2014 Chrysler 300

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

On April 22, 2016, Fiat Chrysler Automotive US LLC, (FCA) submitted a Defect Information Report (DIR) to NHTSA regarding a defect that could result in unattended vehicle rollaway with the engine running in approximately 811,586 model year (MY) 2012 to 2014 Dodge Charger and Chrysler 300 vehicles and MY 2014 to 2015 Jeep Grand Cherokee vehicles equipped with 8-speed transmissions and a monostable gear selector (NHTSA Recall #16V-240, FCA Recall #S27). According to FCA's DIR, The existing strategies built into these vehicles to deter drivers from exiting the vehicle after failing to put the transmission into PARK have not stopped some from doing so. Drivers erroneously concluding that their vehicle's transmission is in the PARK position may be struck by the vehicle and injured if they attempt to get out of the vehicle while the engine is running and the parking brake is not engaged.The vehicles recalled by FCA are equipped with Monostable electronic (shift-by-wire) gearshift assemblies supplied by ZF Group (see Figure 1).The subject Monostable shifter has a single neutral position that it snaps back to when the driver releases the shift knob.Although the Monostable gearshift has the familiar appearance of a conventional console mechanical gearshift assembly, it has an unfamiliar movement that does not provide the tactile or visual feedback that drivers are accustomed to receiving from conventional shifters.Consequently, the driver must take additional time to verify that the desired gear position was achieved by checking the PRNDL display on the shift knob or the Electronic Vehicle Information Center (EVIC) display.

Dealer Gladiator Auto Sales LLC, 7040 NW 77th Ter #1, Medley FL 33166 sold me this vehicle on [XXX] stating 98,854 miles as ACTUAL MILEAGE on contract and FL Form 82042. Florida title record shows 170,520 miles on 07/27/2019 and current brand NOT ACTUAL MILEAGE. Odometer rolled back 71,666 miles. This is federal odometer fraud. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11739657

Incident

Apr 24, 2026

See attached document for complaint.

NHTSA ID

11723812

Incident

Jan 22, 2026

As I was driving my car felt like if it went on neutral. I almost crashed. Stopped. Then it would not come off of park. I kept putting it on drive and it automatically kept going into park mode. The car was still running though. And turns on. It still wont drive. Turns on but doesn't go onto drive mode.

NHTSA ID

11685522

Incident

Sep 5, 2025

Valve , computer in transmission stoped working , no communication.

NHTSA ID

11680648

Incident

Aug 7, 2025

My backup camera works when it wants to mostly not at all. It just flickers when I put the car in reverse. I really need it because of the blind spots. Also since the fuel issue was recalled and fixed my car smells like it's not burning the gas properly. In other words I can smell fumes.

NHTSA ID

11656394

Incident

Jan 1, 2024

I HAVE OWNED THIS VEHICLE FOR 9 YEARS, AND TAKEN IT IN FOR NUMEROUS OIL CHANGES AND MULTI-POINT INSPECTIONS. ONE ITEM THAT IS INCLUDED TO BE SERVICED IS TO CHECK AND TOP OFF (IF NEEDED) THE POWER STEERING FLUID. DUE TO WHERE THE POWER STEERING RESERVOIR AND PUMP IS LOCATED, THE PASSENGER SIDE TIRE AND FENDERWELL COVER MUST BE REMOVED TO ACCESS THE TWO PARTS. THIS IS QUITE A BIT OF LABOR FOR AN OIL CHANGE AND MULTI-POINT INSPECTION, YET THE SERVICE REP ASSURES ME THAT THE STEERING FLUID HAS BEEN CHECKED, EVEN THOUGH THE NOISE AND STIFF STEERING IS STILL PRESENT. MY CONCERN IS THAT DEALERSHIPS ARE NOT CHECKING THE POWER STEERING FLUID DUE TO A FAULTY LOCATION DESIGN AND THE LABOR REQUIRED TO ACCESS THE PARTS THAT NEED SERVICING FOR ROUTINE MAINTAINANCE; THE ALTERNATIVE FOR THEM IS A PROFITABLE STEERING PUMP REPLACEMENT. FROM MY OBSERVATION, THE FENDERWELL COVER HAS NEVER LOOKED AS THOUGH IT WAS REMOVED TO CHECK THE STEERING FLUID.

NHTSA ID

11651799

Incident

Dec 7, 2024

When the weather is very cold or it is raining or snowing my sunroof leaks into my car. The windshield fogs up and I am not able to drive the vehicle and the rear seat and floor is usually wet.

NHTSA ID

11644451

Incident

Jan 1, 2025

The contact owns a 2014 Chrysler 300. The contact stated while driving at an undisclosed speed, the vehicle briefly vibrated before returning to normal functionality however, the failure became a regular failure. The check engine warning light was illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the engine. The vehicle was not repaired. After investigating the failure, the contact related the failure to Technical Service Bulletin: 09-002-14. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was 96,000.

NHTSA ID

11631603

Incident

Dec 19, 2024

Mileage

96,000 mi

The vehicle will exhibit a service transmission/check engine warning indicator for the following transmission models: 845RE, 8HP45, 850RE, 8HP50, 8HP70, 8HP75, 8HP75-PHEV, 8HP75-LCV, 8HP90, 8HP95. Transmissions may exhibit the following diagnostic codes: P07E4, P1DB2, P0716, P1B14, P0733, P1D90, P1DB7, P1B13.

Active Diagnostic Trouble Code (DTC) B1A10-00, B1A11-00, B1A12- 00, B1A13-00-, B1A14-00, B1A15-00, B1A16-00, and B1A17-00 in The Radio Frequency Hub (RFH)

PAD KIT - REAR DISC BRAKE, FRONT DISC BRAKE

PAD KIT - REAR DISC BRAKE, FRONT DISC BRAKE

Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates.

Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges or other exterior surface areas of the hinges, doors, fenders, swing gates or liftgates