR STOP OR TURNS. CAN'T FIND A PATTERN - HAPPENS IN ALL SEASONS, TEMPERATURES AND ROAD CONDITIONS.*AK

NHTSA ID

764336

Incident

Jan 15, 1999