Owner-reported complaints naming the electrical system, filed with NHTSA
Data refreshed
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories. Every record below is an owner-reported complaint about the 1998 Dodge Ram 3500 submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 9 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Shown in the owner’s own words, exactly as filed
AT LEAST THE THIRD TIME I HAVE REPLACE THE HEADLIGHT SWITCH, TWICE THE HARNESS BECAUSE IT MELTED TOGETHER. AND NOW TODAY HAVING TO REPLACE MARKER WIRE (GREEN WITH WHITE STRIPE) AND IT IS TO HOT TO TOUCH, THE WIRE HAS GONE STIFF AND HARD AND I AM AFRAID IT WILL CAUSE A FIRE THIS TIME.
TL* THE CONTACT OWNS A 1998 DODGE RAM 3500. THE CONTACT STATED THAT THE HEADLIGHTS AND RUNNING LIGHTS FAILED TO ACTIVATE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE WIRING MELTED TO THE CONNECTOR AND THE INTERNAL SWITCH WAS MELTED. THE VEHICLE WAS REPAIRED BUT THE FAILURE PERSISTED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.
DASHBOARD CRACKED AND CAVED IN WHEN I HIT A BUMP WHILE DRIVING APPROX 68 MPH ON THE FREEWAY (I- 15 NORTHBOUND THROUGH LAS VEGAS). PLASTIC FALLING INTO THE DASHBOARD AREA DISCONNECTED SEVERAL WIRES CAUSING THE HEADLIGHTS TO GO OUT AS WELL AS SEVERAL OTHER ELECTRICAL ACCESSORIES. FREEWAY WAS WELL LIT ENOUGH FOR ME TO STOP SAFELY AND CALL FOR ASSISTANCE. *TR
ON THREE DIFFERENT OCCASIONS THE RETAINING NUT FOR FIFTH-GEAR HAS FAILED. DEALER OFFERED REPAIR KIT... CONTAINED NEW MAIN SHAFT FOR TRANNY. COST WAS $3600.00, CHRYSLER REFUSES TO ACKNOWLEDGE DEFECT IN MANUFACTURING OF THREAD TAPERING. THERE IS ALSO NO POWER BRAKES. ABS SEEMS TO NOT BE WORKING, RELIES ON PRESSURE FROM OIL TO BRAKE. IF PRESSED CONTINUOUSLY, WILL GO ALL THE WAY TO THE FLOOR. WIRING HARNESS BURNED UP AFTER DEALER WORK, FRANK SHOUPE OF GEORGETOWN KENTUCKY REFUSED TO REPAIR THEIR MISTAKE. SAID IT WAS MY FAULT, THEN REFUSED TO KEEP SPEAKING WITH ME. STATED REPLACEMENT WAS $2015.00, AND WOULD TAKE A WEEK;RECEIVED ONE FROM JUNKYARD IN MONTANA, TOOK THREE DAYS, AND $300.00. *TR
DT*: THE CONTACT STATED AFTER THE VEHICLE WAS PARKED FOR TWO DAYS, THE ALARM SUDDENLY SOUNDED. BY THE TIME THE DOOR WAS OPENED, SMOKE HAD FILLED THE CAB. THE VEHICLE WAS TOWED TO THE DEALER WHO DETERMINED THE WIRING HARNESS UNDER THE DRIVER SEAT SHORTED OUT CAUSING THE WIRES TO BURN. THE DEALER REPLACED THREE WIRING HARNESSES, THE FUSE BOX AND THE FUSES.
DT: THE CONTACT STARTED VEHICLE IN ORDER TO MOVE IT. THEN, HE TURNED THE VEHICLE OFF. THE STARTER KEPT RUNNING, CAUSING THE VEHICLE TO CATCH ON FIRE. THE FIRE WAS EXTINGUISHED. THE VEHICLE WAS TOWED TO A DEALERSHIP TO BE INSPECTED. THEY FOUND THE FUEL SHUT OFF SOLENOID SHORTED OUT. THE MANUFACTURER WAS CONTACTED.*AK
1998-2001 B-VAN (DODGE FULL SIZE) BS CONTROL MODULE IS PROTECTED WITH A 40 AMP FUSE. A 10 GA. WIRE COMES OUT OF THE CONTROL MODULE THEN THE WIRE "Y"'S OUT TO TWO 14 GA. WIRES. IT APPEARS AS THOUGH THE ABS PUMP OR RELAY STICKS ON THESE VEHICLES. THEN ONE OF THE 14 GA. WIRES OVER HEATS AND STARTS THE WIRING HARNESS ON FIRE. THE 40 AMP FUSE DOES NOT BLOW. THE FIRE CONTINUES UNTIL THE ENTIRE VAN IS FULLY ENGULED IN FLAMES.*AK
THE ELECTRICAL WIRES BECAME VERY HOT AND MELTED, AND SHORTED OUT THE HEAD LIGHT SWITCH AND DISABLED THE PARKING LIGHTS. *JB *TS
WHILE DRIVING VEHICLE CAUGHT ON FIRE IN THE ENGINE COMPARTMENT DUE TO A MALFUNCTION WITHIN THE MAIN FUSE WIRING HARNESS. PLEASE GIVE ANY FURTHER DETAILS. *AK
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .