2004 WORKHORSE PACE ARROW RV. CONSUMER WRITES IN REGARDS TO BRAKE CONCERNS RECALL NOTICE. *SMD THE CONSUMER STATED IN 2010, WHILE HIS SON WAS DRIVING THE RV, HE EXPERIENCED A TOTAL LOSS OF BRAKE FAILURE. THE RV WAS TAKEN TO A REPAIR SHOP, BUT NO PROBLEM WAS FOUND. THE RECALL WAS PERFORMED IN AUGUST 2011. AFTER THE RECALL WAS PERFORMED, THE BRAKES AND CALIPERS HAD TO BE REPLACED AGAIN. THE REPAIR SHOP STATED THE BRAKES WERE SIGNIFICANTLY INADEQUATE. THE CONSUMER STATED THE RECALL, DID NOT ELIMINATE THE PROBLEM. *JB
- NHTSA ID
- 10566139
- Incident
- Feb 3, 2014
MOTORHOME 2004 PACE ARROW 36R, SAFETY RECALL 51101-C. AT THE TIME THE CALIPERS WERE REPLACED, CRACKED ROTORS WERE FOUND AND HAD TO BE REPLACED BECAUSE IT WAS NOT SAFE TO DRIVE. *TR
- NHTSA ID
- 10396595
- Incident
- Dec 28, 2010
- Mileage
- 37,011 mi
TL*THE CONTACT OWNS A 2004 FLEETWOOD PACE ARROW. THE CONTACT STATED THAT THE BRAKE CALIPERS WERE REPLACED UNDER WARRANTY BUT ALL FOUR ROTORS HAD A QUARTER INCH SIZED CRACK. THE CONTACT HAD TO PAY OUT OF POCKET TO REPLACE THE ROTORS. THE MANUFACTURER HAD NOT BEEN NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 42,000.
- NHTSA ID
- 10366581
- Incident
- Oct 1, 2010
- Mileage
- 42,000 mi
UNDER NORMAL DRIVING CONDITIONS THE BRAKES ON MY 2004 FLEETWOOD PACE ARROW MOTORHOME (WORKHORSE CHASSIS)WILL PERIODICALLY NOT RELEASE AFTER BEING USED TO SLOW OR STOP THE MOTORHOME. THIS CAUSES SEVERE OVERHEATING AT THE EFFECTED BRAKE AND NECESSITATES TO PULL OFF THE ROAD, LET THE BRAKE COOL, AND HOPE IT RELEASES. THE FIRST INCIDENT OCCURRED AROUND APRIL 2009 AND I THOUGHT MAYBE IT WAS DUE TO STOP AND GO TRAFFIC BUT I WAS SUSPICIOUS OF THE SMELL OF BURNING BRAKES. I RECEIVED THE FIRST SAFETY RECALL NOTICE FROM WORKHORSE IN APRIL OF 2009, BUT NO PARTS WERE AVAILABLE TO FIX THE PROBLEM. I HAD BEEN ADVISED BY A WORKHORSE SERVICE CENTER THAT IF I TAP ON THE OVERHEATED BRAKE WITH A HAMMER IT MAY RELEASE SOONER (NORMAL COOL-DOWN TIME WOULD BE ABOUT 1 TO 1 1/2 HOURS . THE FOURTH INCIDENT OCCURRED IN EARLY OCT 2009 AND WAS QUITE SEVERE. WHEN I TAPPED ON THE BRAKE WITH A HAMMER, BURNING EMBERS FELL FROM THE BRAKE. I LET IT COOL AWHILE AND THEN BEGAN TO POUR WATER ON IT. I COOLED IT WITH WATER FOR ABOUT 1 HOUR AND FINALLY IT RELEASED. TOTAL TIME OFF THE ROAD WAS AROUND 2 1/2 HOURS. THE NEXT DAY I CALLED MY LOCAL AUTHORIZED WORKHORSE SERVICE CENTER (KELLEY CHEVROLET) AND MADE AN APPT.. UPON EXAMINING THE PROBLEM, KELLEY DETERMINED THAT THE VISIBLE CRITERIA ON THE BRAKE DID NOT MATCH THE CRITERIA FOR THE RECALL. KELLEY CALLED THE WORKHORSE REP WHO SUGGESTED TO LUBRICATE THE SLIDERS, WHICH KELLEY DID. (MY $200 EXPENSE) I PUT THE MOTORHOME IN STORAGE IN MID OCT 2009. I RECEIVED AN INTERIM RECALL NOTICE FROM WORKHORSE DECEMBER 2009 STATING THE PARTS ARE STILL NOT AVAILABLE. I RE-ACTIVATED THE MOTORHOME EARLY APRIL 2010 TO PREPARE FOR MY APRIL 16 TRIP. THE NORMAL 2 1/2 HOUR TRIP TOOK ABOUT 4 1/4 HOURS AS I WAS OFF THE ROAD POURING WATER ON THE BRAKES. I CALLED WORKHORSE WHO SAID THEY CAN ONLY AUTHORIZE WORK PER THE RECALL. I TOOK THE RV BACK TO KELLY APRIL 19. I AM IN CONSTANT FEAR OF A FIRE OR LOOSING BRAKES ALTOGETHER CAUSING AN ACCIDENT. LEGAL ACTION WILL BE TAKEN IF NEED. *TR
- NHTSA ID
- 10326914
- Incident
- Apr 18, 2009
- Mileage
- 38,000 mi
TL* THE CONTACT OWNS A 2004 FLEETWOOD PACE ARROW RV, WITH A WORKHORSE CHASSIS. AFTER EXITING THE VEHICLE THERE WAS A STRONG BURNING ODOR COMING FROM THE PASSENGER SIDE REAR WHEEL. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC FOR INSPECTION. THE FAILURE WAS CONTRIBUTED TO THE BRAKES LOCKING. THE REAR PASSENGER ROTORS WERE RESURFACED. THE VEHICLE IDENTIFICATION NUMBER WAS EXCLUDED FROM RECALL CAMPAIGN ID NUMBER 09V198000 (SERVICE BRAKES, AIR). THE FAILURE MILEAGE WAS 21,776. THE CURRENT MILEAGE WAS 43,988. UPDATED 2/17/10 *CN UPDATED 02/22/10
- NHTSA ID
- 10297539
- Incident
- Feb 14, 2007
- Mileage
- 21,776 mi
SMELLED BURNING THEN ABS LIGHT CAME ON. BRAKES WENT TO THE FLOOR WHEN I TRIED TO STOP. HAD TO PUMP BRAKES TO STOP. STOPPED AND CHECKED FLUID, ETC., COULD FIND NO PROBLEM. CONTINUED ON OUR WAY WITHOUT INCIDENT, BUT ABS LIGHT STAYED ON. *TR
- NHTSA ID
- 10244103
- Incident
- Sep 29, 2008
- Mileage
- 10,840 mi
TL- THE CONTACT OWNS A 2004 FLEETWOOD PACE ARROW. THE CONTACT STATED THAT ON 2 SEPARATE OCCASIONS WHILE DRIVING APPROXIMATELY 50 MPH THE ABS LIGHT ILLUMINATES ON THE DASH BOARD, HE SMELLED BURNING RUBBER AND THE VEHICLE DID NOT STOP WHILE PUMPING THE BRAKE. THE CONTACT HAD TO CONTINUE TO PUMP THE BRAKES AND VEER OVER TO THE SIDE OF THE ROAD TO STOP THE VEHICLE. THE CURRENT MILEAGE IS 150000 AND THE FAILURE MILEAGE WAS 149400. JP UPDATED 10/03/08 *BF THE CONSUMER STATED HE HAD A PROBLEM WITH THE FRONT AND REAR BRAKES. UPDATED 10/06/08. *JB
- NHTSA ID
- 10240885
- Incident
- May 19, 2008
- Mileage
- 14,400 mi
WHILE DRIVING MY 2004 PACE ARROW MOTORHOME, MY ABS WARNING LIGHT CAME ON; WHEN I STOPPED TO CHECK OUT THE VEHICLE, I NOTED THAT THE RIGHT FRONT WHEEL WAS SMOKING. IMMEDIATELY DROVE 12 MILES TO AN RV SERVICE FACILITY, WHERE IT WAS DISCOVERED THAT THE BRAKE CALIPER HAD FROZEN IN AN ENGAGED POSITION, OVERHEATING THE WHEEL COMPONENTS AND DISABLING THE ABS SYSTEM FOR ALL 4 WHEELS. UPON FURTHER INVESTIGATION, I FOUND THAT WORKHORSE, THE CHASSIS MFR. FOR MY RV, HAD ISSUED A SAFETY RECALL FOR FAULTY BRAKE CALIPERS FOR THE 3 MODEL YEARS PRECEDING MY UNIT. THE SERVICE FACILITY REPLACED THE FOLLOWING PARTS: R/F CALIPER, WHEEL SPEED SENSOR, FRONT WHEEL CAP, WHEEL SEAL, BRAKE PADS, BRAKE FLUID. *TR
- NHTSA ID
- 10229295
- Incident
- May 22, 2008
- Mileage
- 26,039 mi
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.