1999 Dodge Intrepid

THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.

BASED ON THE LOW FAILURE RATE, THE ABSENCE OF FAILURES OVER THE PAST YEAR, THE ABSENCE OF INJURIES, AND ODI'S FIELD INVESTIGATION OF INCIDENT VEHICLES, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.

THE AIR CONDITIONING AND HEAT WENT OUT IN CAR. WINDOWS POWER KEEP GETTING STUCK.

NHTSA ID

11104994

Incident

Jul 1, 2017

Mileage

142,000 mi

TL* THE CONTACT OWNS A 1999 DODGE INTREPID. WHILE DRIVING APPROXIMATELY 75 MPH, THE AIR BAGS DEPLOYED WITHOUT WARNING OR IMPACT. THERE WERE NO INJURIES SUSTAINED. THE CHECK ENGINE INDICATOR ILLUMINATED BEFORE THE FAILURE. THE VEHICLE WAS NOT TOWED, REPAIRED, OR TAKEN TO A DEALER TO BE DIAGNOSED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 172,000.

NHTSA ID

11074157

Incident

Feb 21, 2018

Mileage

172,000 mi

I BOUGHT THIS 1999 DODGE INTREPID FROM CLIFFS USED CARS SALES TWO MONTHS AGO. EVERYTHING SEEMED GOOD ONE MONTH OR LESS LATER DRIVER SEAT BREAKS GOES BACKWARDS. THE EXTERIOR HEADLIGHTS CAN'T SEE AT NIGHT. TRIED EVERY TYPE IF BULB ITS THE HOUSING UNITS. NOW FRONT EBR CLYNKS OVER EVERY BUMP AND MAJESA THUNP WHEN HARD TURBUBG LFT OR RT. STEERING IS OUT IF LINE. HAVE NO MEANS OF GETTING IT REPAIRED STILL PAYING IN IT. 166000 NILES AND OWE $1500.00. CAN ANYONE HELP ME? THIS SHOULD FALL UNDER THE RECALLS

NHTSA ID

10979716

Incident

Feb 20, 2017

Mileage

166,000 mi

TL* THE CONTACT OWNS A 1999 DODGE INTREPID. WHEN THE IGNITION WAS TURNED OFF AND THE KEY WAS REMOVED, THE GEAR SHIFTER MOVED OUT OF THE PARK POSITION ON ITS OWN. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V021000 (POWER TRAIN). THE MANUFACTURER WAS NOTIFIED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 160,000.

NHTSA ID

10923792

Incident

Sep 28, 2016

Mileage

160,000 mi

TL* THE CONTACT OWNS A 1999 DODGE INTREPID. THE CONTACT HEARD AN ABNORMAL NOISE AND THE VEHICLE STALLED. THE VEHICLE WAS UNABLE TO BE RESTARTED AND WAS PUSHED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT NOTFIED OF THE FAILURE. THE VIN WAS INVALID. THE FAILURE MILEAGE WAS APPROXIMATELY 120,785.

NHTSA ID

10838909

Incident

Feb 28, 2016

Mileage

120,785 mi

TL* THE CONTACT OWNS A 1999 DODGE INTREPID. AFTER PERFORMING MAINTENANCE ON THE VEHICLE, THE CONTACT STARTED THE VEHICLE AND THE INTAKE MANIFOLD EXPLODED. THE CONTACT SUSTAINED A STOMACH INJURY THAT DID NOT REQUIRE MEDICAL ATTENTION. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

NHTSA ID

10671900

Incident

Dec 31, 2014

TL* THE CONTACT OWNS A 1999 DODGE INTREPID. THE CONTACT STATED THAT WHILE GETTING BAGS OUT OF THE TRUNK, THE TRUNK LIFT SUPPORT FAILED AND IMPACTED THE CONTACT'S HEAD. THE CONTACT SUSTAINED A BUMP ON THE HEAD BUT DID NOT SEEK MEDICAL ATTENTION. THE VEHICLE WAS NOT TAKEN TO THE DEALER OR REPAIRED. THE MANUFACTURER WAS NOTIFIED ABOUT THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 95,000.

NHTSA ID

10659812

Incident

Nov 18, 2014

Mileage

95,000 mi

SEVERELY CORRODED BRAKE LINES, LINES BLEW. NEAR MISS ACCIDENT. THIS IS A COMMON COMPLAINT ACROSS MFRS. HAD THE SAME INCIDENT 1 MONTH AGO ON 1997 GM PRODUCT. WELL MAINTAINED CARS WITH SEVERELY CORRODED FUEL AND BRAKE LINES. I BET IT CAN BE TRACED TO A CHEAP SUPPLIER THAT SUPPLIED THE BIG 3 FOR A PERIOD OF YEARS. NO CORROSION RESISTANCE ON THE STEEL. CAN'T BLAME THIS ON NE WINTER SALT. MY OEM 1964 LOOKS BETTER THAN MY LATE MODEL VEHICLES. *TR

NHTSA ID

10629432

Incident

Aug 27, 2014

Mileage

66,903 mi

KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehicle, use the "AC" NIC level part and submit a part warranty.

KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehicle, use the "AC" NIC level part and submit a part warranty.

Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are necessary.

Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.

Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.

Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.