2012 Dodge Ram 2500 Problems

The contact owns a 2012 Ram 2500. The contact stated while driving at an undisclosed speed, the vehicle drove over a bump in the roadway and started to shake violently. The vehicle was taken to an independent mechanic where it was determined that the reinforcement bracket over the front track bar bracket had failed and needed to be replaced. The vehicle was repaired; however, the failure recurred. Neither the dealer nor the manufacturer were notified of the failure. The failure mileage was approximately 205,000.

Tie rod end sheared/broke causing the vehicle to be un-stearable. Fortunately, it happened as I was backing out of my driveway.

The switch to start the vehicle has to be pushed down and turned at the same time. Vehicle starts but shuts the engine down when the key returns sometimes. On one occasion vehicle shut down while driving.

The contact owns a 2012 Ram 2500. The contact stated the vehicle failed to start intermittently. The contact also stated that the air bag warning light was illuminated. The vehicle was taken to the local dealer and the dealer was made aware of the failure. The vehicle was not repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 168,000.

We purchased our 2012 Dodge Ram heavy duty with tow package new. At just over 152000 miles, the engine started knocking while on vacation. We were not towing at the time. We put in injector cleaner to try and help the knocking. During our vacation, we were on the freeway when we suddenly lost power, the service engine light popped on, and the engine died. We were literally driving one minute and the next were trying to get out of the traffic lane with no control. We restarted the engine, the knocking had stopped and power was restored. Two days later, another episode of power decrease but with no engine service light. We used premium gas, injector cleaner and listened for the knocking that came and went, to drive home. We were told by our local dealership it is a lifter failure and the truck needs a replacement engine.

The contact owns a 2012 Ram 2500. The contact stated the vehicle failed to start intermittently. The contact also stated that the air bag warning light was illuminated. The vehicle was taken to the local dealer and the dealer was made aware of the failure. The vehicle was not repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 168,000.

My passenger headlights keeps going in and out. The wiring harness has been replaced twice and it still does it. My check engine light keeps coming on for the evap system even though its been replaced.

Our 2012 RAM 2500 truck with 135k miles, had it's fuel tank fail. The dealership in Oak Ridge, TN tested the vehicle and found that the gas tank tubes were broken causing us to not be able to fill the tank. The dealership recommended "NEED TO REPLACE GAS TANK". Mopar aka Stellantis does not make the fuel tank anymore, the "replacement" fuel tank does not work (completely wrong configuration), there is not an aftermarket tank. We have a Million Mile bumper to bumper warranty with MOPAR. "Customer Care" does not care.

Recall T79 or 17V-821 or break transmission shift pin stuck in open position. This is the 2nd time this has happened and serious damage has occurred to the vehicle. Dodge won't do anything about it. Vehicle was parked, turned off, no key. I came out of building and it shifted into gear on its own and rolled backwards into a pole.

The contact owns a 2012 Ram 2500. The contact stated while the vehicle was parked, the vehicle rolled away. The contact was standing near the vehicle with the key fob. There were no warning lights illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The contact related the failure to NHTSA Campaign Number: 17V821000 (Power Train). The manufacturer was not contacted. The failure mileage was approximately 220,000.

When driving at highway speed, if I hit the seam between the road and a bridge and it is not smooth my truck goes into a, "Death wobble." The steering wheel and the whole truck shakes uncontrollably. I can barely keep it in the road. It will only stop when the vehicle slows below 30mph. This problem started about 48,000 miles, I only have a little over 56,000 now. I have changed the stabilizer, got new tires and an alignment. I will be taking it to a mechanic on the 17th but I really believe the manufacture should have a recall on this vehicle. It is very dangerous. I am not the only person to own one of these trucks and this happens to.

TL* THE CONTACT OWNS A 2012 RAM 2500. THE CONTACT STATED WHILE DRIVING AT AN UNKNOWN SPEED THE TRACK BAR BUSHING FELL APART AND CAUSED EXCESSIVE SHAKING WITHOUT WARNING. THE CONTACT HAD TO PULL THE VEHICLE TO THE SIDE OF THE ROAD FOR SEVERAL MINUTES. THE CONTACT DROVE THE VEHICLE TO THE RESIDENCE. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR A DIAGNOSTIC TEST OR REPAIRS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE HOWEVER, NO ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 135,000.

PLEASE LOOK INTO ABS MODULE AND HCU FAILURES REQUIRING REPLACEMENT. I SPOKE WITH DODGE AND THEY STATED IT IS A KNOW PROBLEM AND REQUIRES REPLACEMENT OF PARTS. THE ANTI LOCK BRAKING SYSTEM AND HYDRAULIC CONTROL UNIT HAVE BEEN FAILING ON RAM 2500 AND 3500 SINCE 2006. MY TRUCK IS A 2012 WITH JUST 35972, (NOT A DAILY DRIVEN TRUCK SO YES LOW MILES) MILES ON IT AND IS FAILING. THIS FAILURE CAUSES THE CRUISE CONTROL TO STOP FUNCTIONING. PLEASE LOOK INTO RAM FORUMS AND READ ALL THE COMPLAINTS AND LOOK AT THE VARIATIONS IN YEARS, IF THIS IS A KNOW PROBLEM THAT CAN CAUSE THE ABS TO FAIL HOW ARE THEY NOT REPAIRING THIS. THIS TRUCKNIS STILL ON THE FACTORY INSTALLED BRAKES

FACTORY INSTALLED TRAILER BREAKS DO NOT WORK, I TOW A 10,000# TRAILER THAT I CANT TOW WITHOUT TRAILER BREAKS. CALLED DODGE @1-866-726-4636, THAY KNOW OF THE PROBLEM BUT CANT FIX IT. THIS WILL EVENTULY LEAD TO AN ACCIDENT.I WAS ON THE C.A. 101 NORTH AND HAD NO TRAILER BREAKS THIS IS DANGEROUS

The contact owns a 2012 Ram 2500. The contact stated the vehicle failed to start intermittently. The contact also stated that the air bag warning light was illuminated. The vehicle was taken to the local dealer and the dealer was made aware of the failure. The vehicle was not repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 168,000.

AIRBAG LIGHT ON; AIRBAG INOP. RECALL THAT HAVE BEEN IDENTIFIED TO BE EFFECT THE 2013 MODELS ALSO EFFECT THE 2012 MODELS.

FRAME BROKE IN 3 SPOTS, ALONG WITH A FRAME AND WHEEL BEARINGS, GEAR CONTROL BOX, ALIGNMENT, THE TRUCK BODY MOVES WHEN TURNING NOT THE WHEELS. THE TIRE STABILIZER HASN'T TURNED OFF IN OVER A YEAR AFTER POURING THOUSANDS OF DOLLARS IN REPAIRS.. TRUCK IS UNDRINKABLE AND NOT EVEN 10 YEARS OLD. *TR

R03 (REPLACES L25) WIRELESS IGNITION NODE (WIN) MODULE WIN MODULE FAILURE. WHEN DRIVING THE VEHICLE IN MOTION, THE ENGINE AND POWER SHUTS OFF TO THE VEHICLE, CAUSING LOSS OF POWER STEERING AND BRAKING POWER. THIS HAPPENED TO ME WHILE DRIVING ON THE FREEWAY. THIS HAS BEEN RECALLED DUE TO THE SAME SITUATION ON MULTIPLE OTHER DODGE/CHRYSLER VEHICLES THAT HAVE THE SAME WIN MODULE PART/PART# AS MY 2012 RAM. 'THE WIRELESS IGNITION NODE (WIN) MODULE ON THESE VEHICLES MAY HAVE UNINTENTIONAL MOVEMENT OF THE FREQUENCY OPERATED BUTTON IGNITION KEY, OR FOBIK, FROM THE 'ON' TO THE 'ACCESSORY' POSITION WHILE DRIVING. THIS COULD CAUSE UNINTENDED ENGINE SHUT OFF AND INCREASE THE RISK OF A CRASH.' HTTPS://STATIC.NHTSA.GOV/ODI/RCL/2016/RCMN-16V240-9929.PDF

My passenger headlights keeps going in and out. The wiring harness has been replaced twice and it still does it. My check engine light keeps coming on for the evap system even though its been replaced.

MY PASSENGER HEADLIGHT WORKS INTERMITTENTLY. THE BULB IS GOOD. THE WIRING HARNESS INSIDE OF THE HOUSING HAS BEEN CHANGED AND DID NOT SOLVE THE ISSUE. IT WILL WORK FOR A MONTH OR SO THEN NOT WORK.

