1998 Dodge Intrepid

THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.

BASED ON THE LOW FAILURE RATE, THE ABSENCE OF FAILURES OVER THE PAST YEAR, THE ABSENCE OF INJURIES, AND ODI'S FIELD INVESTIGATION OF INCIDENT VEHICLES, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.

TL* THE CONTACT OWNS A 1998 DODGE INTREPID. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 10 MPH, THE BRAKES FAILED TO RESPOND AND THE PEDAL DID NOT ENGAGE IN ORDER TO STOP THE VEHICLE. THE CONTACT WAS FORCED TO USE THE EMERGENCY BRAKE IN ORDER TO STOP THE VEHICLE. THE CONTACT MERGED ONTO THE SHOULDER. WHEN THE CONTACT TURNED THE VEHICLE OFF AND BACK ON, THE FAILURE PERSISTED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 156,000.

NHTSA ID

10492876

Incident

Jan 12, 2013

Mileage

156,000 mi

TL* THE CONTACT OWNS A 1998 DODGE INTREPID. THE CONTACT STATED THAT THE BRAKE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE THEY ADVISED HIM THAT THE ABS SENSOR FAILED AND NEEDED TO BE REPLACED. THE DEALER ALSO ADVISED THAT THERE WERE NO PARTS AVAILABLE FOR THE REPAIR AND THEY HAD BEEN BACK ORDERED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 94,000.

NHTSA ID

10453793

Incident

Mar 19, 2012

Mileage

94,000 mi

ENGINE FAILURE CLICKING NOISE POSSIBLE VALVE TRAIN. CONSUMING LARGE AMOUNTS OF OIL BUT NO PROPERLY LUBRICATING ENGINE PARTS. *TR

NHTSA ID

10423863

Incident

Sep 3, 2011

TL*THE CONTACT OWNS A 1998 DODGE INTREPID. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH WHEN THE ENGINE BEGAN TO SMOKE. THE VEHICLE WAS INSPECTED BY A INDEPENDENT MECHANIC WHO INFORMED HER THAT THE MOTOR FAILED DUE TO THE ANTI-FREEZE AND OIL MIXING TOGETHER. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS UNAVAILABLE.

NHTSA ID

10366680

Incident

Nov 14, 2010

TL* THE CONTACT OWNS A 1998 DODGE INTREPID. THE CONTACT STATED GASOLINE FUEL WAS LEAKING FROM THE FUEL LINE THAT CONNECTED TO THE FUEL RAIL. THERE WAS ALSO AN OVERPOWERING ODOR OF GASOLINE FROM THE INTERIOR OF THE VEHICLE. THE CONTACT WAS ADVISED BY BOTH THE DEALER AND MANUFACTURER THAT THE VEHICLE WAS NOT UNDER RECALL. THE VEHICLE WAS NEITHER REPAIRED NOR DIAGNOSED FOR THE FAILURE. THE FAILURE MILEAGE WAS 76,945 AND THE CURRENT MILEAGE WAS 76,985.

NHTSA ID

10347043

Incident

Aug 1, 2010

Mileage

76,945 mi

IN 2007 I BOUGHT A 1998 DODGE INTREPID 2.7 L ENGINE....NONETHELESS THE ENGINE BLEW. THE CAR HAD REGULAR OIL CHANGES AND MAINTENANCE. IT GAVE NO WARNING THAT THERE WERE ANY SIGNS OF ENGINE TROUBLE. I PAID $6995 FOR THE CAR, IT HAD 67,000 MILES ON IT.....2YRS LATER AT 87,000 IT DIED....LEAVING ME TO PAY THE REST OF THE LOAN OF $2200 ON A CAR THAT JUST SITS IN THE DRIVEWAY!!! *TR

NHTSA ID

10278329

Incident

Apr 2, 2009

Mileage

87,000 mi

POWER STEERING FEELS LIKE THERE IS NO POWER STEERING ,NO POWER STEERING LEAKS BELTS OK AND NO NOISE UNDER HOOD. *TR

NHTSA ID

10255485

Incident

Jan 18, 2009

Mileage

280,000 mi

SEVERE STEERING PROBLEMS. WHEEL LOCKS WHEN TURNED COMPLETELY TO RIGHT OR LEFT. WANDERS ON DRY PAVEMENT, ALMOST IMPOSSIBLE TO DRIVE IN WET WEATHER. HAVE BEEN TOLD TO REPLACE STEERING RACK AND INNER TIE RODS. *TR

NHTSA ID

10251146

Incident

Dec 8, 2008

Mileage

122,544 mi

KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehicle, use the "AC" NIC level part and submit a part warranty.

KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehicle, use the "AC" NIC level part and submit a part warranty.

Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are necessary.

Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.

Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.

Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.