2013 Chrysler 300

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

On April 22, 2016, Fiat Chrysler Automotive US LLC, (FCA) submitted a Defect Information Report (DIR) to NHTSA regarding a defect that could result in unattended vehicle rollaway with the engine running in approximately 811,586 model year (MY) 2012 to 2014 Dodge Charger and Chrysler 300 vehicles and MY 2014 to 2015 Jeep Grand Cherokee vehicles equipped with 8-speed transmissions and a monostable gear selector (NHTSA Recall #16V-240, FCA Recall #S27). According to FCA's DIR, The existing strategies built into these vehicles to deter drivers from exiting the vehicle after failing to put the transmission into PARK have not stopped some from doing so. Drivers erroneously concluding that their vehicle's transmission is in the PARK position may be struck by the vehicle and injured if they attempt to get out of the vehicle while the engine is running and the parking brake is not engaged.The vehicles recalled by FCA are equipped with Monostable electronic (shift-by-wire) gearshift assemblies supplied by ZF Group (see Figure 1).The subject Monostable shifter has a single neutral position that it snaps back to when the driver releases the shift knob.Although the Monostable gearshift has the familiar appearance of a conventional console mechanical gearshift assembly, it has an unfamiliar movement that does not provide the tactile or visual feedback that drivers are accustomed to receiving from conventional shifters.Consequently, the driver must take additional time to verify that the desired gear position was achieved by checking the PRNDL display on the shift knob or the Electronic Vehicle Information Center (EVIC) display.

Driving approximately 50 mph on highway when the front glass panel of the sunroof exploded. No other traffic on the road or pulled off the road. No planes flying overhead. Explosion sounded like a gunshot. Have cleaned the car of shattered glass, didn’t find any foreign objects in the car.

NHTSA ID

11749461

Incident

Jul 9, 2026

My HFM has failed and I think it may be caused by the alternator but it has killed 2 battery's and there was no warning lamps or lights of any kind. I am going to have victory motors in craig colorado diagnosis the issue also.

NHTSA ID

11636722

Incident

Feb 15, 2024

Seat control module. The adjustable pedals move forward on their own while driving.

NHTSA ID

11629517

Incident

Dec 8, 2024

2013 Chrysler 300C rear video camera for driver stopped working. Unsafe backing up. Need help

NHTSA ID

11608974

Incident

Jul 15, 2024

The contact owns a 2013 Chrysler 300. The contact stated that driving on multiple occasions while driving at various speeds, the infotainment panel went black and did not work as intended. Additionally, the contact stated that the message “Wrong Gear/Change Gear” was displayed. The contact stated that several unknown warning lights were illuminated. The contact stated that on another occasion while in neutral, the vehicle failed to shift into park as intended. The vehicle was taken to a dealer twice however, the failure was not duplicated. The vehicle was not repaired. The contact stated that years later, the vehicle was taken to an independent mechanic where it was diagnosed that the infotainment system needed to be replaced. The failure persisted. The manufacturer was not notified of the failure. The failure mileage was approximately 8,000.

NHTSA ID

11596233

Incident

Nov 30, 2014

Mileage

8,000 mi

The alternator ceased up on me while I was driving on 7/12/2019. This almost caused an accident! I was driving around 55MPH and the steering and brakes completely locked up. I couldn't turn the wheel or stop my car. Eventually I slowed down and barely got the steering wheel to turn so I wasn't stuck right on the highway. My car was towed to a mechanic that replaced the alternator. I later received a recall notice in the mail for the alternator and have been trying to get reimbursed.

NHTSA ID

11591758

Incident

Jul 12, 2019

Shifter Transmission

NHTSA ID

11577861

Incident

Jan 15, 2024

The timing chain guides broke under 100,000 miles just look a recall notice given to many that the same motor and vehicle had the same year. Notice states q1 2013 with the 5.7 mds motor and this motor has all the labels amd original. Car almost cause a pile up on i-20

NHTSA ID

11572316

Incident

Oct 23, 2023

The vehicle will exhibit a service transmission/check engine warning indicator for the following transmission models: 845RE, 8HP45, 850RE, 8HP50, 8HP70, 8HP75, 8HP75-PHEV, 8HP75-LCV, 8HP90, 8HP95. Transmissions may exhibit the following diagnostic codes: P07E4, P1DB2, P0716, P1B14, P0733, P1D90, P1DB7, P1B13.

PAD KIT - REAR DISC BRAKE, FRONT DISC BRAKE

PAD KIT - REAR DISC BRAKE, FRONT DISC BRAKE

Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates.

Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates.

Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates