1995 Ford Aerostar Owner Complaints

TL* THE CONTACT OWNS A 1995 FORD AEROSTAR. AFTER REFUELING THE VEHICLE, THE CONTACT DETECTED A STRONG FUEL ODOR AROUND THE VEHICLE. THE CONTACT DISCOVERED THAT THE FUEL TANK WAS LEAKING FUEL. IN ADDITION, THE FUEL STRAP AND THE FUEL INLET WERE CRACKED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS DIAGNOSED THAT THE FUEL TANK NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 165,000.

NHTSA ID

10639902

Incident

Sep 22, 2014

Mileage

165,000 mi

TL*THE CONTACT OWNS A 1995 FORD AEROSTAR. WHILE DRIVING 20 MPH, THE VEHICLE SHUT OFF WITHOUT WARNING. THE CONTACT OPENED THE HOOD AND NOTICED THAT THE FUEL LINES WERE EXTREMELY HOT BEFORE THEY BURST INTO FLAMES. THE CONTACT SUSTAINED A BURNED RIGHT HAND. THE FIRE DEPARTMENT STATED THAT THE FUEL PUMP CAUSED THE FIRE. A POLICE REPORT WAS FILED. THE MANUFACTURER STATED THAT HIS VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 99V028000 (ELECTRICAL SYSTEM: WIRING: FRONT UNDER HOOD). THE CURRENT AND FAILURE MILEAGES WERE 150,000.

NHTSA ID

10206495

Incident

Oct 18, 2007

Mileage

150,000 mi

WENT TO INSTALL CAR SEAT IN THREE ROW, PASSENGER SIDE AND THE SEAT BELT CAME UNLATCHED. IT WILL NOT STAY BUCKLED AT ALL. WENT TO A DEALERSHIP AND THEY WANT TO CHARGE US OVER $100 FOR BUCKLE AND AN HOURS WORTH OF LABOR. WE ARE DUE IN 2 WEEKS WITH THIRD CHILD AND THAT IS THE ONLY SPOT LEFT IN THE VAN THAT THE CAR SEAT FITS IN. *NM

NHTSA ID

10161916

Incident

Jul 7, 2006

Mileage

140,000 mi

AT APPROXIMATELY 12:00 AM 6/23/06, I WAS DRIVING FROM ALBANY, TX TO DALLAS, TX ON HIGHWAY 180... AND THE TREAD ON MY RIGHT REAR TIRE SEPARATED FROM THE REST OF THE TIRE. THE TIRE IS A BRIDGESTONE TURANZA. I WAS DOING BETWEEN 70 AND 75 AT THE TIME AND THE VEHICLE WAS TOTALLY OUT OF CONTROL UNTIL I WAS ABLE TO REDUCE SPEED TO ABOUT 25. INTERESTINGLY, THE REMAINING TIRE DID NOT GO FLAT. IT WAS STILL INFLATED WHEN I CAME TO A HALT. THE TREAD TORE OFF PART OF MY REAR BUMPER AND MARKED UP THE REAR SIDE PANEL OF MY VEHICLE. I HAVE TAKEN MANY PICTURES OF THE TIRE AND OF THE DAMAGE TO MY VEHICLE. THIS IS THE THIRD TIRE OF A 4 TIRE SET THAT HAS GIVEN ME PROBLEMS. THE FIRST TWO DEVELOPED RIDGES IN THE TREAD. I REPLACED THEM LAST AUGUST. THE REAR TIRES AT THE TIME SEEMED FINE. NOW, TEN MONTHS LATER... HERE I AM ON THE HIGHWAY AND THE TREAD SEPARATES. I COULD HAVE EASILY DIED OR BEEN SERIOUSLY INJURED. IF THERE HAD BEEN TRAFFIC AT THE TIME... THERE WOULD HAVE BEEN AN ACCIDENT AS MY VEHICLE WAS ALL OVER THE HIGHWAY UNTIL THE SPEED WAS REDUCED AND CONTROL COULD BE REGAINED. *JB

NHTSA ID

10160640

Incident

Jun 23, 2006

Mileage

138,000 mi

DT: THE CALLER SAID IGNITION FAILED. SHE SAID A YEAR AGO THAT THE VEHICLE STARTED BY ITSELF WITHOUT A KEY. SHE STATED THAT CURRENTLY SHE HAD INTERMITTENT TROUBLE STARTING THE VEHICLE. THE LIGHTS ON THE DASHBOARD WILL COME ON BUT THE VEHICLE WILL NOT START. DEALER SAID VEHICLE WAS NOT RECALLED. THEY WILL NOT HELP HER FOR FREE. MANUFACTURER HAS NOT BEEN CONTACTED YET. *AK *NM

