Owner-reported complaints naming the fuel system system, filed with NHTSA
Data refreshed
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks. Every record below is an owner-reported complaint about the 2012 Dodge Ram 2500 submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 34 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
The 25 most recent of 34, in the owner's own words
My passenger headlights keeps going in and out. The wiring harness has been replaced twice and it still does it. My check engine light keeps coming on for the evap system even though its been replaced.
Our 2012 RAM 2500 truck with 135k miles, had it's fuel tank fail. The dealership in Oak Ridge, TN tested the vehicle and found that the gas tank tubes were broken causing us to not be able to fill the tank. The dealership recommended "NEED TO REPLACE GAS TANK". Mopar aka Stellantis does not make the fuel tank anymore, the "replacement" fuel tank does not work (completely wrong configuration), there is not an aftermarket tank. We have a Million Mile bumper to bumper warranty with MOPAR. "Customer Care" does not care.
TL* THE CONTACT OWNS A 2012 RAM 2500. THE CONTACT STATED THAT ALL THE WARNING INDICATORS ILLUMINATED AND THE GEAR SHIFTER FAILED TO SHIFT INTO PARK. THE CONTACT USED THE EMERGENCY BRAKE TO STOP THE VEHICLE. THE VEHICLE WAS TOWED TO LANDERS CHEVROLET OF NORMAN (1221 ED NOBLE PKWY, NORMAN, OK 73072, 405-321-7021), BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE CONTACT STATED THAT SHE WAS UNAWARE OF NHTSA CAMPAIGN NUMBERS: 14V635000 (ENGINE AND ENGINE COOLING, FUEL SYSTEM, DIESEL), 15V459000 (AIR BAGS) ,AND 17V821000 (POWER TRAIN). THE FAILURE MILEAGE WAS APPROXIMATELY 100,000. PARTS DISTRIBUTION DISCONNECT.
EXCESSIVE FUEL CONSUMPTION..LESS THAN 10MPG, HIGH OPERATING TEMPERATURE, POWER/PERFORMANCE WITH/ WITHOUT. MODERATE TOWING LOADS. HIGH TEMPERATURES ASSOCIATED WITH ELEVATIONS IN EXCESS OF 4OOO FEET. FREQUENT ENGINE LIGHT APPEARANCE.
TL* THE CONTACT OWNS A 2012 RAM 2500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V635000 (ENGINE AND ENGINE COOLING, FUEL SYSTEM, DIESEL) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.
TL* THE CONTACT OWNS A 2012 DODGE RAM 2500. WHILE ATTEMPTING TO REFUEL THE VEHICLE, THE FILLER NECK REJECTED FUEL. THE CONTACT MENTIONED THAT THE VEHICLE WOULD NOT ALLOW THE PUMP TO REFUEL AND WOULD RESPOND AS IF THERE WERE A FULL TANK WHEN THE VEHICLE WAS LOW ON FUEL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 7,771. THE VIN WAS NOT AVAILABLE.
PRIOR TO EPA EMISSIONS RECALL I WOULD ACHIEVE DIESEL FUEL EFFICIENCIES AS HIGH AS 21 MPG HIGHWAY, PULLING A 18 FOOT TRAILER AT A 1 HOUR DURATION. THE CITY MPG AVERAGED TO 13-15 MPG, SINCE THE EMISSIONS RECALL UPDATE MADE ON THIS VEHICLE, MPG HAS AVERAGED BETWEEN 10-13 MPG ON HIGHWAY WITH NO LOAD/NO TRAILER AND AVERAGES BETWEEN 9-11 MPG IN CITY. THESE BENCHMARKS HAVE BEEN CONSISTENTLY COMPARED AND ROAD CONDITIONS HAVE BEEN SAME. TO ADD TO THIS ISSUE, THERE HAS BEEN A LOSS OF POWER THAT HAS CAUSED UNEXPECTED HESITATION IN A NUMBER OF INSTANCES. SEVERAL TIMES I WAS PUT IN HARMS WAY AS CROSSING CITY DIVIDED HIGHWAY, CROSSING STREETS AND/OR DIVIDING HIGHWAYS WHERE THAT MULTI-DIRECTIONAL TRAFFIC LIGHTS ARE NOT ALWAYS PRESENT. TO FURTHER EXPLAIN, REALIZING THE POWER PICKUP WAS NOT PRESENT AND TURBO DID NOT SEEM TO BE 'SPUN UP' EVEN THOUGH ACCELERATION WAS INCREASED DRAMATICALLY. NOTE, TO HELP TO POSSIBLY REMEDIATE THESE POTENTIAL ACCIDENT OCCURRENCES, I MUST POWER BRAKE AND INCREASE ENGINE RPM'S TO HELP BRING THE VEHICLE TO A POWER LEVEL TO REDUCE THE RISK OF POWER LATENCY. THIS SOMETIMES HELPS BUT NOT ALWAYS BECAUSE POWER IMPOTENCY SEEMS TO BE UNPREDICTABLE AT TIMES.