FRAME BROKE IN 3 SPOTS, ALONG WITH A FRAME AND WHEEL BEARINGS, GEAR CONTROL BOX, ALIGNMENT, THE TRUCK BODY MOVES WHEN TURNING NOT THE WHEELS. THE TIRE STABILIZER HASN'T TURNED OFF IN OVER A YEAR AFTER POURING THOUSANDS OF DOLLARS IN REPAIRS.. TRUCK IS UNDRINKABLE AND NOT EVEN 10 YEARS OLD. *TR

TL* THE CONTACT OWNS A 2012 RAM 2500. THE CONTACT STATED THAT ON SEVERAL OCCASIONS WHILE DRIVING AT APPROXIMATELY 30 MPH, THE VEHICLE LIFTERS DETACHED. IN ADDITION, THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE CONTACT MENTIONED THAT THE VEHICLE MISFIRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FUEL INJECTOR, THE SPARK PLUGS, AND COIL NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN A RECALL. THE FAILURE MILEAGE WAS APPROXIMATELY 115,000.

I purchased a pair of Treadwright warden tires for the rear of my wife’s truck. In less than 100 miles the tread separated from the casing on one of the tires. I caught it before it completely blew out and have pictures. The replacement they sent has a blown sidewall. I mounted it and a bubble started to form that was 1/2” high and 3” around with just 20psi, operating PSI for the tire is 80PSI. I immediately stopped inflation and contacted Treadwright. They tried to convince me that it was “overlap” and safe to use. I told them it is not over lap and showed them multiple pictures of the tire from different angles to prove it has a blown belt. They still insisted it was a serviceable tire. It’s not and I have pictures. I’ve used Treadwright tires for the last 5 or so years. Over the last year and a half to 2 years I’ve received 6 defective tires. All defects were fatal defects, all being broken belts. That’s 1 out of every 4.5 tires purchased. If I’ve received that many fault tires I can be the only one. On top of that the insistence of Treadwright trying to convince people to use fatally defective tires is negligent, reckless and dangerous.

The contact owns a 2012 RAM 2500 equipped with Kenda Tires, Tire Line: Klever, Tire Size: LT275/70/R18, DOT Number: 02T6NAANL12228260. The contact stated while driving 60 MPH, the vehicle started bouncing. The contact stated no warning light was illuminated. The contact continued to drive back to the tire shop and was informed that the front passenger’s side tire was showing tread separation. The tire shop replaced the front passenger’s side tire. The contact stated that approximately two weeks later, he experienced the same failure with the front driver’s side tire. The contact took the vehicle back to the tire shop and had the front driver’s side tire replaced with the spear tire. The vehicle was not diagnosed or repaired. A dealer was not contacted. The contact stated that he had left a voicemail with the manufacturer but had not yet received a callback. The failure mileage was approximately 151,000.

DRIVING DOWN THE ROAD THE TRUCK SHAKES SO BAD YOU HAVE TO GET STOPPED BEFORE IT GOES AWAY. ALMOST FELT LIKE I WAS GOING TO FLIP THE TRUCK

TL* THE CONTACT OWNS A 2012 RAM 2500. THE CONTACT STATED THAT THE REAR AXLES SEIZED AND THE REAR TIRES SLID WHILE OPERATING THE VEHICLE. THE VEHICLE SLID OFF THE ROAD DUE TO THE FAILURE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE DEALER WAS NOT CONTACTED. THE CONTACT WAS A MECHANIC AND DIAGNOSED THAT THE VEHICLE NEEDED A FILL PLUG AND NEW GEAR OIL. THE VEHICLE WAS NOT REPAIRED BECAUSE THE CONTACT DID NOT HAVE THE PROPER FILL COVER FOR THE FILL PLUG. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT ASSIST. THE DEALER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 50,000. THE VIN WAS UNKNOWN.

TL* THE CONTACT OWNS A 2012 RAM 2500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 17V821000 (POWER TRAIN); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER (CHARLIE'S DODGE CHRYSLER JEEP RAM IN MAUMEE, OH, (419) 893-0241) WAS CONTACTED AND CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS NOT NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

TL* THE CONTACT OWNS A 2012 DODGE RAM 2500. THE CONTACT STATED THAT WHILE ACCELERATING AT 50 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS ABLE TO RESTART. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED ON MULTIPLE OCCASIONS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 1,500.

