2013 Chevrolet Silverado 1500

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.

The vehicle's structural frame rails have suffered a catastrophic failure. The driver-side frame rail has a physical separation gap measuring between 1/2-inch and 1 inch wide. The passenger-side frame rail is actively delaminating and separating from the inside out. The vehicle and the failed component are completely intact and available for immediate inspection upon request. SAFETY RISK TO OTHERS:The structural integrity of the truck is entirely gone, creating an extreme safety hazard. If driven, the frame is at risk of snapping completely in half, which would cause an immediate, catastrophic loss of steering, suspension control, and braking on public roads, risking a fatal crash for the occupants and nearby drivers. CONFIRMATION BY A SERVICE CENTER:The problem has not been visually confirmed via a safety inspection. The catastrophic splitting aligns exactly with the premature corrosion patterns caused by the failing factory wax defect openly documented by General Motors in Technical Service Bulletin (TSB) 19-NA-255.4. INSPECTION BY MANUFACTURER/POLICE/INSURANCE:The vehicle has not yet been inspected by General Motors corporate, local police, or insurance representatives. It was immediately deemed unroadworthy and taken off public roads and parked. WARNING LAMPS AND PRIOR SYMPTOMS: There were no warning lamps, or dashboard messages. The only symptoms was when going over a bump it made a weird noises which was inspected and found the crumbling/failing frame. Because the multi-layered steel frame rots from the inside out due to moisture trapped behind the defective factory wax coating, the structural failure remained entirely invisible until the frame physically cracked open and separated.

NHTSA ID

11752287

Incident

Jul 22, 2026

Was involved in an MVA at @ 40 MPH no air bags were deployed

NHTSA ID

11740841

Incident

May 4, 2026

I am submitting this complaint regarding an unrepaired Takata airbag recall associated with my vehicle VIN and concerns related to dealership representations and compliance charges at the time of sale. My vehicle currently shows an active unrepaired Takata airbag recall under NHTSA Recall Number 21V053 with recall status listed as “Recall Incomplete.” The recall states that the passenger-side front airbag inflator may rupture and send metal fragments into the vehicle interior, potentially causing serious injury or death. The vehicle was purchased on October 30, 2023 from an Alexandria, La Used car lot. Despite this unresolved federally recognized safety recall, a “compliance” fee was charged in the sales transaction. I was not informed that the vehicle had an active unrepaired Takata airbag recall associated with the VIN at the time of sale. I have also filed complaints with Louisiana regulatory authorities regarding the transaction. During review of the matter and related documentation, I discovered that the vehicle had an active unrepaired Takata recall associated with the VIN which currently remains listed as “Recall Incomplete” in the NHTSA database. I am requesting that this complaint be documented and reviewed regarding the unresolved safety recall and the representations made during the sale of the vehicle. The unrepaired Takata recall remains active on the vehicle while it sits in my driveway unused pending an ongoing rescission dispute. According to the recall notice, the inflator propellant may degrade over time from age, heat, and humidity exposure, increasing the risk that the passenger-side airbag inflator could rupture during deployment and send metal fragments into the vehicle, potentially causing serious injury or death.

NHTSA ID

11739656

Incident

Mar 17, 2026

The White Diamond Tri Coat paint that General Motors applied to vehicles is sub par and defective. There is no reason why the paint should be this bad. It is not due to damage or anything the driver has done. This is a factory defect and should be addressed. Every single vehicle I have seen with this same Tri Coat paint is chipping, flaking and peeling. My truck is the LTZ model of Silverado and that is supposed to be the top of the line, best vehicle sub trim that Chevrolet offers. I would like this to be looked into.

NHTSA ID

11738753

Incident

Apr 1, 2019

Odometer Fraud. The contact purchased a 2013 Chevrolet Silverado 1500. The contact stated that they discovered that there was a mileage discrepancy after the purchase. The vehicle was a private sale. At the time of purchase, the vehicle mileage was 163,000. It was later discovered upon checking Carfax that the mileage was 302,584.