TL* THE CONTACT OWNS A 2012 DODGE RAM 2500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V635000 (ENGINE AND ENGINE COOLING, FUEL SYSTEM, DIESEL); HOWEVER, THE PART NEEDED TO PERFORM THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
WHEN ACCELARATING, FROM A STOP ESPECIALLY, THE THROTTLE INTERMITANTLY WILL GIVE AN ALMOST DEAD RESPONSE. IT CAN BE PRESSED ALL OF THE WAY DOWN TO WIDE OPEN AND IT SLOWELY DEVELOPES POWER AND DOES NOT REACH FULL POWER UNTILL AFTER THE 1, 2 SHIFT. IT IS DANGEROUS AND IS GOING TO CAUSE AN ACCIDENT. NO MIL LIGHT NOR TROIBLE CODES ARE PRESENT.
I HAVE TWO RECALLS FOR THE FUEL HEATER SHORTING OUT AND POSSIBLE FIRE. I CALL DODGE TO GET IT FIXED AND THEY TELL ME THE PARTS ARE ON BACK ORDER. IF THEY CAN'T FIX MY TRUCK I WANT ONE THAT ME AND MY FAMILY CAN DRIVE AND FEEL SAFE IN.
I WAS DRIVING DOWN I 10 TODAY GOING 70 MY TRUCK STARTED VIGOROUSLY SHACKING AND MAKING MY TRUCK RUN OFF THE ROAD IT WAS ALL I HAD TO KEEP FROM CRASHING MY FRONT END OR READ END FELT LIKE IT LOCKED UP THEN I TRIED PULLING OFF AND MY TRUCK HAD LITTLE POWER IT TOOK SEVERAL MINUTES TO GET IT RUNNING RIGHT AGAIN BUT EVERY BUMP I HIT THE SAME PROBLEM HAPPENED I LOOKED UNDERNEATH MY TRUCK AND COULD SEE FLUID COMING FROM MY STEERING COLUMN THIS HAPPENED LITERALLY AT 180000 MILES AT 86000 MILES MY 2012 DIESEL EXHAUST FILTER CLOGGED COMPLETELY UP AND THE DEALER SAID IT WASN'T COVERED UNDER THE 100000 MILE WARRANTY I PAID $934 TO HAVE IT REPAIRED I BELIEVE THAT I HAVE EXHAUST PROBLEM S STILL TOO.
I HAVE RECEIVED A NOTICE OF RECALL 2 TIMES SINCE DECEMBER 1,2014 FOR DIESEL FUEL HEATER ELECTRICAL CONNECTOR AND HAVE BEEN TO THE DODGE DEALER SEVERAL TIMES TO GET THIS TAKEN CARE OF. THE DEALER STATES THAT THEY DO NOT HAVE THE PARTS. THIS HAS BEEN OVER 8 MONTHS NOW AND I AM NOW EXPERIENCING ELECTRICAL PROBLEMS WITH THIS VEHICLE AS WELL AS WHAT APPEARS TO BE A STICKING THROTTLE AS I DRIVE. THIS IS A SERIOUS SITUATION AS THE VEHICLE DOES NOT SLOW DOWN WHEN RELEASING THE THROTTLE. IT ALSO AT IDLE WILL INCREASE THE RPM ON IT'S OWN. UPDATE 9/15/15*CW THE FUEL HEATER WAS FIXED. THE ELECTRICAL PROBLEM STILL EXISTS WITH HIGH IDLE AND THE VEHICLE ONLY SLOWED DOWN WHEN THE BRAKE WAS APPLIED. THE HIGH IDLE AND CONSTANT INSTANCES OF FAILURE OF THE VEHICLE TO SLOW DOWN WAS A RECURRING PROBLEM AS WELL AS THE INABILITY TO OBTAIN INFORMATION FROM THE VEHICLES INFORMATION PORT STILL EXISTS. UPDATED 10/01/15*JB
TL* THE CONTACT OWNS A 2012 DODGE RAM 2500. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 14V635000 (FUEL SYSTEM); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS UNKNOWN. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
I WAS GIVEN NOTICE OF RECALL ON DECEMBER 9TH 2014.RECEIVED ANOTHER NOTICE THIS MONTH ON THE FUEL HEATER. I HAVE BEEN TO THE DEALER SEVERAL TIMES AND THEY DO NOT HAVE THE PART.IT HAS BEEN OVER 6 MONTHS SINCE THE FIRST RECALL NOTICE THEN THEY SEND ANOTHER ONE AND STILL DO NOT HAVE THE PARTS.WHAT GOOD IS A RECALL OF A DANGEROUS SITUATION WITH THE VEHICLE AND THE MANUFACTURE DOES NOT SUPPLY THE PARTS! I HAVE ALSO HAD A PROBLEM AND MADE A REPORT BEFORE ABOUT THE TRUCK NOT STOPPING OR SLOWING DOWN.THE ELECTRONIC THROTTLE STICKS AND THIS IS VERY DANGEROUS.
