RoadVitals

1998 Chevrolet Silverado 1500

Recalls, owner-reported complaints, investigations and safety data

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
361
Latest Jan 3, 2021
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
2
Latest Oct 24, 2007
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
26
6 injuries, 0 deaths reported

Overview

Our database contains 361 NHTSA owner-reported complaints for the 1998 Chevrolet Silverado 1500, most frequently naming the brakes, visibility and steering categories. 2 safety recalls have been issued covering this model year; and 18 manufacturer communications are on file.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

What owners report

Complaints grouped by the component NHTSA recorded

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Safety recalls

2 campaigns cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
07E088000

EQUIPMENT

Oct 24, 2007
121,680 units potentially affected
The defect: CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
The risk: THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
The remedy: HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
HONEYWELL INTERNATIONAL, INC.View on NHTSA.gov
06E043000

FUEL SYSTEM, GASOLINE

May 19, 2006
88,303 units potentially affected
The defect: CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
The risk: THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
The remedy: HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
HONEYWELL INTERNATIONAL, INC.View on NHTSA.gov

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

View all 361
Interior & seats
Filed Jan 3, 2021

WHILE ADJUSTING MY POSITION IN THE DRIVER SEAT AFTER ENTERING THE TRUCK I FELT THE BACK OF THE SEAT ON THE RIGHT SIDE GIVE WAY. IT IS NOT BENT, THE SEAT FRAME IS BROKEN OR HAS COME LOOSE INSIDE. THE SEAT LEANS TO THE RIGHT PUTTING ME IN AN AWARD AND UNSAFE POSITION. I ONLY DRIVE IT WHEN I HAVE NO OTHER CHOICE. I AM 6'1" 214 LBS. SEAT IS OTHERWISE IN GOOD CONDITION.

NHTSA ID
11386327
Incident
Sep 15, 2019
Fuel system
Filed Dec 19, 2018

TANK WAS REMOVE DUE GAS COMING ONTO GROUND WHEN ATTEMP TO PUMP GAS, COME TO FIND THERE WAS A CRACK AROUND THE NECK OFTANK, POOR WELDING JOB TO ATTACH NECK TO TANK. CRACKS ALONG SIDE OF WELDING JOB AND COST ME $1,000.00.

NHTSA ID
11162596
Incident
Dec 4, 2018
Mileage
137,000 mi
Brakes
Filed Apr 7, 2016

BRAKE PEDAL SUDDENLY WENT TO FLOOR WITHOUT WARNING WHILE DRIVING. I WAS LUCKY TO AVOID A COLLISION.

NHTSA ID
10854157
Incident
Mar 20, 2016
Mileage
100,000 mi
ElectricalFuel systemExterior lighting
Filed Sep 14, 2015

TL* THE CONTACT OWNS A 1998 CHEVROLET SILVERADO 1500. WHEN TURNING THE KEY IN THE IGNITION, THE VEHICLE FAILED TO START. IN ADDITION, THE FUEL PUMP WARNING LIGHT ILLUMINATED. AN INDEPENDENT MECHANIC INSPECTED THE VEHICLE AND REPLACED THE FUEL PUMP. THE CONTACT ALSO STATED THAT THE WINDSHIELD WIPERS FUNCTIONED INTERMITTENTLY AND THE VENT CONTROLS FAILED. THE BOLTS ON THE TAIL LIGHTS WERE REPLACED TWICE, BUT THE FAILURE RECURRED WHERE A WIRE FAILED CAUSING THE LIGHTING FOR THE REAR TAIL LIGHTS TO FAIL. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 200,000.

NHTSA ID
10763606
Incident
Nov 14, 2014
Mileage
200,000 mi
Electrical
Filed Sep 11, 2015

THE HEATER BLOWER ON THE HIGH SETTING THAT DEFROSTS THE WINDSHIELD FOR VISIBILITY STOPPED WORKING. THE CAB OF THE TRUCK FILLED WITH SMOKE AND SMELLED LIKE PLASTIC BURNING. THE ELECTRICAL HARNESS FOR THE BLOWER MOTOR WAS BURNING. THE DEALERSHIP SAID IT WAS A DESIGN DEFECT BUT THE YEAR OF MY TRUCK DIDN'T QUALIFY FOR THE RECALL. IF I DIDN'T CAN'T THE BURNING WIRES WHEN I DID MY TRUCK WOULD HAVE BURNED TO THE GROUND. THIS IS A LIFE THREATENING DEFECT. I HAD IT VERIFIED THAT THE LOAD FOR THE WIRE AND THE TYPE OF CONNECTOR USED FOR THE WIRING HARNESS IS NOT ADEQUATE FOR THE ELECTRICAL LOAD OF BLOWER MOTOR AND BLOWER SPEED RELAY. I OWNED THIS TRUCK FOR YEARS WITHOUT BEING IN A HOT OR EXTREME COLD ENVIRONMENT. WHEN I USED THE HIGH SPEED BLOWER TO DEFROST THE WINDSHIELD IT COULD HAVE KILLED ME. THE TRUCK STILL HAS NOT BEEN REPAIRED, THE MFR REFUSES TO ACCEPT THAT THIS TRUCK FALLS UNDER THE SAME DEFECT AS OTHER YEARS.