DRIVING DOWN THE INTERSTATE AT APPROXIMATELY 70 MPH WHEN THE VEHICLES IN FRONT OF THE TRUCK SLAMMED ON BRAKES. I WAS ROUGHLY 30 FT BEHIND THE VEHICLE IN FRONT OF ME. I SLAMMED ON MY BRAKES AND THE PEDAL FELT SPONGY BEFORE GOING TO THE FLOOR. THE TIRES DID NOT LOCK UP, AND THE TRUCK SLOWED 20MPH IN ABOUT 30 FT. THE TRUCK MADE IMPACT WITH A CHEVROLET TAHOE AT 50 MPH. THE AIRBAGS FAILED TO DEPLOY AND THE SEATBELT FAILED TO LOCK, THROWING MY KNEES INTO THE DASH. THE CHEVROLET TAHOE WAS TOTALED. THE CURRENT ESTIMATE TO REPAIR THE RAM IS $5,448. THE BUMPER, DRIVER FENDER, GRILLE, AND HOOD WERE DAMAGED. UPON REMOVING THOSE ITEMS THE SHOP FOUND ALMOST EVERY BRACKET IN THE FRONT END HAD BEEN BROKEN AND THE FRAME HORNS BENT UPWARDS FROM THE COLLISION. THE IMPACT WAS HARD ENOUGH TO BREAK A RATCHET STRAP IN THE BED OF THE TRUCK, SENDING A LADDER THAT I WAS CARRYING INTO THE CAB CORNER, LEAVING A SOFTBALL SIZED DENT. WE WERE ABLE TO DRIVE AWAY FROM THE INCIDENT AND THE BRAKES WERE FUNCTIONAL ON THE TRIP TO THE BODY SHOP, HOWEVER ANY ATTEMPT TO DEPRESS THE PEDAL RAPIDLY WOULD RESULT IN A SPONGY PEDAL. MILEAGE AT THE TIME OF THE INCIDENT WAS 81,110. RAM WAS CONTACTED AND AFTER A WEEK OF BACK AND FORTH RAM AGREED TO SEND SOMEONE TO INSPECT THE VEHICLE TO DETERMINE IF THERE IS A FAULT IN THE TRUCK.

TL* THE CONTACT OWNS A 2012 RAM 2500. WHILE DRIVING APPROXIMATELY 55 MPH, THE BRAKES FAILED WHEN THE BRAKE PEDAL WAS DEPRESSED. AS A RESULT, THE CONTACT'S VEHICLE CRASHED INTO THE OTHER VEHICLE. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT STATED THAT THE SEAT BELT FAILED TO SECURE THE DRIVER. THE CONTACT SUSTAINED NECK AND LOWER BACK INJURIES THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO A TOW LOT AND A COLLISION CENTER WHERE THE VEHICLE WAS REPAIRED FOR THE BODY DAMAGE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 71,994. ..UPDATED 12/11/17 *BF *CN

ON MONDAY 9-2-2013 I DROPPED OF MY TRUCK AND TOOK MY CAR FOR A RIDE. WHEN I RETURNED TO GET MY TRUCK FOR WORK I REALIZED THAT THE CENTER DASH HAD CAUGHT ON FIRE.THE TRUCK WAS FULL OF SMOKE SO I DISCONNECTED THE BATTERY AND CALLED MY INSURANCE COMPANY. ON 9-3-2013 I CONTACTED CHRYSLER CORPORATION TO REPORT THE INCIDENT BUT I AM NOT GETTING ANY CALL BACKS FROM THEM SO KNOW IM LETTING THE INSURANCE COMPANY HANDLE IT.I HAVE OBTAINED A SURVEILLANCE TAPE COPY OF THE FIRE. *TR

THE SPRAY NOZZLES ON ALL DODGES ARE BREAKING WAY BEFORE THEY SHOULD. THE HARD PLASTIC NOZZLE BREAKS WHERE IT IS ATTACHED TO THE FLUID TUBE. THIS MAKES IT SO THE NOZZLE DOES NOT SPRAY THE WINDSHIELD TO CLEAN IT WITH THE WIPERS. MY TRUCK IS ONLY 5 YEARS OLD AND BOTH NOZZLES HAVE BEEN REPLACED. THERE ARE MANY OTHER DODGE OWNERS WITH THIS PROBLEM, MANY VIDEOS TO SEE ON YOUTUBE.