1995 Dodge Intrepid

ON SEPTEMBER 5, 2004, MR. ROBERT GALENTY OF ISELIN, NJ, PETITIONED THE AGENCY TO CONDUCT DEFECT INVESTIGATIONS OF CERTAIN MODEL YEAR (MY) 1993-1997 VEHICLES PRODUCED BY DAIMLERCHRYSLER CORPORATION.HIS PETITION IDENTIFIED THREE ISSUES OF CONCERN: 1) FUEL LEAKING FROM THE FUEL INJECTOR RAILS; 2) BRAKE FLUID CONTAMINATION RESULTING IN BRAKE FAILURE; AND 3) SUSCEPTIBILITY OF THE VEHICLE FRAME TO DAMAGE WHILE THE VEHICLE IS BEING TOWED.MR. GALANTY ALLEGED THAT HIS 1996 DODGE INTREPID HAD EACH OF THESE THREE PROBLEMS.CONCERNING FUEL RAIL LEAKAGE, DAIMLERCHRYSLER COMMENCED A RECALL (98V-184) OF APPROXIMATELY 722,600 VEHICLES TO ADDRESS ENGINE FUEL RAIL LEAKS THAT COULD LEAD TO A FIRE, INCLUDING THOSE VEHICLES CITED IN THE PETITION AND THE PETITIONER'S 1996 DODGE INTREPID.ON OCTOBER 7, 1998, NHTSA OPENED A RECALL QUERY INVESTIGATION (RQ98-018) TO EVALUATE THE ADEQUACY OF THE RECALL REMEDY.THAT INVESTIGATION WAS CLOSED ON JULY 8, 2002 WITHOUT REQUIRING FURTHER ACTION BY DAIMLERCHRYSLER.VERY RECENTLY, ON JUNE 9, 2004, NHTSA DENIED A PETITION (RP04-001) TO REOPEN RQ98-018 AFTER FINDING THAT THERE WAS NO NEW INFORMATION THAT WOULD INDICATE ANY BASIS FOR REOPENING IT.THIS IS STILL THE CURRENT POSITION OF NHTSA ON THIS ISSUE.CONCERNING BRAKE FLUID CONTAMINATION AND FRAME ALIGNMENT, A REVIEW OF NHTSA'S DATABASE SHOWS NO OTHER COMPLAINTS ON EITHER ONE OF THESE ISSUES ON THE VEHICLES CITED IN THE PETITION.

THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.

MR. LARRY A. SACKEY SUBMITTED A PETITION TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) BY LETTER DATED APRIL 18, 2003, REQUESTING THAT NHTSAFURTHER INVESTIGATE THE DEFECTIVE COLLAPSIBLE STEERING SHAFT SYSTEM ON 1987-1995 VEHICLES MANUFACTURED BY THE DAIMLERCHRYSLER CORPORATION.IN PART BECAUSE OF 49 CFR ? 30120(G), NHTSA HAS DECIDED TO LIMIT THE SCOPE OF THE PETITION VEHICLES TO 1993-1995 MODELS, EXCLUDING THE 1993 JEEP GRAND CHEROKEE AND 1994-1995 DODGE RAM SERIES TRUCKS THAT WERE RECALLED (93V210 & 96V230) FOR STEERING COLUMN FAILURE.IF THE ANALYSIS OF THESE VEHICLES HAD IDENTIFIED A POTENTIAL PROBLEM, THE SCOPE COULD HAVE BEEN EXPANDED IN AN INVESTIGATION.A REVIEW OF ODI'S DATA BASE SHOWS NO RECENT COMPLAINTS AND A LACK OF A COMPLAINT TREND CONCERNING THE SUBJECT ISSUE ON THE SUBJECT VEHICLES AS A WHOLE OR BY INDIVIDUAL MODELS.THEREFORE, THE PETITION IS DENIED.FOR DETAILS, SEE FEDERAL REGISTER NOTICE VOLUME 68, NO. 130, JULY 8, 2003.

There is no summary currently available

TL* THE CONTACT OWNS A 1995 DODGE INTREPID. WHILE DRIVING 65 MPH, THE BRAKE PEDAL WAS DEPRESSED AND TRAVELED TO THE FLOORBOARD. THE VEHICLE DID NOT STOP AND CRASHED INTO THE REAR OF ANOTHER VEHICLE. THE DRIVER'S SIDE AIR BAG DID NOT DEPLOY. THE PASSENGER SIDE AIR BAG DEPLOYED, BUT THERE WAS NO PASSENGER. THERE WERE NO INJURIES. POLICE REPORT NUMBER: 19-341341 WAS FILED. THE VEHICLE WAS TOWED TO AN INDEPENDENT LOT. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 113,000. *TR*JB

NHTSA ID

11205691

Incident

May 3, 2019

Mileage

113,000 mi

RACK AND PINION ISSUES. ISSUES WITH FRONT WHEELS AND STEERING. I'VE HAD IT FIXED THREE TIMES, VERY EXPENSIVE. I WAS PULLING OUT OF A PARKING SPACE, WHEN THE STEER STOPPED CONTROLLING THE WHEELS. I'M GRATEFUL I WASN'T ON THE FREE WAY.

NHTSA ID

10905974

Incident

Sep 5, 2013

Mileage

175,000 mi

1995 DODGE INTREPID. CONSUMER WRITES IN REGARDS VEHICLE STALLING WHILE DRIVING. *SMD THE CONSUMER STATED WHEN THE VEHICLE STALLED, THE POWER STEERING FAILED AND IT WAS DIFFICULT TO STEER THE VEHICLE. THE VEHICLE WAS TAKEN TO A REPAIR SHOP, WHERE THE IGNITION SWITCH WAS REPLACED. *JB

NHTSA ID

10669040

Incident

Oct 17, 2014

PURCHASED CAR ON 8/11/14, DROVE IT HOME AND ON 8/12/14 STARTED CAR AND SAY GAS SPRAYING OUT OF INJECTORS ON TOP OF MOTOR. ALL INJECTOR SEALS WERE BAD AND HAD TO BE REPLACED, SAME WITH VALVE COVER GASKETS OIL WAS RUNNING DOWN ON EXHAUST MANIFOLDS. BOTH WERE FIRE HAZARDS, 8/27/14, RIGHT SIDE AXLE IS BAD AND BEARING IN DIFFERENTIAL IS BAD. THIS CAR HAS A 4/15 INSPECTION STICKER ON WINDSHIELD, HOW COULD THIS CAR PASS THE VA STATE INSPECTION WITH THIS MANY PROBLEMS? AND ALL BRAKE PADS HAD TO BE REPLACED. THEY WERE WORN OUT TO. *TR

NHTSA ID

10628944

Incident

Aug 12, 2014

Mileage

115,849 mi

TL* THE CONTACT OWNS A 1995 DODGE INTREPID. WHEN THE CONTACT STARTED THE VEHICLE, FUEL FUMES SEEPED INTO THE VEHICLE. THE CONTACT INSPECTED THE VEHICLE AND NOTICED A FUEL LEAK NEAR THE INTAKE MANIFOLD IN THE MOTOR. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE CONTACT STATED THAT THE O-RINGS NEEDED TO BE REPLACED, BUT THE PARTS WERE NOT AVAILABLE IN ORDER TO REPAIR THE VEHICLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 92,000. UPDATED 10/10/14*CN UPDATED 3/31/15 *JS

NHTSA ID

10626440

Incident

Aug 16, 2014

Mileage

92,000 mi

TL* THE CONTACT OWNS A 1995 DODGE INTREPID. THE CONTACT STATED THAT THE KEY WOULD BECOME STUCK IN THE IGNITION SPORADICALLY AND THE CONTACT WOULD HAVE TO ABRUPTLY SHIFT INTO PARK. THE CONTACT STATED THAT THE FAILURE DID NOT OCCUR UNTIL HAVING REPAIRS TO THE VEHICLE UNDER NHTSA RECALL CAMPAIGN ID NUMBER: 04V021000 (POWER TRAIN: AUTOMATIC TRANSMISSION: LEVER AND LINKAGE: FLOOR SHIFTER). THE MANUFACTURER STATED THAT THE REPAIR HAD ALREADY BEEN DONE AND COULD NOT BE CORRECTED. THE FAILURE MILEAGE WAS 143,600.