NHTSA ID
10763036
Incident
Oct 1, 2012
Mileage
80,000 mi
Body & structureBrakes
Filed Sep 11, 2015
Crash reported

BRAKE PEDAL GOES SPONGES AND ALL THE WAY TO THE FLOOR. THE TRUCK HAD OVER 120,000 MILES BEFORE REAR BRAKES WERE REPLACED. IN THAT TIME I WENT THROUGH 8 SETS OF BRAKES AND ROTORS. IN 2005 I REAR ENDED A CAR AT ABOUT 30 MPH. THE BRAKES WENT TO THE FLOOR. LOCAL CHEVY DEALERSHIP REPLACED A DEFECTIVE BRAKE BOOSTER ASSEMBLE. THIS WAS THE SECOND BRAKE BOOSTER/ MASTER CYLINDER ASSEMBLY REPLACE ON MY TRUCK SINCE 2005. SINCE THEN. I HAVE LOST BRAKES ON THE TRUCK 4 MORE TIMES. FAILED BRAKE LINES (LEAK AND BREAK) BLOWN BRAKE CALIPER AND RUBBER HOSE. I AM AN ASE CERTIFIED MECHANIC. THE REAR BRAKES OF THE TRUCK DID NOT PROVIDE ANY BRAKING ASSISTANCE WHEN INSPECTED. SUSPECTED FAULT WAS A DEFECTIVE DESIGN ON THE 1500 SERIES TRUCK BRAKES. WHEN 2500 BRAKE PARTS ARE USED ( MASTER CYLINDER ASSY, PROPORTIONING VALVE, AND REAR BRAKES CHANGE TO 11" DRUMS THE BRAKE PEDAL FEELS FIRM AND THE BRAKING POWER OF THE TRUCK IS DRASTICALLY IMPROVED. I'VE OWNED THE TRUCK FOR OVER 11 YEARS AS THE SECOND OWNER I BOUGHT IT WITH VERY LOW MILES. THE BRAKES ON THE VEHICLE HAVE ALWAYS BEEN TERRIBLE. I INITIALL SPENT OVER $2,000 AT THE DEALERSHIP STRING TO BET THE BRAKES CORRECT. IN THE END THE DEALER SAID THAT "THIS IS HOW THEY ALL ARE".

NHTSA ID
10763035
Incident
Jun 1, 2005
Mileage
60,000 mi
Other / unspecified
Filed Feb 12, 2015

RIMS ARE VERY VERY RUSTY. *TR

NHTSA ID
10683086
Incident
Feb 12, 2015
Brakes
Filed Oct 21, 2014

WE WERE GOING TO A FRIENDS HOUSE IN OUR 1998 CHEVY TRUCK. THE PEDAL WENT DOWN TO THE GROUND. WE BROUGHT THE TRUCK IN AND THERE WAS A LEAK IN THE BRAKE LINE FOR THE REAR BRAKES. WE REPLACED THE BRAKE LINES. SUBSEQUENTLY, I PUT THE CAR UP TO SEE HOW THE FRONT BRAKE LINES LOOK. THEY ARE ALMOST ROTTED THROUGH. WE NOW NEED TO REPLACE THE FRONT BRAKE LINES. CHEVY SHOULD FIND OUT WHY THE TRUCK LOOKS SO BAD; THE DOORS ARE ALL ROTTING AWAY ALSO. *TR

NHTSA ID
10649083
Incident
Oct 4, 2014
Mileage
180,900 mi

Manufacturer communications

A bulletin sent by a manufacturer to its dealers. Not a recall, and repairs are not necessarily free.

PIT3665M

ELECTRICAL SYSTEM: INTEGRATED TRAILER BRAKE CONTROL

This Preliminary Information communication advises the technician that the Hydro-Boost is not serviceable and will need to be replaced if the brake pedal moves or applies on its own at a full turn.

17-NA-073

EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

PIT3665L

SERVICE BRAKES

This Preliminary Information communication advises the technician that the Hydro-Boost is not serviceable and will need to be replaced if the brake pedal moves or applies on its own at a full turn.

PIP4723F

FUEL SYSTEM, GASOLINE; SERVICE BRAKES, HYDRAULIC

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

PIT3665J

SERVICE BRAKES

This Preliminary Information communication advises the technician that the Hydro-Boost is not serviceable and will need to be replaced if the brake pedal moves or applies on its own at a full turn.

PIT3665H

SERVICE BRAKES

This Preliminary Information communication advises the technician that the Hydro-Boost is not serviceable and will need to be replaced if the brake pedal moves or applies on its own at a full turn.

Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Compare model years

Complaint and recall counts across every year of this model

Chevrolet Silverado 1500 by model year
YearComplaintsRecallsInvestigationsIssue Index
2026693053.3
2025840046.9
20242812360.5
20233573364.4
20225836367.2
20217818469.6
202069512367.0
20191,05310264.7
20185117054.9
20177116057.9
201679011160.3
20151,09511262.9
20141,4326259.0
20133012254.0
20122152252.3
20115634257.1
20103603255.0
20094443253.6
20089143359.1
20078492355.7
20063570039.0
20055250039.6
20047970036.5
20038050343.9
20025090249.0
20014680249.0
20006110249.9
19995872257.5
1998Viewing3612048.1
19975552049.3
1996700—
1995300—
1994100038.6

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.