2001 Dodge Ram 2500 Engine Problems

PCM HAS BEEN REPLACE FOR THE 2ND TIME SINCE THE ORIGINAL ONE. THE DEALER HAS SENT OUT THE PCM FOR REPROGRAMMING. IT WAS RETURNED AND THE PCM DOES NOT FUNCTION PROPERLY. IF THEY CAN NOT FIND A USED ONE, THE TRUCK IS TOTALLY WORTHLESS. DODGE HAD STOPPED PRODUCING THE PCM. BECAUSE OF THIS DODGE IS FORCING ME TO REPLACE A PERFECTLY GOOD TRUCK EXCEPT FOR THE PCM. BECAUSE THE TRUCK WAS DRIVEN IN CALIFORNIA EXCEPT FOR THE LAST 4 YEARS, THERE IS NO RUST. THERE HAS BEEN NO RECALL. I DON'T FEEL I SHOULD HAVE TO BUY A NEW/USED TRUCK BECAUSE DODGE DOES NOT WANT TO MAKE THE PCM. THEY ARE PRODUCING VEHICLES KNOWING THE VEHICLE CAN'T BE FIXED AFTER A CERTAIN AMOUNT TIME.

NHTSA ID

11139715

Incident

Oct 11, 2018

Mileage

150,000 mi

I WAS DRIVING SOUTH ON INTERSTATE 5 CALIFORNIA THE TRUCK JUST DIED ON THE HIGHWAY. I WAS STUCK IN 105 DEGREE HEAT FOR 2 HOURS BEFORE THE TOW TRUCK GOT THERE. I HAD NO WATER AND I AM A CANCER SURVIVOR. I HAVE BEEN EXTREMELY ILL EVER SINCE. VERY TIRED AND I HAVE NO APPETITE. 4,200 HUNDRED TRUCK REPAIR BILL. I HAD TO PAY BECAUSE I HAVE NO OTHER TRANSPORTATION. *TR

NHTSA ID

10464513

Incident

Jul 2, 2012

Mileage

150,000 mi

DASH AND BEZEL ARE CRACKING. PIECES ARE FALLING INTO IT. WHAT PROBLEMS WILL THIS CAUSE. HEATER CORE IS LEAKING SPILLING COOLANT ONTO CAB CARPET AND PAD. WAS TOLD THIS MODEL TRUCK HAS NO AIR INTAKE FILTER TO STOP LEAVES AND OTHER TRASH FROM ENTERING THE SYSTEM THEN ROTTING IN THE HEATER CORE BOX CREATING MOLD WHICH CORRODES THE CORE. *TR

NHTSA ID

10458950

Incident

Aug 31, 2010

Mileage

55,000 mi

TL* THE CONTACT OWNS A 2001 DODGE RAM 2500. THE CONTACT STATED THAT THE VEHICLE WOULD LOOSE POWER WHILE DRIVING ON THE HIGHWAY. THE DEALER WAS NOTIFIED, BUT WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 70,000 AND THE CURRENT MILEAGE WAS 130,000. UPDATED 02/09/12*LJ UPDATED 02/13/12

NHTSA ID

10443721

Incident

Jan 15, 2007

Mileage

70,000 mi

1.) AFTER OPENING THE HOOD THE RUBBER STRIP RUNNING ACROSS THE TOP EDGE OF THE FIREWALL (WHERE BACK OF HOOD MEETS) MAY BECOME DISLODGED AND FALL ONTO THE TURBOCHARGER HOUSING. 2.) THIS OCCURS ALMOST EVERY TIME HOOD IS OPENED. THE LAST TIME I HAD TO OPEN THE HOOD IT WAS DARK AND I DID NOT NOTICE THAT IT HAD BECOME DETACHED AGAIN WHEN I CLOSED THE HOOD. 3.) SINCE THE RUBBER HAD CAUGHT ON FIRE I REMOVED IT AND ALLOWED IT TO BURN ITSELF OUT ON MY DRIVEWAY. THE LAST TIME IT CAME IN CONTACT WITH THE TURBO I WAS ABLE TO NOTICE IT BEFORE IT ACTUALLY HAD CAUGHT ON FIRE, THIS TIME I WAS NOT SO LUCKY. *TR

NHTSA ID

10345998

Incident

Jul 28, 2010

Mileage

187,450 mi

BOOSTER PUMP FOR POWER STEERING AND TRANSMISSION DON'T WANT TO SHIFT WHEN DRIVE FROM STOP TO DRIVE INTO SECOND GEAR. *TR

NHTSA ID

10342332

Incident

Jun 26, 2010

Mileage

130,000 mi

# 53 CRACKED CUMMINS TURBO DIESEL ENGINE BLOCK. *TR

NHTSA ID

10253687

Incident

Oct 15, 2008

Mileage

170,000 mi

2001 DODGE RAM CUMMINS ISB/24V TURBO DIESEL ENGINE, BLOCK # 53 CRACK. *TR

NHTSA ID

10248540

Incident

Nov 12, 2008

Mileage

170,000 mi

2001 DODGE RAM 2500 DASHBOARD CRACKING . TV INVESTIGATION SLOT SHOWN ON INTERNET. MY VEHICLE HAS THE SAME PROBLEM - PURCHASED NEW DASHBOARD PANEL FROM DODGE DEALER $200. IN THE PAST YEAR HAVE FRONT AXLE SEALS, WATER PUMP, POWER STEERING PUMP , FUEL INJECTION PUMP AND AUTOMATIC TRANSMISSION FAILED. REPAIRED OVER $ 6400 IN EXPENSE - THE DASH PROBLEM BROKE THE MONKEY'S BACK. *AK

NHTSA ID

10194859

Incident

Jun 20, 2007

Mileage

100,000 mi

DT*: THE CONTACT STATED WHILE DRIVING 30 MPH THE ENGINE STARTED SPUTTERING AND SMOKING RESULTING IN A LOSS OF POWER. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP FOR INSPECTION. THE MECHANIC DETERMINED THE INJECTION PUMP NEEDED TO BE REPLACED, WHICH NO REPAIRS WERE MADE. ALSO, THE MECHANIC NOTICED THE TIE RODS WERE PULLING APART ON THE FRONT LEFT AND RIGHT SIDE. THE MECHANIC REPLACED THE FRONT LEFT AND RIGHT TIE RODS AND BALL JOINTS. THE DEALERSHIP AND MANUFACTURER WERE ALERTED.

NHTSA ID

10151051

Incident

Feb 10, 2006

Mileage

80,000 mi

DIESEL ENGINE LOOSES POWER WHILE DRIVING. THIS USUALLY HAPPENS WHILE ACCELERATING. WHEN YOU PRESS ON THE ACCELERATOR, NOTHING HAPPENS. TAKES A MINUTE BEFORE IT RECOVERS AND YOU CAN ACCELERATE AGAIN. I TOW A 5TH WHEEL RV WHICH MAKES MORE DANGEROUS. HAPPENED ON THE INTERSTATE ONCE WHILE TRYING TO PASS. THIS WAS FIXED BY THE DEALER. THEY REPLACED THE INJECTOR PUMP. IT'S MY UNDERSTANDING THERE WAS A RECALL ON SCHOOL BUSSES WITH THESE ENGINES FOR THE SAME THING. MAYBE IT SHOULD BE LOOKED INTO FURTHER. *NM

NHTSA ID

10143280

Incident

Jun 1, 2005

Mileage

65,000 mi

FAN BLADE CLUTCH BROKE AND ASSEMBLY CAME OFF AND CAUSED SEVERE DAMAGE TO RADIATOR, SHROUD, HOSES, PULLIES, BELT AND FAN BLADE. ALL ITEMS HAD TO BE REPLACE AND TOTAL COST OF REPAIR IS $1200.00. *AK