NHTSA ID

10430682

Incident

Oct 3, 2011

Mileage

143,600 mi

DODGE TRANSMISSION ON INTREPIDS, CARAVANS, AND NEONS HAVE A HISTORY OF FAILING AND NEEDING TO BE REPLACED OR REBUILT. MY VEHICLE ONLY HAS 55800 MILES ON IT ALL ORIGINAL. EVEN THOUGH THE CAR IS 15 YEARS OLD IT HAS ALWAYS BEEN MAINTAINED SINCE IT WAS PURCHASED FROM THE DEALER BRAND NEW IN 1995. I BELIEVE THAT IF DODGE IS NOT HELD RESPONSIBLE FOR THE PROBLEMS THEN SOMEONE CAN SERIOUSLY GET INJURED FROM THEM. WHETHER IT BE FROM THE TRANSMISSION FAILING ON THE HIGHWAY AND CAUSING ACCIDENTS OR SOMETHING BREAKING WHILE JUST DRIVING AND CAUSING SERIOUS INJURY. *TR

NHTSA ID

10369402

Incident

Nov 14, 2010

Mileage

55,695 mi

I WAS DRIVING DOWN THE ROAD WHEN MY CAR JUST DIED. I DIDN'T GET ANY FLASHING LIGHTS, CHECK ENGINE LIGHT OR ANYTHING. IT WAS AS IS SOMEONE HAD TURNED THE CAR OFF WITH OUT MOVING THE KEY FROM THE ON POSITION. ONCE I COME TO A STOP, I CAN SIT FOR A LITTLE BIT AND THEN THE CAR WILL START BACK UP AS IF NOTHING EVER HAPPENED. I HAVE RECENTLY HAD A FEW ISSUES WITH SOME OTHER THINGS THAT WERE RESOLVED BY REPLACING THE IGNITION SWITCH BUT IT DIDN'T SEEM TO FIX THIS ISSUE. I TOOK THE CAR TO A REPAIR SHOP AND HAD THE DIAGNOSTICS RAN ON IT BUT IT DIDN'T COME BACK WITH ANY CODES. I OFTEN DRIVE WITH MY WIFE AND KIDS IN THE CAR SO NOW I FEAR THAT THIS MAY CAUSE US TO GET IN A WRECK. *TR

NHTSA ID

10342970

Incident

Jul 13, 2010

Valve Body. These may cause over drive cycling.

Child Seat Tether Anchor Installation This bulletin describes procedures to install Child Seat Tether Anchors based on Customer Request. Retrofits are subject to part availability. Vehicles in the following list that are marked **** for the model year are no longer supported with OEM retrofit kits. NOTE: Dealers are encouraged to honor any customers? request for the installation of the Child Seat Tether Anchors and Dealer reimbursement will be made by FCA US LLC regardless of vehicle age or mileage. See the Warranty Policy and Procedure Manual and/or Warranty Bulletin D-08-33 for reimbursement detail.

FLASH PROGRAMMING FAILURE RECOVERY. *SLC

SUBJECT REGARDING LOW OR NO CABIN HEAD, ENGINE COOLING SYSTEM SYSTEM FILL PROCEDURE. *TT

SUBJECT REGARDING CAMSHAFT / BEARING SERVICE. *TT

SUBJECT REGARDING AIRBAG / CLOCK SPRING SERVICE FOR VARIOUS MODELS INCLUDING 2002 MODEL YEAR JEEP LIBERTY. *TT