2000 Chevrolet Silverado 1500

IN A LETTER DATED APRIL 20, 2005, GM NOTIFIED NHTSA THAT IT HAD DECIDED THAT DEFECTS THAT RELATE TO MOTOR VEHICLE SAFETY EXIST IN CERTAIN MODEL YEAR (MY) 1999-2002 C/K 1500 SERIES (PBR PARKING BRAKE SYSTEM) AND MY 2001-2005 C/K 2500 AND 3500 SERIES (TRW PARKING BRAKE SYSTEM) PICKUPS WITH MANUAL TRANSMISSIONS.ACCORDING TO GM, SOME OF THESE VEHICLES MAY HAVE CONDITIONS THAT CAUSE THE FRICTION LININGS TO WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.GM'S ACTION COVERS AN ESTIMATED TOTAL OF 142,585 VEHICLES.DEALERS WILL INSTALL A LOW-FORCE SPRING CLIP RETAINER FOR VEHICLES EQUIPPED WITH THE PBR PARKING BRAKE SYSTEM AND INSTALL A REDESIGNED PARKING BRAKE CABLE ASSEMBLY ON VEHICLES EQUIPPED WITH THE TRW PARKING BRAKE SYSTEM. A TOTAL OF 58 NON-DUPLICATIVE COMPLAINTS WERE RECEIVED BY ODI AND GM CONCERNING THE APPROXIMATELY 59,000 MY 1999-2002 C/K 1500 SERIES PICKUP TRUCKS WITH THE PBR PARKING BRAKE SYSTEM.THESE INCLUDED 22 ALLEGED ROLLAWAY INCIDENTS, RESULTING IN A RATE OF 38.5 ROLLAWAY INCIDENTS PER 100,000 VEHICLES.ODI IS AWARE OF 24 COMPLAINTS REGARDING THE MY 2001-2005 C/K 2500 AND 3500 SERIES MANUAL TRANSMISSION TRUCKS RECALLED BY GM, INCLUDING 5 ALLEGING ROLLAWAY INCIDENTS.THOUGH THE CONDITIONS DESCRIBED IN GM'S LETTER ARE ALSO PRESENT IN THE C/K TRUCKS WITH AUTOMATIC TRANSMISSIONS, THE ROLLAWAY RATE IN THOSE VEHICLES WAS SIMILAR TO THOSE OBSERVED IN PEER VEHICLES STUDIED BY ODI IN THIS INVESTIGATION.THIS ENGINEERING ANALYSIS IS CLOSED. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.

ODI OPENED PE03-057 TO ASSESS PARKING BRAKE INEFFECTIVENESS IN THE SUBJECT VEHICLES.THESE VEHICLES ARE EQUIPPED WITH FOUR WHEEL DISC BRAKES THAT INCORPORATE A SINGLE-SHOE DRUM-IN-HAT PARKING BRAKE INDEPENDENT OF THE SERVICE BRAKES.COMPLAINT AND WARRANTY DATA INDICATE THAT THE PARKING BRAKE LININGS TEND TO WEAR OUT EARLY IN THE LIFE OF THE VEHICLE (AT AN AVERAGE OF 24 MONTHS IN SERVICE), REDUCING THE PARKING BRAKE SYSTEM'S TORQUE BELOW THAT NEEDED TO IMMOBILIZE THE VEHICLE.GM HAS ATTRIBUTED THIS ACCELERATED WEAR TO FOREIGN MATERIAL INTRUSION AND A FAILURE OF THE BRAKE SHOE TO PROPERLY SELF-CENTER WITHIN ITS BRAKE DRUM.EFFECTIVE WITH THE START OF MY 2003 PRODUCTION, A NEWER REDUCED FORCE HOLD-DOWN CLIP WAS INTRODUCED TO FACILITATE BRAKE SHOE DISENGAGEMENT FROM THE DRUM SURFACE.THIS PART IS ALSO AVAILABLE AT THE SERVICE LEVEL FOR THE MY 1999-2002 VEHICLES.GM HAS INDICATED THAT THE PAKING BRAKE IS INTENDED TO OPERATE IN CONJUNCTION WITH THE TRANSMISSION TO IMMOBILZE PARKED VEHICLES, AND THAT IN MANY CASES, ACCELERATED PARKING BRAKE LINING WEAR IS CAUSED BY ROUGH USE, VEHICLE MODIFICATIONS, AND DRIVING WITH THE PARKING ENGAGED. ODI HAS UPGRADED THE PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING PARKING BRAKE USAGE FACTORS AND THE CIRCUMSTANCES SURROUNDING THE SEVENTEEN REPORTED VEHICLE CRASHES.

The vehicle was involved in a frontal collision with a light pole at an estimated speed of approximately 30–40 mph. Despite the severity and frontal nature of the impact, the driver-side steering wheel airbag did not deploy. To my knowledge, no airbags deployed. The vehicle/component may be available for inspection upon request. The lack of airbag deployment may have increased the risk of injury to the driver. The driver sustained four broken ribs and a fractured back in the crash, and there was also concern that the driver may have struck the throat/neck area on the steering wheel. The airbag issue has not been reproduced or confirmed by a dealer or independent service center. Police responded to the crash and saw the vehicle. The vehicle has not yet been inspected by insurance representatives, and I am not aware of any inspection by the vehicle manufacturer regarding the airbag non-deployment. I do not know whether there were any airbag warning lights, warning messages, or other symptoms related to the airbag system before the crash. The police report indicates a non-fatal injury with same-day hospital release. However, the driver was actually transferred to another hospital out of state and remained hospitalized for approximately six additional days due to injuries sustained in the crash, including four broken ribs and a fractured back. The responding officer may not have been aware of the subsequent transfer and hospitalization at the time the police report was completed.

NHTSA ID

11764553

Incident

Aug 28, 2026

The vehicle was involved in a frontal collision with a light pole at an estimated speed of approximately 30 mph. Despite the severity and frontal nature of the impact, the driver-side steering wheel airbag did not deploy. To my knowledge, no airbags deployed. The vehicle/component may be available for inspection upon request. The lack of airbag deployment may have increased the risk of injury to the driver. The driver sustained four broken ribs and a fractured back in the crash, and there was also concern that the driver may have struck the throat/neck area on the steering wheel. The airbag issue has not been reproduced or confirmed by a dealer or independent service center. Police responded to the crash and saw the vehicle. The vehicle was seen my police at the time of the incident but has not yet been inspected by insurance representatives, and I am not aware of any inspection by the vehicle manufacturer regarding the airbag non-deployment. I do not know whether there were any airbag warning lights, warning messages, or other symptoms related to the airbag system before the crash. The police report indicates a non-fatal injury with same-day hospital release. However, the driver was actually transferred to another hospital out of state and remained hospitalized for approximately six additional days due to injuries sustained in the crash, including four broken ribs and a fractured back. The responding officer may not have been aware of the subsequent transfer and hospitalization at the time the police report was completed.

NHTSA ID

11764552

Incident

Aug 28, 2026

The contact owns a 2020 Chevrolet Silverado 1500 equipped with Dextero Tires, Tire Line: DHT2, Tire Size: LT245/75/R16, DOT Number: Y9B0LL1X3718. The contact stated that while driving approximately 55 MPH, the vehicle was shaking abnormally, and the doors were rattling. The vehicle was not diagnosed or repaired. The vehicle was taken to the residence where the lug nuts were checked but no failure was found; however, the contact felt a large bulge on the front passenger’s side tire. The tire was not repaired. The contact stated that the failure persisted, and approximately a week later there was a bulge in the rear passenger’s side tire. The vehicle was taken to an independent mechanic, but the tires were no longer in stock. The vehicle was taken back to the residence, and all four tires were removed and inspected. The contact stated that the driver's side front and rear tires rolled, wobbled, and fell over, indicating treadwear issues. The manufacturer was not notified of the failure. The vehicle failure mileage was 153,358. The tire failure mileage was 11,000.

NHTSA ID

11762213

Incident

Aug 10, 2026

Mileage

153,358 mi

Airbag recall Recall Engine knock sensors bad

NHTSA ID

11724481

Incident

Mar 3, 2026

The contact owns a 1995 N/A Chevrolet GMT-400. The contact received notification of NHTSA Campaign Number: 03V159000 (VISIBILITY); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ID

11646499

Incident

Feb 23, 2003

From the initial report, the driver was over speed limit. However, the airbags DID NOT deploy that could have potentially saved his life.

NHTSA ID

11620815

Incident

Sep 29, 2024

The contact owns a 2000 Chevrolet Silverado 1500. The contact received notification of NHTSA Campaign Number: 02V178000 (Air Bags); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ID

11614014

Incident

Sep 11, 2024

Emergency brake keeps engaging Power steering problem, seat belt light stays on even when buckled. Headlights are dim

NHTSA ID

11524964

Incident

May 31, 2023

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

This service bulletin explains how to measure for oil consumption and possible reasons for loss of oil.

This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and vent temperature.

This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have high and low pressures, outside temperature, humidity, and vent temperature.

Vehicle Wide Programming (VWP) is a new process to update software on GM Vehicles. It provides the ability via a single selection within Techline Connect to first identify which modules need updating and then proceed to updating affected modules (with some exceptions). The updating of modules is completed in parallel instead of the technician needing to update one module at a time. This allows a more streamlined approach for dealers and customers.

GM is receiving damaged (cracked or broken) transmission cores returned to the reman facilities. The damage is being caused either in the removal process by the technician, or inadequate packaging or shipping. This bulletin advises the dealers to be more careful not to damage the transmissions during removal and to package the core properly for return.