IN DECEMBER CHRYSLER MAILED AN "IMPORTANT SAFETY RECALL" P65/NHTSA 14V-635. WHEN I CALLED MY LOCAL DODGE RAM DEALERSHIP TO SCHEDULE AN APPOINTMENT TO CORRECT THE SAFETY ISSUE, THEY TOLD ME THE PARTS WERE NOT AVAILABLE. FOR MORE INFORMATION I WOULD HAVE TO CALL CHRYSLER. ON 12/26/14 I WAS TOLD BY CHRYSLER THE PARTS WOULD BE AVAILABLE APRIL 2015. ON MAY 1ST, I RECEIVED A SUBSEQUENT "IMPORTANT SAFETY RECALL" P65/NHTSA 14V-635 FROM CHRYSLER, SO I CALLED MY LOCAL DOGE RAM DEALERSHIP TO SCHEDULE THE APPOINTMENT. I WAS TOLD AGAIN THE PARTS ARE NOT AVAILABLE AND I WOULD HAVE TO CALL CHRYSLER TO GET MORE INFORMATION. I DO NOT BELIEVE CHRYSLER IS TAKING THIS IMPORTANT SAFETY RECALL SERIOUSLY. THAT BEING SAID, ON THE SAFETY NOTICE IT SAYS "A LEAKING DIESEL FUEL FILTER/HEATER COULD CAUSE UNDER HOODSMOKE AND/OR AN ENGINE COMPARTMENT FIRE". *TR
TL* THE CONTACT OWNS A 2012 DODGE RAM 2500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V635000 (ENGINE AND ENGINE COOLING, FUEL SYSTEM, DIESEL); HOWEVER, THE PART NEEDED TO REPAIR THE VEHICLE WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
TL* THE CONTACT OWNS A 2012 DODGE RAM 2500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V635000 (ENGINE AND ENGINE COOLING, FUEL SYSTEM, DIESEL). TWO DEALERS STATED THAT THE PART NEEDED WAS NOT AVAILABLE. THE DEALER DID NOT PROVIDE A SPECIFIC DATE FOR WHEN THE PART WOULD BECOME AVAILABLE. THE MANUFACTURER WAS CONTACTED AND COULD NOT PROVIDE AN ESTIMATED DATE FOR WHEN THE VEHICLE WOULD RECEIVE THE RECALL REPAIR. THE CONTACT HAD NOT EXPERIENCED A FAILURE. UPDATED 7/13/15*CN
TL* THE CONTACT OWNS A 2012 DODGE RAM 2500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER:14V635000 (ENGINE AND ENGINE COOLING, FUEL SYSTEM, DIESEL); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
TL* THE CONTACT OWNS A 2012 DODGE RAM 2500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V635000 (ENGINE AND ENGINE COOLING, FUEL SYSTEM, DIESEL); HOWEVER, THE PART NEEDED TO REPAIR THE VEHICLE WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. UPDATED 6/11/15*CN
TL* THE CONTACT OWNS A 2012 DODGE RAM 2500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER:14V635000 (ENGINE AND ENGINE COOLING, FUEL SYSTEM, DIESEL); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. UPDATED 5/28/15 *TA THE VEHICLE WAS REPAIRED UNDER RECALL. UPDATED 11/23/2015*JS
TL* THE CONTACT OWNS A 2012 DODGE RAM 2500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V635000 (ENGINE AND ENGINE COOLING, FUEL SYSTEM, DIESEL); HOWEVER, THE CONTACT WAS UNABLE TO HAVE THE VEHICLE SERVICED UNDER THE RECALL BECAUSE THE PART NEEDED WAS UNAVAILABLE TO PERFORM THE REPAIR. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. UPDATED 6/8/15*CN