NHTSA ID

11738460

Incident

May 18, 2026

Mileage

302,584 mi

Due to General Motors AFM lifter defect and oil consumption issues that have been proven faulty, #4 AFM gave out on us in February of 2026 costing us approximately $5,000 in Engine repairs on our 2013 Chevrolet Silverado plus several tow bills and the inconvenience of not having a vehicle for weeks. GM Recently lost a class action lawsuit for this issue that they have failed to fix but the lawsuit didnt pay enough to fix the issues. GM knew about the oil consumption issues and lifter failures with these vehicles since 2007 and didnt do anything. To this day, there are still issues including on new vehicles.

NHTSA ID

11729338

Incident

Feb 10, 2026

The contact owns a 2013 Chevrolet Silverado 1500. The contact stated that while the vehicle was stopped at a traffic light or stop sign, the vehicle experienced rough idling. No warning lights were illuminated. The contact was adding engine oil every 3,000 miles. The contact stated that the engine was consuming an excessive amount of engine oil. No warning lights were illuminated. The vehicle was taken to the dealer; however, no cause for the failure was found. The contact was informed by the dealer that the oil consumption was normal due to the mileage on the vehicle. A year prior to the failure, there was an abnormal grinding sound coming from the steering wheel while turning. The vehicle was taken to the dealer; however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and advised the contact to report the failure to the NHTSA Hotline. The failure mileage was approximately 90,000.

NHTSA ID

11716199

Incident

Feb 6, 2024

Mileage

90,000 mi

The truck lost power, starred sputtering and misfiring. I shut the engine down, restarted and was able to drive it home. This same issue occurred a couple more times but each time it was restarted it drove okay. I started doing research and found a history of this same issue being reported by other owners and upon complaining to GM, nothing was done. I stopped driving the truck and it has been sitting for 3 years now. On April 22 2024 I had the truck towed to Stingray Chevrolet to have the issue checked. I was informed that the engine was would need to be replaced at a cost estimated to be 18K. I had the truck towed back to my home and it has been sitting, until I decide what I am going to do. I have continued investigating and I have found where GM acknowledged there were engine issues that dated back from 2013/2014 more than 10 years where the same problems were reported. Several law suits were found to have been filed with some wins and some losses including class action suits. I wrote GM and asked them to step up, do the right thing and replace the engine. They refused naturally so I have been waiting, contemplating my actions but the fact still remains. GM built and sold defective engines back into the early 2000's and replaced these 5.3L V8's with another engine that there are still defects being reported. I would like for GM to fully replace the engine including all components and Auxiliary devices on my truck, at no cost to me. Give it another 100K mile guarantee and compensate me for the 3 years I have not been able to use my truck.

NHTSA ID

11712414

Incident

Feb 1, 2023

This preliminary information communicates information about how to determine if a wheel and tires size change is available.

This Preliminary information communicates the steps on how to save a GDS2 Session Log and upload to a Technical Assistance Case in CX Connect.

This preliminary information advises a dealer on how to email GDS2 session logs into Technical Assistance.

This PI Communications information on an alternative product dealers can use to perform 19-NA-255: Wax Coating on Frame Peeling, Metal Shows Corrosion/Rusting due to issue with getting product from current supplier listed in the bulletin.

This preliminary information advises a dealer on how to email GDS2 session logs into Technical Assistance.

This Preliminary Information communication provides information to the technician about vehicles that have had multiple repair attempts that are being performed on customer’s vehicles that exhibit vibration conditions without utilizing the support of General Motors Technical Assistance Center. If valid vibration frequency or Road Force Variation data has been collected and a repair attempt does not correct the customer complaint, contact General Motors Technical Assistance Center for further support. For any vehicles that remains unrepaired after being at the dealer for three days or more and a related bulletin or PI is not found, contact General Motors Technical Assistance Center for further support.