NHTSA ID

10103064

Incident

Dec 13, 2004

Mileage

110,000 mi

THERMOSTAT CLOSED, CAUSING ENGINE TO OVERHEAT, BOILING THE COOLANT OUT OF THE COOLING SYSTEM OUT OF THE OVERFLOW PIPE, PAST THE RADIATOR CAP, THROUGH THE COOLANT RECOVERY BOTTLE. POSSIBLE CONSEQUENCES: DESTRUCTION OF ENGINE THROUGH OVERHEATING, POSSIBLE FIRE. TEMPERATURE GAUGE DID NOT FUNCTION DUE TO LOSS OF COOLANT. SERVICE DEALER AND DAIMLER CHRYSLER STATE THAT THE THERMOSTAT IS NOT A WARRANTY ITEM, EVEN THOUGH NOTHING IN THE OWNER'S MANUAL, THE EXTENDED WARRANTY CONTRACT OR ANY OTHER DOCUMENTATION THAT I HAVE STATES THIS. INSTEAD. DAIMLER CHRYSLER COVER THE CUMMINS DIESEL ENGINE AND ALL INTERNAL COMPONENTS. THIS IS AND WAS INTERPRETED BY THIS OWNER AS MEANING THAT THE THERMOSTAT, BEING AN INTERNAL ENGINE PART, SHOULD BE COVERED, AND ALL LITERATURE SUPPLIED ME AT THE TIME OF PURCHASE IMPLY THIS. FAILURE OF THIS PART COULD RESULT IN A FIRE OR ENGINE DESTRUCTION. *LA

NHTSA ID

10072349

Incident

Feb 10, 2004

Mileage

46,480 mi

WHILE DRIVING AT ANY SPEED DRIVER HEARD A KNOCKING NOISE COMING FROM THE ENGINE. CONSUMER CONTACTED DEALERSHIP ON FOUR SEPARATE OCCASIONS, BUT THE PROBLEM STILL OCCURS.*AK

NHTSA ID

10050172

Incident

Sep 15, 2003

Mileage

125,000 mi

WHILE DRIVING VEHICLE'S STEERING WHEEL LOCKED UP. DEALER NOTIFIED. TS STEERING WHEEL WOULDN'T TURN. POWER STEERING PUMP REPLACED. TIRE PRESSURE WAS TOO LOW. STEERING BOX FAILED AND REPLACED. WINDSHIELD CRACKED AND REPLACED. VEHICLE WON'T SHIFT AT 40 MPH. CLUNKING NOISE FROM PARK TO REVERSE. FOUND NORMAL OPERATION. OIL LEAK IN FRONT OF MOTOR. OVERFLOW BOTTLE TOO FULL. VEHICLE WANDERED ALL OVER THE ROAD. STEERING BOX ADJUSTED. AND LOW TIRE PRESSURE WAS TO BLAME. CONSOLE ON SEAT DOESN'T CLOSE PROPERLY. TURBO WHISTLES ON ACCELERATION. NO PROBLEM FOUND. TRANSMISSION SURGES AT 10 TO 45 MPH. NO PROBLEM FOUND. POWER STEERING BOX LEAKED AND REPLACED SECOND TIME. LEAK WAS FOUND AT VACUUM PUMP SEAL CAUSED LEAK AT POWER STEERING RESERVOIR. STEERING DRIFTS TO RIGHT AND WHEEL IS OFF CENTER. CENTER DRAG LINK ADJUSTED SECOND TIME. AFTER SET FOR A FEW DAYS, VEHICLE WON'T MOVE WHEN IT IS PLACED IN DRIVE. NORMAL. NO PROBLEM FOUND. ALL ACCESSORIES WORK WITH THE KEYS OUT OF IGNITION SWITCH. COULD NOT DUPLICATE. FLUID LEAKING FROM TRUCK. REPLACED STEERING BOX FOR THIRD TIME. BRAKES PULSATES WHEN APPLIED. LOW FLUID FOUND DUE TO STEERING LEAK. *TT

NHTSA ID

10001940

Incident

Oct 11, 2000

Mileage

7,525 mi

CONSUMER CALLED COMPLAINING ABOUT HAVING PROBLEMS WITH THE ENGINE OIL. ALSO STATED THAT WHILE DRIVING THE VEHICLE ALL THE ENGINE OIL BLOW OUT. DEALER WAS CONTACTED AND STATED THAT THE OIL FILTER WAS PUT IN WRONG. TS

NHTSA ID

8023328

WHILE DRIVING AT ANY SPEED OIL WILL BURN OUT QUICKLY, AND CONSUMER WILL BE FORCED TO PULL OVER AND REFILL VEHICLE WITH OIL. DEALER NOTIFIED.*AK

NHTSA ID

8018464

Incident

Sep 6, 2002

WHILE STOPPING OR SLOWING DOWN, FUMES FROM THE CRANKCASE FILL THE ENGINE COMPARTMENT AND COME INTO THE CAB. CONSUMER BELIEVES THAT THE FUMES ARE BEING CAUSED BY THE OPEN CRANKCASE SYSTEM AND STATES THAT THIS IS AN ENVIRONMENTAL AND PERSONAL HEALTH HAZARD. *YD

NHTSA ID

565425

VEHICLE CAUGHT FIRE WHILE PARKED, VEHICLE WAS A TOTAL LOSS AND THE FIRE APPEARED TO HAVE STARTED IN THE ENGINE AREA, CLAIM 59-V606-925. *SLC

NHTSA ID

6900897

Incident

Oct 25, 2000

WHILE DRIVING, CONSUMER NOTICED SMOKE COMING FROM THE ENGINE, CLAIM 55-S396-819. *SLC

NHTSA ID

6900894

Incident

Sep 11, 2001

WHILE DRIVING, VEHICLE BEGAN ACTING FUNNY, CONSUMER NOTICED SMOKE AND THEN VEHICLE CAUGHT ON FIRE IN THE ENGINE COMPARTMENT, CLAIM 37-3264-228. *SLC

NHTSA ID

6900572

Incident

Nov 7, 2001

WHILE DRIVING, VEHICLE BEGAN ACTING FUNNY, CONSUMER NOTICED SMOKE AND VEHICLE CAUGHT ON FIRE, CLAIM 37-3264-228. *SLC

NHTSA ID

6900896

Incident

Nov 7, 2001

WHILE DRIVING, CONSUMER SAW SMOKE COMING FROM THE ENGINE, CLAIM 55-S396-819. *SLC

NHTSA ID

6900570

Incident

Sep 11, 2001

THIS VEHICLE LEAKS OUT A SUBSTANCIAL AMOUNT OF ENGINE OIL THRU THE BREATHER TUBE WHEN DECENDING A GRADE STEEPER THAN 25 DEGREES. THIS CAUSES THE HOT OIL TO HIT THE ENGINE FAN WHERE IT IS FLUNG ALL OVER THE HOT ENGINE AND EXHAUST MANIFOLD CREATING A EXTREME FIRE DANGER. THIS CONDITION ALSO COATS THE FRONT BRAKE ROTORS WITH OIL CAUSING A LOSS OF VEHICLE BRAKING CAPACITY WHEN DECENDING STEEP HILLS. THIS CONDITION CAN AND WILL CAUSE THE ENGINE TO LOSE ALL OF ITS OIL RESULTING IN ENGINE FAILURE AND/OR FIRE, AND LOSS OF CONTROL. THIS HAS OCCURRED TWICE ON THIS VEHICLE. DODGE SAID THEY ARE AWARE OF IT, BUT RECOMMENDED I AVOID DECENDING STEEP GRADES. THIS IS AN UNACCEPTABLE ANSWER. THEY OFFER NO OTHER SOLUTION. THE GRADES IN QUESTION ARE NOT EXCESSIVELY STEEP, AND ARE WELL WITHIN THE OPERATING PARAMETERS OF THIS VEHICLE. THE ONLY REASON I DID NOT SUSTAIN A SERIOUS INJURY OR FIRE IS DUE TO MY EXTENSIVE OFF ROAD DRIVING EXPERIENCE. THIS PROBLEM NEEDS TO BE ADDRESSED ASAP.

NHTSA ID

751075

Incident

Aug 22, 2001

PART OF THE INTERIOR BREAKS OFF AND BLOCKS THE EXHAUST WHICH CAUSES A LOSS OF POWER - HAS OCCURRED ON THE HIGHWAY WHICH IS ESPECIALLY DANGEROUS WHEN PASSING ANOTHER VEHICLE. *AK

NHTSA ID

744135

Incident

Apr 1, 2001