TL* THE CONTACT OWNS A 2012 DODGE RAM 2500. THE CONTACT RECEIVED A NOTICE FOR NHTSA CAMPAIGN NUMBER: 14V635000 (FUEL SYSTEM) HOWEVER THE PART TO DO THE REPAIR WAS NOT AVAILABLE. THE CONTACT FELT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
I WAS DRIVING AT 60 MPH WHEN I HAD TO COME TO A STOP BECAUSE OF TRAFFIC AND THE THROTTLE APPARENTLY DID NOT DISENGAGE CAUSING ME TO SLAM ON THE BRAKES HARD. ONLY AFTER A FEW SECONDS WHEN I STOPPED DID THE VEHICLE DOWNSHIFT AND RETURNED TO IDLE FUNCTION.THIS HAS HAPPENED BEFORE AND SINCE THIS INCIDENT.THE VEHICLE HAS ALSO IDLED HIGH AT TIMES AND WILL NOT SLOW DOWN WHEN REMOVING PRESSURE TO THE FUEL PEDAL.IT IS AS IF THE THROTTLE ASSEMBLY STICKS WHICH IS AN APPARENT ELECTRICAL MALFUNCTION.THIS IS AND HAS BECOME A SERIOUS SAFETY ISSUE WITH THIS VEHICLE. I HAVE MADE A COMPLAINT BEFORE AND CONTACTED DODGE RAM ABOUT THIS WITH NO SATISFACTION.I WILL BE DRAFTING A REGISTERED LETTER TO NHTS BOARD AND DODGE RAM RELEASING LIABILITY FROM THIS ISSUE UNTIL IT IS RESOLVED. I ALSO HAVE A RECALL ABOUT THE FUEL FILTER HEATER FROM DECEMBER AND STILL THE MANUFACTURE HAS NOT PROVIDED THE PARTS SO AS TO FIX THIS PROBLEM WHICH CAN CAUSE FIRES IN THE ENGINE COMPARTMENT. *TR
TL* THE CONTACT OWNS A 2012 DODGE RAM 2500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V635000 (ENGINE AND ENGINE COOLING, FUEL SYSTEM, DIESEL); HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. MA 08/05/15
RECALL P65, RECEIVED NOTICE IN OCT. 2014, CONTACTED DODGE DAY LETTER WAS RECEIVED. ASKED IF VEHICLE WAS SAFE TO DRIVE AT WHICH TIME THEY STATED "WE CAN NOT TELL YOU IF YOUR VEHICLE IS SAFE OR NOT", ASKED TO SCHEDULE SERVICE AND INFORMED NO PARTS AT THIS TIME...FAST FORWARD 5 MONTHS..ON THE DODGE WEBSITE IT CLEARLY STATES MY VEHICLE MUST BE INSPECTED FOR FUEL LEAK ON THIS RECALL...SO I CALL DODGE AND ONCE AGAIN I'M TOLD NO PARTS YET, THEY DON'T EVEN KNOW WHAT PARTS ARE NEEDED, SO I ONCE AGAIN ASKED IF THE VEHICLE WAS SAFE TO DRIVE AND THAT I WON'T HAVE AN ENGINE FIRE AND RECEIVED THE SAME RESPONSE AS LAST TIME...I ASKED IF AT LEAST MY VEHICLE CAN BE INSPECTED TO SEE IF IT HAS A FUEL LEAK SO I KNOW IF IT'S SAFE TO DRIVE AND THE RESPONSE WAS NO, SINCE NO PARTS, "ITS A LIABILITY ISSUE IF THEY INSPECT AND DON'T HAVE PARTS".....NOR WILL THEY PROVIDE A RENTAL AND GUESS WHAT IF IT CATCHES FIRE THEY WON'T PAY FOR IT...I DIDN'T SPEND OVER 50K TO HAVE A LAWN DECORATION, I BOUGHT THE VEHICLE TO DRIVE! *TR
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .