2002 Ford Crown Victoria Owner Complaints

..

NHTSA ID

11682007

Incident

Jul 31, 2025

Driving down the roadway at 55 mph a spark plug in cylinder 2 blow out. The car started making a popping noise and started to lose power. After a while the car shut off. The car was able to restart and be driven home. Upon inspection by a mechanic they found the spark plug had came dislodged and shot out of the cylinder and caused damage to the cylinder head the ignition coil and fuel rail. A new Heli coil was installed. A year later while in Texas driving down the road around 35 mph car made a pop noise and shot a spark plug out of cylinder 5 cause the car to lose power and start smoking with a heavy smell of fuel. Car was stopped and inspected. Found a spark plug was blown out of cylinder 5 with damage to the ignition cylinder and fuel rail. repaired the heli coil and placed with new spark plug ignition coil and fuel rail. 2019 while driving down road at 75 mph vehicle makes a loud pop and starts to lose power. Upon inspection by mechanic find spark plug blown out of cylinder 1 with damaged ignition coil. Having mechanic is now replacing both cylinder heads on the engine.

NHTSA ID

11448585

Incident

Jun 12, 2019

TL* THE CONTACT OWNS A 2002 FORD CROWN VICTORIA. WHILE DRIVING APPROXIMATELY 45 MPH AND ATTEMPTING TO MAKE A TURN, THE TURN SIGNALS AND HEADLIGHTS FAILED TO WORK, EXCEPT WHEN THE BRAKE PEDAL WAS DEPRESSED. THE CONTACT ALSO NOTICED THAT THE TAIL LIGHTS DID NOT WORK AND THE DASHBOARD WAS BLACKED OUT. THE VEHICLE WAS TAKEN TO A LOCAL DEALER WHO WAS UNABLE TO SCHEDULE THE VEHICLE FOR A DIAGNOSTIC EVALUATION. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES AND STATED THAT THERE WAS NO RECALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 38,000. UPDATED 10/06/16*LJ ** UPDATED 10/19/16*LJ *TR

NHTSA ID

10899549

Incident

Aug 25, 2016

Mileage

38,000 mi

TL* THE CONTACT OWNS A 2002 FORD CROWN VICTORIA. THE CONTACT STATED THAT THE HEADLAMPS DID NOT ILLUMINATE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE LIGHTING CONTROL MODULE WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 15V861000 (EXTERIOR LIGHTING); HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 197,000.

NHTSA ID

10892934

Incident

Jul 28, 2016

Mileage

197,000 mi

TL* THE CONTACT OWNS A 2002 FORD CROWN VICTORIA. WHILE DRIVING 35 MPH AND PROCEEDING TO STOP AT A RED LIGHT, THE ENGINE STALLED AND THE CHECK ENGINE LIGHT ILLUMINATED. THE VEHICLE WAS ABLE TO RESTART AFTER NUMEROUS ATTEMPTS. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE MANIFOLD WAS FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 81,218.

NHTSA ID

10818444

Incident

Dec 29, 2015

Mileage

81,218 mi

I HAD DRIVEN UP A STEEP MOUNTAIN DIRT ROAD TO SERVE SOME LEGAL PAPERS, AFTER REACHING THE TOP, I CONTINUED DOWN THE OTHER SIDE TO THE ADDRESS I WAS LOOKING FOR. I THOUGHT I STARTED SMELLING SOMETHING BURNING, IT SMELLED ELECTRICAL. WHEN I ARRIVED AT THE ADDRESS, I STOPPED THE CAR AND SHUT IT OFF WHILE I WAS SPEAKING WITH THE RESIDENT. MY WIFE YELLED AT ME THAT THE CAR WAS ON FIRE, IT STARTED FILLING UP WITH SMOKE FAST, MY WIFE AND DOGS WERE STILL IN THE CAR. I OPENED THE DRIVERS DOOR TO POP THE HOOD WHILE MY WIFE STARTED GETTING THE DOGS OUT, I THEN NOTICED IT WAS MY FLOOR THAT WAS BURNING, JUST ABOUT UNDER THE GAS PEDDLE, A HOLE HAD BURNED THROUGH AND THE METAL WAS GLOWING RED WHERE THE PADDING HAD BURNED AWAY. I POURED A CUP OF COFFEE TO PUT THE FIRE OUT WHILE THE RESIDENT GOT SOME WATER FOR ME. THE PADDING AND RUBBER MAT HAD BURNED AWAY AND A HOLE ABOUT 3 INCHES LONG HAD MELTED AWAY FROM THE FLOOR BOARD. THE CATALYTIC CONVERTER IS DIRECTLY BENEATH THE HOLE BUT THERE DOESN'T SEEM TO BE ANY HOLES IN THE CONVERTER AND THERE IS A EMPTY SPACE ABOUT 1.5 - 2 INCHES FROM THE MELTED HOLE TO THE CONVERTER. WE LET EVERYTHING COOL DOWN BEFORE DRIVING HOME, HOWEVER THE ENTIRE WAY HOME, (49 MILES) WE WERE AFRAID THE CAR WAS GOING TO BURST INTO FLAMES. ONCE WE WERE BACK ON THE PAVED ROADS AND WERE ABLE TO DRIVE THE NORMAL SPEED LIMIT, THERE WERE NO MORE ISSUES NOR ANY FURTHER BURNING, JUST THE LINGERING SMELL. I LOOKED UP AND FOUND A RECALL FOR AN ISSUE IN THE SAME LOCATION HOWEVER THAT WAS FOR 2003 - 2005 VEHICLES. *JS

NHTSA ID

10669204

Incident

Dec 30, 2014

Mileage

132,421 mi

TL** THE CONTACT OWNS A 2002 FORD CROWN VICTORIA. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, THE FRONT DRIVER AND PASSENGER SEAT BELT BECAME UNLATCHED SPORADICALLY. THE CONTACT MENTIONED THAT THE FAILURE COULD HAVE BEEN DIRECTLY RELATED TO NHTSA CAMPAIGN NUMBER: 01V227001 (SEAT BELTS). THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 50,000.

NHTSA ID

10653386

Incident

Jan 2, 2006

Mileage

50,000 mi

BOUGHT THE CAR FROM A FELLOW FRIEND HE ADVISED ME THAT THE CAR HAS HAD A ISSUE WITH THE STEERING WHERE THE STEERING WHEEL HAS PLAY TO IT AND ITS VERY DANGEROUS WHEN I DRIVE OVER 50MPH IM SCARED I MAY CRASH CAUSE THE CAR MOVES LEFT TO RIGHT, AND THE ABS BRAKES HAVE A PROBLEM THE BRAKE JUMP WHEN I HIT THEM IDK WHAT TO DO IM LOW ON FUNDS AND I WANT TO KNOW IF THIS IS A DEFECT THESE CARS ARE KNOWN FOR STEERING AND BRAKES DEFECTS..... *TR

NHTSA ID

10631810

Incident

Jul 17, 2013

Mileage

120,898 mi

POWER STEERING STARTED CATCHING AND COULDN'T TURN THE STEERING WHEEL SMOOTHLY. HIT A CURB WITH MY TIRE AND ALMOST HIT ANOTHER CAR. STILL JAMMING BUT I DON'T HAVE ENOUGH MONEY TO TAKE IT INTO A DEALERSHIP. HELP! *TR

NHTSA ID

10610431

Incident

Jun 2, 2014

Mileage

138,000 mi

TL* THE CONTACT OWNS A 2002 FORD CROWN VICTORIA. THE CONTACT STATED THAT THE STEERING FAILED AND THE WHEEL BECAME TIGHT. THE VEHICLE WAS REPAIRED BY THE CONTACT AND THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 140,000.

NHTSA ID

10538549

Incident

Aug 21, 2013

Mileage

140,000 mi

TL* THE CONTACT OWNS A 2002 FORD CROWN VICTORIA. THE CONTACT STATED THAT WHILE DRIVING 75 MPH, THE DRIVER'S SEAT BELT CAME UNDONE. THE CONTACT RE-SECURED THE SEAT BELT AND THE FAILURE RECURRED. THE CONTACT HAD TO PURCHASE A SEAT BELT EXTENSION IN ORDER TO KEEP THE SEAT BELT BUCKLED. THE VEHICLE WAS NOT REPAIRED. THE DEALER WAS NOT NOTIFIED OF THE ISSUE. THE MANUFACTURER WAS NOTIFIED AND INFORMED THE CONTACT THAT THE VEHICLE WAS OUT OF THE VEHICLE SAFETY WARRANTY AND HE WOULD HAVE TO REPLACE THE SEAT BELT HIMSELF. THE FAILURE MILEAGE WAS 40800.

NHTSA ID

10459951

Incident

Apr 3, 2012

Mileage

40,800 mi

POWER WINDOWS FRONT ELECTRIC WHEN YOU TOUCH REAR WINDOW BUTTON THE DRIVERS WINDOW GOES DOWN. *TR

NHTSA ID

10448120

Incident

Feb 1, 2012

THE ENGINE STALLED WHILE DRIVING, FOR NO APPARENT REASON. DRIVER (MY RETIRED MOTHER, AGE 72) HAD TO GET CAR OFF ROAD AND RESTART CAR TO CONTINUE. THE POWER STEERING DISABLED WHEN THE CAR ENGINE STALLED. THIS HAS HAPPENED MULTIPLE TIMES (2-3) OVER THE PAST MONTH, AND THE LOCAL FORD DEALERSHIP CANNOT REPLICATE THE PROBLEM AND IS UNABLE TO CORRECT IT. ON ANOTHER OCCASION THERE WAS A THUMPING NOISE AND THE CAR SLOWED CONSIDERABLY, BUT THEN PICKED BACK UP AGAIN. THE "ENGINE HEAT/THERMOMETER" LIGHT HAS FLASHED ALSO, BUT THE ENGINE TEMPERATURE HEAT IS NORMAL. I CONSIDER THIS A VERY DANGEROUS SITUATION FOR MY MOTOR IF IT WOULD HAPPEN IN A HEAVILY CONGESTED, HIGH TRAFFIC AREA AND COULD CAUSE A VEHICLE CRASHES. IT IS A VERY STRESSFUL SITUATION.

NHTSA ID

10438291

Incident

Nov 24, 2011

Mileage

40,134 mi

I HAD BEEN DRIVING 250 MILES OR SO AND DROVE DOWN A LONG WINDING INCLINE, AS THE ROAD FLATTENED OUT I HEARD A NOISE FROM THE ENGINE COMPARTMENT. THE NOISE SOUNDED LIKE A HOLE IN THE FIRST PART OF THE EXHAUST SYSTEM. I FOUND A SAFE PLACE TO PULL OVER AND TURNED OFF THE VEHICLE. THERE WAS A SLIGHT ODOR OF NATURAL GAS AS THIS VEHICLE IS FUELED WITH NATURAL GAS. AFTER THE ODOR PASSED, I OPENED THE HOOD TO FIND THAT THE #2 IGNITION COIL MOUNT WAS BROKEN, AND THE COIL AND SPARK PLUG ASSEMBLY WERE LOOSE IN THE SPARK PLUG WELL. MY INITIAL THOUGHT WAS THE SPARK PLUG HAD LOOSENED AND EJECTED. I ATTEMPTED TO RE-INSTALL THE SPARK PLUG BUT THE THREADS IN THE CYLINDER HEAD WERE INEFFECTIVE. THE SPARK PLUG HAD BLOWN OUT OF THE CYLINDER HEAD. I HAVE SUBSEQUENTLY FOUND OUT THAT THIS IS NOT AN UNCOMMON DEFECT FOR THESE FORD ENGINES. THE REPAIR INVOLVED REAMING AND TAPPING THE SPARK PLUG HOLE AND PLACING AN INSERT IN THE HOLE. THE SPARK PLUG COIL HAD TO BE REPLACED TOO. THE REPAIR COST WAS $450 AND THE REPAIR SHOP WARNED THAT THIS MAY HAPPEN AGAIN. THIS IS A DESIGN DEFECT THAT COULD POTENTIALLY BE DANGEROUS UNDER DIFFERENT CIRCUMSTANCES. IF I WAS NOT ABLE TO STOP IN A SAFE PLACE FAIRLY QUICKLY, THERE COULD HAVE BEEN MORE FUEL AIR MIXTURE ACCUMULATION UNDER THE HOOD AND SINCE THE SPARK PLUG WAS STILL OPERATIVE, AN IGNITION SOURCE WAS PRESENT TOO. *TR

NHTSA ID

10423166

Incident

Aug 26, 2011

Mileage

116,954 mi

TL*THE CONTACT OWNS A 2002 FORD CROWN VICTORIA. WHILE DRIVING APPROXIMATELY 45 TO 50 MPH ON NORMAL ROAD CONDITIONS PRESSURE WAS APPLIED TO THE ACCELERATOR PEDAL. THE "ABS" WARNING LIGHT INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL AND THE DRIVER WAS ABLE TO COAST INTO THE EMERGENCY LANE. THE WARNING INDICATOR REMAINED ILLUMINATED UNTIL THE ENGINE WAS TURNED OFF. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO CONFIRMED THAT THE FAILURE WAS RELATED TO THE REAR DRIVE SHAFT AXLE. NHTSA CAMPAIGN ID NUMBER 04V328000 (SUSPENSION;REAR) WAS RELATED TO THE FAILURE; HOWEVER, THE VIN WAS EXCLUDED FROM THE RECALL. THE VEHICLE IS IN THE PROCESS OF BEING REPAIRED. THERE WERE CONCERNS OF THE SAFETY RISK INVOLVED. THE FAILURE AND CURRENT MILEAGES WERE 120,000.

NHTSA ID

10281789

Incident

Aug 25, 2009

Mileage

120,000 mi

1. WHILE DRIVING ,LED CIRCUITBOARD ,( UNDER DASHBOARD)BURNED UP EMITTING SMOKE INTO THE PASSENGER COMPARTMENT. IT BURNED A ONE INCH HOLE IN THE CIRCUITBOARD PLASTIC COVER . 2. FAILURE,THE PART BURNED UP, IT MAY HAVE BURNED BEFORE ALSO,BECAUSE WE HAVE HAD A BURNING SMELL BEFORE. 3. CAR WAS PARKED,TURNED OFF FOR ABOUT ONE-HALF HOUR , THEN DRIVEN 6 MILES HOME.,NO ADDITIONAL SMOKE WAS SEEN AT THIS TIME. PART HAS BEEN REMOVED BY OWNER .OLD PART IS AVAILABLE,PART # F8VB-14A597-AB. FUSE DID NOT BLOW AND CAR IS DRIVABLE WITH PART REMOVED. I THINK THIS PART IS A COMPONENT OF THE FACTORY INSTALLED ALARM SYSTEM. *TR

NHTSA ID

10274193

Incident

Jun 17, 2009

Mileage

153,400 mi

TL*THE CONTACT OWNS A 2002 FORD CROWN VICTORIA. WHILE DRIVING BETWEEN 55-60 MPH ON NORMAL ROAD CONDITIONS, THE VEHICLE BEGAN TO HESITATE AND VIBRATE. IN ADDITION, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL AND REMAINED LIT UNTIL THE ENGINE WAS TURNED OFF. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSTIC TESTING AND STATED THAT THERE WAS AN INTERNAL COIL SHORTAGE. THE MISFIRE CYLINDER 5, COIL PACK, AND SPARK PLUGS WERE REPLACED IN THE VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER ON A SEPARATE OCCASION FOR THE IDENTICAL FAILURE AND THE MISFIRE CYLINDER 7, COIL PACK, AND SPARK PLUGS WERE REPLACED AT THAT TIME. THE FAILURE MILEAGE WAS 67,425 AND CURRENT MILEAGE WAS 68,045. UPDATED 03-27-09 *BF UPDATED 03/31/09.*JB

NHTSA ID

10261458

Incident

Feb 10, 2009

Mileage

67,425 mi

WHILE DRIVING THE LOW BEAMS WENT OUT ON CAR,20 MINUTES LATER HIGH BEAMS WENT OUT. ALL OTHER LIGHTS WORK PROPERLY, HEADLIGHTS HAVE NOT WORKED SINCE. CURRENTLY IN THE PROCESS TO REPLACE PART. *TR

NHTSA ID

10257804

Incident

Jan 28, 2009

JUST CRUISING THROUGH A PARKING LOT ON MY WAY INTO WORK AND HAD A SPARK PLUG BLOWOUT. DAMAGED THE SPARK PLUG COIL AS WELL. HAD TO BUY A NEW COIL, AND A HELICOIL KIT TO RE-TAP THE SPARK PLUG HOLE. *TR

NHTSA ID

10224285

Incident

Apr 11, 2008

Mileage

118,000 mi

TL*THE CONTACT OWNS A 2002 FORD CROWN VICTORIA. THE CONTACT OPENED THE HOOD, BUT IT FAILED TO OPEN AUTOMATICALLY. HE PLACED HIS HAND ON THE FENDER AND THE HOOD SUDDENLY FELL AND SLAMMED DOWN ON HIS HAND. THE CONTACT SUSTAINED SEVERAL BRUISES, CUTS, AND BLISTERS. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE FAILURE AND CURRENT MILEAGES WERE 56,000. UPDATED 03/18/08. *LJ THE CONSUMER STATED AT THE TIME OF THE INCIDENT THE HOOD WAS RAISED TO THE FULL CAPACITY AND VEHICLE WAS TAKEN TO THE DEALER. THE DEALER STATED STRUTS WERE REPLACED AT CONSUMER'S EXPENSE. UPDATED 03/18/08 *TR UPDATED 4/2/08 *CN UPDATED 04/02/08 *TR

NHTSA ID

10219392

Incident

Feb 28, 2008

Mileage

56,000 mi

2002 FORD CROWN VICTORIA LEFT REAR WHEEL SEPARATED FROM THE VEHICLE. *KB THE VEHICLE WAS DAMAGED AS A RESULT OF THE WHEEL COMING OFF. OHIO TRAFFIC CRASH REPORT# 10-89-0577. *JB

NHTSA ID

10213958

Incident

Nov 24, 2007

TL*THE CONTACT OWNS A 2002 FORD CROWN VICTORIA. THE CONTACT STATED THAT THE TIRES ON HIS VEHICLE CONSTANTLY DEFLATE. THE MECHANIC STATED THAT THERE WAS A LEAK OUTSIDE OF THE RIMS AND THAT THE FAILURE WAS CAUSED BY THE RIMS AND NOT THE TIRES. THE MECHANIC WAS UNABLE TO REPAIR THE RIMS. THE CURRENT MILEAGE IS 59,000 AND FAILURE MILEAGE WAS 15,000.

NHTSA ID

10194019

Incident

Jan 1, 2004

Mileage

15,000 mi

FRONT END CRASH WITH 2002 FORD CROWN VIC ON INTERSTATE 95 IN BALTIMORE COUNTY MARYLAND. THE PASSENGER AIR BAG DEPLOYED BUT THE DRIVERS SIDE AIR BAG DID NOT. PRIOR TO THIS ACCIDENT THIS MORNING THERE HAD NOT BEEN ANY INDICATION THAT THE AIR BAG SYSTEM HAD ANY PROBLEMS. THE DAMAGE WAS THE RIGHT FRONT FENDER, BUMPER, AND HOOD. THE VEHICLE HAD TO BE TOWED. *JB

NHTSA ID

10183835

Incident

Feb 28, 2007

Mileage

97,500 mi

DT*: THE CONTACT STATED WHILE TRAVELING 55 MPH THE CRUISE CONTROL WOULD NOT DISENGAGE. THE CONTACT TRIED TO DISENGAGE THE CRUISE CONTROL AT THE STEERING WHEEL. WHEN THAT DID NOT WORK, THE BRAKE WAS APPLIED. THE VEHICLE ACCELERATED AND THE BRAKE WOULD NOT STOP THE VEHICLE. THE VEHICLE CRASHED INTO SOMEONE'S YARD. THERE WERE NO INJURIES SUSTAINED AND THERE WAS A POLICE REPORT FILED. THERE WAS SUBSTANTIAL DAMAGE DONE TO THE CONTACT'S VEHICLE. UPDATED 03/03/06. *JB

NHTSA ID

10150088

Incident

Jan 27, 2006

Mileage

33,180 mi

SUDDEN FAILURE OF FRONT SUSPENSION SYSTEM CAUSED COLLAPSE OF SUSPENSION MAKING THE CAR UNCONTROLLABLE AND AFTER COMING TO A STOP, IMMOBILE. RIGHT FRONT WHEEL TURNED INWARD AT THE FRONT UPON FAILURE AND LEFT FRONT WHEEL REMAINS POINTING STRAIGHT AHEAD. RIGHT FRONT WHEEL ALSO SHIFTED TOWARD THE REAR CONTACTING THE REAR PORTION OF THE WHEEL/FENDER OPENING CAUSING CRUMPLING OF BODY SHEET METAL TO THE EXTENT THAT FENDER WILL PROBABLY HAVE TO BE REPLACED AUTO IS AT DEALER AWAITING ANALYSIS. *NM

NHTSA ID

10136594

Incident

Sep 15, 2005

Mileage

84,500 mi