NHTSA ID

10136919

Incident

Sep 5, 2005

Mileage

111,000 mi

THE VEHICLE WAS PARKED IN THE OFFICE PARKING LOT. SUDDENLY A CUSTOMER NOTIFIED THE CONSUMER THAT THERE WAS A VEHICLE FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE MANUFACTURE WILL MAKE CONTACT WITH THE CONSUMER FOR INSPECTION. *NM *NM

NHTSA ID

10113062

Incident

Feb 23, 2005

Mileage

125,000 mi

THE INTERIOR OF THE DASH BOARD CAUGHT FIRE ON ITS OWN, WHILE THE VEHICLE WAS PARKED. MANUFACTURER WILL BE CONTACTED BY CONSUMER. *NM

NHTSA ID

10113031

Incident

Feb 23, 2005

CONSUMER ATTEMPTED TO GET THE VEHICLE RECALL 99V029000 REPAIRED. HOWEVER, THE DEALER KEPT GIVING THE CONSUMER EXCUSES WHY THEY COULD NOT FIX THE IGNITION SWITCH. *AK *SC *JB

NHTSA ID

10071645

Incident

Apr 10, 2004

Mileage

151,000 mi

HEADLIGHTS GO OFF AND ON. USE TO ONLY HAPPEN WHILE ON HIGH BEAM. BUT IS NOW DOING IT ON LOW BEAM. THIS IS THE SECOND FORD I HAVE OWNED TO DO THIS.*AK

NHTSA ID

10064311

Incident

Mar 19, 2004

Mileage

170,000 mi

REAR PASSENGER WHEEL CAME OFF OF 1995 FORD AEROSTAR EXT VAN. THE WHEEL INCLUDED THE REAR BRAKE DRUM AND BROKE THE AXLE, RESULTING IN A CRASH INTO THE HIGHWAY MEDIAN AT 60MPH.

NHTSA ID

10039513

Incident

Sep 12, 2003

Mileage

148,000 mi

SLIDING DOOR WILL EITHER NOT LATCH AT ALL OR IT WILL STAY CLOSED AND WE ARE UNABLE TO OPEN IT .

NHTSA ID

10020635

Incident

May 20, 2003

WHILE DRIVING, THE DRIVER'S SIDE DOOR PANEL BEGAN SMOKING AND THEN CAUGHT FIRE WITHOUT WARNING. THE CONSUMER PUT OUT THE FLAMES, BUT THE PANEL KEPT SMOKING. THE GROUND WIRE TO THE POWER WINDOWS HAD TO BE CUT TO STOP THE PANEL FROM SMOKING. *JB THE BURNED SWITCH ASSEMBLY WAS REPAIRED ON THE LEFT SIDE DOOR. *SCC

NHTSA ID

10017827

Incident

Apr 29, 2003

BLOW OUT AND TREAD SEPERATION ON A BF GOODRICH RADIAL T/A (P215/70SR14 96S M+S) AT HIGHWAY SPEEDS. APPROX 34,000 MILES ON THE TIRE. WHILE TRAVELING 65 MPH SOUTH ON THE SAWGRASS EXPRESSWAY (SUNRISE, FL) BETWEEN MILE MARKER 4 AND 5, MY RIGHT REAR TIRE MADE A POPING SOUND AND WENT FLAT ALMOST IMMEDIATLY (3 TO 4 SECONDS). I WAS ABLE TO GET MY VEHICLE SAFELY TO THE SIDE OF THE ROAD. THE OUTSIDE OF THE TIRE SHOWED ABOUT A 4 TO 6 INCH TREAD SEPERATION. AFTER AAA REMOVED THE TIRE, THE INSIDE OF THE TIRE SHOWED ALMOST COMPLETE TREAD SEPERATION (IT LOOKED LIKE THE TIRE HAD EXPLODED). THE SIDEWALLS APPEAR TO HAVE FAILED AS WELL. I HAD HAD THE TIRES CHECKED ABOUT TWO WEEKS PRIOR AFTER HAVING A NAIL REMOVED AND PATCHED ON THE LEFT FRONT. INFLATION WAS NORMAL. THE TEMERATURE WAS ABOUT 68 DEGREES AND I HAD BEEN AT HIGHWAY SPEEDS FOR ABOUT 20 MINUTES. THE TIRES HAD ABOUT 34,000 MILES OF WEAR ON THEM. THEY WERE REGULARLY ROTATED AND INSPECTED. THE VEHICLE IS A 1995 FORD AREOSTAR XLT. I WAS NOT ABLE TO KEEP THE TIRE, BUT I WAS ABLE TO TAKE 13 DIGITAL PICTURES OF THE FRONT, BACK AND TREAD OF THE TIRE. I WILL MAKE THEM AVAILABLE AT YOUR REQUEST (CD-ROM OR ELECTRONICALY).

NHTSA ID

10003140

Incident

Jan 17, 2003

Mileage

103,000 mi

OUR VAN WAS THE FIRST VEHICLE HIT IN A FOUR CAR PILE UP. OUR VAN AND TWO OTHER VEHICLES WERE STOPPED FOR A RED LIGHT WHEN STRUCK. OUR VAN SUSTAINED SUBSTANCIAL ENOUGH DAMAGE BOTH IN FRONT AND BEHIND TO TOTAL IT. THE DRIVERS AIR BAG NEVER DEPLOYED SO I'M HAVING TO RECEIVE SOME PHYSICAL THERAPY FOR NECK INJURIES. I WONDER IF MY AIR BAG HAD DEPLOYED WOULD I HAVE HAD TO GO THROUGH THESE DOCTORS APPOINTMENTS AND THERAPY. DO I HAVE ANY RECOURSE? DT

NHTSA ID

769792

Incident

Oct 31, 2002

SEVERE SHIMMY OF FRONT END. REPLACE BUSHINGS AND SHOCKS STILL THERE. DEALERS AND SERVICE SHOPS UNABLE TO CONFIRM COMPLAINT. FRIENDS HAVE SIMILAR PROBLEM. DT

NHTSA ID

769280

CONSUMER STATES THE VEHICLE WAS INVOLVED IN A FRONTAL COLLISION WITH A LIGHT POLE AT 27 MPH AND THE FRONTAL DRIVER AIR BAG DID NOT DEPLOYED. DEALER CONTACTED. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*JB

NHTSA ID

8019228

Incident

Sep 10, 2002

PLASTIC FUEL TANK IS CRACKING AT THE TOP WHICH IS CAUSING A MASSIVE FUEL LEAK, AND POSSIBLE HAZARD. FUEL TANK MUST BE KEPT AT HALF LEVEL, BUT IT DOES NOT STOP FUMES FROM ENTERING COMPARTMENT. *AK *YH

NHTSA ID

8016902

BLACK EXHAUST/SMOKE STARTED COMING FROM REAR END OF VAN DUE TO HEAD GASKET FAILING WHILE BEING DRIVEN. PLEASE DESCRIBE DETAILS. *AK

NHTSA ID

8015460

THE CONSUMER NOTICED THAT THE PAINT ON THE ROOF OF HIS VEHICLE HAS BEGUN TO FLAKE OFF IN DIFFERENT AREAS. THE CONSUMER TOOK THE VEHICLE TO TWO LOCAL BODY SHOPS. THE TECHNICIANS AT BOTH SHOPS TOLD THE CONSUMER THAT THEY SAW THIS PROBLEM WITH OTHER FORD VEHICLES. THE CONSUMER CONTACTED THE MANUFACTURER BUT THE REFUSED TO PROVIDE ANY FINANCIAL ASSISTANCE. *NM

NHTSA ID

566128

Incident

Jan 1, 1901

A BOLT WHICH HOLDS BACK REST HAS SHEARED OFF AND CAUSED SEAT TO COLLAPSE WHILE DRIVING. DEALER CONTACTED. FEEL FREE TO PROVIDE ANY FURTHER INFOIRMATION.*AK

NHTSA ID

8010137

AN ELECTRICAL SHORT IN FUEL PUMP. VEHICLE WAS EXPERIENCING A LOSS OF POWER AND FUEL GAUGE BECOMES ERRATIC. DEALER CONTACTED. *AK ALL THE GAUGES QUIT WORKING AND THE ENGINE STALLS WHILE DRIVING DUE TO MAIN DASH WIRING HARNESS OVERHEATED AND BURNT. *YH

NHTSA ID

8007423

WHILE IN REVERSE VEHICLE ACCELERATED FORWARD AT 40MPH, RESULTING IN A COLLISION WHICH CAUSED MINOR INJURIES. DEALER HAS VEHICLE FOR INSPECTION.*AK

NHTSA ID

8004758

Incident

Feb 20, 2002

HAD ADJUSTED SEATBACK WITH LEVER, BUT WHEN RESTING AGAINST IT, IT WOULD MAKE A CLICKING NOISE AND JUMP OUT POSITION. THIS CAUSES PROBLEM WITH VISIBILITY. HAD TAKEN VEHICLE TO DEALER, AND HAD SEAT REPLACED. BUT, PROBLEM STILL EXISTS. *AK

NHTSA ID

8003469

WHILE HAVING WINDSHIELD REPLACED, THE PINCH WELD HAD CORRODED DUE TO IMPROPER PREPARATION DURING PREVIOUS INSTALLATION. *YH

NHTSA ID

564010

WHILE VEHICLE WAS MOVING IN REVERSE, IT SUDDENLY ACCELERATED FORWARD AND BRAKE SYSTEM FAILED TO STOP VEHICLE. DEALERSHIP DID NOT EXAMINE VEHICLE TO DETERMINE A CAUSE FOR THIS PROBLEM. *AK *TT

NHTSA ID

899759

Incident

May 1, 1995